ITS61187
Service Bulletin/Repair Instructions
Instructions to Service to incorporate a PLC Update to prevent interlock activation when CAN speed messages are absent.
Vehicle report
2014 NEW FLYER XDE40
Service bulletins
31 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSIB 22-13 Rev B
Service Bulletin/Repair Instructions
Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
ITS58843
Service Bulletin/Repair Instructions
This is a technical service instruction describing how to weld/repair cracks as required at Diesel Exhaust Fluid (DEF) tank bracket, and add reinforcement bracket at DEF tank bracket area.
SMB186
Service Bulletin/Repair Instructions
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
SMB188
Service Bulletin/Repair Instructions
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
SMB187
Service Bulletin/Repair Instructions
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
ITS6702
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Install BAE Auto Traction Control (ATC) enabling software update.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
ITS6602
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove And Replace Fuel Fitting
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
SMB168
Service Bulletin/Repair Instructions
Service Manula Bulletin provides revised OEM information on the exhaust, after treatment System and DEF tank.
ITS6415
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE CHARGE AIR COOLING TUBE SUPPORT BRACKET
ITS6262
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - REPLACE ISB ENGINE COOLANT SURGE TANK - SPECIFICALLY EQUIPPED VEHILCES.
1604 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6216
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REMOVE AND REPLACE DEFROSTER HEATER BLOWER RESISTOR.
1603 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6167
Service Bulletin/Repair Instructions
Technical Instruction to Rotate Current Sensor.
ITS6031
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE DIMMER SWITCH.
ITS6019
Service Bulletin/Repair Instructions
Technical Instruction to Inspect and Repair HV Wiring Connections.
ITS5930
Service Bulletin/Repair Instructions
NEW FLYER: 2010 EPA XCELSIOR DIESEL NON-HYBRIDS WITH ISOLATED PIPE CLAMPS OR WITH NEWER ENGINES AND MINI-HYBRID COOLING SYSTEMS MAY EXPERIENCE RADIATOR CORROSION. *TA
ITS5909
Service Bulletin/Repair Instructions
NEW FLYER: 2010 EPA OR NEWER ENGINES AND MINI-HYBRID COOLING SYSTEM BUSES WITH ISOLATED PIPE CLAMPS MAY EXPERIENCE RADIATOR CORROSION. *TA
ITS6014
Service Bulletin/Repair Instructions
Technical Instruction to Remove Front Brake Air Line P-clamps and Brackets.
ITS5927
Service Bulletin/Repair Instructions
Technical Instruction to Add Brackets to Driver's Side Console.
ITS5910
Service Bulletin/Repair Instructions
Technical Instruction to Inspect and Correct BAE Accessory HV Cable Insulation.
ITS5856
Service Bulletin/Repair Instructions
Technical Instruction to Replace BAE Hybrid Fluid Dipstick.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.