KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
Vehicle report
2012 VOLVO VNM
Service bulletins
90 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-776
Service Bulletin/Repair Instructions
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
KC-183
Service Bulletin/Repair Instructions
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
V-265-002
Service Bulletin/Repair Instructions
TSB-Charge Air Cooler t-clamp install.
SMB00-108C
Service Bulletin/Repair Instructions
Expendable Items Parts List.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-750
Service Bulletin/Repair Instructions
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
KC-751
Service Bulletin/Repair Instructions
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
KC-2112
Service Bulletin/Repair Instructions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
Service Bulletin/Repair Instructions
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
Service Bulletin/Repair Instructions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Service Bulletin/Repair Instructions
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
Service Bulletin/Repair Instructions
AMT Control Housing Bench Testing - False Failures
KC-2174
Service Bulletin/Repair Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Service Bulletin/Repair Instructions
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Service Bulletin/Repair Instructions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer
KC-735
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
KC-2107
Service Bulletin/Repair Instructions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
Service Bulletin/Repair Instructions
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
Service Bulletin/Repair Instructions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Service Bulletin/Repair Instructions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Service Bulletin/Repair Instructions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-2149
Service Bulletin/Repair Instructions
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-695
Service Bulletin/Repair Instructions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-687
Service Bulletin/Repair Instructions
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
KC-675
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration ( Regen ) Failure Diagnostic Process - US07 to US16 Emissions
KC-639
Service Bulletin/Repair Instructions
Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
KC-640
Service Bulletin/Repair Instructions
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
KC-642
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
KC-647
Service Bulletin/Repair Instructions
Volvo Chassis Ghost Codes Due To Poor Grounding
KC-649
Service Bulletin/Repair Instructions
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
KC-650
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
KC-660
Service Bulletin/Repair Instructions
Volvo Chassis - PTO Pump Speed Calculator
KC-635
Service Bulletin/Repair Instructions
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
KC-636
Service Bulletin/Repair Instructions
Volvo Fault Code MID 144 PSID 204 FMI 9
SNV22-003
Service Bulletin/Repair Instructions
The Diagnostic Process
KC-623
Service Bulletin/Repair Instructions
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-784
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
KC-705
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
KC-793
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical Service Bulletin V-216-001 Twin Mass Flywheel Conversion
SLV22-002
Service Bulletin/Repair Instructions
Volvo Monthly Bulletin Release Letter - Feb 2022
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
Service Manager
Service Bulletin/Repair Instructions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-418
Service Bulletin/Repair Instructions
Volvo Chassis - Air Brake System Schematics And Routing VN, VHD Version 2, VT From Build Date 11.2011
KC-392
Service Bulletin/Repair Instructions
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-358
Service Bulletin/Repair Instructions
Volvo Chassis - US10 to US16 Emissions - Soot Level Will Not Reset After Regen Or Locked At 140%
KC-304
Service Bulletin/Repair Instructions
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Service Bulletin/Repair Instructions
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-226
Service Bulletin/Repair Instructions
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-163
Service Bulletin/Repair Instructions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-124
Service Bulletin/Repair Instructions
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
KC-521
Service Bulletin/Repair Instructions
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And Programming Information - Model Year 2008 Through 2017
K41105570
Service Bulletin/Repair Instructions
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
K44250068
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
K21533201
Service Bulletin/Repair Instructions
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve Deletion Kit , Installation
K15812145
Service Bulletin/Repair Instructions
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
K37146742
Service Bulletin/Repair Instructions
US07 / US10 D13 Turbocharger Gasket
K62132009
Service Bulletin/Repair Instructions
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
K11907301
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
K86900043
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B, P1121 - Temperature Sensor Inspection
K91214678
Service Bulletin/Repair Instructions
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5 Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
K51303113
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative, No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Commonly Model Years 2011 To 2014
K14701433
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 ) Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
K24483157
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16 Emissions And Newer Rewrote test procedure for better clarity.
K24400052
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
K97651904
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
K52326370
Service Bulletin/Repair Instructions
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 ( Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
K14637412
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 ( GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
K82320750
Service Bulletin/Repair Instructions
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The Key On And Engine OffChanged repair information to reflect new software available.
K03179378
Service Bulletin/Repair Instructions
Service Only Regen Requested With No Warning. Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
K15164821
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect release of FSB284-064 (Above)
K27690302
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
K86412082
Service Bulletin/Repair Instructions
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 (Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
K42708399
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis (Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
K84412328
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16, Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
FSB711-009
Service Bulletin/Repair Instructions
Some Volvo VNM, VNL and VAH trucks built between 02/23/2009 and 07/14/2017 with steel bogie cross members may develop cracks depending on application or duty cycle.
TJ-25329
Service Bulletin/Repair Instructions
VOLVO: ON SOME VEHICLES, THE STEERING KNUCKLE WOULD HAVE WHEEL HUB DISPLACED AND WOULD TO REPLACE WHEEL HUB. *PE
FSB 293-024
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
FSB-322-002
Service Bulletin/Repair Instructions
VOLVO: THE LOCATION OF FRONT LEFT BATTERY BOX, VOLTAGE DROP ON CHARGING CIRCUIT IS HIGHER THAN RECOMMENDED WHEN UTILIZING VOLTAGE DROP TEST WITH INTELLICHECK TESTER. MODEL 2010-2013 VN. *PE
EER-RVXX1105
Service Bulletin/Repair Instructions
VOLVO: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON SOME VEHICLES THE D13F ENGINE, THE ENGINE EXHAUST GAS RECIRCULATION (EGR) WILL EXPERIENCE LEAKAGE BETWEEN EXHAUST GAS AND COOLANT PATS INSIDE COOLER. EMISSIONS NOT IMPACTING COOLER ISSUE. MODELS VAH, VHD, VNL AND VNM. NO MODEL YEARS LISTED. *PE
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.