ITS61080
Service Bulletin/Repair Instructions
Instructions to remove DEF sensor bypass calibration from engine ECM and new sensor installation AR - 18inch DEF tank CA emissions
Vehicle report
2016 NEW FLYER XDE40
Service bulletins
38 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ITS61267
Service Bulletin/Repair Instructions
Instructions to replace current k-member with an upgraded casting design.
ITS61187
Service Bulletin/Repair Instructions
Instructions to Service to incorporate a PLC Update to prevent interlock activation when CAN speed messages are absent.
TSIB 22-13 Rev B
Service Bulletin/Repair Instructions
Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
ITS60458
Service Bulletin/Repair Instructions
Technical Instruction describing how to replace the air compressor scroll bearing access plug with a bait well plug.
ITS59105
Service Bulletin/Repair Instructions
Technical instruction describing how to re-mark existing BAE HS300 ACTM dipsticks.
ITS58838
Service Bulletin/Repair Instructions
Technical Instruction describing how to repair cracks in DEF tank bracket welds, and add reinforced support bracket to DEF tank area.
ITS58835
Service Bulletin/Repair Instructions
Technical Instruction describing how to download a program to the Vansco Programmable Logic Control (PLC) system on buses equipped with under-dash USB port.
ITS58760
Service Bulletin/Repair Instructions
Technical Service Instruction Describing How to Replace the DEF Fluid Module/Pump Cover Assembly.
SMB186
Service Bulletin/Repair Instructions
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
SMB188
Service Bulletin/Repair Instructions
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
SMB187
Service Bulletin/Repair Instructions
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
ITS58474
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Rework Engine Mount for Water Belt Clearance.
SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
ITS6754
Service Bulletin/Repair Instructions
This Maintenance Instruction Decribes How to Update Battery Equalizer Programming.
ITS6724
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Replace the Air Compressor Filter.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
ITS6706
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Rewire the Engine Compartment Cooling Fill Mode Switch
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
ITS6602
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove And Replace Fuel Fitting
ITS6623
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect Rear Axle Hub Spindle Nuts
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
SMB168
Service Bulletin/Repair Instructions
Service Manula Bulletin provides revised OEM information on the exhaust, after treatment System and DEF tank.
ITS6413
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE VERTICAL BOOSTER PUMP WITH A HORIZONTAL BOOSTER PUMP
ITS6415
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE CHARGE AIR COOLING TUBE SUPPORT BRACKET
ITS6420
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION FOR AMEREX DISPLAY MODULE AND FIRMWARE VALIDATION
ITS6337
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO RETROFIT NEW AIR COMPRESSOR MOUNTING BRACKETS.
ITS6406
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO CORRECT INSTALLATION OF STEERING GEARBOX MOUNTING PLATE.
ITS6364
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWORK HEAT EXCHANGER CABIN LOOP LINE AND ROUTING.
ITS6307
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - INSPECT REAR BUMPER AND RE-TORQUE MOUNTING HARDWARE IF REQUIRED - SPECIFICALLY EQUIPPED VEHILCES
ITS6234
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSPECT FRONT MASK SUPPORT BRACKET BOND AND REPAIR IF REQUIRED ON SPECIFICALLY EQUIPPED VEHICLES
1603 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6167
Service Bulletin/Repair Instructions
Technical Instruction to Rotate Current Sensor.
ITS6182
Service Bulletin/Repair Instructions
Technical Instruction to Remove and Reinstall Driver's Barrier with Loctite.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.