34123.1.7
Service Bulletin/Repair Instructions
This is a Technical Journal: T8 P0EA773 Auxiliary Cooling System Performance. install component 32139082
Vehicle report
2018 VOLVO S90H
Service bulletins
132 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
36202.2.1
Service Bulletin/Repair Instructions
This is a Technical Journal: Vibration/shudder while braking. Replace front brake pads
36899.1.0
Service Bulletin/Repair Instructions
This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700). Download software.
36916.1.0
Service Bulletin/Repair Instructions
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000. Replace the VCM Backup Battery and download the relevant Software.
31698.3.3
Service Bulletin/Repair Instructions
This is a Technical Journal. If you experience difficulty programming remote keys on Hybrid vehicles, please follow the advise in Technical Journal under service.
36665.4.1
Service Bulletin/Repair Instructions
This is a Technical Journal: ERAD (Electric Rear Axle Drive) Bearing Noise. Bearing kit replacement.
36845.1.4
Service Bulletin/Repair Instructions
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
34295.7.1
Service Bulletin/Repair Instructions
This is a Technical Journal: High Voltage Battery repairs. Always repair the battery according to the methods in VIDA.
36845.1.3
Service Bulletin/Repair Instructions
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
35924.1.4
Service Bulletin/Repair Instructions
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time. Use had held tester.
36845.1.2
Service Bulletin/Repair Instructions
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
36376.4.0
Service Bulletin/Repair Instructions
This is a Technical Journal: SR PHEV Cell Module Replacement. Updated BECM software was released
36693.2.1
Service Bulletin/Repair Instructions
This is a Technical Journal: WPC, none or unstable charging. recalibrate the WPC by performing a WPC reload.
34647.6.1
Service Bulletin/Repair Instructions
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
26745.13.14
Service Bulletin/Repair Instructions
This is a Technical Journal: 12V Battery Testing Method
34102.3.1
Service Bulletin/Repair Instructions
This is a Technical Journal: Unnecessary Replacements of TurboCord Charge Cable (PN 31419235)
35912.5.0
Service Bulletin/Repair Instructions
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
36814.1.0
Service Bulletin/Repair Instructions
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
TJ35912.4.0
Service Bulletin/Repair Instructions
Updated Chassis Range.
TJ3666530
Service Bulletin/Repair Instructions
ERAD (Electric Rear Axle Drive) Bearing Noise
C00009
Service Bulletin/Repair Instructions
COMPLIMENTARY UPGRADE C00009 DESCRIPTION.
TJ3656330
Service Bulletin/Repair Instructions
Rubber cushion
TJ35902
Service Bulletin/Repair Instructions
Connectivity services activation - PSIM issues
TJ36455
Service Bulletin/Repair Instructions
Volvo Cars App Android, no climate setting button
TJ36224
Service Bulletin/Repair Instructions
No bass function (High Performance Audio)
SMB00-108C
Service Bulletin/Repair Instructions
Expendable Items Parts List.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-331
Service Bulletin/Repair Instructions
Fuel Filters ( Primary and Secondary ) ( Backwards Compatible ) and Fuel Filter Housings
Special Tools Bu
Service Bulletin/Repair Instructions
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.
Service Manager
Service Bulletin/Repair Instructions
ICUP/Google Built-In Diagnostic Operations
TJ 3622430
Service Bulletin/Repair Instructions
No bass from sound system.
TJ 3622420
Service Bulletin/Repair Instructions
No bass from sound system.
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
KC-281
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And Time Stamps (Two To Four Codes), Possible Vehicle Derate - US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 2019
KC-159
Service Bulletin/Repair Instructions
Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
TJ 35507 6 0
Service Bulletin/Repair Instructions
Outer rear view mirror glass incorrect position after reversing.
TJ 34647 6 0
Service Bulletin/Repair Instructions
Perform a software upgrade in accordance with TJ 31543.
TJ3595620
Service Bulletin/Repair Instructions
If the check engine lamp may appear in the DIM (Driver Information Module) and the listed DTC is
ST 229
Service Bulletin/Repair Instructions
BEV, PHEV Battery, and Powertrain Lift Table.
