FT5567
Service Bulletin/Repair Instructions
Battery Unbalanced Light Logic with AGM Battery.
Vehicle report
2020 NOVA BUS LFS
Service bulletins
70 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
FT5550
Service Bulletin/Repair Instructions
The Parker PHD70 display might freeze or not work properly.
FT5554
Service Bulletin/Repair Instructions
The Cabin Coolant Level Sensors for the LOW and HIGH levels are swapped.
LI5316ER2
Service Bulletin/Repair Instructions
Crank case vent (CCV) hoses may get damaged over time.
BS5543E
Service Bulletin/Repair Instructions
Battery tray structure cracks due to thin sheet metal.
BS5468E
Service Bulletin/Repair Instructions
Driver barrier door stanchion hardware loose, missing, or broken.
FT5536
Service Bulletin/Repair Instructions
Battery Tray Structure Cracks. Battery hold downs may slip between batteries.
LI5427E
Service Bulletin/Repair Instructions
Improved durability of engine-side heat exchanger hoses.
BS5469E
Service Bulletin/Repair Instructions
The belt guard hinge may crack.
FT5514
Service Bulletin/Repair Instructions
Upper door shaft nut may get loose.
FT5510E
Service Bulletin/Repair Instructions
Lower door shaft nut may get loose.
BS5447E
Service Bulletin/Repair Instructions
Rework allied motion e-Steering motor. 24V e-steering power supply threads length tolerances are not respect to standard.
FT5448
Service Bulletin/Repair Instructions
Rework allied motion e-Steering motor. 24V e-steering power supply threads length tolerances might not be respecting to the drawing specifications.
LI5485E
Service Bulletin/Repair Instructions
Introduction of headlight N109645 to replace N71373. The new headlight is interchangeable and offers better protection against water intrusion. It is possible to replace only one headlight if necessary.
FT5465
Service Bulletin/Repair Instructions
Erroneous Fault Codes reporting on the AVM System of Clever Devices.
FT5409
Service Bulletin/Repair Instructions
A bad connection at the ZF transmission connector may cause the transmission to jerk when shifting or show the fault code 188.
FT4651
Service Bulletin/Repair Instructions
Failure of DEF sensor GEN 6 within the expected 5-years lifespan.
FT5404E
Service Bulletin/Repair Instructions
There is a potential restriction of fluid due to an improperly placed clamp which could cause the power steering system to not operate has intended.
FT5437
Service Bulletin/Repair Instructions
The supplier Lift-U recommends the addition of a detection delay to prevent wrong fault code in the AVM.
BS5381E
Service Bulletin/Repair Instructions
P-clamps holding the transmission coolant pipes can break and cause coolant leaks.
BS5320ER1
Service Bulletin/Repair Instructions
Fire light coming on in the dash, Fire detection system
BS5356E
Service Bulletin/Repair Instructions
Lexan panels cracking at mounting holes. Need to change the attachment of Lexan panels due to apparent cracks.
FT5361
Service Bulletin/Repair Instructions
Coolant pipe assy failing. The adaptor on the Coolant pipe assembly between the engine and circulation pump broke in service at the beginning of the copper thread.
APS5370E
Service Bulletin/Repair Instructions
The Delco-Remy alternator is obsolete. Air cooled ductless (Almott) alternator, power cable and hardware kit to replace the Delco-Remy oil-cooled alternator.
FT5294E
Service Bulletin/Repair Instructions
Secure wiring and add wiring protection to avoid chafing/abrasion of wiring harness of the E-compressor.
FT5145R1
Service Bulletin/Repair Instructions
Due to the lack of bonding surface between the two large roof top panels, when thermal expansion and contraction occur these panels separate and leave an opening
FT5360
Service Bulletin/Repair Instructions
Reposition Electrical Air Compressor cooling hose to avoid chafing/abrasion.
BS5322E
Service Bulletin/Repair Instructions
The anchor bolt of one of the auxiliary heater high voltage cable retaining collar may come into contact with one of the coolant pipes under certain conditions.
FT5321
Service Bulletin/Repair Instructions
The anchor bolt of one of the auxiliary heater high voltage cable retaining collar may come into contact with one of the coolant pipes under certain conditions.
FT5328
Service Bulletin/Repair Instructions
Leveling valve N92260 found out of adjustment
LI5316ER1
Service Bulletin/Repair Instructions
Crank case vent (CCV) hoses may get damaged over time.
li5316E
Service Bulletin/Repair Instructions
Crank case vent (CCV) hoses may get damaged over time.
BS5320E
Service Bulletin/Repair Instructions
Fire light coming on in the dash. Addition of a bracket so water wonât drip on temperature sensor.
LI5315E
Service Bulletin/Repair Instructions
On the Thermo King HVAC roof unit, after replacing the actuator N8897109, some customers could see the error code 36.
