ITS61267
Service Bulletin/Repair Instructions
Instructions to replace current k-member with an upgraded casting design.
Vehicle report
2017 NEW FLYER XDE40
Service bulletins
21 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ITS58838
Service Bulletin/Repair Instructions
Technical Instruction describing how to repair cracks in DEF tank bracket welds, and add reinforced support bracket to DEF tank area.
SMB186
Service Bulletin/Repair Instructions
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
SMB188
Service Bulletin/Repair Instructions
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
SMB187
Service Bulletin/Repair Instructions
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
ITS58474
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Rework Engine Mount for Water Belt Clearance.
ITS-58444
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Replace RECARO Seatbelts.
SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
ITS6754
Service Bulletin/Repair Instructions
This Maintenance Instruction Decribes How to Update Battery Equalizer Programming.
ITS6724
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Replace the Air Compressor Filter.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
ITS6703
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Update Voltage Equalizer Programming.
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
ITS6632
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove and Replace the Speedometer Module.
ITS6602
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove And Replace Fuel Fitting
ITS6623
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect Rear Axle Hub Spindle Nuts
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.