CBR 2246-5 032026
Service Bulletin/Repair Instructions
CBR - Z Spring Bracket Wear. Volvo Chassis
Vehicle report
2012 VOLVO VN
Service bulletins
170 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CBR 2488 072025
Service Bulletin/Repair Instructions
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication but failing to transmit GPS location data.
CBR 170-8 202505
Service Bulletin/Repair Instructions
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure) (Possible Related Codes - SPN4811 , SPN 100 , PID 100)
CBR 561 202503
Service Bulletin/Repair Instructions
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR-731 202409
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR-343 202408
Service Bulletin/Repair Instructions
CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR-561 202408
Service Bulletin/Repair Instructions
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR-2350 202407
Service Bulletin/Repair Instructions
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR-2383 202406
Service Bulletin/Repair Instructions
CBR - Accelerator Pedal: Inspection/Instructions
CBR-207 202406
Service Bulletin/Repair Instructions
CBR - Volvo Chassis - Models VNL, VNX Only Equipped With A USD16 Volvo Engine - AHI Harness Failure Related Fault Codes P249F00, P20DD13, P113413
CBR-2139 202405
Service Bulletin/Repair Instructions
CBR - 11 Liter Engines - Fuel In Oil.
KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2292
Service Bulletin/Repair Instructions
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
SLV23-005
Service Bulletin/Repair Instructions
Service Literature Published and Released in May, 2023
KC-503-Ver3
Service Bulletin/Repair Instructions
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 / P10AE81 Fault Codes Being Generated
KC-2229-Ver2
Service Bulletin/Repair Instructions
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
KC-474-Ver5
Service Bulletin/Repair Instructions
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
KC-2033
Service Bulletin/Repair Instructions
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4. The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
KC-2260
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Timing Gear Plate Repair. This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
KC-2248
Service Bulletin/Repair Instructions
Flywheel Housing Thread Repair
KC-607
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT-C, AMT-D, I-Shift) - - Unable To Program Transmission Electronic Control Unit (TECU) That Comes With A Reman Transmission - US07 TO US14 OBD13
KC-687
Service Bulletin/Repair Instructions
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
KC-183
Service Bulletin/Repair Instructions
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
V-265-002
Service Bulletin/Repair Instructions
TSB-Charge Air Cooler t-clamp install.
SMB00-108C
Service Bulletin/Repair Instructions
Expendable Items Parts List.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
V-366-003
Service Bulletin/Repair Instructions
Had to update the images and wording on how to access the programming file in Truck Dealer Portal.
KC-2112
Service Bulletin/Repair Instructions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
Service Bulletin/Repair Instructions
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
Service Bulletin/Repair Instructions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Service Bulletin/Repair Instructions
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
Service Bulletin/Repair Instructions
AMT Control Housing Bench Testing - False Failures
KC-2174
Service Bulletin/Repair Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Service Bulletin/Repair Instructions
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Service Bulletin/Repair Instructions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer.
KC-2107
Service Bulletin/Repair Instructions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
Service Bulletin/Repair Instructions
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
Service Bulletin/Repair Instructions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Service Bulletin/Repair Instructions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Service Bulletin/Repair Instructions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-722
Service Bulletin/Repair Instructions
Mack Chassis - Data Link Diagnostics - Diagnostic Trouble Codes ( DTC ) / Fault Codes From Multiple Components - Unable To Connect To Chassis, Programming Failure With Premium Tech Tool ( PTT ) Errors - Troubleshooting And Oscilloscope Instructions
KC-2149
Service Bulletin/Repair Instructions
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-695
Service Bulletin/Repair Instructions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-674
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Sending Unit Specification Information
KC-675
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration ( Regen ) Failure Diagnostic Process - US07 to US16 Emissions
KC-647
Service Bulletin/Repair Instructions
Volvo Chassis Ghost Codes Due To Poor Grounding
SNV22-003
Service Bulletin/Repair Instructions
The Diagnostic Process
KC-623
Service Bulletin/Repair Instructions
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-784
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
KC-366
Service Bulletin/Repair Instructions
Volvo Chassis - FSB 392 - 004 - Radio, Replacement
KC-705
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
KC-793
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical Service Bulletin V-216-001 Twin Mass Flywheel Conversion
SLV22-002
Service Bulletin/Repair Instructions
Volvo Monthly Bulletin Release Letter - Feb 2022
