Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
33031.6.0
This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
34521.11.1
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36496.10.0
This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.
35526.1.8
This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
37809.1.1
This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section
34521.10.0
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
37773.1.2
This is a TJ - Text only no attachments - If customer experiences an incorrect ambient temperature reading in DIM (Driver Information Module) or reduced A/C performance, follow the advice under Service. Please refer to the wiring diagram in VIDA to locate the relevant circuit for the ambient temperature sensor (component 7/481) at the passenger door mirror harness.
35842
This is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when turning the steering wheel, follow the advice under Service.
TJ 34498
This is a Technical Journal: Text plus TJI-516730-1_1_0 Headliner, squeak/rattle noise If a squeaking noise can be heard from the headlining around the sun roof, see instructions under Service referring to TJI-516730-1_1_0
34521
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36902
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
19245
This is a Technical Journal. Vehicle type and platform identification.
TJ36902.1.0-2025-10-31
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
AC pressure check
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice under service.
TJ34648.5.0-2025-10-29
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice under service.
TJI VCC-517278-1
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice under service.
37428
This is a Tech Journal - If a customer complains that RTTI information is NOT visible in the navigation system when an internet connection is available (globe in the top left corner), follow the instructions under "service". This Technical Journal handles only SENSUS vehicles.
36048
This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
35912
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
TJ31514.1.0
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
8501
This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session: •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
36961
This is a Technical Journal: Improved 12V battery test in VIDA. Service: Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
S10303
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customer’s key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
36257
This is a Technical Journal: Climate system heating performance (HVCH). Replace HVCH.
37175
This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory
34647
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
36277
This is a Technical Journal: White patch defect in paint when removed rapgard. Expose vehicle to outside daylight for 48hrs.
37000
This is a Technical Journal: Outer rear view mirror intermittently not folding. May required replacing terminals.
37048
This is a Technical Journal: Difficulty clearing SODx DTCs. put the car in usage mode "Driving" and continue the erasing process
TJ27536.21.1-2024-08-07
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
TJ34647.6.3-2024-08-07
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
TJ36961.2.1-2024-08-07
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
36845
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ34647.6.2-2024-06-19
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
TJ36845.1.6-2024-06-19
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36895.1.0-2024-06-19
This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control). software is available in VIDA beginning 2024 week 21.
TJ36845.1.5-2024-06-07
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36961.1.0-2024-06-04
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
36202.2.1
This is a Technical Journal: Vibration/shudder while braking. Replace front brake pads
36899.1.0
This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700). Download software.
36845.1.4
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
36845.1.3
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
35924.1.4
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time. Use had held tester.
36845.1.2
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
34647.6.1
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
26745.13.14
This is a Technical Journal: 12V Battery Testing Method
35912.5.0
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
TJ31543
P5(SPA)/P6(CMA) Software Download Guide
TJ36147.1.1
Poor radio reception and sound (FM)
TJ35912.4.0
Updated Chassis Range.
TJ36048.2.0
Alleged issues with Intellisafe functionality.
TJ3671210
Propulsion Message in DIM with BECM DTC
C00009
COMPLIMENTARY UPGRADE C00009 DESCRIPTION.
TJ34936110
No internet connection and intermittent.
36678.1.0
This is a Technical Journal. Recovering control modules stuck in ânot respondingâ after failed SW download. Connect VIDA to read-out the car. Follow steps outlined in this TJ.
TJ3667810
Recovering control modules stuck in ?not responding?
TJ3662910
Driver support systems
TJ3627710
Body, cab and interior.
TJ3641580
Electrical rear axis drive
TJ3416550
Mobile data services, general
TJ3656330
Rubber cushion
TJ3625752
New Information.
TJ36202.2.0
Vibration/shudder while braking
TJ3641540
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
TJ36415A
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
TJ3551120
Creaking noise from Steering Wheel Module (SWM)
TJ3641530
Electrical rear axis drive
TJ3252552
DIM message ?Parking brake service required?
TJ36415
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
TJ32525A
DIM message ?Parking brake service required?
