Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CSA-047
Other
Mercedes-Benz Campaign #2025070001 Software Update. Mercedes-Benz AG, the manufacturer of Mercedes-Benz Sprinter vans, has determined that on certain Model Years 2017-2021 Sprinter vehicles, the software of the engine control unit might not meet specifications. In this case, the IUMPR function of the OBD system might not perform as intended under certain circumstances. An authorized Mercedes-Benz Sprinter dealer will update the Engine Control Unit software on your vehicle in connection with this Service Campaign at no charge to you.
MCD-012
Other
Instructions only ( no letter), on how to install a cover on the battery pack box for 2021 and 2022 Cahabas. Instuctions emailed only.
CSA-044
Other
From Mercedes-Benz: Mercedes=Benz is extending the coverage of the exhaust gas recirculation (EGR) valve on vehicle from the vehicle's basic warranty of 5 years/100,000 miles to 15 years/150,000 miles (whichever occurs first) and applies to the vehicle regardless of ownership. Extension is being given because M/B has determined that dimensional variations during engine valve seating may cause the EGR valve to be switched off, and the vehicle may experience a loss of power and enter a limp home mode. The MIL will illuminate and remain illuminated until the vehicle is serviced. When this occurs, the driver may perceive a jerky driving experience while operating the vehicle.
MCD-009
Other
Stopped using the lights we had been using due to expense. Replaced with these, but these new lights have to be wired in instead of just clicking in. These are the instructions to wire in.
SB-67
Service Bulletin/Repair Instructions
Wheel/lug bolts on certain 2021 and 2022 Cahabas may be cross threaded. If the wheel/lug bolts are cross threaded, this would cause difficulties removing the wheel.
SB-066
Service Bulletin/Repair Instructions
On certain 2022 Cahaba Motorhomes equipped with a DragonFly charging system, it may not have the connections for the house batteries wired correctly. If the connections are not correct, that may result in batteries not being able to charge.
CSA-027 (FINAL)
Service Bulletin/Repair Instructions
On certain Sprinter vehicles, the fuse layout of the interior heating ventilation and air conditioning (HVAC) blower motor might not meet the requirements for prolonged operation at the highest blower setting. The interior blower motor circuit may be inadequate, which can allow the wiring harness to overload. Consequently, a risk of fire during operation and a risk of injury cannot be ruled out.
CSA-027 Interim
Service Bulletin/Repair Instructions
On certain Sprinter vehicles, the fuse layout of the interior heating ventilation and air conditioning (HVAC) blower motor might not meet the requirements for prolonged operation at the highest blower setting. The interior blower motor circuit may be inadequate, which can allow the wiring harness to overheat. Consequently, a risk of fire during operation and a risk of injury cannot be ruled out.
CSA-025 Final
Service Bulletin/Repair Instructions
Mercedes-Benz AG, the manufacturer of Mercedes-Benz Sprinter vans, has determined that a defect, which relates to motor vehicle safety, exists in certain Model Year 2019-2022 Mercedes-Benz Sprinter vehicles. a component of the vehicle's park lock system might fatigue, which can cause the parking pawl not to engage and result in a vehicle rollaway. This may increase the risk of a crash. an authorized Mercedes-Benz Sprinter dealer will update the software of various controls units on the affected vehicles, free of charge. This repair will take approximately 1 hour. For any questions regarding this safety recall, please contact Mercedes-Benz USAâs Customer Assistance Center at 1-800-367-6372 or visit their website at https://www.mbvans.com/en/recall-information.
CSA-025
Service Bulletin/Repair Instructions
Mercedes-Benz Safety Recall #22V-796 A component of the vehicle's park lock system might fatigue, which can cause the parking pawl not to engage and result in a vehicle rollaway. This may increase the risk of a crash.
CSA-019 (Final)
Service Bulletin/Repair Instructions
Customer Service Advisory was sent regarding Mercedes Benz Recall # 22V360, The communication module's SIM card could become disabled and prevent a connection with a mobile phone network. In this case, the digital owner's manual as well as the automatic eCall function would not be available, which could preclude or delay the arrival of emergency responders. This could increase the risk of an injury following an emergency event.
CSA-020
Service Bulletin/Repair Instructions
Mercedes-Benz AG (âMBAGâ), the manufacturer of Mercedes-Benz vehicles, has determined that on certain Sprinter vehicles, the Engine Control Unit (ECU) software, Transmission Control Unit (TCU) software and Dosing Control Unit (DCU) software does not correspond to current series production specifications. An authorized Mercedes-Benz Sprinter dealer will update the Engine Control Unit (ECU) software, Transmission Control Unit (TCU) software and Dosing Control Unit (DCU) software.
TIF-021
Service Bulletin/Repair Instructions
Mercedes-Benz has initiated a Recall Campaign for Model Year 2020 Sprinter vehicles to update the Engine Control Unit (ECU) software and Transmission Control Unit (TCU) software in these vehicles. To ensure your vehicle is in compliance with emissions regulations and is covered by the full protection of the emission warranty provisions, it is recommended that you have your vehicle serviced as soon as possible. Failure to do so could be deemed a lack of proper maintenance on your vehicle. This Recall Campaign does not cover any other components, and standard warranty terms and exclusions apply to those components.
CSA-19
Service Bulletin/Repair Instructions
MBAG has determined that on certain Mercedes-Benz Sprinter vehicles, the communication module's SIM card might become disabled and prevent a connection with a mobile phone network. In this case, the manual as well as the automatic eCall function would not be available, which could preclude or delay the arrival of emergency responders. This might increase the risk of an injury following an emergency event.
CSA-17
Service Bulletin/Repair Instructions
Mercedes-Benz's NHTSA #21V-055 recall for "Updating "eCall" Software.
CSA-14
Service Bulletin/Repair Instructions
Replace Tire and Loading Information Label Mercedes-Benz Sprinter vans. Mercedes NHTSA # 22V-073
CSA-12
Service Bulletin/Repair Instructions
MBAG was notified of customer complaints claiming a van had "rolled away" after the driver had selected the Park ("P") gear position and P was displayed to the driver in the instrument cluster. MBAG confirmed that if the vehicle is not properly secured in accordance with the parking instructions in the vehicle Operator's Manual, in particular by always engaging the parking brake after shifting to P, the vehicle could roll from its parked position which could increase the risk of a crash. Always secure the van in accordance with the instructions in the Operator's Manual.