CBR 2246-5 032026
Service Bulletin/Repair Instructions
CBR - Z Spring Bracket Wear. Volvo Chassis
Vehicle report
2013 VOLVO VHD
Service bulletins
206 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CBR 2488 072025
Service Bulletin/Repair Instructions
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication but failing to transmit GPS location data.
CBR 170-8 202505
Service Bulletin/Repair Instructions
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure) (Possible Related Codes - SPN4811 , SPN 100 , PID 100)
TSB V-710-001 202504
Service Bulletin/Repair Instructions
TSB - V-710-001 Engine Crossmember Loose Hardware.
CBR 561 202503
Service Bulletin/Repair Instructions
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR 2438-1 202501
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - No-Crank Issue After Programming
CBR-731 202409
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR-343 202408
Service Bulletin/Repair Instructions
CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR-561 202408
Service Bulletin/Repair Instructions
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR-2350 202407
Service Bulletin/Repair Instructions
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR-2383 202406
Service Bulletin/Repair Instructions
CBR - Accelerator Pedal: Inspection/Instructions
CBR-2139 202405
Service Bulletin/Repair Instructions
CBR - 11 Liter Engines - Fuel In Oil.
KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
V-258-001 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
V-258-002 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2191 Ver 5
Service Bulletin/Repair Instructions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2292
Service Bulletin/Repair Instructions
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
KC-2191 Ver 3
Service Bulletin/Repair Instructions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2194
Service Bulletin/Repair Instructions
CBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
SLV23-005
Service Bulletin/Repair Instructions
Service Literature Published and Released in May, 2023
KC-503-Ver3
Service Bulletin/Repair Instructions
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 / P10AE81 Fault Codes Being Generated
KC-2229-Ver2
Service Bulletin/Repair Instructions
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
KC-474-Ver5
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
KC-2265
Service Bulletin/Repair Instructions
CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO. VHD chassis may experience Diagnostic Trouble Code P071A or P07CE along with symptoms of no reduced engine load (RELS) when coming to a stop and/or the transmission going into 4th gear lock up when applying the service brake.
KC-2191
Service Bulletin/Repair Instructions
CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions. The primary failure mode the NOx Sensors is internal failure, which will generate a sensor specific fault code.
KC-2269
Service Bulletin/Repair Instructions
CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16
KC-2033
Service Bulletin/Repair Instructions
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4. The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
KC-2260
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Timing Gear Plate Repair. This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
KC-776
Service Bulletin/Repair Instructions
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
KC-2248
Service Bulletin/Repair Instructions
Flywheel Housing Thread Repair
KC-607
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT-C, AMT-D, I-Shift) - - Unable To Program Transmission Electronic Control Unit (TECU) That Comes With A Reman Transmission - US07 TO US14 OBD13
KC-2195
Service Bulletin/Repair Instructions
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-687
Service Bulletin/Repair Instructions
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
KC-183
Service Bulletin/Repair Instructions
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
V-265-002
Service Bulletin/Repair Instructions
TSB-Charge Air Cooler t-clamp install.
SMB00-108C
Service Bulletin/Repair Instructions
Expendable Items Parts List.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-750
Service Bulletin/Repair Instructions
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
KC-751
Service Bulletin/Repair Instructions
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
KC-2112
Service Bulletin/Repair Instructions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
Service Bulletin/Repair Instructions
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
Service Bulletin/Repair Instructions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Service Bulletin/Repair Instructions
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
Service Bulletin/Repair Instructions
AMT Control Housing Bench Testing - False Failures
KC-2174
Service Bulletin/Repair Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Service Bulletin/Repair Instructions
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Service Bulletin/Repair Instructions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer.
