Vehicle report

2024 RAM 3500

Compare every RAM 3500 yearNHTSA and EPA records

Service bulletins

291 bulletins

Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.

9100901

Service Bulletin/Repair Instructions

Passive Entry O/S Dr Handle Prior to replacing an inoperative passive entry door handle, perform Star Online S2623000040.

9100892

Service Bulletin/Repair Instructions

Switch - Tailgate Handle Prior to replacing the Tailgate Handle Switch, please review MasterTech Article - Tailgate Handle Inoperative.

S2623000052 REV. A

Service Bulletin/Repair Instructions

Airbag Warning Light On or Intermittent. The Occupant Restraint Controller (ORC) May Have The Following DTCs (Active/Stored)

114254

Service Bulletin/Repair Instructions

RADIATOR - ENGINE COOLING

114255

Service Bulletin/Repair Instructions

RADIATOR - ENGINE COOLING

113854

Service Bulletin/Repair Instructions

SWITCH AND BEZEL - FRONT DOOR

113855

Service Bulletin/Repair Instructions

SWITCH AND BEZEL - FRONT DOOR

113742

Service Bulletin/Repair Instructions

SENSOR - TURBOCHARGER SPEED

113744

Service Bulletin/Repair Instructions

SENSOR - TURBOCHARGER SPEED

08-272-26 REV. A

Service Bulletin/Repair Instructions

Air Handling Performance Test (APT) Availability In wiTECH Technicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0234-00 - Turbocharger Overboost Condition. ● P0299-00 - Turbocharger Underboost. ● P0101-00 - Mass Air Flow Sensor "A" Circuit Performance. ● P2463-00 - Diesel Particulate Filter Restriction - Soot Accumulation Bank 1. ● P24A4-00 - Particulate Filter Restriction - Soot Accumulation Too High. ● P2262-00 - Turbocharger Boost Pressure Not Detected - Mechanical. ● P0471-00 - Exhaust Pressure Sensor 1 Performance. ● P1451-00 - Diesel Particulate Filter System Performance. ● P2457-00 - Exhaust Gas Recirculation Cooling System Performance. ● P2263-00 - Turbo Boost System Performance. ● P2459-00 - Diesel Particulate Filter Regeneration Too Frequent. ● P24A2-00 - Diesel Particulate Filter Regeneration Incomplete - Bank 1. ● P0401-00 - EGR System Performance. ● P0402-00 - EGR Flow Excessive Detected.

08-272-26

Service Bulletin/Repair Instructions

113292

Service Bulletin/Repair Instructions

INJECTOR - FUEL

113293

Service Bulletin/Repair Instructions

INJECTOR - FUEL

113276

Service Bulletin/Repair Instructions

CORE – HEATER

113277

Service Bulletin/Repair Instructions

CORE – HEATER

9100803 Rev 3

Service Bulletin/Repair Instructions

Front Fog Lamp RT 1) If the lamp contains moisture, do not replace it immediately. Turn the fog lamp on for one hour and inspect it afterward. Refer to 23-008-25 Rev.A. Exterior Front Lamps Condensation Clearing Procedure for details. 2) If the fog lamp(s) do not light. Refer to Star Online Publication S2523000085 for details.

S2508000025 REV. B

Service Bulletin/Repair Instructions

Instrument Panel Cluster (IPC) and Radio Compass Display has Dashes (--)

113069

Service Bulletin/Repair Instructions

SWITCH – HEADLAMP

113070

Service Bulletin/Repair Instructions

SWITCH – HEADLAMP

9100803 Rev 1

Service Bulletin/Repair Instructions

1) If the lamp contains moisture, do not replace it immediately. Turn the fog lamp on for one hour and inspect it afterward. Refer to 23-008-25 Rev.A. Exterior Front Lamps Condensation Clearing Procedure for details. 2) If the fog lamp(s) do not light. Refer to Star Online Publication S2523000085 for details.

S2208000045 REV.D

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

S2508000025 REV.A

Service Bulletin/Repair Instructions

Instrument Panel Cluster (IPC) and Radio Compass Display has Dashes (--)

S2623000047

Service Bulletin/Repair Instructions

Blind Spot Alert Trailer Type Conventional Goose / 5th Displays On Cluster. Cannot Select Trailer Type.

113065

Service Bulletin/Repair Instructions

OUTLET - AIR CONDITIONING & HEATER

113066

Service Bulletin/Repair Instructions

OUTLET - AIR CONDITIONING & HEATER

9100841 Rev 1

Service Bulletin/Repair Instructions

If customer concern diagnosis leads to suspect u-joint issue with the prop shaft, u-joint service kit should be utilized to fix concern. Prop shaft replacement would not be required.

112906

Service Bulletin/Repair Instructions

BEARING - CRANKSHAFT THRUST and KIT

9100841

Service Bulletin/Repair Instructions

HD Front and Rear Prop Shafts Increase U-Joint Usage If customer concern diagnosis leads to suspect u-joint issue or failure with the prop shaft, u-joint service kit should be utilized to fix concern. Prop shaft replacement would not be required.

S268A000014

Service Bulletin/Repair Instructions

Radio/ETM is Adding Approximately 27mA Draw to Vehicle When in Logistics Mode

S1623000028 Rev. K

Service Bulletin/Repair Instructions

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

9100835

Service Bulletin/Repair Instructions

Prior to replacing an inoperative passive entry door handle, perform Star Online S2623000040.

S1623000028 REV.J

Service Bulletin/Repair Instructions

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

S2623000040

Service Bulletin/Repair Instructions

Passive Entry Exterior Door Handle Inoperative When Touched To Lock And Or Unlock.

9100831

Service Bulletin/Repair Instructions

For Dealer awareness, HD truck, eliminate 1 of 2 M8 Joints for Sidestep bracket to Body Attachment, Bolt and rivet (06102165AA, 06511062AA) per TCR # 402632, CN 80403-T18

S1623000028 REV.I

Service Bulletin/Repair Instructions

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

111478

Service Bulletin/Repair Instructions

RADIATOR - ENGINE COOLING

9100692 Rev 1

Service Bulletin/Repair Instructions

On Cummins diesel applications that are for 2019 and newer the bpro part 1BP00507AB can on occasions create a check engine light. In these situations, it is recommended to use the appropriate Mopar air filter originally installed on the vehicle. The "AC" level of the part is in development to resolve this issue. 1BP00507AB should still be usable for 2018 and older Model year Cummins engines.

9100820

Service Bulletin/Repair Instructions

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders, Warranty, Mopar, Customer Pay and Service Contract. Order "68" part number for New, Unsold units only.

08-208-26 REV. A

Service Bulletin/Repair Instructions

Radio Message "Power Surge On USB Detected" Customers may comment on the following: ● The radio displays the message: “Power surge on USB hub detected” Fig. 1. NOTE: After the message appears, no USB devices function in the hub (no charging, no data). NOTE: Hub operation does not return until the vehicle undergoes a full key cycle.

08-208-26

Service Bulletin/Repair Instructions

08-207-26

Service Bulletin/Repair Instructions

Instrument Panel Cluster (IPC) Flicker Turn By Turn The customer may experience flickering on their Instrument Panel Cluster (IPC) when the turn-by-turn feature is enabled. This issue occurs when using Google Maps for Navigation via CarPlay

S268A000013

Service Bulletin/Repair Instructions

Radio Volume Jumping Up To Max Volume After Radio Wake Up

S2623000032

Service Bulletin/Repair Instructions

Squeak Or Squawk Noise Coming From Either Side Door Of The Vehicle, It Could Be Just One Door Or More. The Noise Can Be Present In Either The Upper Or The Lower Hinge.

S2308000034 REV.B

Service Bulletin/Repair Instructions

No Wireless Charging Or Slow Wireless Charging

9100803

Service Bulletin/Repair Instructions

1) If the fog lamp contains moisture, do not replace it immediately. Turn the fog lamp on for one hour and inspect it afterward. Refer to 23-008-25 Rev.A. Exterior Front Lamps Condensation Clearing Procedure for details. 2) If the fog lamp(s) do not light. Refer to Star Online Publication S2523000085 for details.

S2509000005 REV.B

Service Bulletin/Repair Instructions

Light Random Tick Noise From The Engine.

