CBR-2214 202404
Service Bulletin/Repair Instructions
CBR: Turbo Compound 2nd Generation - EGR And / Or DPF Diagnostic Trouble Codes (DTC), Diagnostic And Repair Information.
Vehicle report
2020 VOLVO VNL
Service bulletins
152 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CBR-2013 202404
Service Bulletin/Repair Instructions
CBR: Turbo Compound (TC) Hot Side Noise, Diagnostic Information.
CBR-2139 202403
Service Bulletin/Repair Instructions
CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
CBR-408 202403
Service Bulletin/Repair Instructions
CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
KC-2014
Service Bulletin/Repair Instructions
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
S3875 202401
Service Bulletin/Repair Instructions
Fleet Improvement Campaign: (ABS) Software Update and Brake Inspection
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
S2962 202312
Service Bulletin/Repair Instructions
Service Campaign: Volvo trucks has determined that certain VN model trucks built with an D13 Turbo Compound engine that have had a reman TC unit installed could experience a failure with the reman TC unit.
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
S3672 202311
Service Bulletin/Repair Instructions
Service Campaign: For certain Volvo Trucks configurations an updated adaptive cruise software has been developed. The new software will be delivered as an updated PAR file to the ABS Module and will help reduce heat load on steer axleâÂÂs brake assemblies during an adaptive cruise control braking event. Follow the instructions below to visually inspect the brake rotors on the steer axle for excessive heat damage and update the ABS software.
PSM23vna73
Service Bulletin/Repair Instructions
Parts Sales and Marketing Bulletin: Volvo Trucks is excited to announce an additional year warranty program on Volvo Reman AMT I-Shift Complete Transmissions. This extended warranty of 3 years or 350,000 miles on the transmission will be applicable when dealer installed, required parts are installed and is registered via eService.
CBR-399 202310
Service Bulletin/Repair Instructions
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
CBR-206 202310
Service Bulletin/Repair Instructions
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
U114 202309
Service Bulletin/Repair Instructions
Owner Notification Letter, Extended Warranty Coverage U114. The EGR Cooler is the component provided coverage under this warranty extension.
CBR-2297 202309
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
V-258-001 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
V-258-002 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2305 202308
Service Bulletin/Repair Instructions
CBR: Valve Stem Extension Contacting Outer Wheel
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR-2297 202307
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
V-821-002 202307
Service Bulletin/Repair Instructions
TSB: Hood Cable Breaking or Binding
CBR-2298 202307
Service Bulletin/Repair Instructions
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
KC-399
Service Bulletin/Repair Instructions
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
KC-2195
Service Bulletin/Repair Instructions
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â October 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-183
Service Bulletin/Repair Instructions
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
V-363-001
Service Bulletin/Repair Instructions
TSB Washer Reservoir Leak
KC-401
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
V-265-002
Service Bulletin/Repair Instructions
TSB-Charge Air Cooler t-clamp install.
SMB00-108C
Service Bulletin/Repair Instructions
Expendable Items Parts List.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-561
Service Bulletin/Repair Instructions
11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
KC-750
Service Bulletin/Repair Instructions
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
KC-751
Service Bulletin/Repair Instructions
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
KC-2112
Service Bulletin/Repair Instructions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
Service Bulletin/Repair Instructions
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
Service Bulletin/Repair Instructions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Service Bulletin/Repair Instructions
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
Service Bulletin/Repair Instructions
AMT Control Housing Bench Testing - False Failures
KC-13
Service Bulletin/Repair Instructions
Volvo Chassis - Air Leak At Wet Tank - Model VNL
KC-2174
Service Bulletin/Repair Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Service Bulletin/Repair Instructions
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Service Bulletin/Repair Instructions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer
KC-735
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
KC-736
Service Bulletin/Repair Instructions
(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) - US17 And Newer Emissions (Common Rail Fuel System)
KC-2107
Service Bulletin/Repair Instructions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
Service Bulletin/Repair Instructions
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2149
Service Bulletin/Repair Instructions
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-2157
Service Bulletin/Repair Instructions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
Service Bulletin/Repair Instructions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Service Bulletin/Repair Instructions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Service Bulletin/Repair Instructions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-2158
Service Bulletin/Repair Instructions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-695
Service Bulletin/Repair Instructions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-662
