37270.2.1
Service Bulletin/Repair Instructions
This is a Technical Journal: Text only no attachments - DIM Message and DTC BECM P0C3200. perform a total upgrade of the software please follow the advice under "Service"
Vehicle report
2026 VOLVO V60PHEV
Service bulletins
35 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
37631.3.0
Service Bulletin/Repair Instructions
This is a TJ - text only no attachments - If customer complains of a headlamp error message in DIM, in combination with any of the DTCs stated below, follow advice under "Service".
37774.1.0
Service Bulletin/Repair Instructions
This is a TJ - Text plus 1 PDF attachment - f the headlamp horizontal light aim cannot be adjusted via the set screw, If the horizontal light aim cannot be adjusted because the cogwheel knob is broken, do not replace the entire headlamp. Instead, use the spare part kit part number 32476677 to replace the affected component, please follow the instructions under "Service".
36555.8.0
Service Bulletin/Repair Instructions
This is a Technical Journal: text plus 3 .png files and 1 mp4 CSD Stuck in Recovery Mode, iCUP. In most cases this Recovery mode can be resolved by preforming a IHU reload.
37342.2.3
Service Bulletin/Repair Instructions
This is a Technical Journal: iCUP IHU - Text plus 1 PDF Prior Approval. In most cases, the IHU does not need to be replaced -In many cases the Infotainment Head Unit (IHU) does not need to be replaced and can be retained by following the fault tracing in VIDA.
33031.6.0
Service Bulletin/Repair Instructions
This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
37813.2.0
Service Bulletin/Repair Instructions
This is a TJ - Text plus 1 mp4 file - If, an iCup model year 2026 vehicle equipped with Sound System defined by VDN K501 or K502, experiencing the symptom where the audible turn-indicator sound is out of sync and may occasionally skip a “beep” (see TJ_37813_1.mp4), follow the guidance provided in the Service.
34521.11.1
Service Bulletin/Repair Instructions
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36496.10.0
Service Bulletin/Repair Instructions
This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.
35503.4.0
Service Bulletin/Repair Instructions
This is a Technical Journal: Panoramic sunroof, sealing strip has a gap
35526.1.8
Service Bulletin/Repair Instructions
This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
36923.9.1
Service Bulletin/Repair Instructions
This is a Technical Journal: Text document plus 1 PDF attachment Coolant Pump Dry Coolant Mix Residue. If the coolant pump has an active leak, a photo must be taken prior to replacement (see example as in attached picture TJ_36923_3). The photo showing the active water pump leak on the vehicle must be saved for the TMA photo return process and provided when requested. Sealing improvements have been made to PNs 32382367, 32441161 and 32382368, but the part numbers are unchanged. To assist with identification of improved parts, a marking has been added to the parts: an "X," as shown in the attached document TJ_36923_1.pdf. If you receive a replacement pump that does not have the "X" marking, please return it and order a replacement
37514.6.0
Service Bulletin/Repair Instructions
This is a TJ. Text only no attachments - If a customer complains it is not possible to download third-party apps (only ICUP MY2026 cars affected) follow advice under "Service". Workaround is to perform a "IHU factory reset". analysis will now continue to find the root cause and provide a better improvement.
37809.1.1
Service Bulletin/Repair Instructions
This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section
34521.10.0
Service Bulletin/Repair Instructions
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
37511.1.0
Service Bulletin/Repair Instructions
This is a TJ - 1 txt file plus 3 PDF's - If the customer complains about any of the below symptoms after updating vehicle to next software release (5.0.x or later,) either with VIDA or OTA, follow instruction under "Service".
37654
Service Bulletin/Repair Instructions
This is a TJ - text only no additional attachments - If the DIM is not responding during start and no response in DIM is visible in VIDA in combination with DTC VCU1 U015500 follow the instructions under “Service.”
