CBR 983-7 202604
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - Model VHD - Splash Shield Rubbing Lower Cowl - Model Year 2018 - Current.
Vehicle report
2023 VOLVO VHD
Service bulletins
118 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CBR 2172-7 032026
Service Bulletin/Repair Instructions
CBR - No Start Condition After Over the Air Programing - VECU5 No Start "Safe State"
CBR 2246-5 032026
Service Bulletin/Repair Instructions
CBR - Z Spring Bracket Wear. Volvo Chassis
CBR 976-7 202601
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - I-Shift Transmission - Moisture / Contamination Found In The Transmission Electronic Control Unit (TECU ) Air Ports And Control Housing.
CBR 2190-10 202601
Service Bulletin/Repair Instructions
CBR - Volvo DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and US22+OBD23 (DOES NOT APPLY TO VN(4))
CBR 199-7 202512
Service Bulletin/Repair Instructions
CBR - 3 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between The Coolant Pump Housing And Oil Cooler Housing
CBR 2016-18 202511
Service Bulletin/Repair Instructions
CBR - Frame or Cab Lean
CBR 199-6 202511
Service Bulletin/Repair Instructions
CBR - 13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between The Coolant Pump Housing And Oil Cooler Housing
CBR 2172-5 082025
Service Bulletin/Repair Instructions
CBR - When an OTA (Over-The-Air) job starts to program the VECU blocks the starter relay out, if the job ends in a Critical failure, the vehicle will remain in Safe State.
CBR 2488 072025
Service Bulletin/Repair Instructions
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication but failing to transmit GPS location data.
CBR 939 072025
Service Bulletin/Repair Instructions
CBR - US17AbstractVolvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19 on Premium Tech Tool ( PTT ) or J-Pro, and code 167 in Bendix ACOM software.
CBR 170-8 202505
Service Bulletin/Repair Instructions
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure) (Possible Related Codes - SPN4811 , SPN 100 , PID 100)
CBR 901-5 202505
Service Bulletin/Repair Instructions
Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model Year 2018 And Newer
CBR 2016-14 202505
Service Bulletin/Repair Instructions
Volvo Chassis - Frame Or Cab Lean
TSB V-710-001 202504
Service Bulletin/Repair Instructions
TSB - V-710-001 Engine Crossmember Loose Hardware.
CBR 2452 202503
Service Bulletin/Repair Instructions
CBR - Driver Display Popup Error "Door Is Open. Shift Transmission To Neutral." -Instrument Cluster Software Update
CBR 561 202503
Service Bulletin/Repair Instructions
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR - 2016 202502
Service Bulletin/Repair Instructions
CBR - Troubleshooting cab lean should only begin after completing a vehicle preparation procedure to ensure all components are in place and settled.
CBR - 2416 202502
Service Bulletin/Repair Instructions
This CBR solution provides a step-by-step procedure for using longer Hood Tilt Switch mount screws and additional washers on Volvo Auto Hauler (VAH) and Volvo Heavy Duty (VHD) models.
TSB - V-891-001
Service Bulletin/Repair Instructions
TSB - Due to cracking in the step area of the fairing, an updated support bracket has been introduced. The new support bracket will provide the better structure behind the fairing, reducing the likelihood of cracking.
CBR 2438-1 202501
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - No-Crank Issue After Programming
CBR 2016-12 202501
Service Bulletin/Repair Instructions
CBR - Frame Or Cab Lean
CBR 2361-12 202501
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life (VCS2)
S7631 202501
Service Campaign
SC - Volvo Proprietary Steerable Axle Hubcap Replacement
S7639 202501
Service Campaign
SC - Volvo Proprietary Fixed Axle Hubcap Replacement.
S3977 202412
Service Campaign
This Service Campaign is the solution for vehicles affected by the Hub cover Insufficient Retention Recall RVXX2302. This campaign also covers trucks that were shipped from the factory without hubcaps.
RD24-041 202412
Service Bulletin/Repair Instructions
These repair instructions are intended to address the following fault(s): P009B-13 (Electric Pressure Relief Valve – Circuit Open).
CBR-2016 202412
Service Bulletin/Repair Instructions
Frame lean can be caused by several seemingly isolated possibilities. The two most common are suspension and frame assembly issues.
V-321-001 202412
Service Bulletin/Repair Instructions
Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience insufficient battery system charging. This could lead to early battery failure and improper functioning of the auxiliary power systems. Follow the instructions in the attached document to upgrade the charging system.
V-321-002 202412
Service Bulletin/Repair Instructions
Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience insufficient battery system charging. This could lead to early battery failure and improper functioning of the auxiliary power systems. Follow the instructions in the attached document to upgrade the charging system.
