Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
M0307 EC0033 202606
Volvo Trucks has determined that certain vehicles equipped with a model year (“MY”) 2017-2018 13L Turbo Compound (TC) engine may not meet California and Federal Regulations (CARB). This Recall is for updated software that will reduce the amount of time necessary for the system to operate in a cold engine warm-up strategy and provide health monitoring of the Selective Catalyst Reduction (SCR).
CBR 983-7 202604
CBR - Volvo Chassis - Model VHD - Splash Shield Rubbing Lower Cowl - Model Year 2018 - Current.
CBR 2246-5 032026
CBR - Z Spring Bracket Wear. Volvo Chassis
CBR 126 022026
CBR - The purpose of this solution is to give information on Engine Control Module (EMS) Software content.
M0305 022026
Emissions - Volvo Trucks has determined that certain vehicles equipped with a model year (“MY”) 2017-2018 11L engine may not meet California and Federal Regulations (CARB).
CBR 976-7 202601
CBR - Volvo Chassis - I-Shift Transmission - Moisture / Contamination Found In The Transmission Electronic Control Unit (TECU ) Air Ports And Control Housing.
CBR 2190-10 202601
CBR - Volvo DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and US22+OBD23 (DOES NOT APPLY TO VN(4))
CBR 2016-18 202511
CBR - Frame or Cab Lean
CBR 2488 072025
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication but failing to transmit GPS location data.
CBR 939 072025
CBR - US17AbstractVolvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19 on Premium Tech Tool ( PTT ) or J-Pro, and code 167 in Bendix ACOM software.
CBR 170-8 202505
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure) (Possible Related Codes - SPN4811 , SPN 100 , PID 100)
CBR 901-5 202505
Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model Year 2018 And Newer
CBR 2016-14 202505
Volvo Chassis - Frame Or Cab Lean
CBR 445-11 202505
Vehicles Equipped With a Common Rail Fuel System - Aftermarket Secondary Fuel Filters, Important Information On Approved Filters - US17+OBD16 toUS21+OBD23
M0349 202504
ER - Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with the MY 2017 or 2018 13L VGT and Turbo Compound (TC) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance.
TSB V-710-001 202504
TSB - V-710-001 Engine Crossmember Loose Hardware.
CBR 2452 202503
CBR - Driver Display Popup Error "Door Is Open. Shift Transmission To Neutral." -Instrument Cluster Software Update
CBR 561 202503
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
M0308 202503
EM - Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with the MY 2017 or 2018 (13L VGT) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance.
CBR - 2016 202502
CBR - Troubleshooting cab lean should only begin after completing a vehicle preparation procedure to ensure all components are in place and settled.
CBR - 2416 202502
This CBR solution provides a step-by-step procedure for using longer Hood Tilt Switch mount screws and additional washers on Volvo Auto Hauler (VAH) and Volvo Heavy Duty (VHD) models.
TSB - V-891-001
TSB - Due to cracking in the step area of the fairing, an updated support bracket has been introduced. The new support bracket will provide the better structure behind the fairing, reducing the likelihood of cracking.
CBR 2438-1 202501
CBR - Volvo Chassis - No-Crank Issue After Programming
CBR 2016-12 202501
CBR - Frame Or Cab Lean
RD24-041 202412
These repair instructions are intended to address the following fault(s): P009B-13 (Electric Pressure Relief Valve – Circuit Open).
CBR-2016 202412
Frame lean can be caused by several seemingly isolated possibilities. The two most common are suspension and frame assembly issues.
V-321-002 202412
Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience insufficient battery system charging. This could lead to early battery failure and improper functioning of the auxiliary power systems. Follow the instructions in the attached document to upgrade the charging system.
CBR-997 202411
Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping. These symptoms can be mistaken as a crankshaft rear main seal leak, when the actual cause is the crankshaft adaptor O-ring.
