Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9100226
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
23-015-20
Disinfectant Solution Recommended for COVID-19
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
LI09.40-N-070781
Check engine light on and fault codes P3005A9, P3005FF, P30074B in CDI Control Unit
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
9003220
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
LI41 10-N-068968
Noise on propeller shaft/rear axle from approx. 25mph
LI4700N069277
Engine running complaints - Fault code P062700 current and/or stored in FSCU (N118)
LI0716N069263
Fuel Injector Electrical Fault With Fault Codes
Weekly Parts Upd
Status of Parts Ordering - Sprinter
LI41-10-N-068968
Noise on propeller shaft/rear axle as from 35mph
GI49 00-N-067800
Automatic transmission housing cracked - Consequential damage due to cracked diesel particulate filter bracket
Parts Update - J
Status of Parts Ordering - Sprinter
LI54.00-N-068243
Transport mode active/transport mode cannot be deactivated
Sprinter Weekly
Status of Parts Ordering - Sprinter
14CSA23
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
Sprinter October
Status of Parts Ordering - Sprinter
Sprinter Septemb
Status of Parts Ordering - Sprinter
Sprinter July 28
Status of Parts Ordering - Sprinter
Sprinter July 14
Status of Parts Ordering - Sprinter
LI54 25-N-065909
447 Metris does not shift out of Park
LI33 00-N-066643
Ball joint check on front axle
Sprinter June 30
Status of Parts Ordering - Sprinter
Sprinter June 23
Status of Parts Ordering - Sprinter
LI14 20-N-051286
Exhaust gas recirculation (EGR) valve leaking or not closing properly
LI91 40-N-051128
Seat belt does not roll up correctly
LI32 20-N-066562
Creaking noises at front spring at low outside temperatures
Sprinter June 16
Status of Parts Ordering - Sprinter
LI27 60-N-048766
ESM (electronic selector lever module) fault 0002 "Undervoltage"
LI54 25-N-061756
ESP indicator lamp active, fault code C007500 in ESP control unit
LI68 74-N-057463
Sliding door in partition wall cannot be locked in open position
LI88 10-N-062698
Installation position of fender liner twisted at rear
LI91 40-N-066319
SRS Lamp Illuminated
Sprinter June 9-
Status of Parts Ordering - Sprinter
LI54 65-N-062609
Signal tone of Parktronic system (PTS) too quiet
LI83 25-N-062699
Noise from area of blower motor with climate control switched on
LI46 10-P-065829
Lane Keeping Assist: Fault message in instrument cluster, function not available.
Sprinter June 2-
Status of Parts Ordering - Sprinter
LI18 00-N-054809
Engine oil level above max, oil indicator light on
9003687
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
9003681
Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
LI49.10-N-060969
OM651 Exhaust Bracket Cracking
08-052-16
Flash: UConnect and Voice Recognition Inoperative This bulletin involves replacing the Hands Free Module (HFM). The customer may describe the following conditions: · A complete loss of UConnect operation. · A complete loss of Voice Recognition functionality
16TS7
16TS7 Reman Diesel Particulate Filter Serial Number
R2118796A
Valve Body. These may cause over drive cycling.
RL108213A$
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
9003215
Part Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications. An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
9002887
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications. To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
14TL8
14TL8 TorcUP? Non-Impacting Torque Tool.
14CSA22
14CSA22 DTNA Chassis Wiring Diagrams
14TL9
14TL9 Special Tool Warranty Program.
14TL7
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
sb2080
sb2080 Australian CST M1400 Isolated Radiator Retrofit
14TL2
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
14TL5 ABS Power Line Carrier Converter Available Through PDC
14TS19
14TS19 DD Platform High Pressure Fuel Lines
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.