S2614000002

Service Bulletin/Repair Instructions

Diagnostic Trouble Code (DTC) P2459-00 Particulate Filter Regeneration Too Frequent Setting in the Powertrain Control Module (PCM) or Under Fueling or Over Fueling Condition After Fuel Injector(s) Replacement

08-143-26

Service Bulletin/Repair Instructions

Traffic Sign Assist Unavailable – Service Required The customer may experience one or more of the following: SYMPTOM: ● “Traffic Sign Assist Unavailable – Service Required” message and icon displays on the Instrument Panel Cluster (IPC). This occurs after a remote start and typically at the first start of the day. ● The Odometer flashes when the traffic alert message is active. . No part of this publication may be reproduced, stored in a retrieval system, or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise, without written permission of FCA US LLC.

S1623000028 REV.H

Service Bulletin/Repair Instructions

Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.

08-134-26

Service Bulletin/Repair Instructions

Universal Garage Door Opener (UGDO) Inoperable Technicians may or may not find the following Diagnostic Trouble Code (DTC) present: SYMPTOM: ● B251D1-00 - Universal Garage Door Opener Control. Customers may comment on the following: ● Operational questions regarding the usage of the HomeLink® UGDO. . No part of this publication may be reproduced, stored in a retrieval system, or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise, without written permission of FCA US LLC.

18-044-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0111-00 - Intake Air Temperature Sensor 1 Circuit Range Performance Bank 1. (In Active or Stored status) ● P0071-00 - Ambient Air Temperature Sensor Performance. (In Active or Stored status) ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. (In Active or Stored status) ● P0073-00 - Ambient Air Temperature Sensor Circuit "A" High. (In Active or Stored status) ● P0011-00 - Bank 1 Camshaft 1 Position Timing Over Advanced Or. (In Active or Stored status) ● P25E4-00 - B Camshaft Position - Unable To Achieve Locked Position Bank 1. (In Active or Stored status) ● P05BD-00 - Stop-Start Mode Switch Range/Performance. (In Active or Stored status) ● P0116-00 - Engine Coolant Temperature Sensor 1 Performance. (In Active or Stored status) ● P062B-00 - Internal Control Module Fuel Injector Control Performance. (In Active or Stored status) ● P0604-00 - Internal Control Module Random Access Memory Ram Error. (In Active or Stored status) ● P060C-00 - Internal Control Module Main Processor Performance. (In Active or Stored status)** ● P018B-00 - Fuel Pressure Sensor "B" Circuit Range/performance. **(In Active or Stored status)** ● P1CEA-00 - Boost Side EVAP Purge System Performance. **(In Active or Stored status)** ● P06DD-00 - Engine Oil Pressure Control Circuit Performance/Stuck Off. **(In Active or Stored status)** ● P00C6-00 - Fuel Rail Pressure Too Low - Engine Cranking. **(In Active or Stored status)** ● P0300-00 - Multiple Cylinder Misfire. **(In Active or Stored status)** Customers may also experience one or more of the following: ● **Oil Level High Warning in the Instrument Panel Cluster (IPC).** ● Fully Autonomous Parking Assist (FAPA) is not deactivated when accelerator pedal is pressed. ● Vehicle is not heating up fast enough at freezi

S2208000045 REV.C

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

S2523000070 REV.A

Service Bulletin/Repair Instructions

Central ADAS Decision Module (CADM) Diagnostic Trouble Codes C00C0-4A, C00C1-4A, C00C5-4A.

S2621000003 REV.A

Service Bulletin/Repair Instructions

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

18-036-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P208B-00 - Reductant Pump 1 Control Performance. ● P0128-00 - Thermostat Rationality. This bulletin involves reprogramming the PCM with the latest available software.

S2608000010

Service Bulletin/Repair Instructions

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

23-005-26

Service Bulletin/Repair Instructions

Windshield Wiper Blade Maintenance Customers may experience one or more of the following: SYMPTOM: ● Wiper blades that chatter/streak/jump/skip/smear or make noise while traveling across the windshield. . No part of this publication may be reproduced, stored in a retrieval system, or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise, without written permission of FCA US LLC.

S1408000384 REV.J

Service Bulletin/Repair Instructions

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

110599

Service Bulletin/Repair Instructions

SPEAKER - NONE

110600

Service Bulletin/Repair Instructions

SPEAKER - NONE

110603

Service Bulletin/Repair Instructions

SPEAKER - NONE

110604

Service Bulletin/Repair Instructions

SPEAKER - NONE

S268A000009

Service Bulletin/Repair Instructions

Customer States Navigation is Inaccurate, Showing Wrong City or State.

09-003-26

Service Bulletin/Repair Instructions

Cummins 6.7L Air Filter Replacement DTC P0299 Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set the following Diagnostic Trouble Code (DTC): ● P0299-00 - Turbocharger Underboost. Customers may also comment on the following: ● Low power/acceleration or lag condition. This bulletin involves performing an Air Handling Performance Test (APT) and possibly replacing the air filter.

110457

Service Bulletin/Repair Instructions

SENSOR - WHEEL SPEED

S228A000025 REV.A

Service Bulletin/Repair Instructions

Harman R1H Uconnect 5 Radio Software Flash Error Codes

S268A000008

Service Bulletin/Repair Instructions

Uconnect Box Requires Service, Please Visit an Authorized Dealer Message on Display Message With DTCs B1498-13, B1498-19 or B1570-93

S1923000010 REV.A

Service Bulletin/Repair Instructions

Floor Console Center Storage Bin Door Inoperable And Or Stuck Closed.

S2423000027 REV.D

Service Bulletin/Repair Instructions

Horn Sound Is Weak, Off Tone, Inoperative, Or Intermittent.

23-004-26

Service Bulletin/Repair Instructions

Outer Belt Molding Has Excessive Gap Customers may comment on the following: SYMPTOM: ● The outer belt molding appears warped or deformed causing a gap between the edge of the door and the molding. NOTE: This condition can appear on any of the doors. This bulletin involves replacing one or more door outer belt moldings.

9100591 Rev 1

Service Bulletin/Repair Instructions

Universal Garage Door Opener Prior to replacing the UGDO or sun visor, call HomeLink® Customer Care at 1-800-355-3515 for a proper evaluation of the issue. If this does not correct the issue, please follow the steps in SOL: S2508000039

S1408000384 REV.I

Service Bulletin/Repair Instructions

Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS Related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On

S268A000006

Service Bulletin/Repair Instructions

Hands-Free Voice Concerns Including No Voice Pickup, Muffled Audio, Distortion, or Intermittent Microphone Operation

S2623000006

Service Bulletin/Repair Instructions

Washer Fluid Warning Lamp Illuminated When Reservoir Is Full

110081

Service Bulletin/Repair Instructions

MODULE - TRAILER BRAKE & TOWING CONTROL

110082

Service Bulletin/Repair Instructions

MODULE - TRAILER BRAKE & TOWING CONTROL

S2308000120 REV.F

Service Bulletin/Repair Instructions

Rain Sensing Auto Wipers and Auto on Head Lamps Inoperative. Rain Sensor Internal Failure.

S2607000002

Service Bulletin/Repair Instructions

Hemi Water Pump Coolant Leak Inspection

18-004-26

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P1404 - EGR Close Position Performance. Customers may also comment on one or more of the following: ● Engine tugging. ● Unstable idle. This bulletin involves inspecting and possibly reprogramming the PCM with the latest available software.

S2610000001

Service Bulletin/Repair Instructions

Seatbelt Slow Retraction.

08-012-26

Service Bulletin/Repair Instructions

Speaker Diagnostic Procedure Rattle, buzz and squeak coming from specific speakers.

S2308000120 REV.E

Service Bulletin/Repair Instructions

Rain Sensing Auto Wipers and Auto on Head Lamps Inoperative. Rain Sensor Internal Failure.

S258A000025

Service Bulletin/Repair Instructions

Customer states Navigation is inaccurate, showing in wrong city or state.

08-394-25 REV. A

Service Bulletin/Repair Instructions

Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present Technicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● B1E21-96 - Backup Battery Component Internal Failure.

S2508000107

Service Bulletin/Repair Instructions

Comfort Seat Module (CSM) or Comfort Steering Wheel Module (CSWM) do Not Operate

9100734

Service Bulletin/Repair Instructions

If the DTC B1E21-96: Backup Battery-Component Internal Failure is active and customer states Popup message will show at the radio: "Battery of Uconnect Box requires service. SOS call and related functions may be unavailable. Please visit an authorized dealer." PLEASE do not Replace the TBM module, only replace TBM Internal Battery (inside Telematics Box Module) and order PN68493347

9100735

Service Bulletin/Repair Instructions

Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders: Warranty, Mopar, Customer pay and Service contract. Order"68" part number for New unsold units only

S2505000003

Service Bulletin/Repair Instructions

Diagnostic Trouble Code (DTC) C0050-00-Brake System Hydraulic Leak Set After Recent Repair.