M0308 202411
Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with the MY 2017 or 2018 (13L VGT) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance. These vehicles have been flagged due to telematics data showing that the NOx conversion efficiency of the SCR system has dropped below 94% for eight weeks. Alternatively, these vehicles may have communication issues with telematics, such as not reporting or ceasing reporting for the same period.
CBR-2416 202411
This CBR solution provides a step-by-step procedure to replace the hood tilt switch on Volvo Autohauler (VAH) and Volvo Heavy Duty (VHD) models, specifically for units equipped with bodybuilder applications that enable remote start/stop functionality outside the cab when the PTO (Power Take-Off) is engaged. The hood tilt switch is a critical safety component that disables remote start when the hood is opened or tilted.
CBR-2260 202410
CBR - Volvo Chassis - Timing Gear Plate Repair
M0308 202410
CBR - SCR replacement
CBR-466 202410
CBR - Volvo Chassis - Diagnostic Trouble Code (DTC) P009B13 Fuel Pressure Relief Control – Circuit Open; Possible Derate - US17+OBD16 And US17+OBD18 Emissions
CBR-570 202409
CBR - US17 GHG Common Rail Fuel System Component Electrical Faults - Model Year 2017 To 2024
CBR-2398 202409
CBR - Volvo Chassis - HVAC Fresh Air Door Binding
CBR-731 202409
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR-923 202408
CBR: Volvo Chassis - Equipped With Volvo Active Driver Assist( VADA ),With Or Without Lane Departure Warning(LDWS )-Diagnostic Trouble Code ( DTC )SPN 70 FMI 9, Bendix Code 64 With Possible "Lane Departure Warning Malfunction" Message-US17 And Newer
CBR-343 202408
CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR-523 202408
CBR: Overhead Wear Overview - Model Year2018 To Current (Common Rail Fuel System ONLY)
CBR-561 202408
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR-2391 202408
CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
CBR-2350 202407
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR-2383 202406
CBR - Accelerator Pedal: Inspection/Instructions
M0308 202406
Emissions - SCR Replacement 13LVGT
CBR-817 202405
CBR - Volvo Chassis - Enable Air Suspension Gauge Function - US17 And Newer Chassis ONLY
CBR-2139 202405
CBR - 11 Liter Engines - Fuel In Oil.
M0306 202405
EM - SCR Monitoring Software 13L VGT
M0308 202405
EM - SCR Replacement 13LVGT
CBR-408 202403
CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
KC-2350
CBR - Telematics Gateway (TGW) Connect Ability Issues.
KC-2014
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
KC-202
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR-2333 202401
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
EC0028V 202312
Emissions Campaign: Volvo has determined that certain 2014 -2018 model year VN, VHD, and VAH Vehicles require a replacement Diesel Particulate Filter (DPF) along with updated software.
CBR-399 202310
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
CBR-206 202310
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
CBR-570 202309
CBR: Model Year 2017, 2018 - US17GHG Common Rail Fuel System Component Electrical Faults
CBR-2297 202309
CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
V-258-001 202309
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
V-258-002 202309
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
S7568 202309
Service Campaign: (Revision extending the campaign expiration date another year, to 12-31-2024)
CBR-2120 202308
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
TSB: Barksdale Leveling Valve, Leak Test
CBR-2305 202308
CBR: Valve Stem Extension Contacting Outer Wheel
CBR-2112 202307
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR-2297 202307
CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
CBR-2298 202307
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
KC-2094 Rev 3
Infotainment System - Volume Drop During A Phone Call, Phone Connected Via Bluetooth
KC-2293
Vehicles With Back-Of-Cab SCR - Exhaust Stack Replacement Information, PM Sensor Failure Repair Information
KC-321 Rev 5
Cummins Powerplant - Fault Code SPN 1081 FMI 31 - Engine Wait to Start Lamp, Condition Exists - Model Year 2018
KC-2191 Ver 5
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2292
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
KC-2278
CBR - Volvo Chassis - Hood Release Cable Binding Or Broken
KC-2191 Ver 3
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2194
CBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
S7414-Ver2
Campaign: Field Test Software Engine Control Module - Removal
SLV23-005
Service Literature Published and Released in May, 2023
KC-331-Ver6
CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
KC-503-Ver3
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 / P10AE81 Fault Codes Being Generated
KC-2229-Ver2
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
KC-474-Ver5
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
KC-2265
CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO. VHD chassis may experience Diagnostic Trouble Code P071A or P07CE along with symptoms of no reduced engine load (RELS) when coming to a stop and/or the transmission going into 4th gear lock up when applying the service brake.