BS5300E
Service Bulletin/Repair Instructions
HVAC deflectors are breaking at the folded attachment points. The brackets broke right at the bending due to a sharp curve
FT5298R1
Service Bulletin/Repair Instructions
Issue with the Fast Idle function
BS5283E
Service Bulletin/Repair Instructions
Roof fairing bracket cracking. New improve roof fairing bracket available for service.
FT5273
Service Bulletin/Repair Instructions
Bitzer AC compressor electrical failure
FT5239
Service Bulletin/Repair Instructions
Spheros Maintenance Access
LI5164E
Service Bulletin/Repair Instructions
MCC Driver's Display Electrical Terminal Failure. Bracket installation to add a strain relief on the MCC display screen wires.
LI5170E
Service Bulletin/Repair Instructions
New lower shock mount available with an adapter plate better suited for the front and rear axle.
BS5165ER1
Service Bulletin/Repair Instructions
MCC Driver's Display Electrical Terminal Failure.
FT5198R1
Service Bulletin/Repair Instructions
Water Inside Roof Fuse Box
LI5206E
Service Bulletin/Repair Instructions
A faulty coupler could prevent reception of the GPS signal and result in no stop announcements.
LI5185E
Service Bulletin/Repair Instructions
Cummins has issued a Temporary Repair Practice: TRP2484 â ECM Calibration for DEF Header Sensor Failures due to Parts Shortage TRP allowing temporary calibration of the engine ECM in the event of the DEF sensor failure and repeated error codes.
FT5218
Service Bulletin/Repair Instructions
e-steering fault light on Parker screen
FT5184
Service Bulletin/Repair Instructions
Safety Vision Camera system connection issues
BS5067E
Service Bulletin/Repair Instructions
The door interlock gets unexpectedly activated as a result of emergency release valve connector intermittent contacts and the driver is no longer able to move the bus, therefore causing OOS condition & road calls.
BS5146E
Service Bulletin/Repair Instructions
Engine could crank when fuel door is open
BS4934ER1
Service Bulletin/Repair Instructions
Fiber material should be Woven Aramid Fabric, but some parts have knitted Aramid.
BS5082E
Service Bulletin/Repair Instructions
The tell-tale light for the ''Brake worn out'' is actually non-functionnal.
bs5117
Service Bulletin/Repair Instructions
The door alarm comes on when the air is released on the main door valve. The alarm does not reset/turn off even when the air is applied again.
ft5084
Service Bulletin/Repair Instructions
Missing washers on the cover shade Dash
BS5079E
Service Bulletin/Repair Instructions
A 12V relay is installed instead of a 24V relay for the alternator ouput status signal
BS5083E
Service Bulletin/Repair Instructions
Missing washers on the cover shade Dash
FT5073
Service Bulletin/Repair Instructions
Clamps are too small for the elbow of the CAC pipe
ft5090
Service Bulletin/Repair Instructions
Kidde fire suppression system tamper seal
BS4972ER1
Service Bulletin/Repair Instructions
Reports of intermittent low oil level telltale alarms when oil level is adequately filled. Replacement of Hydraulic Oil Level Sensor.
FT5063
Service Bulletin/Repair Instructions
Hydraulic pipe brazing may fail. Replace pipe.
FT4389R1
Service Bulletin/Repair Instructions
ITS Box Shelves Loose
BS5037E
Service Bulletin/Repair Instructions
Quality issue identified by ZF on 20 screws used for rear axle flange shaft connection. The rework shall be done within next scheduled maintenance or service work.
FT5044
Service Bulletin/Repair Instructions
CATA Operator's Complain of Seat Alarm Sensitivity
FT4867R3
Service Bulletin/Repair Instructions
Hydraulic Level Sensor Defective, failures or intermittent Low hydraulic light coming on in service. Sensor failing intermittently this is the new stainless steel improved sensor. Replace sensor by Fozmula.
LI3978E
Service Bulletin/Repair Instructions
Information about the engine coolant. Coolant types should not be mixed in the engine.
LI5011E
Service Bulletin/Repair Instructions
Recommendations on the disinfection of vehicles as well as products and precautions to be taken.
FT5015
Service Bulletin/Repair Instructions
Design error/Current position of switch can cause a road call. Terminals grounding on bracket. Need to rotate switch 180* to move contacts away from bracket
ft5016
Service Bulletin/Repair Instructions
Front door air dump valve screws loosen up and prevent operation of valve. Need to add blue loctite
FT4971
Service Bulletin/Repair Instructions
The AC ON tell tale only turns on 10 seconds and then it turns off. The Compressor and the unit are working properly, but the AC light is not staying ON for the duration of the compressor ON cycle.
BS4934E
Service Bulletin/Repair Instructions
CAC elbow hose failures. Fiber material should be Woven Aramid Fabric, but some parts have knitted Aramid. Installation of new elbow.
BS4903E
Service Bulletin/Repair Instructions
Wheel chair access ramp does not operate under the actual VBEA program.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.