ITS61080
Service Bulletin/Repair Instructions
Instructions to remove DEF sensor bypass calibration from engine ECM and new sensor installation AR - 18inch DEF tank CA emissions
Vehicle report
2016 NEW FLYER XD40
Service bulletins
22 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ITS-58444
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Replace RECARO Seatbelts.
SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
ITS6785
Service Bulletin/Repair Instructions
This Maintenance Instruction Decribes How to Add Relay for Auto Neutral Signal to Transmission Control Module.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
ITS6704
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Ensure Proper Clearance Between CAC Exhaust Support and Gen 5 Coolant Lines.
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
ITS6662
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Add Heat Shrink to Rear Camera Pigtail (wiring).
ITS6623
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect Rear Axle Hub Spindle Nuts
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
SMB168
Service Bulletin/Repair Instructions
Service Manula Bulletin provides revised OEM information on the exhaust, after treatment System and DEF tank.
ITS6420
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION FOR AMEREX DISPLAY MODULE AND FIRMWARE VALIDATION
ITS6368
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWIRE THE VOLTAGE REGULATOR POWER SUPPLY FROM THE BATTERY SIDE TO THE LOAD SIDE OF THE BATTERY DISCONNECT SWITCH.
ITS6339
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWORK HEAT EXCHANGER CABIN LOOP LINE AND ROUTING.
ITS6364
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWORK HEAT EXCHANGER CABIN LOOP LINE AND ROUTING.
ITS6307
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - INSPECT REAR BUMPER AND RE-TORQUE MOUNTING HARDWARE IF REQUIRED - SPECIFICALLY EQUIPPED VEHILCES
ITS6244
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INCORPORATE AN ADDITIONAL PRESSURE PROTECTION VALVE (PPV) TO THE EMERGENCY BRAKE RELEASE SYSTEM, FOR SPECIFICALLY EQUIPPED VEHICLES OPERATING IN NEW YORK STATE ONLY.
ITS6254
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO RECONFIGURE VOLTAGE SENSE CONNECTION WIRING ON SPECIFICALLY EQUIPPED VEHICLES
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.