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
KC-664
Service Bulletin/Repair Instructions
Volvo Chassis - Volvo ( Bergstrom )Parking Cooler System, Technical Information And Diagnostic Guide - Model Year 2018 And Newer
KC-639
Service Bulletin/Repair Instructions
Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
KC-640
Service Bulletin/Repair Instructions
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
KC-642
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
KC-647
Service Bulletin/Repair Instructions
Volvo Chassis Ghost Codes Due To Poor Grounding
KC-649
Service Bulletin/Repair Instructions
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
KC-650
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
KC-660
Service Bulletin/Repair Instructions
Volvo Chassis - PTO Pump Speed Calculator
KC-635
Service Bulletin/Repair Instructions
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
KC-636
Service Bulletin/Repair Instructions
Volvo Fault Code MID 144 PSID 204 FMI 9
SNV22-003
Service Bulletin/Repair Instructions
The Diagnostic Process
KC-631
Service Bulletin/Repair Instructions
B/O Volvo Park Brake warning POPup displays in DID when Park Brake is released and driver door is open Model Year 2018 and Newer
KC-623
Service Bulletin/Repair Instructions
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-609
Service Bulletin/Repair Instructions
Volvo Chassis - Accessory / Auxiliary Connection Points ( Power/Ground Points ) - VNL, VNR, VNX, VAH, VHD - Model Year 2018 And Newer
KC-66
Service Bulletin/Repair Instructions
Volvo Chassis - LED Headlights Conversion Programming Procedure - Model VNL
KC-784
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
KC-816
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis - VN Model - Front Brake Squeal - US14 And Newer
S7617
Service Bulletin/Repair Instructions
Forward Looking Radar Shortage - Plug Inspection
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
Service Manager
Service Bulletin/Repair Instructions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-478
Service Bulletin/Repair Instructions
Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
KC-408
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix Lane Departure Warning System ( LDWS ) Audible Alarm Does Not Deactivate When The Turn Signal Is Switched On - US16; Model Year ( MY ) 2017
KC-415
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate Warning - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
KC-422
Service Bulletin/Repair Instructions
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
KC-423
Service Bulletin/Repair Instructions
Volvo Chassis US13 And Up Pre-trip Assistant Enable
KC-391
Service Bulletin/Repair Instructions
Noise On The AM Radio Band; Thumping, Ticking, Fluttering Sound On AM Radio Band - Model Year 2018 And Newer
KC-392
Service Bulletin/Repair Instructions
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-379
Service Bulletin/Repair Instructions
Engine Brake - Diagnostic Trouble Code (DTC) P1021-11 Volvo Compression Brake (VCB) Control Circuit Short To Ground - US17+OBD16 Through US17+OBD19 Emissions, Model Years 2018 To 2020
KC-325
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And Newer Emissions, Common Year Models 2015 And Newer
KC-304
Service Bulletin/Repair Instructions
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Service Bulletin/Repair Instructions
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-284
Service Bulletin/Repair Instructions
Volvo Chassis - Models VNR, VNX, VNL, VNM, VAH - Headlamp Aiming Instructions; Headlight Alignment Inspection And Adjustment Information - Model Year 2018 And Newer
KC-226
Service Bulletin/Repair Instructions
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-216
Service Bulletin/Repair Instructions
Front Accessory Drive noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - MY 2017 And Newer
KC-167
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error 43 Displayed - US10+OBD13 And Newer Emissions, Common Model Year 2014 And Newer
KC-159
Service Bulletin/Repair Instructions
Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
KC-161
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With A Cummins Engine - Cummins Fuel Pump Timing Correction to Reduce Engine Noise; Drone Noise at 1500 RPM and Increases With Engine Load - US10 And Newer Emissions, Common Model Year 2014 And Newer
KC-163
Service Bulletin/Repair Instructions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-277
Service Bulletin/Repair Instructions
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVER
KC-122
Service Bulletin/Repair Instructions
Volvo Chassis - SNV19 - 019 - VNL/VNR Cab And Front Chassis Harnesses
KC-124
Service Bulletin/Repair Instructions
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-114
Service Bulletin/Repair Instructions
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC, Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
KC-102
Service Bulletin/Repair Instructions
Volvo Chassis - Performance Bonus OBD13 And Newer
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
KC-328
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes (DTC) P208064, P208464, P242B64 and P246F64 Lighting The Malfunction Indicator Lamp (MIL) - US17+OBD19 And Newer Emissions, Model Years 2020 and Newer
KC-2139
Service Bulletin/Repair Instructions
11 Liter Engines - Fuel In Oil - Vehicles Built Between October 2020 And June 2021
KC-271
Service Bulletin/Repair Instructions
Intermittent Occurrences Of Very Brief Loss Of Power, Engine Stumble Or Hiccup Lasting Much Less Than A Second, Most Frequently Between 1500 And 1700 RPM, No Diagnostic Trouble Codes (DTC ) Generated - All Common Rail Fuel System Chassis
KC-2086
Service Bulletin/Repair Instructions
Volvo Chassis - Model VN - Updated Chassis Fairing DEF Door Magnet/Plate
KC-419
Service Bulletin/Repair Instructions