TJ33867.1.3-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is not always the solution. Road Force balancing detects assembly run out measured under load simulating real world driving conditions and will provide a solution to match mount the tire and rim to minimize loaded run out.
TJ35912.1.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: AC evaporator repair, additional parts needed
TJ35902.1.1-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: Connectivity services activation - PSIM issues
TJ31423.18.1-202
Service Bulletin/Repair Instructions
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA.
TJ35507.5.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ34241.2.3-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: 12V battery message and DTC CEM-B129F96
TJ35507.4.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
SMB00-288-2021-0
Service Bulletin/Repair Instructions
Volvo?s Warranty Department tracks Retailer warranty spending by utilizing the Warranty Retailer Counseling Process (WRCP). The WRCP is used to gauge individual retailer performance on objective measures over time. By setting clear performance expectations and parameters and assisting retailers in focusing on individual processes and procedures, all retailers are provided with adequate tools to help achieve the ultimate goal of qualifying for self-authorization status.
TJ35842.1.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: Noise when turning steering wheel. Check rubber gromet in firewall
TJ34857.6.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
TJ33031.5.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
TJ33617.2.1-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring.
TJ35511.1.0-2021
Service Bulletin/Repair Instructions
This is a Technical Journal: Creaking noise from Steering Wheel Module
TJ33358.7.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: *This journal is re-written in its entirety. The ERAD (Electrical Rear Axle Drive) consists of two main parts, a transmission and an electrical motor. To determine if the transmission or the complete ERAD needs to be exchanged follow instructions under "Service". Instructional film is included as attachment, mp4. The repair method is included as attachment, pdf. Service: If the customer is driving in electric mode and experiences noise from the rear that increase with vehicle speed (that corresponds to the electrical motor speed) it is an electrical motor issue. In this case the complete ERAD is to be exchanged. No DTC(s) are set for this issue. If the customer experiences hesitation when the electrical motor should be engaged or no electrical motor engagement at all, the transmission part needs to be exchanged. This fault results in Clutch DTC(s) as indicated in the list, and a message in DIM (Driver Information Module) "Hybrid system failure, Service required". ERAD transmission is ordered according to normal routines. ERAD transmission Part No. 32240142.
TJ35075.5.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: TG-81SC Rough/hard shift in 3-2
TJ33442.12.0-202
Service Bulletin/Repair Instructions
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split by removing the small screw. Lubricate with graphite grease (PN 1161851) on points as in attachment. Torque for small screw is 8 nm.
TJ32985.5.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Seat belt front, may not retract fully
TJ34567.1.2-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: DTC SRS-B15381B High Voltage battery loop control. The resistance of the circuit can be monitored using the SRS parameter "High voltage battery power supply disconnect"
TJ33442.11.0-202
Service Bulletin/Repair Instructions
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split by removing the small screw. Lubricate with graphite grease (PN 1161851) on points as in attachment. Torque for small screw is 8 nm.
TJ31423.18.0-202
Service Bulletin/Repair Instructions
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA.
TJ34803.2.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. The calibration function itself is not changed compared to previous SW versions, it is only how it is presented in the center display that has been changed.A new calibration will start automatically as soon as the VDDM SW is upgraded.
TJ33442.10.0-202
Service Bulletin/Repair Instructions
This is a technical Journal:If the vehicle has a click sound from the left engine pad, follow the advice under "Service". Make sure that the sound is coming from the engine pad, NOT from the drive shaft. Remove the left engine pad and split by removing the small screw. Lubricate with graphite grease (PN 1161851) on points as in attachment. Torque for small screw is 8 nm.
