Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004009
Service Bulletin/Repair Instructions
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
T21 Combo Rev4
Service Bulletin/Repair Instructions
Emissions Recall T21 Reprogram Engine Control Unit
9004275
Service Bulletin/Repair Instructions
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
23-015-20
Service Bulletin/Repair Instructions
Disinfectant Solution Recommended for COVID-19
08-049-20
Service Bulletin/Repair Instructions
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
LI09.40-N-070781
Service Bulletin/Repair Instructions
Check engine light on and fault codes P3005A9, P3005FF, P30074B in CDI Control Unit
31-003-19
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
LI41 10-N-068968
Service Bulletin/Repair Instructions
Noise on propeller shaft/rear axle from approx. 25mph
LI4700N069277
Service Bulletin/Repair Instructions
Engine running complaints - Fault code P062700 current and/or stored in FSCU (N118)
LI0716N069263
Service Bulletin/Repair Instructions
Fuel Injector Electrical Fault With Fault Codes
Weekly Parts Upd
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI41-10-N-068968
Service Bulletin/Repair Instructions
Noise on propeller shaft/rear axle as from 35mph
GI49 00-N-067800
Service Bulletin/Repair Instructions
Automatic transmission housing cracked - Consequential damage due to cracked diesel particulate filter bracket
Parts Update - J
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI54.00-N-068243
Service Bulletin/Repair Instructions
Transport mode active/transport mode cannot be deactivated
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
Sprinter October
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
Sprinter Septemb
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
Sprinter July 28
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
Sprinter July 14
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI54 25-N-065909
Service Bulletin/Repair Instructions
447 Metris does not shift out of Park
LI33 00-N-066643
Service Bulletin/Repair Instructions
Ball joint check on front axle
Sprinter June 30
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
Sprinter June 23
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI14 20-N-051286
Service Bulletin/Repair Instructions
Exhaust gas recirculation (EGR) valve leaking or not closing properly
LI91 40-N-051128
Service Bulletin/Repair Instructions
Seat belt does not roll up correctly
LI32 20-N-066562
Service Bulletin/Repair Instructions
Creaking noises at front spring at low outside temperatures
Sprinter June 16
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI27 60-N-048766
Service Bulletin/Repair Instructions
ESM (electronic selector lever module) fault 0002 "Undervoltage"
LI54 25-N-061756
Service Bulletin/Repair Instructions
ESP indicator lamp active, fault code C007500 in ESP control unit
LI68 74-N-057463
Service Bulletin/Repair Instructions
Sliding door in partition wall cannot be locked in open position
LI88 10-N-062698
Service Bulletin/Repair Instructions
Installation position of fender liner twisted at rear
LI91 40-N-066319
Service Bulletin/Repair Instructions
SRS Lamp Illuminated
Sprinter June 9-
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI54 65-N-062609
Service Bulletin/Repair Instructions
Signal tone of Parktronic system (PTS) too quiet
LI83 25-N-062699
Service Bulletin/Repair Instructions
Noise from area of blower motor with climate control switched on
LI46 10-P-065829
Service Bulletin/Repair Instructions
Lane Keeping Assist: Fault message in instrument cluster, function not available.
Sprinter June 2-
Service Bulletin/Repair Instructions
Status of Parts Ordering - Sprinter
LI18 00-N-054809
Service Bulletin/Repair Instructions
Engine oil level above max, oil indicator light on
LI49.10-N-060969
Service Bulletin/Repair Instructions
OM651 Exhaust Bracket Cracking
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
R2118796A
Service Bulletin/Repair Instructions
Valve Body. These may cause over drive cycling.
RL108213A$
Service Bulletin/Repair Instructions
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
9003215
Service Bulletin/Repair Instructions
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
9002887
Service Bulletin/Repair Instructions
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
9002519
Service Bulletin/Repair Instructions
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
SB-32-20-01
Service Bulletin/Repair Instructions
SPRINTER: REPLACING TORSION BAR MOUNTS. CODES C40 FRONT AXLE STABILIZER BAR AND C45 REINFORCED FRONT AXLE STABILIZER BAR (EXCEPT CODES ZG1 ENGAGEABLE ALL WHEEL DRIVE AND EXCEPT CODE ZG3 ENGAGEABLE ALL WHEEL DRIVE WITH GEAR REDUCTION. *PE