26V573000
ENGINE AND ENGINE COOLING:COOLING SYSTEM Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2023-2024 LFS Artic and 2022-2024 LFS buses. The coolant sensor could send a false signal, causing the engine to shut down.
Remedy: Nova Bus will inspect and replace the coolant sensor as necessary, free of charge. Owner notification letters are expected to be mailed November 2, 2026. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5936. This recall supersedes Recall 24V873. Vehicles repaired under the previous recall will need the new repair completed.
26V355000
SERVICE BRAKES, AIR:SUPPLY:LOW PRESSURE WARNING:SWITCH Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 1997-2002, 2005-2024 LFS, 2009-2014, and 2016 - 2024 LFS Artic transit buses. The low brake air pressure warning light may fail to illuminate when the engine is off. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
Remedy: Nova Bus will update the firmware, free of charge. Interim owner notification letters explaining the safety risk were mailed by July 17, 2026. Owners will receive another notice once remedy becomes available. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5918. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 2, 2026.
26V300000
VISIBILITY:GLASS, SIDE/REAR Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2020 LFS Artic and 2019-2023 LFS transit buses. The driver's speaker hole door may have been built with the prime glazing manufacturer DOT code mark missing. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 205, "Glazing Materials."
Remedy: Nova Bus will replace the plastic panel door, free of charge. Interim owner notification letters explaining the safety risk were mailed by July 7, 2026. Owners will receive another notice once remedy becomes available. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5884. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 23, 2026.
26V275000
ELECTRICAL SYSTEM:PROPULSION SYSTEM:HYBRID MANAGEMENT:POWER CONTROL UNIT/MODULE (HPCU) Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2025 LFS transit buses. The telemetry control unit installed in parallel with the vehicle monitoring system may cause a data overload.
Remedy: Nova Bus will modify the connection configuration and update the software, free of charge. Owner notification letters are expected to be mailed June 29, 2026. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5882. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning June 29, 2026.
26V182000
SEAT BELTS:FRONT Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2016-2018, 2020, 2022-2023 LFS and 2019-2020 LFS Artic transit buses. The driver's seat belt tension-reliving device may fail to disengage without manual intervention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Remedy: Nova Bus will remove the seat belt tension-reliving device, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5873. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 23, 2026.
25V476000
STEERING:ELECTRIC POWER ASSIST SYSTEM Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2023 LFS transit buses. The electric power steering system may be missing a check valve, allowing hydraulic pressure to turn the steering wheel without the driver's input.
Remedy: Nova Bus will install a check valve, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5746.
25V368000
EXTERIOR LIGHTING:TURN SIGNAL Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 LFS buses. A digital display firmware error may cause the instrument panel indicator lights to remain solidly illuminated even when the turn signal are off. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy: Nova Bus will update the digital display firmware, free of charge. Owner notification letters were mailed on July 7, 2025. Nova Bus's number for this recall is CR5732.
25V213000
ELECTRICAL SYSTEM:WIRING Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 LFS transit buses. The engine wiring harness may be the incorrect length, which can result in harness damage and a loss of drive power.
Remedy: Nova Bus will install a wire extension kit, free of charge. Owner notification letters are expected to be mailed February 3, 2026. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus's number for this recall is CR5719.
25V184000
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 Nova Bus LFS transit buses. The high voltage batteries may have loose hardware that can fall inside the battery pack and create a short circuit.
Remedy: Nova Bus will replace the batteries, free of charge. Owner notification letters were mailed June 5, 2025. A second letter will be sent once the remedy is available. Owners may contact Nova Bus customer service at 800-350-6682. Nova Bus's number for this recall is CR5687.
24V907000
EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR RESTRAINTS/SECUREMENT:CRITICAL FASTENERS Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2024 LFS buses. The wheelchair securement system may have been installed with the attachment points in the incorrect locations.
Remedy: Nova Bus will reinstall securement system, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus at 1-866-870-2046. Nova Bus's number for this recall is CR5674.
24V873000
ENGINE AND ENGINE COOLING:COOLING SYSTEM Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2023 LFS Artic and 2022-2024 LFS buses. The coolant sensor could send a false signal, causing the engine to shut down.
Remedy: Nova Bus will inspect and replace the coolant sensor as necessary, free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5668.
24V647000
SEAT BELTS:FRONT Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2010-2020 LFS Artic and 2012-2024 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
Remedy: Nova Bus will install additional seat stoppers to the driver's rear partition, free of charge. Owner notification letters are expected to be mailed July 4, 2025. Nova's number for this recall is CR5635. This recall expands and replaces previous recall number 23V-350. Vehicles that were previously recalled under 23V-350 will need to have the new remedy completed.
24V727000
ELECTRICAL SYSTEM:SOFTWARE Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 LFS buses. A software error may cause the Vehicle Control Unit (VCU) to crash, disconnecting the high voltage batteries and causing a loss of drive power.
Remedy: Nova Bus will validate and update the VCU software, free of charge. Owner notification letters were mailed November 2, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5643.
24V657000
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to not function properly.
Remedy: Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637.
24V564000
VISIBILITY:GLASS, SIDE/REAR Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2023 LFS and 2019-2020 LFS Arctic buses. The glazing used on the glass windows may reduce the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."
Remedy: Nova Bus will inspect the vehicles and replace the driver shield glazing as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5626.
24V518000
PARKING BRAKE:CONVENTIONAL:AIR Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2021-2024 LFS and 2021-2023 LFS Artic buses. An air leak may occur in the parking brake valve and unintentionally engage the parking brake without activating the brake lights.
Remedy: Nova Bus will inspect and tighten the parking brake air line connections, free of charge. Owner notification letters were mailed July 24, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5615.
