KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
Vehicle report
2011 VOLVO VNM
Service bulletins
90 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-776
Service Bulletin/Repair Instructions
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
KC-183
Service Bulletin/Repair Instructions
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
V-265-002
Service Bulletin/Repair Instructions
TSB-Charge Air Cooler t-clamp install.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-750
Service Bulletin/Repair Instructions
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
KC-751
Service Bulletin/Repair Instructions
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
KC-2112
Service Bulletin/Repair Instructions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
Service Bulletin/Repair Instructions
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
Service Bulletin/Repair Instructions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Service Bulletin/Repair Instructions
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
Service Bulletin/Repair Instructions
AMT Control Housing Bench Testing - False Failures
KC-2174
Service Bulletin/Repair Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Service Bulletin/Repair Instructions
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Service Bulletin/Repair Instructions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer
KC-735
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
KC-2107
Service Bulletin/Repair Instructions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
Service Bulletin/Repair Instructions
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
Service Bulletin/Repair Instructions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Service Bulletin/Repair Instructions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Service Bulletin/Repair Instructions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-2149
Service Bulletin/Repair Instructions
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-695
Service Bulletin/Repair Instructions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-687
Service Bulletin/Repair Instructions
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
KC-675
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration ( Regen ) Failure Diagnostic Process - US07 to US16 Emissions
KC-639
Service Bulletin/Repair Instructions
Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
KC-640
Service Bulletin/Repair Instructions
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
KC-642
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
KC-647
Service Bulletin/Repair Instructions
Volvo Chassis Ghost Codes Due To Poor Grounding
KC-649
Service Bulletin/Repair Instructions
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
KC-650
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
KC-660
Service Bulletin/Repair Instructions
Volvo Chassis - PTO Pump Speed Calculator
KC-635
Service Bulletin/Repair Instructions
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
KC-636
Service Bulletin/Repair Instructions
Volvo Fault Code MID 144 PSID 204 FMI 9
SNV22-003
Service Bulletin/Repair Instructions
The Diagnostic Process
KC-623
Service Bulletin/Repair Instructions
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-784
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
KC-705
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
KC-793
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical Service Bulletin V-216-001 Twin Mass Flywheel Conversion
SLV22-002
Service Bulletin/Repair Instructions
Volvo Monthly Bulletin Release Letter - Feb 2022
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
Service Manager
Service Bulletin/Repair Instructions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-418
Service Bulletin/Repair Instructions
Volvo Chassis - Air Brake System Schematics And Routing VN, VHD Version 2, VT From Build Date 11.2011
KC-392
Service Bulletin/Repair Instructions
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-378
Service Bulletin/Repair Instructions
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
KC-358
Service Bulletin/Repair Instructions
Volvo Chassis - US10 to US16 Emissions - Soot Level Will Not Reset After Regen Or Locked At 140%
KC-304
Service Bulletin/Repair Instructions
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Service Bulletin/Repair Instructions
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-226
Service Bulletin/Repair Instructions
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-163
Service Bulletin/Repair Instructions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-124
Service Bulletin/Repair Instructions
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
KC-521
Service Bulletin/Repair Instructions
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And Programming Information - Model Year 2008 Through 2017
K41105570
Service Bulletin/Repair Instructions
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
K44250068
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
K21533201
Service Bulletin/Repair Instructions
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
K15812145
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
K37146742
Service Bulletin/Repair Instructions
US07 / US10 D13 Turbocharger Gasket
K62132009
Service Bulletin/Repair Instructions
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
K11907301
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
K86900043
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B, P1121 - Temperature Sensor Inspection
K91214678
Service Bulletin/Repair Instructions
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5 Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
K51303113
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative, No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Commonly Model Years 2011 To 2014
K14701433
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 ) Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
K24483157
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16 Emissions And Newer Rewrote test procedure for better clarity.
K24400052
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
K97651904
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
K52326370
Service Bulletin/Repair Instructions
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 ( Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
K14637412
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 ( GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
K82320750
Service Bulletin/Repair Instructions
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The Key On And Engine OffChanged repair information to reflect new software available.
K03179378
Service Bulletin/Repair Instructions
Service Only Regen Requested With No Warning. Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
K15164821
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect release of FSB284-064 (Above)
K27690302
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
K86412082
Service Bulletin/Repair Instructions
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 (Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
K42708399
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis (Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
K84412328
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16, Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
FSB711-009
Service Bulletin/Repair Instructions
Some Volvo VNM, VNL and VAH trucks built between 02/23/2009 and 07/14/2017 with steel bogie cross members may develop cracks depending on application or duty cycle.
TJ-25329
Service Bulletin/Repair Instructions
VOLVO: ON SOME VEHICLES, THE STEERING KNUCKLE WOULD HAVE WHEEL HUB DISPLACED AND WOULD TO REPLACE WHEEL HUB. *PE
FSB 293-024
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
FSB-322-002
Service Bulletin/Repair Instructions
VOLVO: THE LOCATION OF FRONT LEFT BATTERY BOX, VOLTAGE DROP ON CHARGING CIRCUIT IS HIGHER THAN RECOMMENDED WHEN UTILIZING VOLTAGE DROP TEST WITH INTELLICHECK TESTER. MODEL 2010-2013 VN. *PE
FSB-258-029
Service Bulletin/Repair Instructions
VOLVO TRUCK: ON CERTAIN VEHICLES, THE ENGINE CONTROL MODULE (ECM) AND THE BYPASS VALVE IS DEACTIVATED DUE TO REPROGRAMMING OF SOFTWARE UPDATES. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.