PIP5601C
Service Bulletin/Repair Instructions
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
Vehicle report
2002 SATURN LS
Service bulletins
189 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
General Communication
Service Campaign
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
18-NA-099
Service Bulletin/Repair Instructions
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
24-NA-098
Service Bulletin/Repair Instructions
This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
10-08-45-001H
Service Bulletin/Repair Instructions
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
16-NA-383
Service Bulletin/Repair Instructions
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
22-NA-074
Service Bulletin/Repair Instructions
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
02-08-42-001J
Service Bulletin/Repair Instructions
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PI1394B
Service Bulletin/Repair Instructions
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
17-NA-170
Service Bulletin/Repair Instructions
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
10-00-89-006J
Service Bulletin/Repair Instructions
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
18-NA-073
Service Bulletin/Repair Instructions
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
19-NA-219
Service Bulletin/Repair Instructions
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
22-NA-009
Service Bulletin/Repair Instructions
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
03-01-39-012A
Service Bulletin/Repair Instructions
This bulletin provides an updated repair procedure to correct a customer concern of a musty odor from A/C system, most noticeable at vehicle start-up.
17-NA-073
Service Bulletin/Repair Instructions
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
01-08-42-001O
Service Bulletin/Repair Instructions
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
10-00-89-006I
Service Bulletin/Repair Instructions
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
16NA383
Service Bulletin/Repair Instructions
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
PIP5338B
Service Bulletin/Repair Instructions
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include “Vibration” “Business Associate Code” and the last 8 of the Vehicle Identification Number.
PIT5353B
Service Bulletin/Repair Instructions
This Preliminary Information communication provides information to the technician about what XM offerings are available for vehicles. A dealer or customer can access the website listed below for vehicle specific XM offerings and availability.
PIP4495E
Service Bulletin/Repair Instructions
This Preliminary Information communication provides information to the technician about vehicles that have a loud tick or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to the upper end oil pressure. Technician will need to inspect the oil feed orifice in the cylinder head. Technician will clean out and debris found in the orifice.
PIC5588D
Service Bulletin/Repair Instructions
This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the activation is initiated by a Service Programming System. For the 2010 and UP model year vehicles, the OnStar set-up procedure and OnStar Activation request have been combined into a single programming event called OnStar Set-up and Activation in Service Programming System.
PIT3099P
Service Bulletin/Repair Instructions
This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
PIC5491J
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP. TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. AFTER THE VEHICLE HAS POWERED DOWN REMOVE POWER TO THE ONSTAR MODULE FOR FIVE MINUTES. AFTER THE POWER HAS BEEN REMOVED FOR FIVE MINUTES, IF THE ONSTAR SYSTEM IS WORKING RELEASE THE VEHICLE. IF THE ONSTAR SYSTEM IS STILL INOPERATIVE CONTINUE WITH PUBLISHED SERVICE INFORMATION DIAGNOSTICS.
PI1394A
Service Bulletin/Repair Instructions
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE.
16NA260
Service Bulletin/Repair Instructions
THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBRATION CONCERNS.
000601012F
Service Bulletin/Repair Instructions
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE GASKET SEALING SURFACES.
PIT5485B
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIC5088F
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS TO DIAGNOSE AND REPAIR THE CONCERN. THE VEHICLE'S XM RADIO ONLY HAS XM PREVEIW CHANNELS.
PIC-4935-E
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT THE NORMAL POWER CONSUMPTION READING SHOULD BE FROM THE ONSTAR SYSTEM.
PIC-5050-A
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CALL GENERAL MOTORS TECHNICAL ASSISTANCE CENTER FOR FURTHER ASSISTANCE IF THE CONCERN IS STILL PRESENT.
PIC4935E
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT THE NORMAL POWER CONSUMPTION READING SHOULD BE FROM THE ONSTAR SYSTEM.
PIC5050A
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN. A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CALL GENERAL MOTORS TECHNICAL ASSISTANCE CENTER FOR FURTHER ASSISTANCE IF THE CONCERN IS STILL PRESENT.
PIT5389A
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN. THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.
PIT5485A
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
PIP5226A
Service Bulletin/Repair Instructions
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE. TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. ONLY REPLACE THE ROLLER ROCKER THAT IS MISSING NEEDLE BEARINGS. BE SURE TO CLEAN THE OIL DRAINS TO RETRIEVE THE NEEDLE BEARINGS. EACH ROLLER ROCKER HAS 66 BEARINGS.