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
Service Manager
Service Bulletin/Repair Instructions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-413
Service Bulletin/Repair Instructions
Volvo Chassis - Coolant Leak Test - Dye Information
KC-418
Service Bulletin/Repair Instructions
Volvo Chassis - Air Brake System Schematics And Routing VN, VHD Version 2, VT From Build Date 11.2011
KC-434
Service Bulletin/Repair Instructions
Volvo Chassis - Model VN, Hood Release Cable Interference
KC-392
Service Bulletin/Repair Instructions
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-357
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse Guidelines
KC-358
Service Bulletin/Repair Instructions
Volvo Chassis - US10 to US16 Emissions - Soot Level Will Not Reset After Regen Or Locked At 140%
KC-304
Service Bulletin/Repair Instructions
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Service Bulletin/Repair Instructions
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-226
Service Bulletin/Repair Instructions
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-160
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative, No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Model Years 2011 To 2014
KC-163
Service Bulletin/Repair Instructions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-124
Service Bulletin/Repair Instructions
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
KC-2134
Service Bulletin/Repair Instructions
Volvo VN Models - Overhead Light Loose, Detaching From Headliner
KC-2136
Service Bulletin/Repair Instructions
Volvo Chassis - Model VN - Water Intrusion In Back Of Cab, Back Wall Of Bunk Leaking
KC-2032
Service Bulletin/Repair Instructions
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
KC-2101
Service Bulletin/Repair Instructions
Volvo Chassis - Model VN - Hood Latch/Cable Sticking Or Binding
KC-290
Service Bulletin/Repair Instructions
Volvo Chassis - Redundant Brake Switch Test - Code MID136 SID55 FMI2, or( DTC ) P1055
KC-521
Service Bulletin/Repair Instructions
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And Programming Information - Model Year 2008 Through 2017
K21533201
Service Bulletin/Repair Instructions
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
K19344221
Service Bulletin/Repair Instructions
Volvo Chassis - Fusion 2 Adaptive Cruise Function Document
K24912512
Service Bulletin/Repair Instructions
Volvo Chassis - Volvo Hill Start Assist System Information
K24113935
Service Bulletin/Repair Instructions
Volvo Chassis - Volvo Active Driver Assist (VADA)
K17408563
Service Bulletin/Repair Instructions
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
K11907301
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
FSB216-002
Service Bulletin/Repair Instructions
Flywheel Resurfacing Guidelines, I-Shift
FSB237-020
Service Bulletin/Repair Instructions
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10, EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt.
FSB373-024
Service Bulletin/Repair Instructions
Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017 may have PTO solenoid bracket or transmission harness connector failures due to excessive vibration.
FSB 237-020
Service Bulletin/Repair Instructions
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10, EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 4 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
FSB 293-022
Service Bulletin/Repair Instructions
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration is required.
SP 398-001
Service Bulletin/Repair Instructions
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the vehicle systems after restarting.
FSB 213-002, Exh
Service Bulletin/Repair Instructions
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression, or a mechanical injector Diagnostic Trouble Code (DTC).
FSB 392-004, Rad
Service Bulletin/Repair Instructions
On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable radio, the old radio may no longer be available for purchase. To upgrade from a GLAD format radio to a DEA500 format radio follow the following instructions.
FSB 561-025
Service Bulletin/Repair Instructions
SOME VOLVO VN MODEL TRUCKS BUILT FROM 11/01/2011 TO 10/03/2016, AND EQUIPPED WITH THE MERITOR/WABCO ELECTRONIC CONTROLLED AIR DRYER (ECAD) MAY EXPERIENCE EXCESSIVE MOISTURE BUILD UP IN THE AIR TANKS.
FSB 561-025, Ele
Service Bulletin/Repair Instructions
Some VOLVO VN model trucks built from 11/01/2011 to 10/03/2016, and equipped with the Meritor/WABCO Electronic Controlled Air Dryer (ECAD) may experience excessive moisture build up in the air tanks.
FSB221-010
Service Bulletin/Repair Instructions
DIAGNOSTIC TROUBLE CODES (DTCS), LOW OIL PRESSURE, VAH, VHD, VN
FSB 593-012
Service Bulletin/Repair Instructions
Hill Start Assist Solenoid, Replacement
FSB 222-004
Service Bulletin/Repair Instructions
Oil Filter Housing
FSB 593 012
Service Bulletin/Repair Instructions
On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid valve for the Hill Start Assist feature is prone to internal contamination in harsh environments. The internal contamination of the solenoid valve is caused by the buildup of grime, salt, road debris and other solid contaminants. In some cases, the buildup of solid contaminants caused the solenoid valve to malfunction. A similar malfunction is possible if the solenoid valve is equipped with a vent fitting that freezes over. The malfunction causes the trailer brake circuit to maintain trailer brake pressure after a grade Hill Start Assist event. Replacement of the existing solenoid valve, elbow, and the addition of a new tube fitting and tube will ensure proper functionality of the Hill Start Assist feature.
