ITS61722
Service Bulletin/Repair Instructions
Instructions for replacing a CNG decal to comply with New York State regulations
Vehicle report
2013 NEW FLYER XN40
Service bulletins
27 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
SMB191
Service Bulletin/Repair Instructions
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
TSIB 20-01
Service Bulletin/Repair Instructions
Technical Service Information Bulletin describing changes to the Cummins ISLG, L9N, ISB6.7G and B6.7N engine oil specifications.
ITS58848
Service Bulletin/Repair Instructions
Technical Instruction describing how to remove and replace the drivers barrier upper door frame assembly.
TSIB-18-01
Service Bulletin/Repair Instructions
This Technical Service Information Bulletin Decsribes How to Inspect and Reroute as Required the Cummins L9N Engine Crankcase Ventilation Hose.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB169
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a procedure for venting the tanks when the solenoid valve is stuck closed or not operating, and a procedure for the installation of the solenoid valve on the CNG tank.
ITS6247
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - REWORK GAS DETECTION SYSTEM WIRING ROUTING - SPECIFICALLY EQUIPPED VEHILCES
1604 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6164
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE SURGE TANK LOW COOLANT LEVEL SENSOR.
ITS6216
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REMOVE AND REPLACE DEFROSTER HEATER BLOWER RESISTOR.
ITS6031
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE DIMMER SWITCH.
ITS5909
Service Bulletin/Repair Instructions
NEW FLYER: 2010 EPA OR NEWER ENGINES AND MINI-HYBRID COOLING SYSTEM BUSES WITH ISOLATED PIPE CLAMPS MAY EXPERIENCE RADIATOR CORROSION. *TA
ITS6006
Service Bulletin/Repair Instructions
Technical Instruction to Revise Surge Tank Low Coolant Level Sensor Harness.
ITS5853
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO ADD 100 PSI REGULATOR TO ALLISON ACCUMULATOR.
ITS-5322
Service Bulletin/Repair Instructions
NEW FLYER: INFORMATION PROVIDED ON THE REMOVAL OF THE ISE COOLING LOOP BYPASS. NO MODEL OR YEARS LISTED. *PE
ITS-5481
Service Bulletin/Repair Instructions
NEW FLYER: INFORMATION ON REWORKING TRANSMISSION COOLER WIRE HARNESS, DUE TO OVER EXPOSURE OF UV RADIATION, BY THE SUN, THE WIRE INSULATION AND RED WIRE IN HARNESS WILL BECOME BRITTLE AND CRACK CAUSING INOPERABLE FAN AND POSSIBLE FAN FAULT DASH LIGHT, OVER HEATING PROPULSION AND SHUTDOWN. NO MODEL OR YEARS LISTED. *PE
ITS5601
Service Bulletin/Repair Instructions
Technical Instruction to Correct Randon Shutdown of Instrument Panel.
TSIB-13-01-A
Service Bulletin/Repair Instructions
NEW FLYER: ON CERTAIN HYBRID BUSES, THE ISE AIR COMPRESSOR INTAKE FILTER IS DIFFICULT TO ACCESS ON ISE GAS/ELECTRIC AND PROPERTIES MAY NOT BE MAINTAINING AIR COMPRESS INTAKE FILTER AND MAY NEED TO BE RELOCATED. NO MODEL OR MODEL YEARS LISTED. *PE
ITS5560
Service Bulletin/Repair Instructions
Technical Instruction to Add Safety Yellow Stripe on Wheelchair Ramp.
ITS5426
Service Bulletin/Repair Instructions
Technical Instruction to Modify Front Curbside Skid Plate Installation.
ITS5424
Service Bulletin/Repair Instructions
Technical Instruction to Add Inline Filter for Air Intake Line.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.