03-08-46-004R
Service Bulletin/Repair Instructions
This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle Communication Interface Modules (VCIM) (GMNA Only)
15-NA-079
Service Bulletin/Repair Instructions
OnStar® Voice Fallback Number Update Some customers may have received a letter from OnStar® stating that "We recently tried to provide a software update to the OnStar® hardware in your vehicle. However, your system could not be updated remotely. As a result, some of your OnStar® system functions may not be working as expected." The customer is further instructed in this letter to "Please contact your dealer or any dealer near you as soon as possible to schedule an appointment for this no-cost software update. Your dealer will reprogram your OnStar® module with an update. This is for vehicles that have previously received the Canada upgrade as described in Service Bulletin #15-08-44-001F."
02-08-42-001H
Service Bulletin/Repair Instructions
This informational bulletin provides information to assist dealership personnel with the identification of vehicle headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
PIT5264B
Service Bulletin/Repair Instructions
Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
PIT5353
Service Bulletin/Repair Instructions
XM Audio Traffic And Travel Link Availability And Operation.
Recalls
Service Bulletin/Repair Instructions
Vehicle Recalls
PIC5088E
Service Bulletin/Repair Instructions
This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Technician will need to use a scan tool and verify current Digital Radio Receiver Status under Data Display. Technician will need to look at the second line labeled Digital Radio Receiver Status will display a number of 00 - 04. Technician will repair per the status code.
PIC5588B
Service Bulletin/Repair Instructions
Programming And Activation Of Replacement OnStar Modules.
PIT4864F
Service Bulletin/Repair Instructions
Information On Requests To Add OnStar Bluetooth Option.
PIT5264
Service Bulletin/Repair Instructions
Canadian Customers Unable To Place Calls In The United States
99-08-51-007F
Service Bulletin/Repair Instructions
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels. GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility Outside Company later in this bulletin.
PI0281D
Service Bulletin/Repair Instructions
Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers. Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.
130089009
Service Bulletin/Repair Instructions
Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
10-00-89-009B
Service Bulletin/Repair Instructions
This informational bulletin provides information on key code security and information on GM key code look up applications.
13-00-89-005
Service Bulletin/Repair Instructions
This technical bulletin provides Warranty Administration - New Labor Codes information.
99-04-20-002H
Service Bulletin/Repair Instructions
This technical bulletin provides a revision of 99-04-20-002G to add 2013-2014 model years.
11-00-89-005B
Service Bulletin/Repair Instructions
This warranty administrational bulletin provides information on Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm
PIC5588A
Service Bulletin/Repair Instructions
Programming And Activation Of Replacement OnStar Modules.
SB-020842001B
Service Bulletin/Repair Instructions