24V519000
VISIBILITY:WINDSHIELD WIPER/WASHER Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 LFS buses. The windshield wiper arms may be incorrectly aligned, which can cause the wiper blades to collide.
Remedy: Nova Bus will inspect and realign the wiper blades, free of charge. Owner notification letters were mailed September 10, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5615.
24V421000
ELECTRICAL SYSTEM Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 LFS buses. The ground connection on the bus bar in the HVAC roof unit may not be secured properly, which can result in an unexpected engine shutdown or an overheated ground connection.
Remedy: Nova Bus will inspect and tighten the ground connection on the bus bar, free of charge. Owner notification letters were mailed July 24, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5605.
24V328000
FUEL SYSTEM, DIESEL:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2022-2023 LFS vehicles. Insufficient crimping may allow the secondary fuel filter hoses to disconnect and leak.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will replace the secondary fuel filter hoses, free of charge. Owner notification letters were mailed July 05, 2024. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5595.
24V231000
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2024 LFS vehicles. The engine coolant return hose may fail, leaking coolant and causing an engine shutdown.
Remedy: Nova Bus will replace the engine coolant return hose, free of charge. Owner notification letters were mailed July 03, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus number for this recall is CR5577.
24V203000
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2021-2022 LFS Artic and 2021-2023 LFS buses. The alternator power cable nut may not have been tightened properly.
Remedy: Nova will inspect and tighten the power cable nut as necessary, free of charge. Owner notification letters were mailed April 10, 2024. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5570.
24V174000
ELECTRICAL SYSTEM:WIRING:SWITCHES/KNOBS/BUTTONS Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2022-2023 LFS vehicles. Missing electrical components may prevent the battery disconnect switch from functioning.
Remedy: Nova will install additional wiring and relay, free of charge. Owner letters were mailed May 15, 2024. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5566.
23V762000
EXTERIOR LIGHTING:TURN SIGNAL Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2021-2023 LFS transit buses equipped with a directional foot switch. The turn signals may intermittently become inoperative.
Remedy: Nova Bus will inspect and repair the directional foot switch wiring, as necessary, free of charge. Owner notification letters were mailed December 4, 2023. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5507.
23V763000
EQUIPMENT:APPLIANCE:AIR CONDITIONER Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2023 LFS and LFS Artic transit buses. The brackets retaining the Mobile Climate Control HVAC Unit could fail and allow the unit to detach from the bus.
Remedy: Nova Bus will inspect the existing brackets and install additional brackets, as necessary, free of charge. Owner notification letters were mailed December 20, 2023. Owners may contact Nova Bus customer service at 1-800-350-6882. Nova Bus's number for this recall is CR5508.
23V607000
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2017-2023 LFS and 2017-2022 LFS Artic transit buses. The 24-volt power cable and grounded mounting fastener that secures the fuse holder may short circuit.
Remedy: Nova will insect, remove, and clean the fuse holder and cable lugs as necessary, free of charge. Owner letters were mailed November 7, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5445. This recall replaces and expands recall number 22V-416. Vehicles previously repaired under recall 22V-416 will need to have the new remedy completed.
23V540000
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2022-2023 LFS battery electric transit buses. The rivnut threaded inserts inside the high-voltage battery may be over-tightened and break, which could result in a short circuit.
Remedy: Nova Bus will replace the batteries, free of charge. Owner notification letters were mailed September 5, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5461.
23V481000
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2022-2023 LFS transit buses. During the hose manufacturing, the power steering hose may not have been assembled correctly, which can result in hose fitting detachment and a loss of power steering assist.
Remedy: Nova Bus will inspect and replace the power steering hoses, as necessary, free of charge. Owner notification letters were mailed August 10, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5451. This recall is an expansion of recall number 23V-054.
23V482000
POWER TRAIN:DRIVELINE:DRIVESHAFT Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2019-2023 LFS and LFS Artic transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Remedy: Dealers will inspect the output yoke bolts, and if necessary, tighten loose output yoke bolts, free of charge. Phase 1 will include 2019-2023 LFS vehicles. Nova notified dealers on 10/03/2024 and notified Phase 1 owners on 10/27/2024. Phase 2 will include 2019-2020 LFS Artic vehicles. Interim letters informing owners of the safety risk were mailed on October 27, 2023. A second notice will be mailed to Phase 2 owners once the remedy is available, expected in January 2025. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5442.
23V350000
SEAT BELTS:FRONT Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2012-2022 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."
Remedy: Dealers will adjust the recline angle of the seat-back rest, or add a spacer on the driver's seat, as necessary, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5419.
23V291000
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:THERMAL MANAGEMENT:FLUID/COOLANT Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022-2023 LFS battery electric transit buses. The coolant line in the high voltage battery pack may not be fully seated and locked, which can result in the loss of coolant and an electrical short circuit.
Remedy: Nova Bus will work with Akasol, the battery pack manufacturer to inspect the battery packs, and replace them as necessary, free of charge. Owner notification letters were mailed May 23, 2023. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5406.
23V239000
EXTERIOR LIGHTING:TAIL LIGHTS Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2022 LFS vehicles. The taillights may fail to illuminate when the headlights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Remedy: Nova Bus will update the vehicle software, free of charge. Owner notification letters were mailed April 24, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5397.
23V054000
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS Recall
Nova Bus (US) Inc. (Nova) is recalling certain 2022 LFS transit buses. During assembly, the power steering hose may not have been assembled correctly, which can result in hose detachment and a loss of power steering assist.
Remedy: Nova Bus will inspect and replace the power steering hoses, as necessary, free of charge. Owner notification letters were mailed March 6, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's numbers for this recall are CR5374 and CR5375.
22V845000
STEERING:CRITICAL FASTENERS Recall
Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.
Remedy: Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, 2022, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5342.