KC-735
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
KC-2107
Service Bulletin/Repair Instructions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
Service Bulletin/Repair Instructions
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2158
Service Bulletin/Repair Instructions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
Service Bulletin/Repair Instructions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Service Bulletin/Repair Instructions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Service Bulletin/Repair Instructions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-722
Service Bulletin/Repair Instructions
Mack Chassis - Data Link Diagnostics - Diagnostic Trouble Codes ( DTC ) / Fault Codes From Multiple Components - Unable To Connect To Chassis, Programming Failure With Premium Tech Tool ( PTT ) Errors - Troubleshooting And Oscilloscope Instructions
KC-2149
Service Bulletin/Repair Instructions
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-695
Service Bulletin/Repair Instructions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-662
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
KC-674
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Sending Unit Specification Information
KC-675
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration ( Regen ) Failure Diagnostic Process - US07 to US16 Emissions
KC-639
Service Bulletin/Repair Instructions
Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
KC-640
Service Bulletin/Repair Instructions
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
KC-642
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
KC-647
Service Bulletin/Repair Instructions
Volvo Chassis Ghost Codes Due To Poor Grounding
KC-649
Service Bulletin/Repair Instructions
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
KC-650
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
KC-660
Service Bulletin/Repair Instructions
Volvo Chassis - PTO Pump Speed Calculator
KC-635
Service Bulletin/Repair Instructions
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
KC-636
Service Bulletin/Repair Instructions
Volvo Fault Code MID 144 PSID 204 FMI 9
KC-2157
Service Bulletin/Repair Instructions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
SNV22-003
Service Bulletin/Repair Instructions
The Diagnostic Process
KC-623
Service Bulletin/Repair Instructions
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-784
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
V-392-004
Service Bulletin/Repair Instructions
Radio, Replacement (revised from FSB 392-005)
KC-366
Service Bulletin/Repair Instructions
Volvo Chassis - FSB 392 - 004 - Radio, Replacement
KC-705
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
KC-793
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical Service Bulletin V-216-001 Twin Mass Flywheel Conversion
SLV22-002
Service Bulletin/Repair Instructions
Volvo Monthly Bulletin Release Letter - Feb 2022
KC-541
Service Bulletin/Repair Instructions
Volvo Chassis - FSB 761-002, Shock Absorber, Inspection
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
Service Manager
Service Bulletin/Repair Instructions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-413
Service Bulletin/Repair Instructions
Volvo Chassis - Coolant Leak Test - Dye Information
KC-418
Service Bulletin/Repair Instructions
Volvo Chassis - Air Brake System Schematics And Routing VN, VHD Version 2, VT From Build Date 11.2011
KC-422
Service Bulletin/Repair Instructions
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
KC-423
Service Bulletin/Repair Instructions
Volvo Chassis US13 And Up Pre-trip Assistant Enable
KC-392
Service Bulletin/Repair Instructions
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-357
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse Guidelines
KC-358
Service Bulletin/Repair Instructions
Volvo Chassis - US10 to US16 Emissions - Soot Level Will Not Reset After Regen Or Locked At 140%
KC-304
Service Bulletin/Repair Instructions
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Service Bulletin/Repair Instructions
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-226
Service Bulletin/Repair Instructions
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-66
Service Bulletin/Repair Instructions
Volvo US13, US14, US15, Chassis LED Headlights Conversion Programming Procedure
KC-160
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative, No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Model Years 2011 To 2014
KC-163
Service Bulletin/Repair Instructions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-124
Service Bulletin/Repair Instructions
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-114
Service Bulletin/Repair Instructions
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC, Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
KC-102
Service Bulletin/Repair Instructions
Volvo Chassis - Performance Bonus OBD13 And Newer
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
KC-2032
Service Bulletin/Repair Instructions
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
DOR-K2T5D-01
Service Bulletin/Repair Instructions
This SKU is a DEF Injector. The customer communication requested return of unsold inventory to inspect the sealing. The injector sealing may have an issue which will cause a slow leak. A slow leak of the DEF Injector can lead to crystal formation which can cause aftertreatment related fault codes and ECU driven engine derating.
KC-521
Service Bulletin/Repair Instructions
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And Programming Information - Model Year 2008 Through 2017
K41105570
Service Bulletin/Repair Instructions
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
K44250068
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
K09201017
Service Bulletin/Repair Instructions
Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet, Omnitracs, GPS, Location Tracker, Etc.) RP1226 connection On The Data Link; Installation Instructions And Information For Third Party ( Aftermarket ) Devices Connected To The Data Link - US17+OBD16 And Newer Emissions, Models Built up to Week 37 (9/13) 2019.