37583
Service Bulletin/Repair Instructions
This is a TJ Text and 3 mp3 files - If the customer is intermittently experiencing distorted audio across multiple sound sources simultaneously—such as Radio/Streaming, Belt Reminder, Park Assist, Speed Warning, etc. see the attached examples (TJ_37583_1-3.mp3) and follow advice under "Service". Note! This TJ is only applicable for MY26 iCUP vehicles, Variant Designation Number (VDN):RP03.
35842
Service Bulletin/Repair Instructions
This is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when turning the steering wheel, follow the advice under Service.
37364
Service Bulletin/Repair Instructions
This is a TJ - When the engine is turned off, the lights in overhead console, reading lamps, footwell, and luggage compartment may not turn on. This issue occurs intermittently, and during such instances, the ON/OFF button for the overhead console becomes unresponsive, follow advice under service. Open the front driver side door, this will restore the interior lights. In this scenario, please follow the advice under "Service".
28874
Service Bulletin/Repair Instructions
This is a TJ If detected during Pre-delivery inspection or if customer complaints of chipped/cracked/distorted screen/glass within 6 months in service we request more information, follow advise under "Service".
34521
Service Bulletin/Repair Instructions
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36902
Service Bulletin/Repair Instructions
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
37541
Service Bulletin/Repair Instructions
This is a TJ - Text plus 1 attachment - instructions TJI-527893-3_1_1- If the Check Engine Light is illuminated in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". Clear the DTC. If the DTC does not reset, release the car to the customer. If the DTC does reset, continue to fault trace according to VIDA.
19245
Service Bulletin/Repair Instructions
This is a Technical Journal. Vehicle type and platform identification.
TJ37364.2.0-2025-11-19
Service Bulletin/Repair Instructions
This is a TJ - When the engine is turned off, the lights in overhead console, reading lamps, footwell, and luggage compartment may not turn on. This issue occurs intermittently, and during such instances, the ON/OFF button for the overhead console becomes unresponsive, follow advice under service. Open the front driver side door, this will restore the interior lights. *Work is ongoing, with the planned software release scheduled for the first quarter of 2026.
TJ36902.1.0-2025-10-31
Service Bulletin/Repair Instructions
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
37224
Service Bulletin/Repair Instructions
This is a technical Journal - iCUP - Estimated Time of Arrival in DIM missing Issue is now resolved with latest SW in VIDA 3.4.4.
37342
Service Bulletin/Repair Instructions
This is a Technical Journal: iCUP IHU - Prior Approval. In most cases, the IHU does not need to be replaced
37418
Service Bulletin/Repair Instructions
This is a Technical Journal: Sunroof Sun Protection. During periods of intense sunlight, it is recommended to keep the sunroof closed when parked to minimize direct sunlight entering the vehicle, as prolonged exposure may cause deterioration or quality issues in the interior materials.
35755
Service Bulletin/Repair Instructions
This is a Technical Journal: BEV and LR-PHEV SW Update for High Voltage Battery Balancer. The Balancer software must be upgraded to version OTG_192-411899-H00-029 or higher
36610
Service Bulletin/Repair Instructions
This is a Technical Journal: Privately Imported Vehicles - Connectivity Setup. Make sure QW90 has been updated prior to performing below steps: If vehicle software is not up to date, please perform a Total Upgrade according to TJ 31543
37366
Service Bulletin/Repair Instructions
This is a Technical Journal: DTC CEM B109A4A Incorrect BBS. A SW solution is planned during 2025 quarter 4.
TJ31514.1.0
Service Bulletin/Repair Instructions
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
36963
Service Bulletin/Repair Instructions
This is a Technical Journal: DIM Message and DTC ECM P0DF400. •Structure weeks 202147 - 202446: Improved ECM software has been released in version 3.4.4. Please perform a software upgrade according to TJ 31543. Structure Weeks 2024w47 - newer: A software release is planned for 2025 quarter 2, please follow the steps belowIf the vehicle is drivable and the turtle light is not on in the DIM, do not replace any parts, clear the DTCs, and release the vehicle to the customer.
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.