TJ34241.2.2-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: 12V battery message and DTC CEM-B129F96
ST-001-2020-09-1
Service Bulletin/Repair Instructions
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
TJ32985.4.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Seat belt front, may not retract fully
TJ35075.4.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: TG-81SC Rough/hard shift in 3-2
TJ35507.2.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ35514.1.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Prior Approval for VCM Replacement
TJ33634.1.5-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Some MY 2018 S90 vehicles listed above were built without a USB hub but also include Android Auto functionality. The Android Auto function requires a USB hub in these vehicles to function properly. If a customer is experiencing USB connection issues with Android Auto, the USB hub can be added to these cars at no cost to them. Service: The accessory kit for Smartphone Integration on cars without a dual USB hub must be installed. Kit part number (PN) and application Software Product (SP) are listed below. Installation instructions are attached. Kit: PN 32204786 Application: SP 30795738
SMB00-006-2020-0
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
TJ20803.21.1-202
Service Bulletin/Repair Instructions
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
SMB00-321-2020-0
Service Bulletin/Repair Instructions
Volvo Complimentary Factory Scheduled Maintenance 'FSM330' MY2013 and later. Factory Scheduled Maintenance up to the first 3 years or 36,000 miles (whichever comes first) as recommended in the Volvo Warranty and Maintenance Information booklet.
TJ34071.2.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Info request, loose door sealing strips. replace if needed
SJ1000167-2020-0
Service Bulletin/Repair Instructions
This is a Service Journal: Coolant Filling Equipment Tool
ST-001-2020-01-2
Service Bulletin/Repair Instructions
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
PB28-S29987-2020
Service Bulletin/Repair Instructions
Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Action S29987 on certain model year 2018 - 2020 S60T8, V60T8, S90T8, XC60T8, XC90T8 vehicles. Volvo has identified that the Engine Control Module (ECM) may not correctly monitor the coolant thermostat (between 20 to 60 degrees Celsius). This condition can result in increased vehicle emissions and non-compliance with On Board Diagnostics (OBD) II requirements. The corrective action is a Total Upgrade.
S29987-2020-01-2
Service Bulletin/Repair Instructions
Volvo Car USA LLC and Volvo Car of Canada Ltd (Volvo) on behalf of Volvo Car Corporation, has decided to launch Service Action S29987 on certain model year 2018 - 2020 S60T8, V60T8, S90T8, XC60T8, XC90T8 vehicles. Volvo has identified that the Engine Control Module (ECM) may not correctly monitor the coolant thermostat (between 20 to 60 degrees Celsius). This condition can result in increased vehicle emissions and non-compliance with On Board Diagnostics (OBD) II requirements. The corrective action is a Total Upgrade.
TJ34948.2.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: IHU, screech noise from sound system when ending phone call.
SMB00-444-2020-0
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: Windshield Cleaning Operation Service Interval Change. Will only be performed at 20k
TJ20803.21.0-202
Service Bulletin/Repair Instructions
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
TJ33617.2.0-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring.
TJ34648.1.4-2020
Service Bulletin/Repair Instructions
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
TJ34648.1.3-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Prior Approval - Lack of airflow causing poor cabin cooling
TJ35058.1.3-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions
TJ32892.2.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: PAC 360 side camera, intermittent no image
TJ33235.4.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Check engine lamp and DTC - ECM P050B00
TJ34647.4.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: DIM message about parking brake. Perform software upgrade.
TJ31602.9.4-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Infotainment System Reboots while driving (blank screen).
TJ35340.1.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: "Ghost" DTCs set: SODL-U210052 and SODR-U210052
TJ35344.1.1-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Removal of "SiriusXM Subscription has Expired" Message
TJ33211.7.1-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make sure the vehicle has the latest voice control database installed.
TJ35058.1.2-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions
TJ31946.1.2-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
TJ31946.1.1-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Swapping control modules from vehicle to vehicle for diagnostics should be avoided. Swapping control modules may result in consequential damage to the swapped control module and in certain cases several other control modules in the vehicle. Swapping the Driver Information Module (DIM) is strictly forbidden as the DIM it is the main carrier of the odometer function, and will, in case of swapping, result in manipulated odometer value. Service: Please do NOT swap any control modules from vehicle to vehicle for testing, unless instructed to do so in a Vehicle Report by the Technical Helpdesk
SMB00-006-2019-1
Service Bulletin/Repair Instructions
Software Installation Policy changes.
