Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
36863.4.0
This is a Technical Journal: DIM Message and DTC IEM P0C0500. 1. Erase the DTC 2. Test drive the vehicle in electrical mode and accelerate until the vehicle reaches a minimum of 30 km/h (19 mph). 3. Perform a new VIDA readout If the DTC IEM P0C0500 does not return, do not replace any parts. Release the car to customer.
37270.2.1
This is a Technical Journal: Text only no attachments - DIM Message and DTC BECM P0C3200. perform a total upgrade of the software please follow the advice under "Service"
37373.8.0
This is a Technical Journal: DIM Message and DTC BECM P0C7800. If the DIM displays a message stating "Drive System Service Required" and the DTC listed below is set, follow the advice under "Service". •Do not replace any parts. This is not hardware-related. •A new BECM software is released in version 3.6.4. or later. Perform a total upgrade according to TJ 31543 and release the car back to customer.
37631.3.0
This is a TJ - text only no attachments - If customer complains of a headlamp error message in DIM, in combination with any of the DTCs stated below, follow advice under "Service".
37774.1.0
This is a TJ - Text plus 1 PDF attachment - f the headlamp horizontal light aim cannot be adjusted via the set screw, If the horizontal light aim cannot be adjusted because the cogwheel knob is broken, do not replace the entire headlamp. Instead, use the spare part kit part number 32476677 to replace the affected component, please follow the instructions under "Service".
37495.3.0
This is a Tech Journal - Text only no attachments - If a customer experiences a “Propulsion System Performance” message in the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".
37867.1.0
This is a TJ only - no attachments If a vehicle has been updated to 5.1.9 SW and experiences one of the error states below in combination with BECM and/or IGM fault codes, please follow the instructions under Service. High Voltage Battery SOC drops down to 0% unexpectedly High Voltage Battery does not charge to 100% SOC Not possible to charge High Voltage Battery
33031.6.0
This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
37839.1.1
This is a TJ - Text plus two .mov attachments - If the customer is experiencing a frozen Sirius Radio banner, meaning in the app view the title of the song and station name will stay on the previous selected station; the audio will be for the station that is selected and not what is shown on the screen, follow the advice on this TJ under “Service”
37373.7.0
This is a Technical Journal: DIM Message and DTC BECM P0C7800. If the DIM displays a message stating "Drive System Service Required" and the DTC listed below is set, follow the advice under "Service". •Do not replace any parts. This is not hardware-related. •A new Battery Energy Control Module software is released in software version 5.1.9. Perform a Total Upgrade according to TJ 31543 and release the car back to the customer.
37826.1.1
This is a TJ Text only no attachments -- If the FLC2 is not responding when attempting to load software, or after a failed software upgrade, VIDA will report that the FLC2 cannot be unlocked. To resolve this issue, follow the instructions in this TJ under "Service".
34521.11.1
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36376.6.0
This is a Technical Journal: Text only no attachments - Before replacing a cell module, make sure the latest BECM software is downloaded. This is important for utilizing the VIDA method described here and receiving the correct cell balancing diagnostics after the replacement.
36496.10.0
This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.
35503.4.0
This is a Technical Journal: Panoramic sunroof, sealing strip has a gap
37814.1.0
This is a TJ - Text Plus 1 .mp4 file - When using the CSD for seat adjustments mode for example lumbar support and seat Cushing, the visualization does not match the selected part for adjustment. Do not fault trace for this symptom. Advice the customer to use the physical seat mode switch knob. A new improved software is planned to be released during quarter 3 2026.
35526.1.8
This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
37514.6.0
This is a TJ. Text only no attachments - If a customer complains it is not possible to download third-party apps (only ICUP MY2026 cars affected) follow advice under "Service". Workaround is to perform a "IHU factory reset". analysis will now continue to find the root cause and provide a better improvement.
37809.1.1
This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section
34521.10.0
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
37495.2.0
This is a Tech Journal - Text only no attachments - If a customer experiences a “Propulsion System Performance” message in the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".
34295.9.0
This is a Technical Journal: Text plus 2 attachments 1 PDF and 1 PNG - High Voltage Battery repairs. Always repair the battery according to the methods in VIDA. This TJ is a guide to the kinds of repairs that can be done instead of a complete HV battery replacement. Parts, methods, and tools are now available to repair almost all faults within the High Voltage Battery.
36376.5.1
This is a Technical Journal: Text only no attachments - Before replacing a cell module, make sure the latest BECM software is downloaded. This is important for utilizing the VIDA method described here and receiving the correct cell balancing diagnostics after the replacement.
37236.5.1
This is a Technical Journal: Text only no attachments - CEL and DTC ECM P04F000. New ECM software has been released
35842
This is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when turning the steering wheel, follow the advice under Service.
36757
This is a Technical Journal: Text plus TJI 528994 - Charge Lid Hard to open/close. begin with replacing the actuator in the lock mechanism
34521
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36902
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
37541
This is a TJ - Text plus 1 attachment - instructions TJI-527893-3_1_1- If the Check Engine Light is illuminated in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". Clear the DTC. If the DTC does not reset, release the car to the customer. If the DTC does reset, continue to fault trace according to VIDA.
19245
This is a Technical Journal. Vehicle type and platform identification.
TJ36902.1.0-2025-10-31
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
TJ37373.6.0-2025-11-05
This is a Technical Journal: DIM Message and DTC BECM P0C7800. Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4. Perform a Total Upgrade according to TJ 31543. • If the DTC sets after SW version 3.6.4 or newer has been installed, please follow VIDA fault tracing and then create a TIE Support Needed Vehicle Report. *Structure Week 2023w46 and older: New BECM software is planned for 2026, Q1. • Please follow VIDA fault tracing and then create a TIE Support Needed Vehicle Report
37428
This is a Tech Journal - If a customer complains that RTTI information is NOT visible in the navigation system when an internet connection is available (globe in the top left corner), follow the instructions under "service". This Technical Journal handles only SENSUS vehicles.