TJ35511
Creaking noise from Steering Wheel Module (SWM)
TJ36548
OHC replaced too often due to CEM U134187,download software prior replacement
TJ36563
Creaking noise from right engine pad
TJ3612530
WPC (Wireless Phone Charger) charging information
TJ36125
WPC (Wireless Phone Charger) charging information
TJ35978
Convert CARE KEY to normal key
TJ36513
Towbar TRM not responding
TJ36224
No bass function (High Performance Audio)
TJ36509
Volvo Cars App Remote climate or ERS, not possible
TJ19245
Vehicle type and platform identification
TJ35902
Connectivity services activation - PSIM issues
TJ36374
General radio deviations ICUP vehicles
TJ36455
Volvo Cars App Android, no climate setting button
TJ35929
OTA not available for customer
TJ35884
OTA - FAQ for technicians
TJ36139
Vehicle cannot receive OTA updates
TJ36106
Electrical motor sound information
TJ36449
If the software is older than V2.4, which was released 22w42, perform a software upgrade
TJ35856
Do not swap TCAM?s unless instructed and guided by the Retailer Technical Support team
TJ36405
Disconnect Charging Cable? With No Cable Attached.
TJ36195
Cannot lock/unlock vehicle with remote control key
SMB87-001
Climate system heating performance.
A10184
Product, Safety and Compliance.
PB32-A10184
Inverter E-Machine.
SMB00-108C
Expendable Items Parts List.
CBR-2131
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
CBR-2163
Engine Control Module (EMS) Software Information - Improvement List (Change Log), US21+OBD2020 â US21+OBD2021 Emissions Turbo compound Engines ONLY
CBR-2201
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
S10177
OTA Software check
QB39S10177
The corrective action is to perform a Total Upgrade Software download.
PB30S10177
The corrective action is to perform a Total Upgrade Software download.
QBS10177
The corrective action is to perform a Total Upgrade Software download.
Special Tools Bu
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.
Service Manager
ICUP/Google Built-In Diagnostic Operations
TJ2873930
Center wheel caps, removal instruction
TJ36226.2.0
ISGM and charging error DTC?s
356EN01
VIDA QR Scanner Mobile App
KC-159
Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
TJ3607310
Information in DIM ?system check, please wait? and no start.
KC-99
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
TJ3597811
Convert Care Key to Standard Key.
TJ 35507 6 0
Outer rear view mirror glass incorrect position after reversing.
TJ 35901 4 0
Driving, Twin Engine/Propulsion using electric motor not possible.
TJ 34647 6 0
Perform a software upgrade in accordance with TJ 31543.
TJ 35978 1 0
New Software Products (SP) have been developed to convert a Care Key to a standard key.
S10090-2021-05-1
Volvo Car USA LLC and Volvo Car Canada Ltd on behalf of Volvo Car Corporation, has decided to launch Service Action S10090 on certain Volvo S60, V60, V60CC, XC60, S90, V90, V90CC, XC90 Model Year 2021 vehicles. Volvo has identified that the software may not be robust enough to handle the large number of signals transmitted to the audio amplifier. This can result in a pop noise from the sound system. The corrective action is to perform a Total Upgrade software. S10090 affects 5,477 vehicles in the U.S. and 1,301 in Canada.
TJ35944.1.0-2021
This is a Technical Journal: Ghost DTC set, VCU1-U210782. does not affect any of the functions in the car.
PB30-S10090-2021
Volvo Car USA LLC and Volvo Car Canada Ltd on behalf of Volvo Car Corporation, has decided to launch Service Action S10090 on certain Volvo S60, V60, V60CC, XC60, S90, V90, V90CC, XC90 Model Year 2021 vehicles. Volvo has identified that the software may not be robust enough to handle the large number of signals transmitted to the audio amplifier. This can result in a pop noise from the sound system. The corrective action is to perform a Total Upgrade software. S10090 affects 5,477 vehicles in the U.S. and 1,301 in Canada
S10090 package 2
Volvo Car USA LLC and Volvo Car Canada Ltd on behalf of Volvo Car Corporation, has decided to launch Service Action S10090 on certain Volvo S60, V60, V60CC, XC60, S90, V90, V90CC, XC90 Model Year 2021 vehicles. Volvo has identified that the software may not be robust enough to handle the large number of signals transmitted to the audio amplifier. This can result in a pop noise from the sound system. The corrective action is to perform a Total Upgrade software. S10090 affects 5,477 vehicles in the U.S. and 1,301 in Canada.