KC-2191
CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions. The primary failure mode the NOx Sensors is internal failure, which will generate a sensor specific fault code.
KC-2269
CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16
KC-2033
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4. The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
KC-2260
CBR: Volvo Chassis - Timing Gear Plate Repair. This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
KC-331
Model Year 2017, 2018 - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
KC-776
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
S7568
Electronic Pressure Releif Valve (EPRV) Delete & Fuel Rail Pressure Sensor
KC-2248
Flywheel Housing Thread Repair
KC-306
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared; Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014
V-212-001
Timing Gear Plate Inspection
V-371-004
TBS- Jumper Harness, Wiper Motor, Replacement
KC-399
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
KC-2195
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2201
Engine Control Module (EMS) Software (MSW) Information â October 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-548
(Back Office Only) Volvo Chassis - Enable Parking Brake Alarm, Parameters - US17 And Newer ( INT-GEN2 )
KC-183
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
KC-401
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
V-265-002
TSB-Charge Air Cooler t-clamp install.
SMB00-108C
Expendable Items Parts List.
CBR-2201
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-420
inquiries received concerning an open connection port present on the exhaust pipe after the One Box System DPF/SCR
KC-561
11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
KC-750
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
KC-751
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
KC-2112
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
AMT Control Housing Bench Testing - False Failures
KC-2174
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer.
KC-735
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
KC-736
(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) - US17 And Newer Emissions (Common Rail Fuel System)
KC-2107
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2149
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-2157
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-2158
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2011
Volvo Chassis - SNV 20-005 - HD Disc Brake Rotor Upgrade
KC-695
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-662
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
KC-664
Volvo Chassis - Volvo ( Bergstrom )Parking Cooler System, Technical Information And Diagnostic Guide - Model Year 2018 And Newer
KC-639
Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
KC-640
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
KC-642
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
KC-647
Volvo Chassis Ghost Codes Due To Poor Grounding
KC-649
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
KC-650
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
KC-660
Volvo Chassis - PTO Pump Speed Calculator
KC-635
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
KC-636
Volvo Fault Code MID 144 PSID 204 FMI 9
SNV22-003
The Diagnostic Process
KC-631
B/O Volvo Park Brake warning POPup displays in DID when Park Brake is released and driver door is open Model Year 2018 and Newer
KC-623
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-608
V-MAC III - Smart Fan Will Not Disengage
KC-609
Volvo Chassis - Accessory / Auxiliary Connection Points ( Power/Ground Points ) - VNL, VNR, VNX, VAH, VHD - Model Year 2018 And Newer
KC-634
Model Year 2017, 2018 - US17 Emission Engines - The ( Donaldson ) Fuel Filter - Part Number P550529 - " Cannot " Be Used