CBR-997 202411
Service Bulletin/Repair Instructions
Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping. These symptoms can be mistaken as a crankshaft rear main seal leak, when the actual cause is the crankshaft adaptor O-ring.
CBR-2417 202411
Service Bulletin/Repair Instructions
11L Engine Block Compatibility and Backward Conversion Parts Requirements
CBR-2416 202411
Service Bulletin/Repair Instructions
This CBR solution provides a step-by-step procedure to replace the hood tilt switch on Volvo Autohauler (VAH) and Volvo Heavy Duty (VHD) models, specifically for units equipped with bodybuilder applications that enable remote start/stop functionality outside the cab when the PTO (Power Take-Off) is engaged. The hood tilt switch is a critical safety component that disables remote start when the hood is opened or tilted.
CBR-2260 202410
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - Timing Gear Plate Repair
M0295 202410
Emissions
CBR - 13L engines may be equipped with an improper engine software calibration that does not match the engine certification label.
CBR-2258 202409
Service Bulletin/Repair Instructions
CBR - Diagnostic Trouble Code (DTC) P107471 - AMT-F
S0302 202409
Service Campaign
Service Campaign: TGW3 Non-Communication
CBR-570 202409
Service Bulletin/Repair Instructions
CBR - US17 GHG Common Rail Fuel System Component Electrical Faults - Model Year 2017 To 2024
CBR-2376 202409
Service Bulletin/Repair Instructions
CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
CBR-2398 202409
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - HVAC Fresh Air Door Binding
CBR-731 202409
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR-2361 202409
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life (VCS2).
CBR-343 202408
Service Bulletin/Repair Instructions
CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
S0302 202408
Service Campaign
Service Campaign: Volvo trucks has determined that certain VN and VHD model trucks built with TGW3 have stopped communicating after production. Follow the instructions below to update the TGW software and perform the SIM card calibration procedure to re-establish TGW connection.
CBR-523 202408
Service Bulletin/Repair Instructions
CBR: Overhead Wear Overview - Model Year2018 To Current (Common Rail Fuel System ONLY)
CBR-561 202408
Service Bulletin/Repair Instructions
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR-2361 202408
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
CBR-2391 202408
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
CBR-2258 202407
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P107471 - AMT-F
CBR-2356 202407
Service Bulletin/Repair Instructions
CBR: Drivers Information Display (DID)Inoperative After Cluster Replacement And Programming
CBR-2350 202407
Service Bulletin/Repair Instructions
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR-2383 202406
Service Bulletin/Repair Instructions
CBR - Accelerator Pedal: Inspection/Instructions
CBR-2334 202406
Service Bulletin/Repair Instructions
CBR - Brake Caliper Concerns And Premature Brake Pad Wear - Model Year 2023 - 2024
CBR-2376 202406
Service Bulletin/Repair Instructions
CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
CBR-2356 202406
Service Bulletin/Repair Instructions
CBR - Drivers Information Display (DID) Inoperative After Cluster Replacement And Programming
CBR-817 202405
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - Enable Air Suspension Gauge Function - US17 And Newer Chassis ONLY
CBR-2139 202405
Service Bulletin/Repair Instructions
CBR - 11 Liter Engines - Fuel In Oil.
CBR-2258 202404
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P107471 -AMT-F
CBR-2361 202404
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
CBR-2360 202404
Service Bulletin/Repair Instructions
CBR: Chassis Equipped With VECU5 Active Datalink/Communication Faults For Multiple Modules; ABS And SRS Communication Faults.
CBR-2139 202403
Service Bulletin/Repair Instructions
CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
CBR-2356 202403
Service Bulletin/Repair Instructions
CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as designed.
CBR-408 202403
Service Bulletin/Repair Instructions
CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
S3903 202403
Service Bulletin/Repair Instructions
Service Campaign: Volvo trucks has determined that certain VAH, VHD, and VN model trucks built with a D13 engine could experience a reduced clamping load on the turbocharger mounting hardware causing the hardware to become loose. On affected vehicles follow the instructions below to remove the turbocharger and replace the mounting hardware and mounting gasket with new parts.
KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
KC-2014
Service Bulletin/Repair Instructions
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
KC-2258
Service Bulletin/Repair Instructions
CBR - Diagnostic Trouble Code (DTC) P107471 - AMT-F
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
PSM23vna73
Service Bulletin/Repair Instructions
Parts Sales and Marketing Bulletin: Volvo Trucks is excited to announce an additional year warranty program on Volvo Reman AMT I-Shift Complete Transmissions. This extended warranty of 3 years or 350,000 miles on the transmission will be applicable when dealer installed, required parts are installed and is registered via eService.
S7654 202311
Service Bulletin/Repair Instructions
Service Campaign: On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear differentials being filled with incorrect fluid. This campaign will require draining the rear differential/differentials, hubs and refilling with the correct fluid.