GENERAL MOTORS VEHICLES AND TRUCKS: SUBJECT REGARDING, 2002 AND PRIOR PASSENGER CARS AND TRUCKS, CHEMICAL DAMAGE TO EXTERIOR POLYCARBONATE HEADLAMP LENSES. *SLC UPDATED *EH UPDATED 3/30/11. HEADLAMP LENS OVERHEATING WHEN COVERED AND CHEMICAL DAMAGE TO EXTERIOR POLYCARBONATE HEADLAMP LENSES. CAN CAUSE CRAZING OR CRACKING OF HEADLAMP LENS. *PE UPDATED 6/24/11. *PE UPDATED 5/14/12. INCLUDING 2013 MODEL YEAR. *PE
09-09-40-001A
Service Bulletin/Repair Instructions
GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/3/12. *PE
SB-10-08-50-003B
Service Bulletin/Repair Instructions
GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE
PIP-4495C
Service Bulletin/Repair Instructions
GM: THERE MAY BE NOISE COMING FROM THE CYLINDER HEAD, BECAUSE OF LOW OIL PRESSURE WHICH IS CAUSED BY DEBRIS. *RM
PIE-0012
Service Bulletin/Repair Instructions
SATURN: E109213-FUEL SMELL/ODOR OR LEAK NEAR FUEL TANK AREA *ENGINEERING INFORMATION). CUSTOMERS COMPLAIN ABOUT A FUEL SMELL/ODOR WHILE DRIVING OR AFTER THE VEHICLE IS PARKED. SOME DAMPNESS MAY ALSO BE NOTICED ON THE GROUND NEAR THE FUEL TANK AREA. *PE
000310006
Service Bulletin/Repair Instructions
INFORMATION ON TIRE RADIAL FORCE VARIATION (RFV). 2008 AND PRIOR GM PASSENGER CARS AND LIGHT DUTY TRUCKS INCLUDING 2008 AND PRIOR HUMMER H2, H3 AND 2005-08 SAAB 9-7X AND 2000-05 SATURN L SERIES AND 2003-07 SATURN ION. *KB UPDATED 4/11/08. *NJ UPDATED 5/27/09. *PE
08089-B
Service Bulletin/Repair Instructions
GENERAL MOTORS CORP: SPECIAL COVERAGE ADJUSTMENT; ANALOG ONSTAR DEACTIVATION. *PE UPDATED 2/17/09. *PE
08-089
Service Bulletin/Repair Instructions
BUICK CADILLAC CHEVROLET GMC HUMMER OLDSMOBILE PONTIAC SAAB SATURN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT-ANALOG ONSTAR DEACTIVATION. FCC RULED IN 2002 WIRELESS CARRIERS WOULD NO LONGER RE REQUIRED TO SUPPORT ANALOG WIRELESS NETWORK STARTING IN 2008. *PE CSC LETTER WAS RECEIVED. UPDATED 12/1/08. *PE
03-00-89-033
Service Bulletin/Repair Instructions
TRAILER, RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *KB UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ UPDATED 4/3/08. *NJ
SB-00-03-10-006C
Service Bulletin/Repair Instructions
GENERAL MOTORS: INFORMATION ON TIRE RADIAL FORCE VARIATION. VEHICLE MUST BE DRIVEN BEFORE MEASURING TIRES ON EQUIPMENT HUNTER GSP9700 TOENSURE REMOVAL OF ANY FLATSPOTTING. MODELS INCLUDE ALL GM PASSENGER CARS AND LIGHT TRUCKS, AS WELL AS CERTAIN HUMMERS, SAABS, AND SATURNS. *PE
070730025
Service Bulletin/Repair Instructions
INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ
3933
Service Bulletin/Repair Instructions
TIMING BELT REPLACEMENT. *KB
030089033A
Service Bulletin/Repair Instructions
TRAILER, RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *TT *SC
709
Service Bulletin/Repair Instructions
OIL LIFE SYSTEM RESET PROCEDURES - CARS. GM TECH LINK. *TT
030524001
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING SATURN REAR DRUM WHEEL CYLINDER INSPECTIONS. *TT UPDATE. *TT
020232009
Service Bulletin/Repair Instructions
POWER STEERING SYSTEM NOISE AND/OR LEAK DIAGNOSIS. *TT
010604016
Service Bulletin/Repair Instructions
SERVICE ENGINE SOON (SES) TELLTALE ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175. *TT
030089032
Service Bulletin/Repair Instructions
RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION. *TT
040604085
Service Bulletin/Repair Instructions