FSB 216-001
Service Bulletin/Repair Instructions
Twin Mass Flywheel Conversion
FSB 252-031
Service Bulletin/Repair Instructions
Turbocharger Outlet Pipe
FSB 210-045
Service Bulletin/Repair Instructions
Regeneration in PTO Mode
FSB 284-057
Service Bulletin/Repair Instructions
High Soot Output
FSB 215-003
Service Bulletin/Repair Instructions
Timing Plate Flange Screw
FSB 215-002
Service Bulletin/Repair Instructions
Timing Plate Leak Repair
FSB 258-036
Service Bulletin/Repair Instructions
DEF Sensor Assembly Routing
SP 430-001
Service Bulletin/Repair Instructions
Transmission Control Module, Programming
FSB 258-035
Service Bulletin/Repair Instructions
Aftertreatment DEF Tank Vent Filter
FSB 253-002
Service Bulletin/Repair Instructions
Engine Brake Loss
FSB 431-010
Service Bulletin/Repair Instructions
Range Synchronizer, Repair
FSB 293-027
Service Bulletin/Repair Instructions
EGR Mass Flow Rate Low, diagnostic trouble code
FSB 363-007
Service Bulletin/Repair Instructions
Windshield Visibility Improvement
SP 386-004
Service Bulletin/Repair Instructions
Fuel Management Module, Replacement, incorrect calibration
FSB 371-049
Service Bulletin/Repair Instructions
Battery Cable, Routing
SP 379-001
Service Bulletin/Repair Instructions
Dual Pin Lift Gate Receptacle
FSB 432-014
Service Bulletin/Repair Instructions
Transmission ECU Compatibility
TJ-25329
Service Bulletin/Repair Instructions
VOLVO: ON SOME VEHICLES, THE STEERING KNUCKLE WOULD HAVE WHEEL HUB DISPLACED AND WOULD TO REPLACE WHEEL HUB. *PE
FSB-216-014
Service Bulletin/Repair Instructions
VOLVO: INFORMATION PROVIDED REGARDING THE COVERSION FROM TWIN MASS FLYWHEEL TO SINGLE MASS FLYWHEEL. MODEL VN, VT. *PE
FSB-511-003
Service Bulletin/Repair Instructions
VOLVO: BRAKE SHOE IS PROTRUDING BEYOND BRAKE DRUM AND IS CORRECTED BY REPLACING/INSTALLING NEW 152 MM (6.0 IN) BRAKE SHOES, DUST SHIELDS, NEW 178 MM (7.0 IN) WIDE BRAKE DRUMS. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-004
Service Bulletin/Repair Instructions
VOLVO: BRAKE SHOE IS PROTRUDING BEYOND BRAKE DRUM AND CAN BE RESOLVED BY REPLACING AND INSTALLING 152 MM (6.0 IN) BRAKE SHOES, DUST SHIELDS, NEW 178 MM (7.0 IN) BRAKE DRUMS WITH NEW Z BRACKETS. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-005
Service Bulletin/Repair Instructions
VOLVO: SOME TRUCKS SHOW SIGNS OF BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM AND NEED REPLACING. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-006
Service Bulletin/Repair Instructions
VOLVO: THE MERITOR OR BENDIX BRAKE SHOES ARE SHOWING SIGNS OF BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM AND CAN BE RESOLVED BY REPLACING BRAKE SHOES (152 MM (6.0 IN) AND WIDE BRAKE DRUMS (178 MM (7.0 IN.)) MODEL 2011-2014 VN, VHD, VAH. *PE
FSB-511-007
Service Bulletin/Repair Instructions
VOLVO: TO RESOLVE CONDITION OF BRAKE SHOES, SHOWING SIGNS OF PROTRUSION OF BRAKE SHOE BEYOND BRAKE DRUM, BY INSTALLING NEW DUST SHIELDS, WIDE BRAKE DRUMS (178 MM) (7.0) AND BRAKE SHOES (152 MM) (6.0). MODEL 2011-2014 VAH, VHD, VN. *PE
FSB-511-008
Service Bulletin/Repair Instructions
VOLVO: REPLACEMENT OF BRAKE SHOES THAT SHOWS BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM. MODEL 2011-2014 VN, VHD, VAH. *PE
FSB 293-024
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
SP 293-027
