ITS61722
Service Bulletin/Repair Instructions
Instructions for replacing a CNG decal to comply with New York State regulations
Vehicle report
2018 NEW FLYER XN60
Service bulletins
18 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSIB 25-01
Service Bulletin/Repair Instructions
Thermo-King has issued a Service Bulletin (SB866-1) related to the clutch bearing maintenance on their QS616 HVAC screw compressor. New Flyer is issuing this Technical Service Information Bulletin to notify New Flyer XD60, XN60 and XDE60 bus operators about this Thermo-King Service Bulletin.
ITS61187
Service Bulletin/Repair Instructions
Instructions to Service to incorporate a PLC Update to prevent interlock activation when CAN speed messages are absent.
ITS59266
Service Bulletin/Repair Instructions
Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support brackets to the existing upper bulkhead structure at the articulation joint.
ITS59076
Service Bulletin/Repair Instructions
Technical instruction describing how to replace specified street and curbside front headlamps.
SMB191
Service Bulletin/Repair Instructions
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
TSIB 20-01
Service Bulletin/Repair Instructions
Technical Service Information Bulletin describing changes to the Cummins ISLG, L9N, ISB6.7G and B6.7N engine oil specifications.
ITS58734
Service Bulletin/Repair Instructions
Technical Instruction to increase the stiffness of external louvered access door panels.
ITS58751
Service Bulletin/Repair Instructions
Technical Instruction to remove and replace the antenna pedestal mounting brackets.
ITS58480
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect and if Necessary, Replace A/C Hoses in the articulation Joint.
TSIB-18-01
Service Bulletin/Repair Instructions
This Technical Service Information Bulletin Decsribes How to Inspect and Reroute as Required the Cummins L9N Engine Crankcase Ventilation Hose.
ITS58416
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Inspect for Correct Installation of O2 Sensor Seals and Insulation.
SMB-182
Service Bulletin/Repair Instructions
This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support Frame Installed on your New Flyer Vehicle.
ITS6914
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove and Install Streetside and Curbside Windshield Wiper Idler Arm Assemblies.
ITS6830
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Install the Optional Wheelchair Ramp Manual Extension Tool. (This tool is not required to manually deploy or stow the wheelchair ramp).
ITS6825
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove & Replace A/C Hoses
ITS6845
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Remove and Replace Exhaust Compartment Harness Heat Shield.
ITS6768
Service Bulletin/Repair Instructions
This Maintenance Instruction Decribes How to Remove and Replace HVAC Return Air Filter Hinge Mounting Hardware.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.