K21533201
Service Bulletin/Repair Instructions
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
K68033394
Service Bulletin/Repair Instructions
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
K17408563
Service Bulletin/Repair Instructions
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
K15812145
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
K39135131
Service Bulletin/Repair Instructions
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
K70734554
Service Bulletin/Repair Instructions
Volvo Chassis - Vehicle with Diagnostic Trouble Code (DTC) P2002-00, Diagnostic Instructions - US10+OBD13 Emssions ONLY, Model Years 2013 (Rare), 2014
K37146742
Service Bulletin/Repair Instructions
US07 / US10 D13 Turbocharger Gasket
K62132009
Service Bulletin/Repair Instructions
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
K11907301
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
K86900043
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B, P1121 - Temperature Sensor Inspection
K91214678
Service Bulletin/Repair Instructions
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5 Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
K51303113
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative, No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Commonly Model Years 2011 To 2014
K14701433
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 ) Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
K24483157
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16 Emissions And Newer Rewrote test procedure for better clarity.
K24400052
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
K97651904
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
K52326370
Service Bulletin/Repair Instructions
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 ( Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
FSB216-002
Service Bulletin/Repair Instructions
Flywheel Resurfacing Guidelines, I-Shift
FSB284-064
Service Bulletin/Repair Instructions
ECM and ACM Reprogramming, OBD2015
K14637412
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 ( GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
K82320750
Service Bulletin/Repair Instructions
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The Key On And Engine OffChanged repair information to reflect new software available.
K03179378
Service Bulletin/Repair Instructions
Service Only Regen Requested With No Warning. Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
K15164821
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect release of FSB284-064 (Above)
K27690302
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
K86412082
Service Bulletin/Repair Instructions
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 (Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
K42708399
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis (Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
K84412328
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16, Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
FSB237-020
Service Bulletin/Repair Instructions
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10, EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt.
FSB373-024
Service Bulletin/Repair Instructions
Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017 may have PTO solenoid bracket or transmission harness connector failures due to excessive vibration.
FSB 237-020
Service Bulletin/Repair Instructions
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10, EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 4 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
TJ27316
Service Bulletin/Repair Instructions
Keyless Drive receiver issues
FSB711-008
Service Bulletin/Repair Instructions
Some VOLVO VN, VHD and VNX trucks built from 09/03/2012 to 07/17/2017, and equipped with the NEWAY ADZ rear suspension may exhibit cracks in the rear suspension front of bogie or bogie crossmember.
FSB 293-022
Service Bulletin/Repair Instructions
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration is required.
SP 398-001
Service Bulletin/Repair Instructions
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the vehicle systems after restarting.
FSB 213-002, Exh
Service Bulletin/Repair Instructions
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression, or a mechanical injector Diagnostic Trouble Code (DTC).
FSB 392-004, Rad
Service Bulletin/Repair Instructions
On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable radio, the old radio may no longer be available for purchase. To upgrade from a GLAD format radio to a DEA500 format radio follow the following instructions.
FSB221-010
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODES (DTCS), LOW OIL PRESSURE, VAH, VHD, VN
FSB 593-012
Service Bulletin/Repair Instructions
Hill Start Assist Solenoid, Replacement
FSB 222-004
Service Bulletin/Repair Instructions
Oil Filter Housing
FSB 593 012
Service Bulletin/Repair Instructions
On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid valve for the Hill Start Assist feature is prone to internal contamination in harsh environments. The internal contamination of the solenoid valve is caused by the buildup of grime, salt, road debris and other solid contaminants. In some cases, the buildup of solid contaminants caused the solenoid valve to malfunction. A similar malfunction is possible if the solenoid valve is equipped with a vent fitting that freezes over. The malfunction causes the trailer brake circuit to maintain trailer brake pressure after a grade Hill Start Assist event. Replacement of the existing solenoid valve, elbow, and the addition of a new tube fitting and tube will ensure proper functionality of the Hill Start Assist feature.