36048
This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
35912
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
37418
This is a Technical Journal: Sunroof Sun Protection. During periods of intense sunlight, it is recommended to keep the sunroof closed when parked to minimize direct sunlight entering the vehicle, as prolonged exposure may cause deterioration or quality issues in the interior materials.
37373
This is a Technical Journal: DIM Message and DTC BECM P0C7800. Structure Week 2023w47 and newer: New BECM software is released in version 3.6.4. Perform a Total Upgrade according to TJ 31543. •If the DTC sets after SW version 3.6.4 or newer has been installed, please follow VIDA fault tracing and then create a TIE Support Needed Vehicle Report. *Structure Week 2023w46 and older: New BECM software is planned for 2026, Q1. •Please follow VIDA fault tracing and then create a TIE Support Needed Vehicle Report
36916
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000. Replace the VCM Backup Battery and download the relevant Software.
35755
This is a Technical Journal: BEV and LR-PHEV SW Update for High Voltage Battery Balancer. The Balancer software must be upgraded to version OTG_192-411899-H00-029 or higher
36814
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
TJ31514.1.0
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
36963
This is a Technical Journal: DIM Message and DTC ECM P0DF400. •Structure weeks 202147 - 202446: Improved ECM software has been released in version 3.4.4. Please perform a software upgrade according to TJ 31543. Structure Weeks 2024w47 - newer: A software release is planned for 2025 quarter 2, please follow the steps belowIf the vehicle is drivable and the turtle light is not on in the DIM, do not replace any parts, clear the DTCs, and release the vehicle to the customer.
37255
This is a Technical Journal: Torque Rod, Right Upper Replacement. replacements of Torque rod, Right upper (P/N's 32298950 and 31682684
8501
This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session: •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
36961
This is a Technical Journal: Improved 12V battery test in VIDA. Service: Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
TJ 34295
This is a Technical Journal: High Voltage Battery repairs. Always repair the battery according to the methods in VIDA.
37235
This is a Technical Journal: Changed front fog/cornering lights behavior. This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later
S10303
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customer’s key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
36257
This is a Technical Journal: Climate system heating performance (HVCH). Replace HVCH.
37175
This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory
36894
This is a Technical Journal: Long Range PHEV ERAD Knocking Noise Repair Kit. Install a repair kit.
34647
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
36277
This is a Technical Journal: White patch defect in paint when removed rapgard. Expose vehicle to outside daylight for 48hrs.
37070
This is a Technical Journal: Apple CarPlay Not OK - iPhone with USB-C, SENSUS. The 56 kO resistor ensures safe and appropriate power delivery.
TJ31543
This is a Technical Journal: Software Upgrade / Download Guide. If one control unit is upgraded and not all, it may result in various problems.
36863
This is a Technical Journal: DIM Message and DTC IEM P0C0500. 1. Erase the DTC 2. Test drive the vehicle in electrical mode and accelerate until the vehicle reaches a minimum of 30 km/h (19 mph). 3. Perform a new VIDA readout
TJ19245
This is a Technical Journal. Vehicle type and platform identification.
37000
This is a Technical Journal: Outer rear view mirror intermittently not folding. May required replacing terminals.
37012
This is a Technical Journal: BECM Spare Part Configuration. BECM Software reload.
37095
This is a Technical Journal: Check Engine Light and DTC ECM P0A821C. Performed a software update.
36823
This is a Technical Journal: PHEV IEM P060700 Control Module Performance DTC. Clear DTCs, road test and then perform a new readout.
36929
This is a Technical Journal: Check Engine Light and ECM P0CD900. Performed total software update.
36627
This is a Technical Journal: Unable to Erase DTC BECM P060647. Improved software is available in VIDA from 2024 week 27 (version 3.1.9)
37048
This is a Technical Journal: Difficulty clearing SODx DTCs. put the car in usage mode "Driving" and continue the erasing process
TJ27536.21.1-2024-08-07
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
TJ34647.6.3-2024-08-07
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
TJ36801.1.1-2024-08-07
This is a Technical Journal: Check Engine Lamp and Misfire DTC - ECM P030098. Do not replace any parts. Improved software was released in 2023 week 48 (version 2.13.1). If the SW is earlier than 2.13.1 first please perform a total upgrade of the SW according to TJ 31543, then reset the flywheel adaptation according to VIDA.
TJ36961.2.1-2024-08-07
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
TJ36823.5.0-2024-07-24
This is a Technical Journal: PHEV IEM P060700 Control Module Performance DTC. Clear DTCs, road test and then perform a new readout.
TJ36894.3.2-2024-07-24
This is a Technical Journal: Long Range PHEV ERAD Knocking Noise Repair Kit. Install a repair kit.
36845
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ34647.6.2-2024-06-19
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
TJ36845.1.6-2024-06-19
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36895.1.0-2024-06-19
This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control). software is available in VIDA beginning 2024 week 21.
TJ36894.3.0-2024-06-12
This is a Technical Journal: Long Range PHEV ERAD Knocking Noise Repair Kit. Install a repair kit.
TJ36647.4.0-2024-06-07
This is a Technical Journal: Incorrect fuel level or tank capacity. Replace fuel tank.
TJ36845.1.5-2024-06-07
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36961.1.0-2024-06-04
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.