ITS61722
Service Bulletin/Repair Instructions
Instructions for replacing a CNG decal to comply with New York State regulations
Vehicle report
2015 NEW FLYER XN40
Service bulletins
34 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
ITS59161
Service Bulletin/Repair Instructions
Technical Instruction describing how to inspect and install new headlamp harness if required.
ITS58950
Service Bulletin/Repair Instructions
Technical Instruction describing how to remove and replace the front suspension air springs,
SMB191
Service Bulletin/Repair Instructions
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
TSIB 20-01
Service Bulletin/Repair Instructions
Technical Service Information Bulletin describing changes to the Cummins ISLG, L9N, ISB6.7G and B6.7N engine oil specifications.
ITS58848
Service Bulletin/Repair Instructions
Technical Instruction describing how to remove and replace the drivers barrier upper door frame assembly.
TSIB-18-01
Service Bulletin/Repair Instructions
This Technical Service Information Bulletin Decsribes How to Inspect and Reroute as Required the Cummins L9N Engine Crankcase Ventilation Hose.
ITS6845
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove and Replace Exhaust Compartment Harness Heat Shield.
ITS6745
Service Bulletin/Repair Instructions
This Maintenance Instruction Decribes How to Replace the Surge Tank Low Coolant Level Sensor.
ITS6754
Service Bulletin/Repair Instructions
This Maintenance Instruction Decribes How to Update Battery Equalizer Programming.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB177
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new inspection and replacement requirements for the coolant hoses located above the SDS enclosure on specifically equipped buses.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
PMB048
Service Bulletin/Repair Instructions
This Parts Manual bulletin provides information on the part numbers of the engine lift brackets
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
SMB169
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides a procedure for venting the tanks when the solenoid valve is stuck closed or not operating, and a procedure for the installation of the solenoid valve on the CNG tank.
ITS6496
Service Bulletin/Repair Instructions
Technical Instruction to inspect and replace solenoid valves if found defective.
ITS6420
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION FOR AMEREX DISPLAY MODULE AND FIRMWARE VALIDATION
ITS6369
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWIRE THE VOLTAGE REGULATOR POWER SUPPLY FROM THE BATTERY SIDE TO THE LOAD SIDE OF THE BATTERY DISCONNECT SWITCH.
ITS6406
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO CORRECT INSTALLATION OF STEERING GEARBOX MOUNTING PLATE.
ITS6358
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWIRE VOLTAGE REGULATOR POWER.
ITS6364
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REWORK HEAT EXCHANGER CABIN LOOP LINE AND ROUTING.
ITS6247
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - REWORK GAS DETECTION SYSTEM WIRING ROUTING - SPECIFICALLY EQUIPPED VEHILCES
ITS6307
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - INSPECT REAR BUMPER AND RE-TORQUE MOUNTING HARDWARE IF REQUIRED - SPECIFICALLY EQUIPPED VEHILCES
ITS6244
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INCORPORATE AN ADDITIONAL PRESSURE PROTECTION VALVE (PPV) TO THE EMERGENCY BRAKE RELEASE SYSTEM, FOR SPECIFICALLY EQUIPPED VEHICLES OPERATING IN NEW YORK STATE ONLY.
ITS6234
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSPECT FRONT MASK SUPPORT BRACKET BOND AND REPAIR IF REQUIRED ON SPECIFICALLY EQUIPPED VEHICLES
ITS6254
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO RECONFIGURE VOLTAGE SENSE CONNECTION WIRING ON SPECIFICALLY EQUIPPED VEHICLES
1604 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6164
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE SURGE TANK LOW COOLANT LEVEL SENSOR.
ITS6185
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSPECT STREET SIDE DRIVER'S EXTERIOR MIRROR SNAP BUSHING.
1603 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6182
Service Bulletin/Repair Instructions
Technical Instruction to Remove and Reinstall Driver's Barrier with Loctite.
ITS6192
Service Bulletin/Repair Instructions
Technical Instruction to Add PPV valve to Parking Brake Optional Emergency Release System for New York State.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.