08-394-25

Service Bulletin/Repair Instructions

Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present echnicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set the following Diagnostic Trouble Code (DTC): ● B1E21-96 - Backup Battery Component Internal Failure

S258A000021

Service Bulletin/Repair Instructions

Diagnostic Trouble Code (DTC) B15A1-00 Media Port Connection 1 Connection Found Set.

S2524000014

Service Bulletin/Repair Instructions

Heated Seats And Heated Steering Wheel Inoperative

08-374-25

Service Bulletin/Repair Instructions

Max Tow Right and Left Rear Wheel Speed Sensors Inoperable Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● C003A-62 - Right Rear Wheel Speed Sensor - Signal Compare Failure. ● C0037-62 - Left Rear Wheel Speed Sensor - Signal Compare Failure. ● C003A-2F - Right Rear Wheel Speed Sensor - Signal Erratic. ● C0037-2F - Left Rear Wheel Speed Sensor - Signal Erratic. Customers may experience one or more of the following: ● The check engine light illuminates. ● The ABS light illuminates. ● The traction control light illuminates. ● The forward collision warning lamps light illuminates. ● The 4WD unavailable message on the Instrument Panel Cluster (IPC). ● Vehicle might not shift from drive to park or vice versa. The vehicle safe hold systems are in place if the vehicle does not shift to park. ● Vehicle will not shut off. This bulletin involves replacing both rear wheel speed sensors.

S2308000034 REV.A

Service Bulletin/Repair Instructions

No Wireless Charging Or Slow Wireless Charging

108458

Service Bulletin/Repair Instructions

DETECTOR - EVAPORATIVE SYSTEM INTEGRITY MODULE

108461

Service Bulletin/Repair Instructions

DETECTOR - EVAPORATIVE SYSTEM INTEGRITY MODULE

9100727

Service Bulletin/Repair Instructions

When installing the new replacement pipe, do not remove or replace the O-ring that comes pre-installed on the new part. This O-ring is factory-fitted and must remain in place to ensure proper sealing and prevent leaks or fitment issues.

S2503000004

Service Bulletin/Repair Instructions

Front Axle Disconnect (FAD) Electrical Connector Design Change On Replacement Axle Assemblies.

108409

Service Bulletin/Repair Instructions

CORE - HEATER

108410

Service Bulletin/Repair Instructions

CORE - HEATER

21-012-25 REV. E

Service Bulletin/Repair Instructions

Not applicable to vehicles built for US market. Rear Selective Thrust Washer Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode This bulletin involves checking for DTCs and possibly replacing the transmission.

S2508000100

Service Bulletin/Repair Instructions

Intermittent Uconnect Box Requires Service Message. TBM Setting Stored Or Pending DTCs B22A9, B1560, B1561, B1562

9100678

Service Bulletin/Repair Instructions

1. General Parts Update The recommended air filter for 2019 Model Year (MY) and newer 6.7L Cummins equipped vehicles has been updated. New Part: 68645327AA (Non-Oiled Air Filter) Replaces: 53034051AA (Oiled Air Filter) - This part is superseded and should no longer be installed. The air filter for all other applications remains unchanged: Continue to use 68517554AA for: All 2018 MY and older 6.7L Cummins equipped vehicles. All 2019 MY and newer vehicles with non-6.7L engines. 2. Special Service Procedure for DTC P0299 Application: 2019-2024 MY HD Trucks with 6.7L Diesel (ETM/ETN) Condition: If DTC P0299 is active and the vehicle is equipped with the previous oiled air filter (PN# 53034051AA). Procedure: Replace the oiled air filter (53034051AA) with the new non-oiled filter (68645327AA). Service Catalog reflects these updated usages.

08-350-25

Service Bulletin/Repair Instructions

Air Handling Performance Test (APT) Availability In wiTECH Technicians may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0234-00 - Turbocharger Overboost Condition. ● P0299-00 - Turbocharger Underboost. ● P0101-00 - Mass Air Flow Sensor "A" Circuit Performance. ● P2463-00 - Diesel Particulate Filter Restriction - Soot Accumulation Bank 1. ● P24A4-00 - Particulate Filter Restriction - Soot Accumulation Too High. ● P2262-00 - Turbocharger Boost Pressure Not Detected - Mechanical. ● P0471-00 - Exhaust Pressure Sensor 1 Performance. ● P1451-00 - Diesel Particulate Filter System Performance. ● P2457-00 - Exhaust Gas Recirculation Cooling System Performance. ● P2263-00 - Turbo Boost System Performance. ● P2459-00 - Diesel Particulate Filter Regeneration Too Frequent. ● P24A2-00 - Diesel Particulate Filter Regeneration Incomplete - Bank 1. ● P0401-00 - EGR System Performance. ● P0402-00 - EGR Flow Excessive Detected

S2516000001

Service Bulletin/Repair Instructions

Driveline Vibration. Prop Shaft Diagnostic Information.

09-029-25

Service Bulletin/Repair Instructions

Cummins Valvetrain Noise Diagnostics Customers may comment on one or more of the following: ● Ticking noise. ● Clicking noise. ● Engine noise.

9100692

Service Bulletin/Repair Instructions

On Cummins diesel applications that are for 2019 and newer the bpro part 1BP00507AB can on occasions create a check engine light. In these situations, it is recommended to use the appropriate Mopar air filter (57008652AA). The "AC" level of the part is in development to resolve this issue. 1BP00507AB should still be usable for 2018 and older Model year Cummins engines.

S2522000003

Service Bulletin/Repair Instructions

Tire Pressure Monitor (TPM) Warning Lamp On Or Flashing. Sensor(s) Not Reading And Or Showing Dashes.

23-008-25 REV. A

Service Bulletin/Repair Instructions

Exterior Front Lamps Condensation Clearing Procedure *Some customers may report that on occasion vehicle exterior front lamps (headlamps, fog lamps, grille lamps, logo lamps or signature lamps) assemblies are fogged with a light layer of condensation on the inside of the lenses*

02-002-25 REV. A

Service Bulletin/Repair Instructions

Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.

S2509000005 REV.A

Service Bulletin/Repair Instructions

Light Random Tick Noise From The Engine

S2522000001

Service Bulletin/Repair Instructions

TPMS Handling & Installation Best Practices

S2522000002

Service Bulletin/Repair Instructions

Customer Indicates Tire Pressure Monitoring System (TPMS) Lights On Dash.

31-001-25 REV. B

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

31-001-25 REV. A

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

31-001-25

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates

S258A000019

Service Bulletin/Repair Instructions

Radio Does Not Turn On Automatically When Vehicle Is Started

9100642

Service Bulletin/Repair Instructions

When customer complaint is related to inoperative 4 Wheel Drive shifter, loss of 4WD function and/or 4WD related MIL please reference SOL Case #S2508000062 prior to replacement of Transfer Case shift motor.

S258A000017

Service Bulletin/Repair Instructions

Door speaker Inoperative or No Sound

S2508000062

Service Bulletin/Repair Instructions

Unresponsive 4WD Shifter, Service 4WD Light Illuminated. ABS And/Or Traction Control Lights May Also Be On

106241

Service Bulletin/Repair Instructions

LAMP - DOME

23-006-25 REV. B

Service Bulletin/Repair Instructions

Windshield Wiper Blade Maintenance Customers may experience one or more of the following: ● Wiper blades that chatter/streak/jump/skip/smear or make noise while traveling across the windshield.

S2523000072

Service Bulletin/Repair Instructions

Central ADAS Decision Module (CADM), Long Range Camera Front (LRCF), Advanced Driver Assist System (ADAS). AEB ACC FCW Message On Cluster.

S2422000001 REV.D

Service Bulletin/Repair Instructions

Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.

08-221-25

Service Bulletin/Repair Instructions

115V Power Outlet LED Always On The amber LED remains continuously illuminated, regardless of whether the switch button is activated. This bulletin involves replacing the inverter switch.

S2523000070

Service Bulletin/Repair Instructions

Central ADAS Decision Module (CADM) Diagnostic Trouble Codes C00C0-4A, C00C1-4A, C00C5-4A.