SERVICE ENGINE SOON (SES) AND/OR REDUCED POWER LAMP ILLUMINATING FOLLOWING COLD ENGINE START UP IN SUBFREEZING TEMPERATURES, DIAGNOSTIC TROUBLE CODES (DTC) P0638, P1510 AND/OR P1516 STORED IN ENGINE CONTROL MODULE (ECM). *TT
040604008
Service Bulletin/Repair Instructions
SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DTC P0135 HO2S HEATER CIRCUIT PERFORMANCE BANK 1 SENSOR 1 AND/OR DTC P0155 HO2S HEATER PERFORMANCE BANK 2 SENSOR 1. *MR THIS BULLETIN REPLACES PREVIOUS 04-06-04-008. *EH
990091002D
Service Bulletin/Repair Instructions
STEERING WHEEL SHAKE OR VIBRATION AT HIGHWAY SPEEDS. *TT UPDATE. *TT
030849022A
Service Bulletin/Repair Instructions
FUEL GAUGE DISPLAYS AN ERRATIC OR FALSE READING OR NO START CONDITION AFTER VEHICLE IS SHUT OFF WITH LOW FUEL LEVEL. *TT THIS BULLETIN REPLACES PREVIOUS DATED 12/01/03. *TT THIS BULLETIN REPLACES PREVIOUS DATED 08/01/04. *TT
040235008
Service Bulletin/Repair Instructions
CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION. *TT
040601004
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING ENGINE SUPPORT DURING REMOVAL OF RIGHT FRONT ENGINE MOUNT ASSEMBLY. *TT
040842001
Service Bulletin/Repair Instructions
INFORMATION ON INTERMITTENT DIMMING (FLICKERING) OF HEADLAMPS AND/OR INSTRUMENT PANEL LIGHTING-NORMAL CHARACTERISTIC. THIS MAY OCCUR BECAUSE OF TRANSIENT CURRENT LOADS ON THE ELECTRICAL SYSTEM DURING NORMAL VEHICLE OPERATION. *MN
0804
Service Bulletin/Repair Instructions
OIL LIFE SYSTEM RESET PROCEDURES - CARS. *NM
040844015
Service Bulletin/Repair Instructions
RETURN FORM FOR COMPACT DISCS (CDS) OR DIGITAL VERSATILE DISCS (DVDS) THAT ARE STUCK IN CD PLAYER WHEN RETURNED AS A CORE RETURN. *TT
040137005
Service Bulletin/Repair Instructions
INFORMATION REGARDING AIR CONDITIONING (A/C) COMPRESSOR NOISE AT ENGINE START (A/C OR DEFROST MODE SELECTED) OR AT A/C OR DEFROST ACTIVATION (AFTER ENGINE START). *TT
040601011
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE FOR ENGINE BLOCK CLEARANCE, CYLINDER HEAD CLEARANCE AND FASTENER TORQUE SPECIFICATIONS. *TT
040089012
Service Bulletin/Repair Instructions
SATURN FIELD PRODUCT REMINDER- VEHICLE FIX IT RIGHT THE FIRST TIME ISSUES, PARTS RESTRICTION INFORMATION AND TECHNICAL BULLETINS RELEASED IN JANUARY, FEBRUARY, AND MARCH 2004. *MR
040310003
Service Bulletin/Repair Instructions
INFORMATION ON CLICKING NOISE FROM CHROME CLAD WHEELS AT LOW SPEEDS- NORMAL CHARACTERISTIC/ NO SERVICE REQUIRED. ALSO INCLUDING 2004-2005 SATURN L-SERIES. *MR
040601009
Service Bulletin/Repair Instructions
OIL LEAK FROM FRONT COVER SEAL DURING EXTREMELY COLD WEATHER. *TT
040601010
Service Bulletin/Repair Instructions
BLUE SMOKE AT ENGINE START-UP. *TT
040730020
Service Bulletin/Repair Instructions
SERVICE VEHICLE SOON LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1811 MAXIMUM ADAPT AND LONG SHIFTS. *TT
030844019
Service Bulletin/Repair Instructions
LOW VOLUME TICKING NOISE, RADIO VOLUME RESOLUTION OR CD WILL NOT LOAD/EJECT. *TT
040846001
Service Bulletin/Repair Instructions
SERVICE SUPPORT AND TECHNICAL ASSISTANCE FOR ONSTAR AND/OR XM RADIO. *MJ
040139001
Service Bulletin/Repair Instructions
AUTOMATIC CLIMATE CONTROL OVERCOMPENSATION. *MR
3036
Service Bulletin/Repair Instructions
DARK RECTANGLES OR CIRCLES IN THE CENTER OF THE ROOF. *TT
3037
Service Bulletin/Repair Instructions
THUMP NOISE/VIBRATION/FLAT SPOTTED TIRES ON VEHICLE. *TT
3099
Service Bulletin/Repair Instructions
ROUTING THE LONGER TUNED POWER STEERING HOSE PER TSB 03-02-32-045. *SC
