ITS61080
Service Bulletin/Repair Instructions
Instructions to remove DEF sensor bypass calibration from engine ECM and new sensor installation AR - 18inch DEF tank CA emissions
Vehicle report
2017 NEW FLYER XDE60
Service bulletins
26 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ITS61267
Service Bulletin/Repair Instructions
Instructions to replace current k-member with an upgraded casting design.
TSIB 25-01
Service Bulletin/Repair Instructions
Thermo-King has issued a Service Bulletin (SB866-1) related to the clutch bearing maintenance on their QS616 HVAC screw compressor. New Flyer is issuing this Technical Service Information Bulletin to notify New Flyer XD60, XN60 and XDE60 bus operators about this Thermo-King Service Bulletin.
ITS61187
Service Bulletin/Repair Instructions
Instructions to Service to incorporate a PLC Update to prevent interlock activation when CAN speed messages are absent.
TSIB 22-13 Rev B
Service Bulletin/Repair Instructions
Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
ITS60288
Service Bulletin/Repair Instructions
This Instruction to Service (ITS) decribes the inspection procedure required to inspect the upper bulkhead brakets for cracks, on the articulation joint of a sixty foot bus.
ITS59266
Service Bulletin/Repair Instructions
Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support brackets to the existing upper bulkhead structure at the articulation joint.
ITS59105
Service Bulletin/Repair Instructions
Technical instruction describing how to re-mark existing BAE HS300 ACTM dipsticks.
ITS59005
Service Bulletin/Repair Instructions
Technical Instruction issued to document and track BAE Systems HDS300 hybrid drive traction motor program update.
SMB186
Service Bulletin/Repair Instructions
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
SMB188
Service Bulletin/Repair Instructions
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
SMB187
Service Bulletin/Repair Instructions
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
ITS58480
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect and if Necessary, Replace A/C Hoses in the articulation Joint.
SMB-182
Service Bulletin/Repair Instructions
This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support Frame Installed on your New Flyer Vehicle.
ITS6914
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove and Install Streetside and Curbside Windshield Wiper Idler Arm Assemblies.
SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
ITS6706
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Rewire the Engine Compartment Cooling Fill Mode Switch
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
SMB175
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides New Preventative MAintenance Inspection Requirements for the Fore and Aft Articulated Joint Electrical Panel Fuse Wiring.
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
ITS6572
Service Bulletin/Repair Instructions
This Maintenance Instruction describes an inspection of ZF center axle hub/rotor bolt torque.
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.