105648

Service Bulletin/Repair Instructions

MODULE - ENGINE CONTROLLER

21-012-25 REV. D

Service Bulletin/Repair Instructions

NOTE: Not applicable to vehicles built for US Market. Rear Selective Thrust Washer Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode. This bulletin involves checking for DTCs and possibly replacing the transmission.

S2523000062

Service Bulletin/Repair Instructions

Bumper Mounted 7 Pin Trailer Tow Connector

41C Combo

Emissions

Emissions Recall 41C - 6.4L Crankshaft Linear Compensation ECM Misfire Monitoring - Dealer Notification

9100607

Service Bulletin/Repair Instructions

MODULE Transfer Case Control If DTC C2112 is set in the DTCM module refer to complete diagnostics in Service Library, it has been seen this is primarily caused by a wiring issue. Please inspect all wiring, wiring connections and drive the vehicle in the conditions that set this fault according to the environmental data. Conduct the following test drive to recreate the condition to get the DTC to go active, - Shift from 2WD to 4HI (drive > 2 mins) - Shift from 4HI to 4LO (drive > 2 mins) - Shift from 4LO to 4HI (drive > 2 mins) - Shift from 4HI to 2WD (drive > 2 mins) Note: Inspect and confirm no corrosion present at the FAD connector If DTCM is still suspected to be at fault proceed with repair.

104974

Service Bulletin/Repair Instructions

LAMP - DOME

105590

Service Bulletin/Repair Instructions

Warranty Newsletter – Volume 11, Issue 6

105591

Warranty Program/Extension

FCA Caribbean Warranty Newsletter – Volume 11, Issue 6

OTHERDOC_132

Over The Air

Global Telematics Box Module Over The Air Update from 5.39.1 to 5.65 TBM2.0 Software Version (FOTA) Customers may experience one or more of the following: - Error display of "Uconnect Box Requires Service/Wifi Unavailable" popups; [ TBM DTC B22A9-96 Internal Performance Failure ]. - Error display of "Uconnect Box Requires Service" pop-ups; [ TBM DTCs B1560, B1561, B1562 - Antenna loose connection ].

08-182-25

Service Bulletin/Repair Instructions

Power Seat Not Adjusting Customers may experience one or more of the following: ● Driver and/or passenger seat moves backwards but not forward. ● Driver and/or passenger seat inoperative. This bulletin involves replacing the front power seat adjusters.

14-010-25 REV. B

Service Bulletin/Repair Instructions

Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as fuel filter. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debris

14-010-25 REV. A

Service Bulletin/Repair Instructions

Frequent Repairs Of Fuel Line Components Such As Fuel Filters Numerous Stellantis vehicles having fuel line components replaced such as fuel filter. Occasionally, components are replaced before their standard life expectancy or when not contaminated with debri

S2509000005

Service Bulletin/Repair Instructions

Light Random Tick Noise From The Engine.

104970

Service Bulletin/Repair Instructions

CORE - HEATER

105322

Service Bulletin/Repair Instructions

D-19-02 Rev. L Fast Feedback Program - 6.7L Cummins Complete Engine, Long Block & Short Block - 2019 - 2024 HD Ram - (D2/DD/DF/DJ/DP)

9100592

Service Bulletin/Repair Instructions

LAMP Courtesy/Ambient Courtesy / Ambient Lamp: Light guide not fully seated into the retainer during IP sub-assembly due to inconsistent operator installation effort, leading to latent BSR issue that manifests under customer usage conditions. Solution: remove and reinstall light guide to be fully seated in the bracket retainer.

9100598

Service Bulletin/Repair Instructions

Module, Urea Pump/Level: HD 6.7L (ETL/ETN/ETM) with Mil On P21C4-00 (Reductant Line Heater Relay Control Circuit High / U11C1-00 (Reductant Control Module Received Implausible Data From ECM/PCM), do not replace the DEF Pump. Follow TSB's released and appropriate Service Diagnostics.

02-002-25

Service Bulletin/Repair Instructions

Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.

9100562

Service Bulletin/Repair Instructions

Frame - Front Seat Back: 2024 2025 DJ D2 Power back frame with INOP motor replaced seat frame Please review TSB 08-159-25 before replacing any parts on the seat back frame.

9100574

Service Bulletin/Repair Instructions

Radio: Capture software version from radio. Record or document software version prior to troubleshooting, as soon as any infotainment issue has been found or reported. Also always document in claim. Steps to capture Radio version number: 1. Go to "Vehicle" 2. Go to "Settings" 3. Go to "System Information" 4. Find the radio version from "Version information" Example software version: U37.2, U39.4, etc.

14-010-25

Service Bulletin/Repair Instructions

S2508000039

Service Bulletin/Repair Instructions

Universal Garage Door Opener (UGDO) Inoperative, LED Indicator Lamps Not Illuminating

08-159-25

Service Bulletin/Repair Instructions

Front Left Power Seat Back Will Not Recline Customers may experience the following: ● Front left power seat back will adjust forward but will not recline back This bulletin involves replacing the front left power seat back and power seat adjuster.

S2308000120 REV.D

Service Bulletin/Repair Instructions

Rain Sensing Auto Wipers and Auto on Head Lamps Inoperative

S2323000002 REV.A

Service Bulletin/Repair Instructions

Washer Light On And Will Not Turn Off After Adding Washer Solvent.

9100579

Service Bulletin/Repair Instructions

Parking Brake Pad When replacing the park brake pedal pad, please use the correct labor operation code. Some technicians have been using the brake pedal pad labor code which is not the same as the parking brake pedal pad. The correct labor operation code should be for parking brake pedal pad replacement is 05-05-06-01.

21-012-25 REV. C

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode. This bulletin involves checking for DTCs and possibly replacing the transmission.

103774

Service Bulletin/Repair Instructions

LAMP - DOME

S2308000120 REV.C

Service Bulletin/Repair Instructions

Rain Sensing Auto Wipers and Auto on Head Lamps Inoperative

104525

Service Bulletin/Repair Instructions

SENSOR - WHEEL SPEED

21-031-25

Service Bulletin/Repair Instructions

Oil Leak In Transfer Case Rear Output Shaft Seal Customers may experience the following: ● Oil leak from transfer case rear output shaft seal. This bulletin involves inspecting and possibly replacing the rear transfer case rear output shaft seal.

104526

Service Bulletin/Repair Instructions

SWITCH - STEERING WHEEL RIGHT & LEFT

9100548

Service Bulletin/Repair Instructions

ADJUSTER Seat DJ D2 DP 1st Row Power Seat Fore/Aft Adjuster Inspection TSB is also released for this concern. SYMPTOM/CONDITION: Fore-aft function does NOT work when actuating the seat switch. DIAGNOSIS: 1) Put seat in position for inspection. 2) Disconnect seat wire harness motor connector from the fore-aft motor on the seat adjuster, wait 10 seconds, and reconnect. 3) Verify function of the fore/aft adjuster. Step 1. Open 2nd row door and function rear seat cushions up to stowed position. Step 2. Adjust the driver front seat to the full up position. Use switches on the side shield to move power seat fully up. Step 3. Remove the 4 bolts that hold the seat to the truck floor and discard. The bolts have lock patch that is not reusable. Step 4. Lay the seat down so its laying on its back so the underside of the seat is easily accessible. Step 5. Remove the fore/aft wire harness motor connector from the fore/aft motor (back right of the seat adjuster). Push on the tab to remove the motor wire harness connector from the motor. Leave disconnected for 10 seconds. Step 6. Reconnect the fore/aft wire harness motor connector to the fore/aft motor. Push / Pull / Push the connector with fingers to ensure the wire harness connector is fully seated to the fore/aft motor connector. Step 7. Before assembling the seat back to the truck floor, cycle the seat to check that the motor is working properly by pressing the fore/aft switch. If fore/aft motor does not function, please refer to Replacement Procedure below. Step 8. If the seat is working properly, carefully reassemble the seat back to the truck floor using the four new bolts. Use a torque wrench to verify 47 Nm. Step 9. *Note: Checking the passenger seat will be the same procedure as the driver seat. REPLACEMENT PROCEDURE Only for seats rejected after inspection. Replace Power Seat Adjuster per MOPAR service part replacement instructions. MOPAR Part Numbers: 68455847AA, 68455848AA, 68455849AA

09-004-25 REV. A

Service Bulletin/Repair Instructions

Clicking Noisse from Engine At Idle Customers may comment on the following: ● A clicking noise from the engine at idle. This bulletin involves adding oil system protection and letting the engine idle.