3116
Service Bulletin/Repair Instructions
SES ILLUMINATED ENGINE MISS/MISFIRE FEEL OR ROUGH IDLE. *SC
3119
Service Bulletin/Repair Instructions
NO SELECTION FIR SATURN WHEN PROGRAMMING A SATURN VEHILCLE. *SC
3135
Service Bulletin/Repair Instructions
POP NOISE FROM ENGINE AREA DURING HEAVY THROTTLE INPUT. *TC
030139015
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE REGARDING A CHANGE IN THE DEFROST OPERATION FOR THE AUTOMATIC CLIMATE CONTROL. *TT
030844016A
Service Bulletin/Repair Instructions
COMPACT DISCS (CDS) SKIP IN SINGLE CD PLAYER. *TT
030139014
Service Bulletin/Repair Instructions
SERVICE INFORMATION ON REPLACING AUTO CLIMATE CONTROL (ACC) CONTROL HEAD. *TT
030843005
Service Bulletin/Repair Instructions
LITTLE OR NO WINDSHIELD SOLVENT COMING FROM WASHER NOZZLES. *TT
030089025
Service Bulletin/Repair Instructions
CLARIFICATION OF LABOR CODES USED FOR REPROGRAMMING VEHICLE CONTROLLERS. VARIOUS MODELS INCLUDING THE 2004 L-SERIES. *TT
030090003
Service Bulletin/Repair Instructions
OIL FILTER CAP ASSEMBLY AND OIL FILTER ELEMENT DESIGN CHANGE. *TT
030232045
Service Bulletin/Repair Instructions
MOAN OR GROAN NOISE WHEN TURNING STEERING WHEEL AT LOW SPEEDS. *TT
030604043
Service Bulletin/Repair Instructions
MALFUNCTION INDICATOR LAMP (MIL) SERVICE ENGINE SOON TELLTALE LAMP ON, REDUCED POWER LAMP MAY ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES P0121, P0221, AND/OR P2135. *TT
030844017
Service Bulletin/Repair Instructions
CHANGES TO THE AM/FM STEREO AND AUDIO DISC PLAYER RADIO ON-BOARD DIAGNOSTIC MODES AND CD LOAD OPERATION. *TT
030856002
Service Bulletin/Repair Instructions
INTERMITTENT SECURITY TELLTALE ILLUMINATION AND/OR DIAGNOSTIC TROUBLE CODE B2960. *TT
030941004
Service Bulletin/Repair Instructions
RATTLE OR BUZZ NOISE FROM REAR OF PASSENGER COMPARTMENT. CURTAIN INFLATOR (SIDE AIRBAG) MODULE CONTACTING THE VEHICLE FRAME. *TT
030139012
Service Bulletin/Repair Instructions
ODOR FROM AIR CONDITIONING AT VEHICLE START-UP. *TT
030844010
Service Bulletin/Repair Instructions
SIX-DISC RADIO WILL NOT LOAD, EJECT AND/OR PLAY COMPACT DISCS (CDS). *TT
030849011
Service Bulletin/Repair Instructions
CENTER CONSOLE ARM REST LID CONTACTS LUMBAR ADJUSTER KNOB. *TT
030601017
Service Bulletin/Repair Instructions
TIMING CHAIN DESIGN CHANGE AND REVISED SERVICE PROCEDURES. *TT
030731004
Service Bulletin/Repair Instructions
BLEEDING PROCEDURE FOR HYDRAULIC CLUTCH RELEASE SYSTEM INCLUDING CLUTCH ACTUATOR CYLINDER. *TT
030139002A
Service Bulletin/Repair Instructions
AUTOMATIC CLIMATE CONTROL PERFORMANCE. *TT
030601014
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE REGARDING THE USE OF SATURN SPECIAL TOOL J-42065 CRANK HUB HOLDING TOOL. *TT
030601015
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE FOR REMOVAL OF THE SEALER USED ON OIL PUMP GASKET DURING OIL PUMP INSTALLATION. *TT
030850010
Service Bulletin/Repair Instructions
POWER DRIVER SEAT INOPERABLE. *TT
030310003
Service Bulletin/Repair Instructions
WHEN MAKING A FULL LEFT TURN ON VEHICLES EQUIPPED WITH P215/55R16 TIRES, A RUBBING NOISE MAY BE ENCOUNTERED COMING FROM THE RIGHT FRONT INNER FENDER AREA. *TT
030602002
Service Bulletin/Repair Instructions
INSUFFICIENT HEAT, SERVICE ENGINE SOON (MALFUNCTION INDICATOR LAMP) TELLTALE ON, DIAGNOSTIC TROUBLE CODE P0128 SET. *TT
030604016