Volvo Chassis - Cab Roof Leaks, Water Intrusion At Roof Joints; Repair Instructions And Information; Supplement To FSB 812-002, Cab Roof Leak Repair - VN Models 740 And 760 ONLY, Model Year 2018 And Newe
FSB 561-029
Service Bulletin/Repair Instructions
Air Dryer Mounting Bracket, Installation
RVXX2101
Service Bulletin/Repair Instructions
Canada Non- Compliance recall for DRL override dealer alert
KC-2051
Service Bulletin/Repair Instructions
Volvo Chassis - Air Conditioning (A/C) Performance Chart - Trucks Built After January 2019
SNV21-001
Service Bulletin/Repair Instructions
Improved method for determining which DTC to troubleshoot in a MIL on situation
KC-723
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P0016-76 - Crankshaft Position - Camshaft Position Correlation - Turbo Compound ( TC ) - Model Year 2018 and Newer
KC-2018
Service Bulletin/Repair Instructions
Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
K53338075
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
K18013154
Service Bulletin/Repair Instructions
Vehicles Equipped With A One-Box Emissions Aftertreatment System ( EATS ) - Diagnostic Trouble Codes ( DTC ) P2463 and P2453. US17+OBD16 (GHG17) And Newer Emissions, Common Model Year 2018 And Newer
K01157283
Service Bulletin/Repair Instructions
Front Accessory Drive Noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - Model Year 2017 And Newer
K52236323
Service Bulletin/Repair Instructions
Volvo Chassis - VNL ONLY With Air Tank Part Number 22945941 - Air Leak At The Wet (Auxiliary) Tank - Build Date 11 March 2019 And Newer
K55899505
Service Bulletin/Repair Instructions
Volvo Chassis - With 2018 New Style Instrument Cluster - Radio Mutes When In Reverse - Model Years 2018 And Newer
K41105570
Service Bulletin/Repair Instructions
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
K44250068
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
K60000804
Service Bulletin/Repair Instructions
Volvo Chassis - VNL Models - Built With Electronic Climate Control ( ECC ) - HVAC: Fading Heat From The Vents, Blower Motor Working Not Properly - Model Year 2018 and Newer
K42065042
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
K40914241
Service Bulletin/Repair Instructions
Common Rail Fuel System Faults - Diagnostic Trouble Codes (DTC) P0094, P228F, P016F, P0087,P00C6, P0257, P2A17, P2A1F, P008A; Repair Information - US17+OBD16, US17+OBD18, and US17+OBD19 Emissions, Model Years 2018 To 2020
K29295744
Service Bulletin/Repair Instructions
Updated PM Sensor Removal Procedure - US17+OBD16 and Newer Emissions
K58203603
Service Bulletin/Repair Instructions
Diagnostic Trouble Code (DTC) P20EE - SCR NOx Catalyst Efficiency Below Threshold (Bank 1) - US17+OBD2019 Emissions, Model Year 2020 ONLY
K21533201
Service Bulletin/Repair Instructions
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
K20878118
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P205B-64 - Reductant Tank Temperature Sensor Circuit Range/Performance - Model Year 2018 and Newer
K68033394
Service Bulletin/Repair Instructions
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
K05144150
Service Bulletin/Repair Instructions
Volvo Chassis - PTO Switch Installation For Vehicles With Updated Interior - Model Year 2018 And Newer
K17408563
Service Bulletin/Repair Instructions
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
K23033111
Service Bulletin/Repair Instructions
Volvo Chassis - Cab Roof Leaks, Water Intrusion At Roof Joints; Repair Instructions And Information; Supplement To FSB 812-002, Cab Roof Leak Repair - VN Models 740 And 760 ONLY, Model Year 2018 And Newer
K15812145
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
K64554358
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared; Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014 And Newer
K47838695
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P2080-64, P2084-64, P242B-64 and P246F-64 Lighting The Malfunction Indicator Lamp ( MIL ) - US17+OBD19 And Newer Emissions, Model Years 2020 and Newer
K39135131
Service Bulletin/Repair Instructions
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
K05913580
Service Bulletin/Repair Instructions
13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In Between The Coolant Pump Housing And Oil Cooler Housing - Model Years 2019 And 2020
K29581430
Service Bulletin/Repair Instructions
Volvo Chassis - Volvo Parking Cooler System, Technical Information And Diagnostic Guide - Model Year 2018 And Newer
K47547856
Service Bulletin/Repair Instructions
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
K37146742
Service Bulletin/Repair Instructions
US07 / US10 D13 Turbocharger Gasket
K93394430
Service Bulletin/Repair Instructions
Engine Brake - Diagnostic Trouble Code (DTC) P1021-11 Volvo Compression Brake (VCB) Control Circuit Short To Ground - US17+OBD16 Through US17+OBD19 Emissions, Model Years 2018 To 2020
K23023545
Service Bulletin/Repair Instructions
Wabco System Saver? HP High Performance Air Dryer - US17 +OBD2019 Emissions, Model Year 2020
K62132009
Service Bulletin/Repair Instructions
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
K11907301
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
K86900043
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B, P1121 - Temperature Sensor Inspection
K85318413
Service Bulletin/Repair Instructions
Noise On The AM Radio Band; Poor Or No Reception On AM Radio - Model Year 2018 And Newer
K51800139
Service Bulletin/Repair Instructions
Volvo Chassis - Windshield Wiper Function Inoperative In Intermittent Mode ONLY; Wiper Intermittent Setting Not Working - Model Year 2018 to 2020
K22004549
Service Bulletin/Repair Instructions
Volvo Chassis - Fixed Center Chassis Fairing Bracket Fatigue, Cracking, Breaking - Model Year 2018 And Newer
K91214678
Service Bulletin/Repair Instructions
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5 Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.