104558

Warranty Program/Extension

FCA Caribbean Warranty Newsletter – Volume 11, Issue 4

104557

Warranty Program/Extension

Warranty Newsletter – Volume 11, Issue 4

S2523000024

Service Bulletin/Repair Instructions

Rear Defogger Solder Terminals Detached.

09-007-25

Service Bulletin/Repair Instructions

Heavy Duty Exhaust Gas Recirculation (EGR) Value Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P1404 - EGR Position Sensor Rationality Closed This bulletin involves replacing the EGR valve.

S2408000015 REV.D

Service Bulletin/Repair Instructions

Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed, Adding Remote Start

S2508000014 REV.B

Service Bulletin/Repair Instructions

Security Gateway (SGW) Module is Setting Diagnostic Trouble Code (DTC) U3033-00 Control Module Security Certificate Missing or Invalid

9100508

Service Bulletin/Repair Instructions

6 CONTROL UNIT, Diesel Exhaust Customer complaints with malfunction light illuminated on 2019 thru 2024 MY DJ / D2 / DD / DP vehicles with 6.7L (ETL / ETM / ETN) built on or before October 15,2024 and exhibiting DTCs P21C4-00 (Reductant Line Heater Relay Control Circuit High) and / or U11C1-00 (Reductant Control Module received implausible Data from ECM / PCM). These DTCs will occur after installation of service DCU 68458603AB. Do not replace parts until after the TSB 25-008-24 is performed. If the DTC(s) continue to set, then follow the Service Diagnostics for the applicable DTC.

09-004-25

Service Bulletin/Repair Instructions

Clicking Noise From Engine At Idle Customers may comment on the following: ● A clicking noise from the engine at idle. REPAIR SUMMARY: This bulletin involves adding oil system protection and letting the engine idle.

S258A000005 REV.A

Service Bulletin/Repair Instructions

Trailer Tow App Gauges Not Showing Data in Widget Screen

S2423000027 REV.C

Service Bulletin/Repair Instructions

Horn Sound Is Weak, Off Tone, Inoperative, Or Intermittent.

103772

Service Bulletin/Repair Instructions

SWITCH - STEERING WHEEL RIGHT & LEFT

S2409000002 REV.A

Service Bulletin/Repair Instructions

Perceived Oil Leak From The Rear Of The Engine

S2508000014 REV.A

Service Bulletin/Repair Instructions

Security Gateway (SGW) Module is Setting Diagnostic Trouble Code (DTC) U3033-00 Control Module Security Certificate Missing or Invalid

S1625000002 REV.B

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination, Diagnostic Trouble Codes (DTCs) P21C4 – (Diesel Exhaust Fluid) Reductant Line Heater Control Circuit High, and U11C1 – Reductant Control Module Received Implausible Data From ECM/PCM, Set

S258A000009

Service Bulletin/Repair Instructions

Apple CarPlay Does Not Complete The First Initial Wireless Connection.

103475

Service Bulletin/Repair Instructions

VALVE BODY & CONTROL UNIT - TRANSMISSION

08-045-25 REV.A

Service Bulletin/Repair Instructions

Flash: Radio Frequency Hub Module (RFHM) Updates Customers may experience one or more of the following: ● Wired Remote Start (WRS) may have to be pressed twice to shut the engine off. ● WRS feature unable to turn off the engine when using the WRS button.

S2108000015 REV.J

Service Bulletin/Repair Instructions

Uconnect Box Require Service Message

21-012-25 REV. B

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode. *This bulletin involves checking for DTCs and possibly replacing the transmission.*

08-047-25

Service Bulletin/Repair Instructions

Flash: Air Suspension Control Module (ASCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● C2202-00 - Original VIN Mismatch/missing. Customers may also experience: ● "Service air suspension" icon light may be on and system may be defaulting to normal ride height. This bulletin involves updating the ASCM with the latest available software.

9100500

Service Bulletin/Repair Instructions

Touchscreen For all infotainment system repairs (touchscreens, radios, etc.), refurbished parts may be available. Follow the Infotainment Ordering guide available under the "Parts" section of Dealer Connect: DealerCONNECT> Parts> News& Information> Audio & Electronic Products Exchange Process

103288

Service Bulletin/Repair Instructions

CAMERA - REAR VIEW

103289

Service Bulletin/Repair Instructions

CAMERA - REAR VIEW

103291

Service Bulletin/Repair Instructions

PANEL - B PILLAR LOWER TRIM

S228A000005 REV.E

Service Bulletin/Repair Instructions

Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)

S2508000014

Service Bulletin/Repair Instructions

Security Gateway (SGW) Module is Setting Diagnostic Trouble Code (DTC) U3033-00 Control Module Security Certificate Missing or Invalid

9100493

Service Bulletin/Repair Instructions

SWITCH AND BEZEL Front Door Before replacing the Window Switch/Mirror Switch, please follow these steps: 1.- Check for what DTC are detected and take proper steps acceding to the DTC's. 2.- Make sure all the switches are properly connected to their harness, disconnect the switch and reconnect it. 3.- Review the window Switch for any physical issue (Button stuck, broken) If after performing these steps the switch remains faulty. Follow suggested repairs per diagnostics performed.

S258A000005

Service Bulletin/Repair Instructions

Trailer Tow App Gauges Not Showing Data in Widget Screen

102940

Service Bulletin/Repair Instructions

CONVERTER - CATALYTIC

103214

Service Bulletin/Repair Instructions

CONVERTER - CATALYTIC

9100393 Rev 1

Service Bulletin/Repair Instructions

TRANSFER CASE BW 44-46 If fluid leak is present between the transfer case and the rear driveshaft on a 4WD vehicle the Output Shaft Seal should be considered in lieu of entire transfer case or driveshaft replacement. In the case of major damage to components, contact StarCenter and/or proceed with replacements as necessary.

9003980

Service Bulletin/Repair Instructions

SWITCH Headlamp Before replacing the Headlamp Switch for faulty dimmer operation. Please follow the next steps to corroborate if the Headlamp Switch is malfunctioning: 1.- Please disconnect and reconnect the headlamp Switch. And verify if the issue is corrected. 2.- Review the internal resistance of the switch: a.- For the Right Dimmer (IP) between Pins 6 & 3. The value should be around 5.74 KOhms, when in the lowest position to 311 ohms in the top position (Parade Detent). b.- For the left Dimmer (Ambient Light) between pins 8 & 3. The value should be around 14.52 KOhms, when in the lowest position to 182 ohms in the top position. If a problem is found in the resistor values. Please replace the Switch.

S1408000384 REV.H

Service Bulletin/Repair Instructions

S1425000019 REV.A

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illuminated. Diesel Exhaust Fluid (DEF) System Diagnostic Trouble Codes (DTCs) due to Hydrocarbon Contamination.

21-012-25

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode This bulletin involves replacing the transmission.

21-012-25 REV.A

Service Bulletin/Repair Instructions

9100490

Service Bulletin/Repair Instructions

SWITCH Instrument Panel Before replacing the driver window switch, please follow these steps: 1.- Review the Trailer brake Switch for any physical issue (Button stuck, broke). If no physical issue identified, move to next steps. 2.- Make sure the switch harness is properly connected, disconnect the switch and reconnect it, and reverify the issue. 3.- Check for what DTC are detected and take proper steps. 4.- Review the internal resistance of the switch to corroborate if it is shorted: a) Between Pins 10&2 it should be around 13ohms +/- 4ohms b) Between Pins 3 & 4 and 4 & 6, 160 ohms +/-10 Ohms If a problem is found in the resistor values. Please replace the Switch.