SMB00-438-2019-1
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: Technician Skillset Requirments
TJ31543.9.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: This Journal is a guide for performing Software Downloads. Service: *See guide updated Oct. 12, 2016 for relevant P5/SPA Software Download information: P5_SPA_SW_Guide.pdf See VIDA Software tab for all other vehicles.The attached checklists can be used for restoring customer settings, where applicable.
TJ33211.7.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: The voice control system on the above referenced models is continuously being improved. At PDS and when attempting to diagnose a customer concern regarding voice controls not working or responding properly, make sure the vehicle has the latest voice control database installed.
ST-001-2019-10-1
Service Bulletin/Repair Instructions
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
TJ20803.20.1-201
Service Bulletin/Repair Instructions
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
TJ21965.7.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Oil in cooling system. New cleaning method developed.
TJ32958.5.0-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: A whining or rattling sound may appear when revving up the engine. ( see attached sample files ). The sound may come from the balance shaft which is fitted in the oil sump area where the noise is most concentrated. A new design of the balance shaft is planned to be introduced 2018-Q2. Replace the balance shaft according the instructions in VIDA. Note: It's extremely important to adjust the new balance shaft with the correct tools according the instructions otherwise the sound may occur again in a short mileage.
TJ35058.1.1-2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions
TJ31602 9 3 2019
Service Bulletin/Repair Instructions
The customer may report that the infotainment system in the vehicle re-starts or reboots intermittently while driving. When this happens the CCD and the center area of the DIM will go blank for a few moments and then start back up as if the vehicle has just been started up. The customer may also notice that the infotainment system is not responding as normal (ex.- long response time) just before this occurs. When the system reboots, some customer settings may change back to a previous setting (ex.- navi destination, climate settings, radio station, etc.)
TJ32469 5 0 2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Gear shift lever inoperable
TJ33557 1 1 2019
Service Bulletin/Repair Instructions
This is a Technical Journal: Prior Approval: T8 ERAD (Electric Rear Axle Drive), Complete
TJ34567 1 1 2019
Service Bulletin/Repair Instructions
This is a Technical Journal: DTC SRS-B15381B High Voltage battery loop control. The resistance of the circuit can be monitored using the SRS parameter "High voltage battery power supply disconnect"
SMB31 010 2019-0
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: High Voltage (HV) Battery Charger Tool loan Process
SMB84 001 2019-0
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: Windshield replacement products.
SMB00325
Service Bulletin/Repair Instructions
Volvo monitors completion rates for all service actions and will complete notification re-mails to vehicle owners when necessary. Listed below are the latest planned owner notification re-mails. Please refer to SMB 00-323 and SMB 00-323A for information on how and where to find the related Service Action documents in VRC2 and TIE.
SMB00321
Service Bulletin/Repair Instructions
To further enhance the customer?s Volvo ownership experience, Volvo Car USA, LLC offers the MY 2013 and later Volvo Complimentary Factory Scheduled Maintenance Program. Model Year 2013 and later vehicles, the service intervals are every 10,000 miles and ALL 2013 and later vehicles must use synthetic oil only.
SMB00-006-2018-0
Service Bulletin/Repair Instructions
Software Installation Policy changes.
SMB00-006C-2018-
Service Bulletin/Repair Instructions
Software Installation Policy changes - Canada
SPJ33644-1-0-201
Service Bulletin/Repair Instructions
This is a Service Product Journal. High Voltage Gloves. Proper use and handling when working on hybrid vehicles
TJ33633-1-2-2018
Service Bulletin/Repair Instructions
This is a Technical Journal: No Internet Connection With Car Modem/"SIM Card Not Inserted" message. In order to restore the connectivity functions, the "Roaming" function must be activated in the vehicle menus.