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING THE ENGINE CONTROL MODULE (ECM) CONNECTOR AND TERMINAL LOCATIONS ON SATURN V6 ENGINES. *TT
030844007
Service Bulletin/Repair Instructions
INFORMATION FOR CONCERNS ON NOISE HEARD THROUGH THE AUDIO SYSTEM WHEN ANOTHER ELECTRICAL COMPONENT IS ACTIVATED OR USED. *TT
030853001
Service Bulletin/Repair Instructions
DEFROSTER GRILLE POPPING NOISE ENCOUNTERED DURING COLD TEMPERATURES. *TT
03T10
Service Bulletin/Repair Instructions
AUTOMATIC CLIMATE CONTROL PERFORMANCE. *TT
03T04
Service Bulletin/Repair Instructions
SPARK PLUG USAGE CHANGE, AND IF NECESSARY, UPDATE PCM (POWER TRAIN CONTROL MODULE) CALIBRATION. *TT
03T01
Service Bulletin/Repair Instructions
SERVICE ENGINE MISFIRE ON PAIRED CYLINDERS (1 AND 4 OR 2 AND 3), DIAGNOSTIC TROUBLE CODES P0300 - P0304 2.2L 4 CYL REVISED REPAIR PROCEDURE. *TT
03T03
Service Bulletin/Repair Instructions
LOOSE OR TORN SEAT COVERS. *TT
02T86
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING ELIMINATION OF AUXILIARY WATER PUMP AND INSTRUMENTS TO INSTALL 2ND DESIGN HEATER INLET HOSE AND HEATER INLET ELBOW IN PLACE OF THE 1ST DESIGN WATER PUMP AND HEATER INLET HOSE. *TT
02T77
Service Bulletin/Repair Instructions
WHISTLE NOISE FROM POWER STEERING WHILE TURNING LEFT. *TT
02T70
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE FOR CERTAIN 2002-2003 MODEL POWERTRAIN ELECTRICAL DIAGNOSTICS SERVICE MANUALS REGARDING DIAGNOSTIC TROUBLE CODES (DTC) P0218, P0711, P0712, P0713, P1810, P1815, P1816, P1817, P1818, P1860 AND P1887. *TT
02I01A
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING REAR SEAT ENTERTAINMENT SYSTEM DIAGNOSTIC AND SERVICE PROCEDURES. *TT
02T62
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING REDESIGNED WIPER LINKAGE AND NEW SERVICE PROCEDURES. *JG
00T72A
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR CHASSIS SERVICE MANUALSS REGARDING ALIGNMENT SPECIFICATIONS AND SERVICE PROCEDURE FOR INSTALLATION OF SPACERS BETWEEN REAR SUSPENSION SUPPORT AND VEHICLE BODY WHEN PERFORMING WHEEL ALIGNMENT. *JG
02T49
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1441 SET IN PCM HISTORY (INSTALL NEW PCM CALIBRATION) *JG
02T58
Service Bulletin/Repair Instructions
SUBJECT REGARDING REAR SEAT ENTERTAINMENT DVD SCREEN WILL NOT LATCH IN STOWED POSITION. (REPLACE MOUNTIG SPRING BUTTON) *JG
99T55C
Service Bulletin/Repair Instructions
SOME CONSUMERS MAY COMPLAIN ABOUT A STEERING WHEEL SHAKE OR VIBRATION FELT WHEN DRIVING VEHICLE AT HIGHWAY SPEEDS. THIS CONDITION IS MOST NOTICEABLE ON SMOOTH ROAD SURFACES AT VEHICLE SPEEDS ABOVE 65MPH (105 KM/H) *JG
01T36A
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE PLACEMENT OF VEHICLE BADGES ON DECKLID APPLIQUE OR LIFTGATE. *JG
02T42
Service Bulletin/Repair Instructions
SUBJECT REGARDING SQUEAK, RATTLE AND POOR FIT FROM DEFROSTER GRILLE (INSTALL REDESIGNED DEFROSTER GRILLE) *JG
02T43
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR TRANSAXLE SERVICE MANUALS REGARDING NEW DIFFERENTIAL RING GEAR REPLACEMENT PROCEDURE. *JG
02T44
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE INFORMATION REGARDING NEW DESIGN LINE PRESSURE CONTROL SOLENOIDS. *JG
02T46
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING POWER STEERING SYSTEM NOISE AND/OR LEAK DIAGNOSIS. *JG
02T48
Service Bulletin/Repair Instructions
SUBJECT REGARDING MASS AIR FLOW SENSOR FAILURE DUE TO OIL CONTAMINATION OF SENSOR MEMBRANE (INSTALL NEW MASS AIR FLOW (MAF) SENSOR AND UPDATE ELECTRONIC CONTROL MODULE CALIBRATION) *JG
