34-074
Service Bulletin/Repair Instructions
The current chassis harness connector contains a wire that is no longer necessary with the latest electrical architecture. The presence of the wire could result in a false fault code.
Vehicle report
2012 PETERBILT 520
Service bulletins
14 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
02-160
Service Bulletin/Repair Instructions
Information Only â Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter.
43-067
Service Bulletin/Repair Instructions
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (âSOCâ) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the exhaust stack to rotate and contact the cab or sleeper.
32-015
Service Bulletin/Repair Instructions
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
11-001
Service Bulletin/Repair Instructions
Information only: Hendrickson Softek front axle maintenance intervals and requirements.
18PBB
Service Bulletin/Repair Instructions
Safety Recall Bulletin: Updated with permanent repair path for phase 1 vehicles. The Tractor ABS Lamp May Not Illuminate When ABS Controller Loses Battery and/or Ignition Power. NHTSA recall number is 18V368. Non compliance to FMVSS and CMVSS 121 and 136. Resolution is to Reflash software.
32-016
Service Bulletin/Repair Instructions
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
34-085
Service Bulletin/Repair Instructions
Information Only â Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead to water intrusion and corrosion in some vehicles.
03-071
Service Bulletin/Repair Instructions
Information Only - Vehicles built with NAMUX software from 2013 to present may experience accuracy issues with the tachometer. The issue can be temporarily resolved using any one of the included procedures.
02-153
Service Bulletin/Repair Instructions
Information only: Some model 320 and 520 vehicles built before 3/11/2019 may experience loss or loosening of doghouse insulation. Reference the procedure in the attachment section to properly remove and replace the insulation.
01-075
Service Bulletin/Repair Instructions
Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor.
02-154
Service Bulletin/Repair Instructions
Fix as Fail: Some model 520 right hand stand up vehicles built before 07/16/19 are experiencing washer fluid leakage from the windshield reservoir through the vent line. Resolution is to replace the current washer fluid line with a longer length.
TIB43-062
Service Bulletin/Repair Instructions
Information Only â This bulletin provides information about the California Air Resources Board (CARB) Periodic Smoke Inspection Program (PSIP) and Heavy Duty Vehicle Inspection Program (HDVIP).
42-058
Service Bulletin/Repair Instructions
Fix-As-Fail: Two separate causes have been identified as root cause of intermittent low coolant indicator illumination.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.