ITS61795
Service Bulletin/Repair Instructions
Instructions to inspect flooring for ridge/raised area, pull back flooring, add screws and re-apply flooring in between front luggage racks.
Vehicle report
2018 NEW FLYER XDE60
Service bulletins
25 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ITS61080
Service Bulletin/Repair Instructions
Instructions to remove DEF sensor bypass calibration from engine ECM and new sensor installation AR - 18inch DEF tank CA emissions
ITS61267
Service Bulletin/Repair Instructions
Instructions to replace current k-member with an upgraded casting design.
TSIB 25-01
Service Bulletin/Repair Instructions
Thermo-King has issued a Service Bulletin (SB866-1) related to the clutch bearing maintenance on their QS616 HVAC screw compressor. New Flyer is issuing this Technical Service Information Bulletin to notify New Flyer XD60, XN60 and XDE60 bus operators about this Thermo-King Service Bulletin.
ITS61187
Service Bulletin/Repair Instructions
Instructions to Service to incorporate a PLC Update to prevent interlock activation when CAN speed messages are absent.
ITS61122
Service Bulletin/Repair Instructions
Instruction to Service for updating the battery program on certain ELFA2 buses for Improved BMS response to overcharging and other functional safety mechanisms, more robust detection of failure modes through DTCs, improving Battery Data Recorder (BDR) capabilities, streamlined flashing processes, and logic improvements for better integration with application.
TSIB 22-13 Rev B
Service Bulletin/Repair Instructions
Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
ITS60288
Service Bulletin/Repair Instructions
This Instruction to Service (ITS) decribes the inspection procedure required to inspect the upper bulkhead brakets for cracks, on the articulation joint of a sixty foot bus.
ITS59266
Service Bulletin/Repair Instructions
Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support brackets to the existing upper bulkhead structure at the articulation joint.
ITS59105
Service Bulletin/Repair Instructions
Technical instruction describing how to re-mark existing BAE HS300 ACTM dipsticks.
ITS59005
Service Bulletin/Repair Instructions
Technical Instruction issued to document and track BAE Systems HDS300 hybrid drive traction motor program update.
ITS58760
Service Bulletin/Repair Instructions
Technical Service Instruction Describing How to Replace the DEF Fluid Module/Pump Cover Assembly.
ITS58768
Service Bulletin/Repair Instructions
Technical Service Instruction Describing How to Replace Side or Top Mount Windshield Washer Pump Assembly.
ITS58779
Service Bulletin/Repair Instructions
Technical Service Instruction Describing How to Rewire TRW Steering Column to Provide a Memory Power Circuit. - The addition of the switch ensures that the TRW Steering System maintains its calibration in the event of a power disruption.
SMB186
Service Bulletin/Repair Instructions
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
SMB188
Service Bulletin/Repair Instructions
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
SMB187
Service Bulletin/Repair Instructions
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
ITS58708
Service Bulletin/Repair Instructions
Instruction to Service explaining how to inspect, and reorient DEF tank support strap if required.
ITS58608
Service Bulletin/Repair Instructions
This technical instruction describes how to add retainer blocks to the SDS (maintenance access only) window hinge.
ITS58480
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect and if Necessary, Replace A/C Hoses in the articulation Joint.
SMB-182
Service Bulletin/Repair Instructions
This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support Frame Installed on your New Flyer Vehicle.
ITS6914
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove and Install Streetside and Curbside Windshield Wiper Idler Arm Assemblies.
SMB180
Service Bulletin/Repair Instructions
This Service Manual Bulletin Provides Updated Preventive Maintenace Interval for the Crankcase Breather Tube Element on Buses Equipped with a Cummins Diesel ISL 07 or ISL 09 Engine.
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB170
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a correction for the information regarding the replacement of the DEF tank suction filter.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.