02T26
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING NEW POSITIVE AND NEGATIVE BATTERY CABLE REPLACEMENT PROCEDURES. *JG
02T27
Service Bulletin/Repair Instructions
SOME CONSUMERS MAY COMPLAIN THAT THE REAR DOOR GLASS IS INOPERATIVE OR DISPLAYS ERRATIC OPERATION. *JG
02T37
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE INFORMATION ON NEW OIL COOLER COVER SEALANT. *JG
02C07
Service Bulletin/Repair Instructions
SUBJECT REGARDING INACCURATE ODOMETER READING AFTER LOSS OF BATTERY POWER. *JG
02T18
Service Bulletin/Repair Instructions
SUBJECT REGARDING ONSTAR SYSTEM UNABLE TO SEND OR RECEIVE CELLULAR PHONE CALLS.*JB
02T19
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING ONSTAR COMMUNICATION AND INTERFACE MODULE (CIM) PROGRAMMING. *TT
02T22
Service Bulletin/Repair Instructions
SUBJECT REGARDING WHISTLE NOISE UNDER CERTAIN ENGINE OPERATING CONSITIONS. *JG
02T23
Service Bulletin/Repair Instructions
SUBJECT REGARDING MUFFLED TONE OR INTERMITTENT LOW OR NO TONE FROM HORN. *JG
02T16
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING DESIGN CHANGE TO THERMOSTAT HOUSING, THERMOSTAT HOUSING BOLTS, AND THERMOSTAT HOUSING O-RING SEAL. *TT
02T17
Service Bulletin/Repair Instructions
INFORMATION ON SERVICE ENGINE SOON LAMP ILLUMINATED.*JB
99T55B
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXPERIENCE STEERING WHEEL SHAKE OR VIBRATION AT HIGHWAY SPEEDS.*JB
00T17C
Service Bulletin/Repair Instructions
SUBJECT REGARDING HEADLINER SAGS OR HANGS TOO LOW AT REAR OF SUNROOF OPENING. *YD
01T01A
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY COMMENT ABOUT A VIBRATION OR BOOM NOISE INSIDE THE VEHICLE WHILE AT IDLE AND THE AIR CONDITIONER IS ON. *JG
02T03
Service Bulletin/Repair Instructions
SUBJECT REGARDING AUTOMATIC CLIMATE CONTROL SYSTEM OVERCOMPENSATION AND EXCESSIVE ELECTRIC PARASITIC DRAW (INSTALL UPDATED AUTOMATIC CLIMATE CONTROL MODULE CALIBRATION). *JG
02T04
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE MANUAL AND QUICK REFERENCE SPECIFICATIONS GUIDE UPDATE REGARDING INCORRECT CYLINDER HEAD BOLT TORQUE SPECIFICATIONS. *SLC
02T05
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE REGARDING FRONT SEAT CUSHION COVER/PAD REMOVAL AND INSTALLATION. *SLC
02T06
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR CHASSIS SERVICE MANUALS REGARDING FRONT STRUT ASSEMBLY PROCEDURE. *SLC
01T61
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE INFORMATION REGARDING TRANSAXLE SHIFT ADAPTIVES RESET PROCEDURE. *SLC
01T55
Service Bulletin/Repair Instructions
SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING CRUISE CONTROL DIAGNOSTICS. *JG
01T56
Service Bulletin/Repair Instructions
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING DIAGNOSTIC TROBLE CODES AND FLOWCHARTS. *JG
01T57
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO INCORRECT PART NUMBER AND REPOSITIONING INSTRUCTION STAMPED ON SIR ROLL COIL CONNECTOR.*JB
01T58
Service Bulletin/Repair Instructions
SERVICE MANUAL REGARDING SOLENOID CIRCUIT SCHEMATIC, INPUT SPEED SENSOR PERFORMANCE, AND INPUT SPEED SENSOR CIRCUIT LOW VOLTAGE SCHEMATICS. *JG
00T66A
Service Bulletin/Repair Instructions
INFORMATION REGARDING ENGINE OIL LEAKS AND OR ENGINE COOLANT LEAKS. *YH
01I10
Service Bulletin/Repair Instructions
SUBJECT REGARDING CHANGE IN PRODUCTION WINDOW WASHER SOLVENT. *JG
01T49
