BS5543E
Service Bulletin/Repair Instructions
Battery tray structure cracks due to thin sheet metal.
Vehicle report
2020 NOVA BUS LFS ARTIC
Service bulletins
26 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
FT5536
Service Bulletin/Repair Instructions
Battery Tray Structure Cracks. Battery hold downs may slip between batteries.
LI5427E
Service Bulletin/Repair Instructions
Improved durability of engine-side heat exchanger hoses.
BS5469E
Service Bulletin/Repair Instructions
The belt guard hinge may crack.
BS5388E
Service Bulletin/Repair Instructions
AC defroster suction line, Condensation dripping from AC hose
BS5379E
Service Bulletin/Repair Instructions
P-clamps holding the transmission coolant pipes can break and cause coolant leaks.
BS5320ER1
Service Bulletin/Repair Instructions
Fire light coming on in the dash, Fire detection system
BS5357E
Service Bulletin/Repair Instructions
Lexan panels cracking at mounting holes. Need to change the attachment of Lexan panels due to apparent cracks.
BS5320E
Service Bulletin/Repair Instructions
Fire light coming on in the dash. Addition of a bracket so water wonât drip on temperature sensor.
BS5299E
Service Bulletin/Repair Instructions
HVAC deflectors are breaking at the folded attachment points. The brackets broke right at the bending due to a sharp curve
FT5239
Service Bulletin/Repair Instructions
Spheros Maintenance Access
LI5170E
Service Bulletin/Repair Instructions
New lower shock mount available with an adapter plate better suited for the front and rear axle.
BS5165ER1
Service Bulletin/Repair Instructions
MCC Driver's Display Electrical Terminal Failure.
FT5184
Service Bulletin/Repair Instructions
Safety Vision Camera system connection issues
BS5067E
Service Bulletin/Repair Instructions
The door interlock gets unexpectedly activated as a result of emergency release valve connector intermittent contacts and the driver is no longer able to move the bus, therefore causing OOS condition & road calls.
BS5082E
Service Bulletin/Repair Instructions
The tell-tale light for the ''Brake worn out'' is actually non-functionnal.
BS5079E
Service Bulletin/Repair Instructions
A 12V relay is installed instead of a 24V relay for the alternator ouput status signal
BS5037E
Service Bulletin/Repair Instructions
Quality issue identified by ZF on 20 screws used for rear axle flange shaft connection. The rework shall be done within next scheduled maintenance or service work.
FT5044
Service Bulletin/Repair Instructions
CATA Operator's Complain of Seat Alarm Sensitivity
FT4867R3
Service Bulletin/Repair Instructions
Hydraulic Level Sensor Defective, failures or intermittent Low hydraulic light coming on in service. Sensor failing intermittently this is the new stainless steel improved sensor. Replace sensor by Fozmula.
BS4970ER1
Service Bulletin/Repair Instructions
Destination sign doors latches may become loose or fail.
LI3978E
Service Bulletin/Repair Instructions
Information about the engine coolant. Coolant types should not be mixed in the engine.
LI5011E
Service Bulletin/Repair Instructions
Recommendations on the disinfection of vehicles as well as products and precautions to be taken.
FT5015
Service Bulletin/Repair Instructions
Design error/Current position of switch can cause a road call. Terminals grounding on bracket. Need to rotate switch 180* to move contacts away from bracket
ft5016
Service Bulletin/Repair Instructions
Front door air dump valve screws loosen up and prevent operation of valve. Need to add blue loctite
FT4867R2
Service Bulletin/Repair Instructions
Hydraulic level sensor defective
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.