18-001-25

Service Bulletin/Repair Instructions

Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit one or more of the following Diagnostic Trouble Codes (DTCs): ● P245D - EGR Cooler Bypass Control Circuit High. ● P02E3 - Diesel Intake Air Flow Control Circuit High. ● P0490 - EGR Control circuit High. ● P229F - Aftertreatment N0X Sensor Circuit Performance - Bank 1 Sensor 2. ● P0299 - Turbocharger Underboost. ● P242F - Diesel Particulate Filter Restriction - Ash Accumulation. ● P0128 - Thermostat Rationality. In addition, the following software enhancements are available: ● Improved troubleshooting and repair accuracy for air handling components. ● Eliminates false faults for air handling actuators. This bulletin involves reprogramming the ECM/PCM with the latest available software

21-010-25

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure This is a proactive RSU Repair Procedure to be performed for all Unsold vehicles not exhibiting any Diagnostic Trouble Codes (DTCs) or Customer Symptoms. The Malfunction Indicator Lamp (MIL) should not be illuminated. If a customer’s VIN is listed in your RSU VIN list, does not have the MIL illuminated and does not exhibit any customer symptom/conditions, perform the repair. For all other vehicles with the MIL illuminated or exhibiting any customer symptoms/conditions, this service action does not apply. Please follow normal diagnostic and repair procedures. This bulletin involves replacing the transmission 4C clutch hub/reaction sun gear assembly and the 4C clutch hub/reaction sun gear assembly rear selective thrust plate/shim. VINs identified as being involved in this campaign are currently live and searchable. Stop Sale is in effect for the above-identified vehicles. NOTE: Some of the involved vehicles may be in dealer new vehicle inventory. Involved vehicles can be determined by using the VIP inquiry process."

9100487

Service Bulletin/Repair Instructions

MODULE Steering Control Before replacing the steering column control module (SCCM) due to turn signal inop, wipers inop, steering controls inop, TCS light DTC C0051 or horn blowing while turning, please follow these steps: 1.- Refer to service library procedure and follow diagnosis steps. 2.- If failure still present, make sure all the switches', horn's, airbag's harness are properly connected and there is no corrosion or pinching, disconnect the switches & reconnect them, and reverify the issue. 3.- Verify if failure is still present, review if there is lack of communication between SCCM and BCM. For example, activate turn signals or wipers. 4.- Read at the BCM diagnosis session if BCM is receiving information from SCCM. Through diagnosis review if activation from horn, wipers or turn signal is requested and are working. 5.- Disconnect the SCCM fuse for around 30s,and repeat the previous steps to see if failure still present. 6.- Do a hard reset to BCM and evaluate if any DTC is set. Retest if failure still present. 7.- Before replacing the SCCM disconnect it and reconnect it again. If there are no DTC's active, physical defects, steering controls inop, wipers inop, nor turn signal inop, horn inop, then SCCM does not need to be replaced.

S2523000002

Service Bulletin/Repair Instructions

Outside Exterior Mirror Power Extend And/Or Retract Is Not Fully Functional.

S1408000384 REV.G

Service Bulletin/Repair Instructions

102387

Service Bulletin/Repair Instructions

SEAL - OUTPUT SHAFT

102389

Service Bulletin/Repair Instructions

SEAL - OUTPUT SHAFT

S2008000186 REV.B

Service Bulletin/Repair Instructions

Engine Control Module (ECM) Flash Failure, Diagnostic Trouble Code (DTC) U1601 – ECU Application Software Code 1 Missing Or Corrupted

102307

Service Bulletin/Repair Instructions

GEAR - REACTION SUN

S2408000123

Service Bulletin/Repair Instructions

Push to Start Button Has a Delay Switching Ignition Positions, DTCs (Diagnostic Trouble Codes), B1A7D-2A Start Button - Stuck, U103C-00 KIN/IGNM Communication

9100462

Service Bulletin/Repair Instructions

SWITCH Mirror Before replacing the driver window switch, please follow these steps: 1.- Review the telescopic mirror Switch for any physical issue (Button stuck, broke). If no physical issue identified, move to next steps. 2.- Make sure the switch harness is properly connected, disconnect the switch and reconnect it, and reverify the issue. 3.- Check for what DTC are detected and take proper steps. If there are no DTC's nor physical defectives, then the telescopic mirror switches can't be replaced.

9100465

Service Bulletin/Repair Instructions

SEAT BELT Front Outer Seatbelt Slow Retraction / Seat Belt Cleaning If the vehicle exhibits slow seatbelt retraction, prior to replacing seatbelt please inspect for debris and any build up on the webbing and DRing. If evidence of debris and build up, please clean seatbelt webbing or turning loop as described below. Seat Belt Maintenance: Do not bleach, dye or clean the belts with chemical solvents or abrasive cleaners. This will weaken the fabric. If the belts need cleaning, use a mild soap solution or lukewarm water. Do not remove the belts from the vehicle to wash them. Dry with a soft cloth. Sun damage can also weaken the fabric. Replace the belts if they appear frayed or worn or if the buckles do not work properly. NOTE: If the belts retract slowly, inspect the upper turning loop for soiling. If soiling is present, clean with a wet soft cloth until all residue is removed.

21-054-24 REV. E

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure **This is a proactive RSU Repair Procedure to be performed for all Unsold vehicles not exhibiting any Diagnostic Trouble Codes (DTCs) or Customer Symptoms. The Malfunction Indicator Lamp (MIL) should not be illuminated. If a customer’s VIN is listed in your RSU VIN list, does not have the MIL illuminated and does not exhibit any customer symptom/conditions, perform the repair. For all other vehicles with the MIL illuminated or exhibiting any customer symptoms/conditions, this service action does not apply. Please follow normal diagnostic and repair procedures.** This bulletin involves replacing the transmission 4C clutch hub/reaction sun gear assembly and the 4C clutch hub/reaction sun gear assembly rear selective thrust plate/shim. VINs identified as being involved in this campaign are currently live and searchable. Stop Sale is in effect for the above-identified vehicles. NOTE: Some of the involved vehicles may be in dealer new vehicle inventory. Involved vehicles can be determined by using the VIP inquiry process.

08-185-24 REV. A

Service Bulletin/Repair Instructions

Flash: Radio Frequency Hub Module (RFHM) Updates Customers must experience the following: ● Wired Remote Start Stop (WRSS) feature unable to turn off the engine stop/start with the WRSS button. This bulletin involves updating the RFHM module with the latest available software.

S2208000045 REV.B

Service Bulletin/Repair Instructions

Backup Camera Poor Image Quality Inspection

S248A000018

Service Bulletin/Repair Instructions

Trailer Tow Pages App Gauges Not Showing Data After Radio Update

05-004-24

Service Bulletin/Repair Instructions

Brake Warning Lamp Illumination Over Rumble Strips Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: ● C003A-2F - Right Rear Wheel Speed Sensor - Signal Erratic. ● C0037-2F - Left Rear Wheel Speed Sensor - Signal Erratic. Customers may also comment on the following: ● Automatic Brake System (ABS) lamp and Electronic Stability Control (ESC) lamp turn on when driving over rumble strips. This bulletin involves replacing one or both rear wheel speed sensors.

21-054-24 REV. D

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure NOTE: This is a proactive RSU Repair Procedure to be performed for all Unsold vehicles not exhibiting the Diagnostic Trouble Codes (DTCs) or Customer Symptoms below. Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following DTCs: ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode. This bulletin involves replacing the transmission rear selective thrust plate located between the Number 6 thrust bearing and the reaction sun gear and replacing the reaction sun gear. VINs identified as being involved in this campaign are currently live and searchable. Stop Sale is in effect for the above-identified vehicles. NOTE: Some of the involved vehicles may be in dealer new vehicle inventory. Involved vehicles can be determined by using the VIP inquiry process.

101683

Service Bulletin/Repair Instructions

CONVERTER - CATALYTIC

101773

Service Bulletin/Repair Instructions

CONVERTER - CATALYTIC

21-054-24 REV. C

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may exhibit/set one or more of the following DTCs: ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode.

25-008-24

Service Bulletin/Repair Instructions

Flash: Diesel Exhaust Fluid (DEF) Dosing Control Unit (DCU) Update Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set the following Diagnostic Trouble Code (DTC): ● P21C4-00 - Reductant Line Heater Relay Control Circuit High. ● U11C1-00 - Reductant Control Module Received Implausible Data From ECM/PCM. These DTCs will occur after installation of service DCU 68458603AB. This bulletin involves reprogramming the DCU with the latest available software.

S2422000001 REV.C

Service Bulletin/Repair Instructions

Tire Pressure Monitor (TPM) Service Information. TPM Lamp On.

101232

Service Bulletin/Repair Instructions

Plate - Planetary

101092

Service Bulletin/Repair Instructions

TRANSMISSION KIT - WITH TORQUE CONVERTER

101094

Service Bulletin/Repair Instructions

TRANSMISSION KIT - WITH TORQUE CONVERTER

21-054-24 REV. A

Service Bulletin/Repair Instructions

Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): lP0218-00 - Transmission High Temperature Operation Activated. lP0716-00 - Input Speed Sensor 1 Circuit Performance. lP0729-00 - Gear 6 Shift Incorrect Ratio. lP0731-00 - Gear 1 Shift Incorrect Ratio. lP0732-00 - Gear 2 Shift Incorrect Ratio. lP0733-00 - Gear 3 Shift Incorrect Ratio. lP0734-00 - Gear 4 Shift Incorrect Ratio. lP0735-00 - Gear 5 Shift Incorrect Ratio. lP0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. lP0868-00 - Transmission Fluid Pressure Low. lP0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. lP0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. lP0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: lHard shifting into gear. lVehicle enters into limp home mode.