FSB 386-007
Service Bulletin/Repair Instructions
Vehicle Speed Sensor, fault codes
FSB-284-061
Service Bulletin/Repair Instructions
VOLVO TRUCK: SOME TRUCKS WILL EXPERIENCE PREMIUM TECH TOOL (PTT) 38 ERROR CODE AND SHOULD CHECK ENGINE ECU SOFTWARE BEFORE ANY TROUBLESHOOTING, IF ECU SOFTWARE HAS LESS NUMBER REFERENCED, THEN ECU AND AFTERTREATMENT CONTROL MODULE (ACM) SHOULD BE REPROGRAMMED. NEW LOGIC ASSOCIATED WITH SOFTWARE ALLOWS REGENERATION TEMPERATURES REACH MAXIMUM LEVEL. MODEL 2013-15 VAH, VHD, VN. *PE
FSB 210-045
Service Bulletin/Repair Instructions
Regeneration in PTO Mode
FSB 284-057
Service Bulletin/Repair Instructions
High Soot Output
FSB 215-003
Service Bulletin/Repair Instructions
Timing Plate Flange Screw
SP 430-001
Service Bulletin/Repair Instructions
Transmission Control Module, Programming
FSB 253-002
Service Bulletin/Repair Instructions
Engine Brake Loss
FSB 431-010
Service Bulletin/Repair Instructions
Range Synchronizer, Repair
FSB 293-027
Service Bulletin/Repair Instructions
EGR Mass Flow Rate Low, diagnostic trouble code
FSB 371-049
Service Bulletin/Repair Instructions
Battery Cable, Routing
FSB 432-014
Service Bulletin/Repair Instructions
Transmission ECU Compatibility
TJ-25329
Service Bulletin/Repair Instructions
VOLVO: ON SOME VEHICLES, THE STEERING KNUCKLE WOULD HAVE WHEEL HUB DISPLACED AND WOULD TO REPLACE WHEEL HUB. *PE
FSB-511-003
Service Bulletin/Repair Instructions
VOLVO: BRAKE SHOE IS PROTRUDING BEYOND BRAKE DRUM AND IS CORRECTED BY REPLACING/INSTALLING NEW 152 MM (6.0 IN) BRAKE SHOES, DUST SHIELDS, NEW 178 MM (7.0 IN) WIDE BRAKE DRUMS. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-004
Service Bulletin/Repair Instructions
VOLVO: BRAKE SHOE IS PROTRUDING BEYOND BRAKE DRUM AND CAN BE RESOLVED BY REPLACING AND INSTALLING 152 MM (6.0 IN) BRAKE SHOES, DUST SHIELDS, NEW 178 MM (7.0 IN) BRAKE DRUMS WITH NEW Z BRACKETS. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-005
Service Bulletin/Repair Instructions
VOLVO: SOME TRUCKS SHOW SIGNS OF BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM AND NEED REPLACING. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-006
Service Bulletin/Repair Instructions
VOLVO: THE MERITOR OR BENDIX BRAKE SHOES ARE SHOWING SIGNS OF BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM AND CAN BE RESOLVED BY REPLACING BRAKE SHOES (152 MM (6.0 IN) AND WIDE BRAKE DRUMS (178 MM (7.0 IN.)) MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-007
Service Bulletin/Repair Instructions
VOLVO: TO RESOLVE CONDITION OF BRAKE SHOES, SHOWING SIGNS OF PROTRUSION OF BRAKE SHOE BEYOND BRAKE DRUM, BY INSTALLING NEW DUST SHIELDS, WIDE BRAKE DRUMS (178 MM) (7.0) AND BRAKE SHOES (152 MM) (6.0). MODEL 2011-2014 VAH, VHD, VN. *PE
FSB-511-008
Service Bulletin/Repair Instructions
VOLVO: REPLACEMENT OF BRAKE SHOES THAT SHOWS BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB 293-024
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
FSB 234-018
Service Bulletin/Repair Instructions
Single Fuel Tank Ventilation Filter Kit
FSB 234-019