S7631 202310
Service Bulletin/Repair Instructions
Service Campaign: This Service Campaign is the solution for the Proprietary Hubcap Recall SC0425 that effected Volvo VAH, VHD, VN, VNE Models. This Service Campaign also covers trucks that were shipped short from the factory or removed in the field. Volvo Trucks now has a solution to replace the Proprietary Hubcaps with new updated hubcaps.
S7639 202310
Service Bulletin/Repair Instructions
Service Campaign: This Service Campaign is the solution for the Ship Shortage of Proprietary Hubcap Recall SC0425 that effected Volvo VAH, VHD, VN, VNE Models. This Service Campaign also covers trucks that were shipped short from the factory or removed in the field. Volvo Trucks now has a solution to replace the Proprietary Hubcaps with new updated hubcaps.
CBR-399 202310
Service Bulletin/Repair Instructions
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
CBR-206 202310
Service Bulletin/Repair Instructions
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
CBR-2297 202309
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
V-258-001 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
V-258-002 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
CBR-2131 202308
Service Bulletin/Repair Instructions
CBR: Intermittent Diagnostic Trouble Codes U02A3,U029D, U029E - USE FOR NEW VEHICLES (US21+OBD22 Emissions)
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2305 202308
Service Bulletin/Repair Instructions
CBR: Valve Stem Extension Contacting Outer Wheel
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR-2297 202307
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
V-821-002 202307
Service Bulletin/Repair Instructions
TSB: Hood Cable Breaking or Binding
CBR-2298 202307
Service Bulletin/Repair Instructions
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
KC-2289
Service Bulletin/Repair Instructions
CBR - Diagnostic Trouble Code (DTC) P103200: Particulate Matter Sensor Removed from Exhaust - US21+OBD22 Emissions
KC-2094 Rev 3
Service Bulletin/Repair Instructions
Infotainment System - Volume Drop During A Phone Call, Phone Connected Via Bluetooth
KC-2191 Ver 5
Service Bulletin/Repair Instructions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2292
Service Bulletin/Repair Instructions
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
KC-2043 Rev 4
Service Bulletin/Repair Instructions
CBR - Engine Control Module (EMS) Software (MSW) Information - Improvement List, Through June 2023 - US21+OBD2020 Emissions
KC-2279
Service Bulletin/Repair Instructions
CBR - iLok Fastener Torque
KC-2191 Ver 3
Service Bulletin/Repair Instructions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2194
Service Bulletin/Repair Instructions
CBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
SLV23-005
Service Bulletin/Repair Instructions
Service Literature Published and Released in May, 2023
KC-2050
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P225C00 : NOx1 Sensor Stuck High - US17+OBD2019 And Newer Emissions
KC-331-Ver6
Service Bulletin/Repair Instructions
CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
KC-503-Ver3
Service Bulletin/Repair Instructions
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 / P10AE81 Fault Codes Being Generated
KC-2229-Ver2
Service Bulletin/Repair Instructions
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
KC-2226-Ver3
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) U1FFF68 - Factory Mode Active, Event Information - Model Year (MY) 2023
KC-474-Ver5
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
S7654-Ver3
Service Bulletin/Repair Instructions
On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear differentials being filled with incorrect fluid.
KC-2274
Service Bulletin/Repair Instructions
CBR: Volvo - Pre-Delivery Inspection (PDI) Torque Values. This solution provides the torque specs needed to complete a Pre- Delivery Inspection (PDI).
KC-2265
Service Bulletin/Repair Instructions
CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO. VHD chassis may experience Diagnostic Trouble Code P071A or P07CE along with symptoms of no reduced engine load (RELS) when coming to a stop and/or the transmission going into 4th gear lock up when applying the service brake.
KC-2272
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P008A - Low Pressure Fuel System Pressure - Too Low
V-366-008
Service Bulletin/Repair Instructions
TSB: Adaptive Cruise Control, Deactivation
V-773-005a
Service Bulletin/Repair Instructions
Hub Cap, Leaking
KC-2191
Service Bulletin/Repair Instructions
CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions. The primary failure mode the NOx Sensors is internal failure, which will generate a sensor specific fault code.
KC-2269
Service Bulletin/Repair Instructions
CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16
KC-2033
Service Bulletin/Repair Instructions
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4. The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
KC-2260
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Timing Gear Plate Repair. This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
V-220-001
Service Bulletin/Repair Instructions
New TSB for oil galley plug leaking oil.
KC-776
Service Bulletin/Repair Instructions
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
S7645
Service Bulletin/Repair Instructions
13L Oil Pickup Replacement
SMB00
Service Bulletin/Repair Instructions
Google Built In Premium Customer Experience Program
KC-306
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared; Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.