KC-966
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off - US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
KC-743
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD15, US14+OBD16 (Common Model Years 2016 And 2017), US17+OBD16 And Newer ( Common Rail Fuel System, Model Year 2018)
KC-778
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P02FA US17+OBD16 And US17+OBD18 (GHG17) Emissions
KC-784
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
V-392-004
Radio, Replacement (revised from FSB 392-005)
KC-367
Volvo Chassis - Technical Service Bulletin V-728-005, Leveling Valve, Leak Test, Air Leaks From The Leveling Valve After The Vehicle Is Parked (Shut Off)
KC-816
(Back Office Only) Volvo Chassis - VN Model - Front Brake Squeal - US14 And Newer
KC-570
Model Year 2017, 2018 - US17 GHG Common Rail Fuel System Component Electrical Faults
S7617
Forward Looking Radar Shortage - Plug Inspection
KC-541
Volvo Chassis - FSB 761-002, Shock Absorber, Inspection
356EN01
VIDA QR Scanner Mobile App
Service Manager
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-478
Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
KC-439
Volvo Chassis - Water leaking Around The Windshield - Model Year 2018 and Newer
KC-408
Volvo Chassis - Bendix Lane Departure Warning System ( LDWS ) Audible Alarm Does Not Deactivate When The Turn Signal Is Switched On - US16; Model Year ( MY ) 2017
KC-413
Volvo Chassis - Coolant Leak Test - Dye Information
KC-415
Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate Warning - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
KC-422
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
KC-423
Volvo Chassis US13 And Up Pre-trip Assistant Enable
KC-391
Noise On The AM Radio Band; Thumping, Ticking, Fluttering Sound On AM Radio Band - Model Year 2018 And Newer
KC-392
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-398
Chassis Equipped With An AMT-F (I-Shift, mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At Low Speed; Information And Repair - Build Date Beginning Of Production 2017 To February 2018
KC-379
Engine Brake - Diagnostic Trouble Code (DTC) P1021-11 Volvo Compression Brake (VCB) Control Circuit Short To Ground - US17+OBD16 Through US17+OBD19 Emissions, Model Years 2018 To 2020
KC-357
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse Guidelines
KC-321
Cummins Powerplant - Fault Code SPN 1081 FMI 31 - Engine Wait to Start Lamp, Condition Exists - Model Year 2018
KC-325
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And Newer Emissions, Common Year Models 2015 And Newer
KC-304
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-311
Diagnostic Trouble Code (DTC, Fault Code) MID 140 PSID 210 FMI 12, Faulty Unit or Component Present On DTC Readout; Vehicle Operation Not Affected: No Physical Symptoms Or Warning Lights In Instrument Cluster - Model Year 2018
KC-226
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-216
Front Accessory Drive noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - MY 2017 And Newer
KC-143
Volvo Chassis - With 2018 New Style Instrument Cluster - Radio Mutes When In Reverse - Model Years 2018 And Newer
KC-167
Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error 43 Displayed - US10+OBD13 And Newer Emissions, Common Model Year 2014 And Newer
KC-159
Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
KC-161
Volvo Chassis - Equipped With A Cummins Engine - Cummins Fuel Pump Timing Correction to Reduce Engine Noise; Drone Noise at 1500 RPM and Increases With Engine Load - US10 And Newer Emissions, Common Model Year 2014 And Newer
KC-163
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-165
Model Year 2018 - Equipped With An Automated Manual Transmission ( AMT-F ) ( I-Shift, mDRIVE ) - Noisy When The Vehicle Is Stationary Shifting From Neutral To Drive Or Reverse