SMB17-2021-2021-
This is a Service Manager Bulletin: Retail Car Delivery Process
TJ35786.3.1-2021
This is a Technical Journal: WPC (Wireless Phone Charger) not charging iPhone 12 models
TJ33867.1.3-2021
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is not always the solution. Road Force balancing detects assembly run out measured under load simulating real world driving conditions and will provide a solution to match mount the tire and rim to minimize loaded run out.
TJ33183.7.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ35907.1.0-2021
This is a Technical Journal: DTC SODL/R-C106057 after replaced SOD
TJ35912.1.0-2021
This is a Technical Journal: AC evaporator repair, additional parts needed
TJ35902.1.1-2021
This is a Technical Journal: Connectivity services activation - PSIM issues
TJ33183.6.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ35507.5.0-2021
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ34241.2.3-2021
This is a Technical Journal: 12V battery message and DTC CEM-B129F96
TJ35507.4.0-2021
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ35867.1.0-2021
This is a Technical Journal: AWD DTC DEM-P188919. Reset the DTC.
TJ33183.5.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ35786.3.0-2021
This is a Technical Journal: WPC (Wireless Phone Charger) not charging iPhone 12 models
TJ35842.1.0-2021
This is a Technical Journal: Noise when turning steering wheel. Check rubber gromet in firewall
TJ33031.5.0-2021
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
TJ33183.4.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ33617.2.1-2021
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring.
TJ35511.1.0-2021
This is a Technical Journal: Creaking noise from Steering Wheel Module
TJ35610.1.2-2020
This is a Technical Journal: No AM radio, Software to activate the AM radio will be made available
TJ32985.5.0-2020
This is a Technical Journal: Seat belt front, may not retract fully
TJ35554.2.0-2020
This is a Technical Journal: IHU, volume restriction w/orange key.
TJ34286.5.0-2020
This is a Technical Journal: Info request: Pull & drift or steering wheel misaligned, feedback needed.
TJ34803.2.0-2020
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. The calibration function itself is not changed compared to previous SW versions, it is only how it is presented in the center display that has been changed.A new calibration will start automatically as soon as the VDDM SW is upgraded.
TJ34241.2.2-2020
This is a Technical Journal: 12V battery message and DTC CEM-B129F96
TJ35560.3.0-2020
This is a Technical Journal: Headlight DTC?s after software upgrade
ST-001-2020-09-1
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
TJ35640.1.0-2020
This is a Technical Journal: MY21- HUD, Lighting/Settings issues after software update
TJ35610.1.1-2020
This is a Technical Journal: No AM radio, Software to activate the AM radio will be made available
TJ32985.4.0-2020
This is a Technical Journal: Seat belt front, may not retract fully
TJ35560.2.0-2020
This is a Technical Journal: Headlight DTC?s after software upgrade
TJ35507.2.0-2020
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
SMB17-2021-2020-
This is a Service Manager Bulletin: Retail Car Delivery Process
TJ35514.1.0-2020
This is a Technical Journal: Prior Approval for VCM Replacement
TJ33183.3.0-2020
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ33442
Left engine pad click sound
TJ33353
Climate unit, not sufficient airflow from vents
TJ33358
Replacement of ERAD components.
TJ33442a
Left engine pad click sound
TJ33442b
Left engine pad click sound
TJ31602
Infotainment System Reboots while driving (blank screen)
TJ32033a
Audio switches on steering wheel, no function
TJ32033
Audio switches on steering wheel, no function
TJ32381
Rattling noise when closing front door.
TJ32525
DIM message ?Parking brake service required?
TJ33170
Mirror cover, noise
TJ33196
CCSM knob, noise when pushing/turning
TJ32185
Voice recognition database upgrades
TJ32921
Infotainment system switches to FM radio source at random.
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.