02-160
Service Bulletin/Repair Instructions
Information Only â Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
Vehicle report
2007 PETERBILT 320
Service bulletins
17 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
43-067
Service Bulletin/Repair Instructions
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (âSOCâ) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the exhaust stack to rotate and contact the cab or sleeper.
32-015
Service Bulletin/Repair Instructions
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
11-001
Service Bulletin/Repair Instructions
Information only: Hendrickson Softek front axle maintenance intervals and requirements.
32-016
Service Bulletin/Repair Instructions
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
34-085
Service Bulletin/Repair Instructions
Information Only â Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
02-153
Service Bulletin/Repair Instructions
Information only: Some model 320 and 520 vehicles built before 3/11/2019 may experience loss or loosening of doghouse insulation. Reference the procedure in the attachment section to properly remove and replace the insulation.
01-075
Service Bulletin/Repair Instructions
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
19PBC
Service Bulletin/Repair Instructions
Safety Recall: Vehicles fail to confirm with FMVSS/CMVSS No 108 Table 1-a requirements which requires 2 red stop lamps. Vehicles were equipped with additional amber stop lamps which may illuminate when the brake is applied, and may confuse other drivers. Resolution is to remove the amber stop lamps and associated wiring.
34-066
Service Bulletin/Repair Instructions
Information Only - Quick Reference Guide for Electric harness damage repairs.
34-077
Service Bulletin/Repair Instructions
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
13-049
Service Bulletin/Repair Instructions
Information: Bendix ACOM Software version 6.16.5.0 for diagnostics may introduce an unrecoverable error. Notice to dealers to replace this version with older software version until Bendix introduces new version.
03-064
Service Bulletin/Repair Instructions
Information - Recommended Practices for Updating ESA Software
15-16
Service Bulletin/Repair Instructions
Fix-As-Fail: Repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.
8110
Service Bulletin/Repair Instructions
CUMMINS ISX, OR CUMMINS ISM ENGINES EXPERIENCING A PREMATURE FAILURE OF THE FAN HUB BEARINGS. *KB
FRN-808-1
Service Bulletin/Repair Instructions
PETERBILT TRUCKS: THE ELECTRICAL SYSTEM MAY SHUT DOWN DUE TO A POWER SURGE. WHEN THIS OCCURS, THE GREEN LIGHT ON THE COMFORTCLASS CONTROL PANEL TURNS TO RED. *PE
408-2
Service Bulletin/Repair Instructions
PETERBILT SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. MODEL 320 LOW COOLANT SENSOR. THIS FIELD REPAIR NOTICE IS APPLICABLE TO CERTAIN PETERBILT MODEL 320 VEHICLES BUILT BETWEEN OCTOBER 4, 2007 AND JANUARY 24, 2008 WITH CATERPILLAR C13 ENGINES. CSC WAS RECEIVED. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.