Service Bulletin/Repair Instructions
Dual Fuel Tanks Ventilation Filter Kit
FSB 801-003
Service Bulletin/Repair Instructions
Service Door Rust Prevention
FSB 432-013
Service Bulletin/Repair Instructions
AMT High Range Cone Replacement
FSB-432-013
Service Bulletin/Repair Instructions
VOLVO TRUCK: PROCEDURAL INFORMATION REGARDING THE REPLACEMENT OF HIGH RANGE CONE IN THE SECTION OF THE AUTOMATED MANUAL TRANSMISSION (AMT). MODEL VN, VHD, VAH, VT. *PE UPDATED 8/8/14. *PE
FSB-593-012
Service Bulletin/Repair Instructions
VOLVO TRUCK: DUE TO INTERNAL BUILD UP CONTAMINATION OF GRIME, SALT, ROAD DEBRIS, IN HARSH ENVIRONMENTS, CAUSES SOLENOID VALVE TO MALFUNCTION AND TRAILER BRAKE CIRCUIT TO MAINTAIN TRAILER BRAKE PRESSURE AFTER HILL START ASSIST EVENT. MODEL VHD, VN, VT, VAH. *PE
FSB-371-046
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, AN IMPROPER TORQUE HAS ALLOWED CORROSION INHIBITOR BETWEEN RING TERMINALS OF MAIN GROUND STUD, LOCATED ON FRAME RAIL, CAUSING INTERMITTENT ISSUES AND DIAGNOSTIC TROUBLE CODES (DTC). MODEL 2010-2014 VAH, VHD, VN. *PE
FSB 375-010
Service Bulletin/Repair Instructions
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
FSB 375-011
Service Bulletin/Repair Instructions
Seat Harness Routing (Swivel) wires pulling away from clipping points
FSB-263-039
Service Bulletin/Repair Instructions
VOLVO TRUCKS: ON SOME TRUCKS, THE HDMS FAN DRIVE WAS REDESIGNED, DUE TO HDMS COOL LOGIC ENGINE COOLING FAN DRIVE WAS LEAKING FLUID FROM REAR OF DRIVE, WITH IMPROVEMENTS OF SEALING AND OVERALL DURABILITY OF DRIVE, MODEL 2013 VAH, VHD, VN. *PE
FSB-313-004
Service Bulletin/Repair Instructions
VOLVO TRUCKS: ON CERTAIN TRUCKS, AN IMPROVEMENT CHANGE WAS MADE, FOR PROTECTION OF STACKABLE BATTERY BOX, FROM ENVIRONMENT, OF PREMATURE CORROSION CONDITION OF TERMINALS, CABLES, AND CONNECTIONS WITHIN. MODEL 2010-2013 VHD. *PE
SP-284-051
Service Bulletin/Repair Instructions
VOLVO TRUCK: THE ENGINE CONTROL MODULE (ECM) HAS SOFTWARE UPDATES WITH ENHANCEMENTS, AVAILABLE, TO ADDRESS COLD START TIME, PISTON COOLING JET (PCJ), REGENERATIONS IN COLD CLIMATES. MODEL VAH, VHD, VN. *PE
SP 284-049
Service Bulletin/Repair Instructions
Engine Control Module (ECM) Software Update
SP-284-042
Service Bulletin/Repair Instructions
VOLVO: THERE ARE ENHANCEMENTS TO SOFTWARE UPDATES FOR ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL MODULE (ACM) TO RESOLVE DIAGNOSTIC TROUBLESHOOTING CODES P1086, P0420, P205B, P2002. MODEL 2013 VAH, VHD, VN. *PE UPDATED 2/28/2014 *JS
SP-284-047
Service Bulletin/Repair Instructions
VOLVO: SOFTWARE UPDATES BEING PROVIDED FOR ENHANCEMENT OF THE ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL MODULE (ACM) FOR SOME TRUCKS BUILT 5/11/13 TO 10/2/13. MODELS VAH, VHD, VN. *PE UPDATED 2/28/2014 *JS
FSB-271-002
Service Bulletin/Repair Instructions
VOLVO: DUE TO A BUG IN THE SOFTWARE, IN SOME VEHICLES, THERE WERE MULTIPLE COUNTS OF INACTIVE FAULTS ON ACCELERATOR PEDAL (STANDARD OR KICKDOWN, ONE OR THE OTHER). MODEL 2013 VN, VHD, VAH. *PE
FSB-386-005