21-054-24

Service Bulletin/Repair Instructions

Rear Selective Thrust Washer Failure Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0218-00 - Transmission High Temperature Operation Activated. ● P0716-00 - Input Speed Sensor 1 Circuit Performance. ● P0729-00 - Gear 6 Shift Incorrect Ratio. ● P0731-00 - Gear 1 Shift Incorrect Ratio. ● P0732-00 - Gear 2 Shift Incorrect Ratio. ● P0733-00 - Gear 3 Shift Incorrect Ratio. ● P0734-00 - Gear 4 Shift Incorrect Ratio. ● P0735-00 - Gear 5 Shift Incorrect Ratio. ● P0841-00 - Transmission Fluid Pressure Sensor/Switch 1 Circuit Performance. ● P0868-00 - Transmission Fluid Pressure Low. ● P0871-00 - Transmission Fluid Pressure Sensor/Switch "C" Circuit Range/Performance. ● P0876-00 - Transmission Fluid Pressure Sensor/Switch "D" Circuit Range/Performance. ● P0944-00 - Loss Of Hydraulic Pump Prime. Customers may also comment on one or more of the following: ● Hard shifting into gear. ● Vehicle enters into limp home mode. This bulletin involves replacing the transmission rear selective thrust plate located between the Number 6 thrust bearing and the reaction sun gear.

S2422000003

Service Bulletin/Repair Instructions

Trailer Tire Pressure Monitor (TTPM) Programming Tips And Operation Information.

100498

Service Bulletin/Repair Instructions

MODULE - ENGINE CONTROLLER

9100415

Service Bulletin/Repair Instructions

Transfer case BW44-47 If fluid leak is present between the transfer case and the rear driveshaft on a 4WD vehicle the Output Shaft Seal - sub component parts should be considered in lieu of entire transfer case or driveshaft replacement. In the case of major damage to components, contact StarCenter and/or proceed with replacements as necessary.

PDI Release: 2024_10_V1

Other

Open and close rear glass window 2 times and check seal is not hanging or loose

S2423000044

Service Bulletin/Repair Instructions

Buzz Squeak Rattle (BSR) Noise From The Steering Shaft Front Bulkhead Boot Area While Turning The Steering Wheel.

S2423000043

Service Bulletin/Repair Instructions

Dome Lamp LED And Incandescent Bulb Servicing.

100774

Service Bulletin/Repair Instructions

SWITCH - HEADLAMP

97802

Service Bulletin/Repair Instructions

SWITCH - HEADLAMP

100595

Warranty Program/Extension

WARRANTY BULLETIN D-24-15 announces the addition of the Rear Axle Assembly replacement for 2019 - 2024 RAM 3500 Cab Chassis (DD), RAM 4500/ 5500 Cab Chassis (DP), RAM 3500 Pickup (D2), RAM 2500 Pickup (DJ), RAM 1500 Pickup (DS) and RAM 1500 Pickup (DT) vehicles to the Powertrain Pre-Authorization program for all dealers (Base, Plus & Premium) to ensure proper repair of Rear Axle Assembly failures and to assist in quality improvements. REV.A

100599

Warranty Program/Extension

FCA Caribbean Warranty Bulletin ID-24-16 Rev. Announces the addition of the Rear Axle Assembly replacement for 2019 - 2024 RAM 3500 Cab Chassis (DD), RAM 4500/ 5500 Cab Chassis (DP), RAM 3500 Pickup (D2), RAM 2500 Pickup (DJ), RAM 1500 Pickup (DS) and RAM 1500 Pickup (DT) vehicles to the Powertrain Pre-Authorization program to ensure proper repair of Rear Axle Assembly failures and to assist in quality improvements. REV.A

S228A000017 REV.A

Service Bulletin/Repair Instructions

Battery Drain Suspected or "Identified" From USB or Media Hub

100490

Warranty Program/Extension

WARRANTY BULLETIN D-24-15 Addition of Rear Axle / Differential Assembly for 2019 - 2024 RAM 3500 Cab Chassis (DD) to the Powertrain Service Center (PTSC) Pre-Authorization Program ALL DEALERS

100494

Warranty Program/Extension

FCA CARIBBEAN WARRANTY BULLETIN ID-24-16 Addition of Rear Axle / Differential Assembly for 2019 - 2024 RAM 3500 Cab Chassis (DD) to the Powertrain Service Center (PTSC) Pre-Authorization Program

S2423000027 REV.A

Service Bulletin/Repair Instructions

Horn Sound Is Weak, Off Tone, Or Inoperative.

S2424000007

Service Bulletin/Repair Instructions

Driver Side Air Vent No Air Flow

99985

Other

AIR BAG - DRIVER

S2423000039

Service Bulletin/Repair Instructions

Wiper Motor Inoperative. Wiper Doesn’t Work or Stops Randomly On Glass

08-185-24

Service Bulletin/Repair Instructions

Radio Frequency Hub Module Updates Customers may experience the following: ● Wired Remote Start (WRS) feature unable to turn off the engine when using the WRS button

S248A000011

Service Bulletin/Repair Instructions

Driver Hears Noise, Static or Can Not Hear Phone Caller on Other End

09-017-24

Service Bulletin/Repair Instructions

Heavy Duty Exhaust Gas Recirculation (EGR) Valve Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P1404 - EGR Position Sensor Rationality Closed This bulletin involves replacing the EGR valve.

31-001-24

Service Bulletin/Repair Instructions

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Verify current warranty policy to determine if digital imaging pre-authorization is required or pre-approval is required from the Regional Office; depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.

9100393

Service Bulletin/Repair Instructions

TRANSFER CASE BW 44-46 If fluid leak is present between the transfer case and the rear driveshaft on a 4WD vehicle the Output Shaft Seal - service part numbers 68161329AA OR 68449218AA (max tow application) - should be considered in lieu of entire transfer case or driveshaft replacement. In the case of major damage to components, contact StarCenter and/or proceed with replacements as necessary

S248A000010

Service Bulletin/Repair Instructions

Satellite Radio Displays “Satellite Hardware Error” Message

S2409000002

Service Bulletin/Repair Instructions

Perceived Oil Leak From The Rear Of The Engine

S2408000015 REV.C

Service Bulletin/Repair Instructions

Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed, Adding Remote Start

9100362

Service Bulletin/Repair Instructions

MODULE Steering Control Before replacing the steering column control module (SCCM), please follow these steps: 1.- Make sure all the switches' and airbag's harness are properly connected, disconnect the switches and reconnect them, and reverify the issue. 2.- Pull the SCCM fuse for 60 sec and then reinstall it. 3.- Reverify if Steering wheel switches are inoperative. If there are no DTC's, physical defects, nor switches inop, then SCCM does not need to be replaced.

03-006-24

Service Bulletin/Repair Instructions

Rear Axle Vibration Shudder Or Chatter Customers may experience the following: ● A chatter, shudder, or vibration from the rear axle during turns. NOTE: This may happen more as the vehicle ages, especially if the vehicle is used extensively for towing or hauling heavy loads. The cause of the concern may be due to degradation of the rear axle fluid. It is very important to follow the routine maintenance schedules on these vehicles when it comes to changing the rear axle fluid if the vehicle is used primarily for towing or hauling heavy loads. If you experience a vehicle with the above condition, please perform the proper maintenance procedures for the rear axle and replace the fluid first before replacing any hardware components. NOTE: This service bulletin is only applicable to vehicles that have no history of an axle fluid replacement. If the vehicle usage includes police, taxi, fleet, off-road or frequent trailer towing, regular axle fluid changes are required every 3 years or 30,000 miles (whichever comes first) per the Maintenance Schedule in the vehicle Owner's Manual. This bulletin involves changing the rear axle lube to possibly address a chatter, shudder or vibration.