KC-277
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVER
KC-124
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-114
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC, Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
KC-102
Volvo Chassis - Performance Bonus OBD13 And Newer
KC-99
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
FSB 211-003_V
Valve Cover Oil Leak at T Joint
KC-342
Selective Catalytic Reduction (SCR) Parts Supersession; New Part Numbers For SCR Muffler/Canister - All One Box And Two Box Configurations EXCEPT Turbo Compound - US17+OBD16 And US17+OBD18 Emissions, Model Years 2018 And 2019
S7575
TECU Software Update
KC-466
Volvo Chassis - Diagnostic Trouble Code (DTC) P009B13 Fuel Pressure Relief Control â Circuit Open; Possible Derate - US17+OBD16 And US17+OBD18 Emissions, Model Years 2018 And 2019
KC-2032
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
FSB 237-021v2
Revision: Valve, Common Rail, Removal
KC-544
Model Year 2017, 2018 - ** Tech Tip ** TT - 000 - 2017 GPS Inoperative Message In DID ( Driver Information Display ) - Telematics Gateway ( TGW )
S7568 v2
RD: EPRV Delete & Fuel Rail Pressure Sensor Update
RVXX2101
Canada Non- Compliance recall for DRL override dealer alert
FSB 237-021
Valve, Common Rail, Removal
KC-723
Diagnostic Trouble Codes ( DTC ) P0016-76 - Crankshaft Position - Camshaft Position Correlation - Turbo Compound ( TC ) - Model Year 2018 and Newer
FSB 284-070
DTC P0194-00 and/or P016E-00, Fuel Rail Pressure Sensor (RPS) and wiring harness, Replacement
KC-2018
Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
FSB 258-039
SCR Fittings, One Box, Replacement PM, NOx and Temperature Sensor Fittings
S7535
Remote Diagnostics - ACM and ECM Software Update
NCRA-2020-V01
EXPANDED SCOPE- Non-Compliance Recall Alert, EC0020 & EC0022 SCR System
SNV20-007
Emissions Recall EC0022 Expanded
S7477v2
CarPlay SW Update
S7484v2
CarPlay SW Update with Hardware
S7486v2
CarPlay SW Update with SEM
K53338075
Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
K03573329
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD16, US17+OBD16, And US17+OBD18 Emissions, Model Years 2017 To 2019
K07192247
Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
K47547856
Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL) - US14+OBD16, US17+OBD16 And Newer Emissions, Model Year 2017 And Newer - To Be Used For EVERY Visit
K65527708
Diagnostic Trouble Codes (DTC) P20EE And P103C, Diagnostic Procedure; REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL ( PTT ) - US17+OBD16 Through US17+OBD2018 Emissions, Model Years 2018 And 2019
K75110032
FSB 233-007, Fuel Filter Housing, Replacement; Extra Port On Fuel Filter Housing When Replacing With New Part - Vehicles Manufactured Between 14 November 2016 And 31 December 2019
FSB 233-007
Fuel Filter Housing, Replacement
S7477
CarPlay SW Update
S7484
CarPlay SW Update with Hardware
S7486
CarPlay SW Update with SEM
K18013154
Vehicles Equipped With A One-Box Emissions Aftertreatment System ( EATS ) - Diagnostic Trouble Codes ( DTC ) P2463 and P2453. US17+OBD16 (GHG17) And Newer Emissions, Common Model Year 2018 And Newer
K01157283
Front Accessory Drive Noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - Model Year 2017 And Newer
K55899505
Volvo Chassis - With 2018 New Style Instrument Cluster - Radio Mutes When In Reverse - Model Years 2018 And Newer
K41105570
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
K44250068
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
K09201017
Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet, Omnitracs, GPS, Location Tracker, Etc.) RP1226 connection On The Data Link; Installation Instructions And Information For Third Party ( Aftermarket ) Devices Connected To The Data Link - US17+OBD16 And Newer Emissions, Models Built up to Week 37 (9/13) 2019.
