ITS61267
Service Bulletin/Repair Instructions
Instructions to replace current k-member with an upgraded casting design.
Vehicle report
2014 NEW FLYER XT60
Service bulletins
28 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSIB 22-13 Rev B
Service Bulletin/Repair Instructions
Service bulletin increasing the torque value of a joint in a double-tilt steering column spline shaft.
ITS59266
Service Bulletin/Repair Instructions
Technical Instruction describing how to mechanically fasten the Engergy Guide System (EGS) support brackets to the existing upper bulkhead structure at the articulation joint.
SMB186
Service Bulletin/Repair Instructions
Service Manual Bulletin providing revised, corrected or additional information for the Preventive Maintenance on buses specifically equipped with a Powerex direct drive air compressor.
SMB188
Service Bulletin/Repair Instructions
Service Manual Bulletin provides revised information for the Preventive Maintenance on specifically equipped vehicles with the Powerex belt driven air compressor.
SMB187
Service Bulletin/Repair Instructions
Service Manual Bulletin which stresses the need for safety when performing maintenance on the high voltage systems on your New Flyer vehicle.
SMB-182
Service Bulletin/Repair Instructions
This Service Manual Bulletin Identifies a New Requirement for Bolt Replacement in the Artic Joint Support Frame Installed on your New Flyer Vehicle.
PMB049
Service Bulletin/Repair Instructions
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB176
Service Bulletin/Repair Instructions
This Service Manual Bulletin provides new information on how to check for proper chain tension, as measured by the chain deflection, while performing the ramp mechanism initial adjustments. This bulletin only applies to vehicles with New Flyer designed ramps.
ITS6467
Service Bulletin/Repair Instructions
This Maintenance Instruction Describes How to Add Re-enforcement Brackets to the Existing Air Accessory Tank Mounting Bracket.
SMB173
Service Bulletin/Repair Instructions
This bulletin provides PM inspection requirements for the K-menber on the fuel tank support structure
ITS6572
Service Bulletin/Repair Instructions
This Maintenance Instruction describes an inspection of ZF center axle hub/rotor bolt torque.
ITS6329
Service Bulletin/Repair Instructions
Technical Instruction to replace air compressor mounting bracket.
ITS6353
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE REAR AXLE FLUID AND FLUID SPECIFICATION TAG.
ITS6318
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REPLACE RUSTED WHEELCHAIR RESTRAINT FLOOR PLATE HARDWARE.
ITS6333
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO REVISE LIFT-U WHEELCHAIR RAMP HARDWARE TORQUE VALUES.
ITS6293
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO APPLY SPECIFIC TORQUE TO ALL MOUNTING BOLTS FOR ROOFTOP COMPONENTS.
ITS6272
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION - ADDITION OF A BRIDGE RECTIFIER TO RAMP POWER SUPPLY - SPECIFICALLY EQUIPPED VEHILCES
ITS6266
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSPECT AND RE-TORQUE CONNECTION POINTS FOR GROUND CABLES.
ITS-6213
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSTALL SUPPORT BRACKET FOR TRANSMISSION MODE SELECTOR HARNESS ON SPECIFICALLY EQUIPPED VEHICLES
ITS613
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSTALL SUPPORT BRACKET FOR TRANSMISSION MODE SELECTOR HARNESS ON SPECIFICALLY EQUIPPED VEHICLES
1604 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6185
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO INSPECT STREET SIDE DRIVER'S EXTERIOR MIRROR SNAP BUSHING.
ITS6215
Service Bulletin/Repair Instructions
TECHNICAL INSTRUCTION TO CLEAN TRACTION MOTOR GROUND CONNECTION.
1603 NHTSA
Service Bulletin/Repair Instructions
Sec. 579.5 - Notices, bulletins, custoimer satisf ac tion campaigns, consumer advisories, and other communications.
ITS6182
Service Bulletin/Repair Instructions
Technical Instruction to Remove and Reinstall Driver's Barrier with Loctite.
ITS5909
Service Bulletin/Repair Instructions
NEW FLYER: 2010 EPA OR NEWER ENGINES AND MINI-HYBRID COOLING SYSTEM BUSES WITH ISOLATED PIPE CLAMPS MAY EXPERIENCE RADIATOR CORROSION. *TA
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.