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, THERE IS AN INTERFERENCE WITH THE FUEL LEVEL SENDING UNIT FLOAT. MODEL 2014 VN, VHD, VAH. *PE
FSB 322-001
Service Bulletin/Repair Instructions
Charging System Voltage
FSB-51-001
Service Bulletin/Repair Instructions
VOLVO: THE AIR DISC BRAKE, ON SOME TRUCKS, MAY EXPERIENCE THERMAL OVERLOAD DUE TO AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION THAT MAINTAINS CLEARANCE RUNNING BETWEEN BRAKE PAD AND ROTOR. MODELS VAH, VHD, VN. NO YEARS LISTED. *PE
FSB-512-002
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, AIR DISC BRAKE MAY EXPERIENCE A CONDITION OF THERMAL OVERLOAD. THERMAL OVERLOAD REDUCES RUNNING CLEARANCE BETWEEN PAD AND ROTOR BELOW DESIRED LEVEL WHICH IS AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION. MODEL VAH, VHD, VN. NO YEARS LISTED. *PE
FSB 284-047
Service Bulletin/Repair Instructions
Oil Level Sensor Harness Wire Splice
FSB 210-001
Service Bulletin/Repair Instructions
Engine Data Label
FSB-284-047
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, THERE IS AN OIL CONTAMINATION INTO THE ENGINE WIRE HARNESS BECAUSE OF A FAILURE OF THE OIL LEVEL SENSOR. MODELS VAH, VHD, VN, VT. NO MODEL YEARS LISTED. *PE
FSB-293-022
Service Bulletin/Repair Instructions
VOLVO TRUCK: ON SOME TRUCKS, DUE TO A POSSIBLE REPLACEMENT OF EGR TEMPERATURE SENSOR, A NEW CONFIGURATION ROUTING REQUIRES THREE DOUBLE LOOP CABLE TIES TO SECURE EGR TEMPERATURE SENSOR CONNECTOR DIRECTLY TO COOLANT PIPE. MODELS VAH, VHD, VN, D13H. NO MODEL YEARS. *PE
SP-431-021
Service Bulletin/Repair Instructions
VOLVO TRUCK: ON SOME TRUCKS, DUE TO LOSS OF CALIBRATION AND ABILITY TO ENABLE SINGLE PTO FUNCTIONALITY, SOFTWARE UPDATES ARE AVAILABLE TO ENHANCE TRANSMISSION ELECTRONIC CONTROL UNIT (TECU). MODELS OBD2013, D11H, D13H, D16H, VHD, VN. MODEL YEARS NOT LISTED. *PE
FSB 371-045
Service Bulletin/Repair Instructions
Battery Cable Lug, Failure
FSB-371-045
Service Bulletin/Repair Instructions
VOLVO TRUCKS: INFORMATION REGARDING THE BREAKING OR CRACKING OF 90 DEGREE POSITIVE BATTERY ABLE LUG AT STARTER SOLENOID STUD; AT TIME OF ASSEMBLY, THE LUG WAS BENT AND ENGINE VIBRATES, CAUSING TERMINATION OF TERMINAL TO WEAKEN AND FAIL. MODELS VN, VHD. NO MODEL YEARS LISTED. *PE UPDATED 1/24/2014 *JS
SP 431-021
Service Bulletin/Repair Instructions
Transmission ECU Programming
SP2 284-036
Service Bulletin/Repair Instructions
Software Update, revise document
SP-284-036-01
Service Bulletin/Repair Instructions
VOLVO: SOFTWARE UPDATE. ENHANCEMENTS ON THE SOFTWARE UPDATE FOR THE ENGINE CONTROL MODULE (ECM), INSTRUMENT CLUSTER (IC), VEHICLE ELECTRONIC CONTROL UNIT (VECU), AFTERTREATMENT CONTROL MODULE (ACM), AND TRANSMISSION ELECTRONIC CONTROL UNIT (TECU). *KB
FSB 371-042
Service Bulletin/Repair Instructions
Jumper Harness, Repair
FSB 371-044
Service Bulletin/Repair Instructions
Battery Cable Mounting Clamps
FSB 293-016
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
FSB 811-005
Service Bulletin/Repair Instructions
Floor Cracks Repair (Front Panel)
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.