K22114901
Engine Control Module (EMS) Software (MSW) Information - November 2019; Improvement List (Change Log) And Explanations For Issues And Diagnostic Trouble Codes (DTC, Fault Codes) US17+OBD2016 And US17+OBD18 Emissions, Model Years 2018 And 2019
K42065042
Volvo Chassis - Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
K40914241
Common Rail Fuel System Faults - Diagnostic Trouble Codes (DTC) P0094, P228F, P016F, P0087,P00C6, P0257, P2A17, P2A1F, P008A; Repair Information - US17+OBD16, US17+OBD18, and US17+OBD19 Emissions, Model Years 2018 To 2020
K29295744
Updated PM Sensor Removal Procedure - US17+OBD16 and Newer Emissions
SP656-001
SP656-001 Hendrickson Lift Axle Hardware, Retorque
K14466413
Volvo Chassis - Equipped With A D13M Engine - Diagnostic Trouble Code ( DTC ) P04DB - Crankcase Ventilation Disconnected; US17+OBD16 And US17+OBD18 Emissions (Common Rail Fuel System), Model Years 2018 And 2019
K21533201
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
K25588222
Model Year ( MY ) 2017, 2018 - US17 GHG Emissions Engine - Common Rail Fuel Injector - Electrical Test
M0070
EC0020C Analysis & SCR Hardware Replacement - 2 Box
K20878118
Diagnostic Trouble Codes ( DTC ) P205B-64 - Reductant Tank Temperature Sensor Circuit Range/Performance - Model Year 2018 and Newer
K68033394
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
K05144150
Volvo Chassis - PTO Switch Installation For Vehicles With Updated Interior - Model Year 2018 And Newer
K17408563
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
M0062
EC0020A SCR Hardware Replacement-2 Box
M0064
EC0022A SCR Hardware Replacement,11L-1 Box
M0074
EC0022B SCR,Label Only-1 Box
K15812145
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
K64554358
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared; Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014 And Newer
K39135131
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
K33593604
Diagnostic Trouble Codes (DTC) P0069-64, P10EC-00, P0191-64 and P240F-00 In Different Combinations, Occurrences, And Time Stamps (Two To Four Codes), Possible Vehicle Derate - US17+OBD16, US17+OBD18 Emissions, Common Model Years 2018 And 2019
K37146742
US07 / US10 D13 Turbocharger Gasket
K93394430
Engine Brake - Diagnostic Trouble Code (DTC) P1021-11 Volvo Compression Brake (VCB) Control Circuit Short To Ground - US17+OBD16 Through US17+OBD19 Emissions, Model Years 2018 To 2020
FSB728-005
Leveling Valve, Leak Test
K62132009
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
K11907301
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
K86900043
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B, P1121 - Temperature Sensor Inspection
K53357197
Dignostic Trouble Code (DTC, Fault Code) MID 140 PSID 210 FMI 12, Faulty Unit or Component Present On DTC Readout; Vehicle Operation Not Affected: No Physical Symptoms Or Warning Lights In Instrument Cluster - Model Year 2018
K85318413
Noise On The AM Radio Band; Poor Or No Reception On AM Radio - Model Year 2018 And Newer
K94743326
Diagnostic Trouble Code (DTC) P009B-13 Fuel Pressure Relief Control - Circuit Open; Possible Derate - US17+OBD16 And US17+OBD18 Emissions, Model Years 2018 And 2019
K51800139
Volvo Chassis - Windshield Wiper Function Inoperative In Intermittent Mode ONLY; Wiper Intermittent Setting Not Working - Model Year 2018 to 2020
FSB563-008
Plugs, Pressure Protection Manifold
K91214678
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5 Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
K04404042
Cummins Powerplant - Fault Code SPN 1081 FMI 31 - Engine Wait to Start Lamp, Condition Exists - Model Year 2018
K14637412
Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic, Intermittent And/Or P016E-00 Closed Loop Fuel Pressure At Control Limit, Pressure Too High - US17+OBD16 (Common Rail Fuel System) Emissions And Newer; Model Year 2018 And Newer
K01029637
Diagnostic Trouble Codes (DTC) P0087 Fuel Rail/System Pressure To Low, P016F Closed Loop Fuel Pressure Control At Limit - Pressure Too Low, P228F Fuel Pressure Regulator Exceeded Learning Limits - Too High; Damaged Lip Seal On Secondary Fuel Filter; Possible Uneven Operation - US17+OBD16 And Newer Emissions (Common Rail Fuel System), Model Year 2018 And Newer