Service Bulletin/Repair Instructions
SUBJECT REGARDING OUTSIDE AIR TEMPERATURE SENSOR SERVICE PROCEDURE. *JG
01T50
Service Bulletin/Repair Instructions
INFORMATION REGARDING SERVICE MANUAL UPDATES, ENGINE SERVICE MANUALS, AND BODY/ELECTRICAL VOLUME II SERVICE MANUALS. *JG
01T51
Service Bulletin/Repair Instructions
SUBJECT REGARDING NEW IGNITION LOCK CYLINDER DESIGN AND NEW KEY CODES FOR IGNITION LOCK CYLINDER AND KEY CUTS. *JG
01T52
Service Bulletin/Repair Instructions
SUBJECT PERTAINING TO A RATTLE NOISE FROM REAR OF VEHICLE WHILE DRIVING, VEHICLES EQUIPPED WITH REAR ANTILOCK DISC BRAKES.*JB
01T36
Service Bulletin/Repair Instructions
SUBJECT REGARDING PLACEMENT OF VEHICLE MODEL BADGES ON DECKLID APPLIQUE OR LIFTGATE. *JG
00T17B
Service Bulletin/Repair Instructions
CUSTOMERS MAY COMPLAIN OF HEADLINER SAGGING OR HANGING TOO LOW AT THE REAR OF THE SUNROOF OPENING. *SLC
00T41A
Service Bulletin/Repair Instructions
CUSTOMERS MAY COMPLAIN OF WATER LEAKING INTO THE PASSENGER COMPARTMENT AND/OR REAR COMPARTMENT CARGO AREA. *SLC
01T06A
Service Bulletin/Repair Instructions
CUSTOMERS MAY COMPLAIN THAT THE REAR FASCIA TO QUARTER PANEL IS NOT CORRECTLY ALIGNED. *SLC
01T34
Service Bulletin/Repair Instructions
INFORMATION REGARDING FRONT BRAKE ROTOR MINIMUM THICKNESS AFTER REFINISH AND DISCARD THICKNESS SPECIFICATONS. *SLC
01T37
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY COMPLAIN OF THE SERVICE ENGINE SOON LAMP ILLUMINATING WITH P0116 OR P1683 SET IN PCM HISTORY. *SLC
01T38
Service Bulletin/Repair Instructions
SERVICE MANUAL REVISION REGARDING BODY/ELECTRICAL VOLUME II. *SLC
01T39
Service Bulletin/Repair Instructions
SERVICE INFORMATION REGARDING REDESIGNED OIL FILTER ELEMENT AND OIL FILTER CAP. *TT
01T40
Service Bulletin/Repair Instructions
INFORMATION REGARDING 1ST AND 2ND DESIGN OIL FILTER ELEMENTS AND OIL FILTER CAPS AVAILABLE FOR THE 4 CYLINDER ENGINE AND HOW TO DETERMINE WHICH OIL FILTER AND CAP COMBINATION SHOULD BE USED. *SLC
99T36A
Service Bulletin/Repair Instructions
CUSTOMERS MAY COMPLAIN OF A RATTLE TYPE NOISE THAT SEEMS TO BE COMING FROM REAR OF VEHICLE WHEN TRAVELING OVER ROUGH ROAD SURFACES. *SLC
99T69B
Service Bulletin/Repair Instructions
SOME CUSTOMERS MAY COMPLAIN OF RATTLE NOISES HEARD IN AREA OF DOME LAMP, SUNROOF, OR HEADLINER DURING NORMAL OPERATING CONDITIONS. *SLC
99Y69N
Service Bulletin/Repair Instructions
EXPERIENCING RATTLE NOISES HEARD IN AREA OF DOME LAMP, SUNROOF, ORHEADLINER DURINGNORMAL OPERATING CONDITIONS. *TT
01I04
Service Bulletin/Repair Instructions
SERVICE INFORMATION ON CALIFORNIA VEHICLE CODE REQUIREMENTS REGARDING 2002 MODELYEAR TIRE CHAIN DISCLOSURE FOR VARIOUS MODELS INCLUDING SATURN VUE. *TT
3295
Service Bulletin/Repair Instructions
SERVICE WRENCH AND SES TELLTALE MAY BE ILLUMINATED AND TRANSAXLE MAY SHIFT HARSHLY. *EH
3419
Service Bulletin/Repair Instructions
IGNITION KEY WILL NOT ROTATE BACK TO OFF POSITION OR SHIFT LEVER WILL NOT MOVE OUT OF PARK. *TT
3648
Service Bulletin/Repair Instructions
HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION. *TT
3668
Service Bulletin/Repair Instructions
TICK NOISE FROM ENGINE. *TT
3859
Service Bulletin/Repair Instructions
LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE. *KB UPDATED 10/18/07. *NJ
4014
Service Bulletin/Repair Instructions
PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE. *KB
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.