Service Bulletin/Repair Instructions
Coolant Hose, EGR Cooler, Replacement
FSB 234-018
Service Bulletin/Repair Instructions
Single Fuel Tank Ventilation Filter Kit
FSB 234-019
Service Bulletin/Repair Instructions
Dual Fuel Tanks Ventilation Filter Kit
FSB 801-003
Service Bulletin/Repair Instructions
Service Door Rust Prevention
FSB 432-013
Service Bulletin/Repair Instructions
AMT High Range Cone Replacement
FSB-432-013
Service Bulletin/Repair Instructions
VOLVO TRUCK: PROCEDURAL INFORMATION REGARDING THE REPLACEMENT OF HIGH RANGE CONE IN THE SECTION OF THE AUTOMATED MANUAL TRANSMISSION (AMT). MODEL VN, VHD, VAH, VT. *PE UPDATED 8/8/14. *PE
FSB-593-012
Service Bulletin/Repair Instructions
VOLVO TRUCK: DUE TO INTERNAL BUILD UP CONTAMINATION OF GRIME, SALT, ROAD DEBRIS, IN HARSH ENVIRONMENTS, CAUSES SOLENOID VALVE TO MALFUNCTION AND TRAILER BRAKE CIRCUIT TO MAINTAIN TRAILER BRAKE PRESSURE AFTER HILL START ASSIST EVENT. MODEL VHD, VN, VT, VAH. *PE
FSB-371-046
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, AN IMPROPER TORQUE HAS ALLOWED CORROSION INHIBITOR BETWEEN RING TERMINALS OF MAIN GROUND STUD, LOCATED ON FRAME RAIL, CAUSING INTERMITTENT ISSUES AND DIAGNOSTIC TROUBLE CODES (DTC). MODEL 2010-2014 VAH, VHD, VN. *PE
FSB 375-010
Service Bulletin/Repair Instructions
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
FSB 375-011
Service Bulletin/Repair Instructions
Seat Harness Routing (Swivel) wires pulling away from clipping points
FSB-321-012
Service Bulletin/Repair Instructions
VOLVO TRUCK: DUE TO INCORRECTLY WIRING OF REMOTE SENSE (S TERMINAL) AND RELAY (R TERMINAL), THE ALTERNATOR WILL OVERCHARGE AND IN-LINE FUSE BATTERY BOX WITH REMOTE SENSE, MAY BLOW. MODEL VN. *PE
SP-396-001
Service Bulletin/Repair Instructions
VOLVO: INFORMATION PROCEDURE IS PROVIDED REGARDING THE REMOVAL OF INVERTER CASE GROUND WIRE TO DOMETIC 7 BATTERY AUXILIARY AC SYSTEM. MODEL 2012-2013 VN. *PE UPDATED 4/22/14. *PE
SP 284-049
Service Bulletin/Repair Instructions
Engine Control Module (ECM) Software Update
FSB 322-001
Service Bulletin/Repair Instructions
Charging System Voltage
FSB 322-002
Service Bulletin/Repair Instructions
Charging System Voltage (Cummins ISX)
FSB-221-011
Service Bulletin/Repair Instructions
VOLVO: LOW OIL PRESSURE, ON CERTAIN VEHICLES, DURING LONG HARD PULL CONDITIONS, DIAGNOSTIC TROUBLE CODES (DTCS) PID 100 FM1, SPN 100 FMI 1 OR P252400, CAN LOG ON, WITH OR WITHOUT ENGINE SHUT DOWN LAMP. MODEL VN, VT. NO YEARS LISTED. *PE
FSB-322-002
Service Bulletin/Repair Instructions
VOLVO: THE LOCATION OF FRONT LEFT BATTERY BOX, VOLTAGE DROP ON CHARGING CIRCUIT IS HIGHER THAN RECOMMENDED WHEN UTILIZING VOLTAGE DROP TEST WITH INTELLICHECK TESTER. MODEL 2010-2013 VN. *PE
FSB-51-001
Service Bulletin/Repair Instructions
VOLVO: THE AIR DISC BRAKE, ON SOME TRUCKS, MAY EXPERIENCE THERMAL OVERLOAD DUE TO AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION THAT MAINTAINS CLEARANCE RUNNING BETWEEN BRAKE PAD AND ROTOR. MODELS VAH, VHD, VN. NO YEARS LISTED. *PE
FSB-512-002
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, AIR DISC BRAKE MAY EXPERIENCE A CONDITION OF THERMAL OVERLOAD. THERMAL OVERLOAD REDUCES RUNNING CLEARANCE BETWEEN PAD AND ROTOR BELOW DESIRED LEVEL WHICH IS AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION. MODEL VAH, VHD, VN. NO YEARS LISTED. *PE