K17696792
Diagnostic Trouble Code (DTC) P24F6-00, Exhaust Aftertreatment Fuel Air Purge Valve Stuck Open Or DTC P24F7-00, Exhaust Aftertreatment Fuel Air Purge Valve Stuck Closed - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
K02901917
Volvo Chassis - VHD Splash Shield Rubbing Lower Cowl - US17+OBD2016 Emissions, Model Year 2018 (Common Rail Fuel System ONLY)
K10075112
Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model Year 2018 And Newer
K06249461
Volvo Chassis - Left Hand Drive ( LHD ) - No Airflow From Defrost And Floor Vents - Model Year 2018 And Newer
K81191298
Volvo Chassis - Vehicles Equipped With Two-Piece Valve Cover - FSB 211-002 Two Piece Valve Cover Name Plate, Replacement; Name Plate Loose Or Missing - Model Year 2015 To 2018
K43113098
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92 Logging, Appears As Inactive - Common Model Years 2018 And 2019
K12246971
Grounding Bus Bar On Frame Rail Stud; Inspection To Be Performed For Power And Ground, Data Link DTCs - US13 And Newer Emissions, Common Model Year 2018 And Newer
K93482141
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
K49053322
Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018 And Newer
K14235517
Common Rail Fuel System - Engine Wiring Harness Will Not Reach / Is Not Long Enough To Connect To Electronic Pressure Relief Valve (EPRV) Connector, Wiring Harness Pulled Tight At EPRV; Correct Clocking, Symptoms, Repair - US17+OBD16 And Newer Emissions, Common Model Years 2018 And Newer
K24992549
Engine Control Module (EMS) Software (MSW) Information; Improvement List (Change Log) And Explanations For Issues And Diagnostic Trouble Codes (DTC, Fault Codes) US17+OBD2016 Emissions, Model Year 2018 (Common Rail Fuel System ONLY)
K90358413
Common Rail Fuel System - Diagnostic Trouble Code ( DTC ) P0094-00 Fuel System Leak Detected, Small Leak, Diagnostic Information - US17+OBD16 And US17+OBD18 Emissions, Common Model Years 2018 And 2019
K67812550
Wiring Harness Rubbing On Radiator Mounting Bolt; Adaptive Cruise Control ( ACC) Forward Looking Radar Inoperative, Datalink Communication Diagnostic Trouble Codes (DTC) Lighting The Malfunction Indicator Lamp (MIL) - US17+OBD16
FSB221-012
Oil Fill Adapter, Replacement
SP284-067
ECM and ACM, Software Updates
K21052070
Intermittent Occurrences Of Very Brief Loss Of Power, Engine Stumble Or Hiccup Lasting Much Less Than A Second, Most Frequently Between 1500 And 1700 RPM, No Diagnostic Trouble Codes ( DTC ) Generated - All Common Rail Fuel System Chassis - US17+OBD16 And Newer Emissions, Commonly Model Year 2018 And Newer
K44597912
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) Power Take-off (PTO) Does Not Engage Or Grinds Intermittently During Engagement Or During Operation; Symptoms Present For PTO That Was Previously Working Properly - US17+OBD16 And Newer Emissions, Common Model Years 2018 And Newer
K24483157
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And Newer Emissions, Common Year Models 2015 And Newer
K86412082
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD15, US14+OBD16 (Common Model Years 2016 And 2017), US17+OBD16 And Newer ( Common Rail Fuel System, Model Year 2018)
K14122525
Volvo Chassis - Vehicles Equipped With A Vertical Selective Catalytic Reduction (SCR) System - Diagnostic Trouble Codes ( DTC ) P1031 With Possible P24DA Lighting The Malfunction Indicator Lamp ( MIL ) - US17+OBD16 (GHG17, Common Rail Fuel System) Emissions, Commonly Model Year 2018
K04342327
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And US17+OBD18 (GHG17) Emissions (Common Rail Fuel System) - Commonly Model Years 2018 And 2019
K14701433
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P009E-73 - Fuel Pressure Relief Control Performance / Stuck Off - US17+OBD16 And US17+OBD18 ( GHG17 ) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
K72614548
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17+OBD16 And US17+OBD18 (GHG17) Emissions (With Common Rail Fuel System), Commonly Model Years 2018 And 2019
K28021025
Volvo Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, I-Shift ), Premium Tech Tool ( PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% - US17+OBD16 (GHG17) And Newer Emissions, Common Model Years 2018 And Newer