S2408000066

Service Bulletin/Repair Instructions

Drained Battery, Low System Voltage, Battery Not Charging, High System Voltage

96076

Other

MOTOR - WINDSHIELD WIPER & WIPERUNIT - WINDSHIELD WIPER

98927

Other

MOTOR - WINDSHIELD WIPER & WIPERUNIT - WINDSHIELD WIPER

S1408000384 REV.F

Service Bulletin/Repair Instructions

94006

Other

WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER

98861

Other

WIPERUNIT - WINDSHIELD WIPER, BLADE - FRONT WIPER.

S2308000120 REV.B

Service Bulletin/Repair Instructions

Rain Sensing Auto Wipers and Auto on Head Lamps Inoperative

98599

Other

MODULE - ANTI-LOCK BRAKE SYSTEM

S228A000005 REV.D

Service Bulletin/Repair Instructions

Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes (DTCs)

05-003-24

Service Bulletin/Repair Instructions

Leaking Power Steering Fluid from the Power Brake Hydro-Booster Assembly Customers may experience the following: ● Leaking power steering fluid from the hydroboost assembly. This bulletin involves inspecting and possibly replacing the power brake hydro-booster assembly if a leak is found.

98550

Other

MODULE - ANTI-LOCK BRAKE SYSTEM

98323

Other

MODULE - TELEMATICS

98354

Other

Valve - EGR

S1625000004 REV.A

Service Bulletin/Repair Instructions

On Board Diagnosis (OBD) Monitor Readiness Information

S2418000009

Service Bulletin/Repair Instructions

Malfunction Indicator Lamp (MIL) Illumination. One Or More Exhaust Temperature Sensor (EGT) Diagnostic Trouble Codes (DTCs), Set.

98171

Other

MODULE - ENGINE CONTROLLER

9100338REV1

Service Bulletin/Repair Instructions

GENERATOR Engine Prior to alternator/generator removal: 1. Inspect & check all electrical connections to the alternator a. 2-way connector containing field control circuit & alternator sense voltage circuit. b. Unplug & plug-in the 2-way connector for field & sense circuit. Verify the connection is tight & check for any bent pins in alternator connector or damage to female terminals in connector. c. Check Alternator B+ Stud connection to be sure nut is securing positive cable terminal properly (i.e. nut is clamping terminal & connection is tight). d. Check fuse between the alternator B+ stud & PDC terminal to make sure it is not blown. e. Be sure to follow service manual sections on ALTERNATOR CONTROL CIRCUIT DIAGNOSTIC & ALTERNATOR SENSE CIRCUIT DIAGNOSTIC looking for any opens & shorts (to ground or battery voltage). 2. Check/verify all grounds in the charging system circuit a. Check tightness of mounting bolts securing alternator to engine block. Alternator is a case ground component. b. Check main ground from engine to chassis; connection must be tight. c. Check battery ground cable connections are tight. d. Potentially, loosen alternator mounting bolts, without removing alternator, and re-tighten to torque specifications in service manual. e. After all steps above are complete, re-start engine & check charging system operation. 3. Verify that the Smart Charging System is not the reason for alternator low voltage & current output (Amps). a. Alternator charging can be suspended during engine idle operation because of the Smart Charge strategy. b. Refer to service manual section "System Operation - Smart Charging System". c. Refer to Star Case S2008000031 Rev A for low charging voltage & Smart Charge Mode Voltage Range diagram & mode descriptions. d. The alternator has no internal regulator; thus, has no smart circuitry. All alternator control signals come from ECM. 4. If alternator is faulty, remove alternator & mounting bolts. Return alternator with bolts for analysis at QEC.

S1908000050 REV.A

Service Bulletin/Repair Instructions

Checking Radio Software Level On A VP2 Radio

98105

Other

DAMPER - STRUT

97960

Other

MODULE - STEERING CONTROL

S2408000015 REV.B

Service Bulletin/Repair Instructions

Remote Keyless Entry (RKE) Button Functions Does Not Work, Intermittent Vehicle Response When Using the RKE, Key Not Programmed

9100301

Service Bulletin/Repair Instructions

UCONNECT 5 W 8.4" DISPLAY Prior to replacing the radio, please check for any related recalls, TSBs, or any STAR Online publications. Please verify the radio is at the latest available software level. If active DTCs are set, perform the appropriate diagnostic procedure in service information. If the condition is intermittent, refer to Section 29 Non-DTC Based Diagnostics and perform the diagnostic procedure related to the customer's complaint. If concern is still present or the customer has returned to the dealer multiple times for the same complaint, contact engineering FCA Redacted Content. If no answer or call back within 15 minutes, continue with regular diagnosis.

S2408000008

Service Bulletin/Repair Instructions

Rain Sensing Auto Wipers Or Auto Headlamps Inoperative, DTC B221D-00, B23AA-00

S1408000384

Service Bulletin/Repair Instructions

S238A000058

Service Bulletin/Repair Instructions

Radio Navigation Displays Message ?No Maps Available?

9100270

Service Bulletin/Repair Instructions

AIR SUSPENSION COMPRESSOR ASSE When servicing a 23 model year Ram 2500/3500 - Service Air Suspension Light On (DTC C2202-00)~ Prior to replacing for a C2202-00 (Original VIN mismatch) contact engineer FCA REDACTED CONTENT~ If no response in 15 minutes proceed with repair.~ ~ Please replace the ASCM for this DTC and do not reset the module. Hold it for parts return~

94684

Service Bulletin/Repair Instructions

Transportation Bulletin T-23-01 Dealer Cleaning Program - 2023 - 2024 RAM Trucks - DJ, D2, DF, DD, DP, DS Models (Mexico RAM Built Trucks Only)

94691

Service Bulletin/Repair Instructions

FCA Caribbean Transportation Bulletin IT-23-01 Dealer Cleaning Program - 2023 - 2024 RAM Trucks - DJ, D2, DF, DD, DP, DS Models (Mexico RAM Built Trucks Only)

9100266

Service Bulletin/Repair Instructions

brake hydroboost When replacing the Hydrobooster Assembly for a warrantable concern, please save the removed unit and call FCA REDACTED CONTENT for a FasTrack part return. ~ If no response in 15 minutes, proceed with repair. Please leave the last 8 of VIN, plus vehicle mileage, and dealer code.

94134

Service Bulletin/Repair Instructions

Warranty Bulletin D-22-07 Part Order Restriction Program ? Engine Control Module (ECM) ? Select 2022 - 2024 Ram 2500 Pickup (DJ), 2022 - 2024 Ram 3500 Pickup (D2), 2022 - 2024 Ram 3500 Cab Chassis (DD) and 2022 - 2024 4500/5500 Ram Cab Chassis (DP) (Rev. C)

94142

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-22-10 Part Order Restriction Program ? Engine Control Module (ECM) ? Select 2022 - 2024 Ram 2500 Pickup (DJ), 2022 - 2024 Ram 3500 Pickup (D2), 2022 - 2024 Ram 3500 Cab Chassis (DD) and 2022 - 2024 4500/5500 Ram Cab Chassis (DP) (Rev. C)

9100229

Service Bulletin/Repair Instructions

LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.

S2323000075

Service Bulletin/Repair Instructions

2nd Row Center Seat Lazy Or Slow When Folding.

9100226

Service Bulletin/Repair Instructions

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.

93023

Service Bulletin/Repair Instructions

Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)

93120

Service Bulletin/Repair Instructions

FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC

2400623

Service Bulletin/Repair Instructions

A/C Diagnostic LOP Change

0700723

Service Bulletin/Repair Instructions

Water Quality When Mixed With Engine Coolant

9100097

Service Bulletin/Repair Instructions

3.5 INCH - SPEAKER ASSY P2 Before ordering a speaker part for crackles or rattling noises make sure to take the following steps: 1. Check for electrical harness routing too close to speaker's rear moving parts, improper connection, and/or harness pinch or damage. 2. Ensure no loose components, including trim grilles, fasteners, surrounding IP parts, etc. were found when removing the speaker. 3. Try "bad" speaker at another IP location and see if noise follows speaker. Try a different "good" speaker at "bad speaker location" and see if noise still happens at "bad" location. If even with this verification and adjustments the speaker sounds bad, test the individual speaker with the audio files provided in the Service Library Homepage under "Reference Materials" prior to replacement

9100158

Service Bulletin/Repair Instructions

Power Window 1 Gang Before Replacing the Switch, please verify the following: 1- Check the switch internal resistance to verify the values are within specification stated in the service procedures. 2- Swap the switch with the issue with the other side. This switch is used in both rear doors. If after the swap the issue is now present at the other door and the original door position no longer has the issue, replace the switch.

Reading this report

Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.