Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
LI09.40-N-070781
Check engine light on and fault codes P3005A9, P3005FF, P30074B in CDI Control Unit
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
LI41 10-N-068968
Noise on propeller shaft/rear axle from approx. 25mph
LI4700N069277
Engine running complaints - Fault code P062700 current and/or stored in FSCU (N118)
LI0716N069263
Fuel Injector Electrical Fault With Fault Codes
Weekly Parts Upd
Status of Parts Ordering - Sprinter
LI41-10-N-068968
Noise on propeller shaft/rear axle as from 35mph
GI49 00-N-067800
Automatic transmission housing cracked - Consequential damage due to cracked diesel particulate filter bracket
Parts Update - J
Status of Parts Ordering - Sprinter
LI54.00-N-068243
Transport mode active/transport mode cannot be deactivated
Sprinter October
Status of Parts Ordering - Sprinter
Sprinter Septemb
Status of Parts Ordering - Sprinter
Sprinter July 28
Status of Parts Ordering - Sprinter
Sprinter July 14
Status of Parts Ordering - Sprinter
LI54 25-N-065909
447 Metris does not shift out of Park
LI33 00-N-066643
Ball joint check on front axle
Sprinter June 30
Status of Parts Ordering - Sprinter
Sprinter June 23
Status of Parts Ordering - Sprinter
LI14 20-N-051286
Exhaust gas recirculation (EGR) valve leaking or not closing properly
LI91 40-N-051128
Seat belt does not roll up correctly
LI32 20-N-066562
Creaking noises at front spring at low outside temperatures
Sprinter June 16
Status of Parts Ordering - Sprinter
LI27 60-N-048766
ESM (electronic selector lever module) fault 0002 "Undervoltage"
LI54 25-N-061756
ESP indicator lamp active, fault code C007500 in ESP control unit
LI68 74-N-057463
Sliding door in partition wall cannot be locked in open position
LI88 10-N-062698
Installation position of fender liner twisted at rear
LI91 40-N-066319
SRS Lamp Illuminated
Sprinter June 9-
Status of Parts Ordering - Sprinter
LI54 65-N-062609
Signal tone of Parktronic system (PTS) too quiet
LI83 25-N-062699
Noise from area of blower motor with climate control switched on
LI46 10-P-065829
Lane Keeping Assist: Fault message in instrument cluster, function not available.
Sprinter June 2-
Status of Parts Ordering - Sprinter
LI18 00-N-054809
Engine oil level above max, oil indicator light on
LI49.10-N-060969
OM651 Exhaust Bracket Cracking
R2118796A
Valve Body. These may cause over drive cycling.
9003215
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
SB-32-20-01
SPRINTER: REPLACING TORSION BAR MOUNTS. CODES C40 FRONT AXLE STABILIZER BAR AND C45 REINFORCED FRONT AXLE STABILIZER BAR (EXCEPT CODES ZG1 ENGAGEABLE ALL WHEEL DRIVE AND EXCEPT CODE ZG3 ENGAGEABLE ALL WHEEL DRIVE WITH GEAR REDUCTION. *PE
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.