TJ33235-2-0-2018
Service Bulletin/Repair Instructions
This is a Technical Journal: Check engine lamp and DTC - ECM P050B00
TJ31582a
Service Bulletin/Repair Instructions
12V battery drained with High Voltage charge cable connected
ST-223-2017-10-0
Service Bulletin/Repair Instructions
Please produce a special tool bulletin with the attached information
SMB00-006-2017-0
Service Bulletin/Repair Instructions
Software Installation Policy changes.
PB21-047-2017-05
Service Bulletin/Repair Instructions
Please return stock of part number 31460615 tooth belt kit to your servicing distribution center.
PB21-046-2017-04
Service Bulletin/Repair Instructions
Please return stock of 31430070 service kit to your servicing distribution center.
SPJ32587.2.0-201
Service Bulletin/Repair Instructions
This is a Service Product Journal: VIDA will not support Windows 8.1 after June 30th 2017
ST-220-2017-04-0
Service Bulletin/Repair Instructions
Drill and Drill fixtures tools used in Recall R89714
TJ32593.1.1-2017
Service Bulletin/Repair Instructions
This is a Technical Journal: Region Code Setting for 7" Media/DVD Player After installing the 7" Media Player/DVD Player Rear Seat Entertainment (RSE) accessory, it may be necessary to set the DVD region code to US (region 1)
PB36-065-2017-03
Service Bulletin/Repair Instructions
Please return stock of part number 31674105 Lever Hub to your servicing distribution center.
SMB00-004-2017-0
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: Factory Scheduled Maintenance menu.
TJ19245.1.10-201
Service Bulletin/Repair Instructions
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Vehicle type and platform identification REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 19245 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America YEAR MONTH DAY 2014 02 06 FUNC GROUP : FUNC DESC : 0 Publications Page 1 of 3 Attachment Vehicle Type Eng Struc Week Type Eng Sales Body Gear Steer Model Year Plant Chassis range Desc Range XXX 1927 - 9999 0000001 - 0999999 0 - 0 CSC Customer Symptom Codes Code Description 1C Administrative and Factory scheduled maintenance / Administrative and Factory scheduled maintenance DTC Diagnostic Trouble Codes Rows beginning with * are modified Note ! If using a printed copy of this Technical Journal , first check for the latest online version . Text In our Service Literature , a vehicle is often referred to by its ? type ? , not its ? model ? . For example the 1999 - 2006 Model Year S80 is type ? 184 ? . You may also see the designation , for example ? P2X ? . This is referring to a platform type or vehicle family . If a document states ? P1X ? or ? 5XX ? as an example , it will apply to all models within the platform type . ? 54X ? will apply to the ? 544 ? , ? 545 ? and ? 542 ? models . ? X ? represents variable data . ? Right first time in Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . © 2014 VOLVO CARS OF NORTH AMERICA , LLC Technical Journal 19245 Platform Model Type Model Years Comments P3 S80 124 2007 - V70 135 2008 - 2010 XC70 136 2008 - XC60 156 2010 - S60 134 2011 - V60 155 2015 - P2 S80 184 1999 - 2006 V70 285 2001 - 2007 XC70 295 2001 - 2007 S60 384 2001 - 2009 XC90 275 2003 - P1 S40 544 2004 - 2012 V50 545 2005 - 2012 C30 533 2007 - 2013 C70 542 2006 - 2013 X40 S40 644 2000 - 2004 V40 645 2000 - 2004 900 940 9
smb17-2018-2017-
Service Bulletin/Repair Instructions
This is a Service Manager Bulletin: Retailer Car Delivery Process. All vehicles must have a pre-delivery service and a proper customer delivery. Perform all required maintenance, repairs and updates prior to delivery to customer.
ST-220-2017-03-1
Service Bulletin/Repair Instructions
Drill and Drill fixtures tools used in Recall R89714
TJ32393.1.1-2017
Service Bulletin/Repair Instructions
This is a technical Journal: SPA transport lock and unlocking. The remotes do not function while the vehicle is in Transport Mode. See transport mode instructions
ST-111A-2017-02-
Service Bulletin/Repair Instructions
MIDTRONICS PSC-550S and PSC-700 VEHICLE POWER SUPPLY information
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.