FSB 284-047
Service Bulletin/Repair Instructions
Oil Level Sensor Harness Wire Splice
FSB-284-047
Service Bulletin/Repair Instructions
VOLVO: ON SOME TRUCKS, THERE IS AN OIL CONTAMINATION INTO THE ENGINE WIRE HARNESS BECAUSE OF A FAILURE OF THE OIL LEVEL SENSOR. MODELS VAH, VHD, VN, VT. NO MODEL YEARS LISTED. *PE
FSB 284-044
Service Bulletin/Repair Instructions
Service Regeneration Failure
FSB-293-022
Service Bulletin/Repair Instructions
VOLVO TRUCK: ON SOME TRUCKS, DUE TO A POSSIBLE REPLACEMENT OF EGR TEMPERATURE SENSOR, A NEW CONFIGURATION ROUTING REQUIRES THREE DOUBLE LOOP CABLE TIES TO SECURE EGR TEMPERATURE SENSOR CONNECTOR DIRECTLY TO COOLANT PIPE. MODELS VAH, VHD, VN, D13H. NO MODEL YEARS. *PE
SP-431-021
Service Bulletin/Repair Instructions
VOLVO TRUCK: ON SOME TRUCKS, DUE TO LOSS OF CALIBRATION AND ABILITY TO ENABLE SINGLE PTO FUNCTIONALITY, SOFTWARE UPDATES ARE AVAILABLE TO ENHANCE TRANSMISSION ELECTRONIC CONTROL UNIT (TECU). MODELS OBD2013, D11H, D13H, D16H, VHD, VN. MODEL YEARS NOT LISTED. *PE
FSB 371-045
Service Bulletin/Repair Instructions
Battery Cable Lug, Failure
SP 431-021
Service Bulletin/Repair Instructions
Transmission ECU Programming
SP2 284-036
Service Bulletin/Repair Instructions
Software Update, revise document
SP-284-036-01
Service Bulletin/Repair Instructions
VOLVO: SOFTWARE UPDATE. ENHANCEMENTS ON THE SOFTWARE UPDATE FOR THE ENGINE CONTROL MODULE (ECM), INSTRUMENT CLUSTER (IC), VEHICLE ELECTRONIC CONTROL UNIT (VECU), AFTERTREATMENT CONTROL MODULE (ACM), AND TRANSMISSION ELECTRONIC CONTROL UNIT (TECU). *KB
SP-593-011
Service Bulletin/Repair Instructions
VOLVO: ABS ECU REPROGRAMMING. ABS MODULE CONTAINS AN INCORRECT SETTING. *JS
FSB 371-042
Service Bulletin/Repair Instructions
Jumper Harness, Repair
FSB 371-044
Service Bulletin/Repair Instructions
Battery Cable Mounting Clamps
FSB-371-044
Service Bulletin/Repair Instructions
VOLVO TRUCK: INFORMATION PROVIDED REGARDING THE BATTERY CABLE MOUNTING CLAMPS, THAT MIGHT BREAK OR CRACK, DUE TO TORQUE ISSUE AND MATERIAL. MODELS 2010-2012 VN, VHD, VT, VAH. *PE
FSB-284-039
Service Bulletin/Repair Instructions
VOLVO: INFORMATION REGARDING REPROGRAMMING OF ENGINE ECM WITH THE NEW SOFTWARE. MODELS VN, VHD, VAH, D13H EPA2010. NO MODEL YEARS LISTED. *PE
FSB 293-016
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
FSB 381-047
Service Bulletin/Repair Instructions
Instrument Cluster Reprogramming
SP 722-001
Service Bulletin/Repair Instructions
Upper Torque Arm, Air Disc Brake, Replacement
FSB-891-016
Service Bulletin/Repair Instructions
VOLVO TRUCK: SUN VISORS ARE CRACKING AT TWO CENTER MOUNTS AND WILL BE REPLACED WITH NEW BRACKET THAT WAS DEVELOPED, TO PREVENT CRACKING. MODELS VN. NO MODEL YEARS LISTED. *PE
SP-722-001
Service Bulletin/Repair Instructions
VOLVO TRUCKS: INFORMATION PROVIDED ON THE INSTALLATION OF SPACERS BETWEEN THE LONGITUDINAL TORQUE RODS AND THE FRAME HANGER BRACKETS, AND ENSURE SPACERS ARE ALIGNED CORRECTLY AS TO NOT CAUSE PINION ANGLES. MODELS 2010-2012 VN. *PE
FSB 284-038
Service Bulletin/Repair Instructions
Engine Coolant Thermostat Software Update
FSB 811-005
Service Bulletin/Repair Instructions
Floor Cracks Repair (Front Panel)
FSB 811-006
Service Bulletin/Repair Instructions
Floor Cracks Repair (Rear Panel)
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.