FSB284-067
ECM and ACM, Reprogramming, OBD2017 and OBD2018
K15560422
Selective Catalytic Reduction ( SCR ) Efficiency And NOx Sensor Codes P225C, P225E, P221A, P2201, P103C, P20EE, And P207F : NOx Sensor Diagnostic Information TO BE USED BEFORE SENSOR REPLACEMENT - OBD13 And Newer Emissions (Commonly Model Year 2014 And Newer)
K21134562
Selective Catalytic Reduction ( SCR ) Efficiency And Diesel Exhaust Fluid ( DEF ) Dosing Valve Diagnostic Trouble Codes ( DTC ) P208E, P103C, P0422, P20EE, P207F, P225E; Dosing Valve Diagnostic Information TO BE USED BEFORE DEF DOSING VALVE REPLACEMENT - OBD13 And Newer Emissions (Commonly Model Year 2014 And Newer)
K13512181
REQUEST REGEN Button Missing From EATS Status and DPF Status Screens In Instrument Cluster (IC) - Chassis Equipped With New (Updated) Cluster Design - Model Year 2018 And Newer
K24400052
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
K14003352
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US17 (GHG17), Common Rail Fuel System ONLY, Updated programming and diagnostic instructions
K97651904
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
K52326370
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 ( Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
FSB216-002
Flywheel Resurfacing Guidelines, I-Shift
FSB284-064
ECM and ACM Reprogramming, OBD2015
K82320750
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The Key On And Engine OffChanged repair information to reflect new software available.
K03179378
Service Only Regen Requested With No Warning. Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
K15164821
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect release of FSB284-064 (Above)
K27690302
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
K48661544
Chassis Equipped With An AMT-F (I-Shift) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At Low Speed; Information And Repair - Build Date Beginning Of Production 2017 To February 2018
K42708399
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis (Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
K84412328
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16, Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
FSB237-020
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10, EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt.
FSB373-024
Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017 may have PTO solenoid bracket or transmission harness connector failures due to excessive vibration.
FSB211-002
On some VOLVO VN, VHD, and VAH trucks built from January 2014 to July 2017 and equipped with the name plate on a two piece valve cover, the name plate may come loose.
FSB 237-020
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10, EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 4 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
FSB 293-022
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration is required.
SP 398-001
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the vehicle systems after restarting.
FSB 593-012
Hill Start Assist Solenoid, Replacement
FSB 222-004
Oil Filter Housing
FSB 210-045
Regeneration in PTO Mode
FSB 284-057
High Soot Output
FSB 215-003
Timing Plate Flange Screw
FSB 431-010
Range Synchronizer, Repair
FSB 293-027
EGR Mass Flow Rate Low, diagnostic trouble code
FSB 371-049
Battery Cable, Routing
FSB 432-014
Transmission ECU Compatibility
FSB 293-024
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
FSB 234-018
Single Fuel Tank Ventilation Filter Kit
FSB 234-019
Dual Fuel Tanks Ventilation Filter Kit
FSB 801-003
Service Door Rust Prevention
FSB 432-013
AMT High Range Cone Replacement
FSB 375-010
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
FSB 375-011
Seat Harness Routing (Swivel) wires pulling away from clipping points
SP 284-049
Engine Control Module (ECM) Software Update
FSB 284-047
Oil Level Sensor Harness Wire Splice
FSB 210-001
Engine Data Label
SP 431-021
Transmission ECU Programming
SP2 284-036
Software Update, revise document
FSB 293-016
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
FSB 811-005
Floor Cracks Repair (Front Panel)
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.