CBR-408 202403
Service Bulletin/Repair Instructions
CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once the turn signals were activated.
Vehicle report
2017 VOLVO VNR
Service bulletins
109 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
KC-2350
Service Bulletin/Repair Instructions
CBR - Telematics Gateway (TGW) Connect Ability Issues.
KC-2014
Service Bulletin/Repair Instructions
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
KC-202
Service Bulletin/Repair Instructions
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
KC-2347
Service Bulletin/Repair Instructions
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR-2333 202401
Service Bulletin/Repair Instructions
CBR: TGW Will Not Connect After SIM Card Replacement
CBR-2320 202312
Service Bulletin/Repair Instructions
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
EC0028V 202312
Service Bulletin/Repair Instructions
Emissions Campaign: Volvo has determined that certain 2014 -2018 model year VN, VHD, and VAH Vehicles require a replacement Diesel Particulate Filter (DPF) along with updated software.
S3672 202311
Service Bulletin/Repair Instructions
Service Campaign: For certain Volvo Trucks configurations an updated adaptive cruise software has been developed. The new software will be delivered as an updated PAR file to the ABS Module and will help reduce heat load on steer axleâÂÂs brake assemblies during an adaptive cruise control braking event. Follow the instructions below to visually inspect the brake rotors on the steer axle for excessive heat damage and update the ABS software.
CBR-206 202310
Service Bulletin/Repair Instructions
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
U111 202309
Service Bulletin/Repair Instructions
Owner Notification Letter, Extended Warranty Coverage U111. The Fuel Control Module is the component provided coverage under this warranty extension.
U112 202309
Service Bulletin/Repair Instructions
Owner Notification Letter, Extended Warranty Coverage U112. The Pre-SCR NOx Sensor is the component provided coverage under this warranty extension.
U113 202309
Service Bulletin/Repair Instructions
Owner Notification Letter, Extended Warranty Coverage U113. The Pre-SCR NOx Sensor is the component provided coverage under this warranty extension.
CBR-570 202309
Service Bulletin/Repair Instructions
CBR: Model Year 2017, 2018 - US17GHG Common Rail Fuel System Component Electrical Faults
CBR-2297 202309
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
V-258-001 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
V-258-002 202309
Service Bulletin/Repair Instructions
TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR-2120 202308
Service Bulletin/Repair Instructions
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off
V728-005A 202308
Service Bulletin/Repair Instructions
TSB: Barksdale Leveling Valve, Leak Test
CBR-2112 202307
Service Bulletin/Repair Instructions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR-2297 202307
Service Bulletin/Repair Instructions
CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
CBR-2298 202307
Service Bulletin/Repair Instructions
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
KC-331
Service Bulletin/Repair Instructions
Model Year 2017, 2018 - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
KC-776
Service Bulletin/Repair Instructions
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening
KC-2195
Service Bulletin/Repair Instructions
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â October 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-399
Service Bulletin/Repair Instructions
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
KC-183
Service Bulletin/Repair Instructions
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer
KC-401
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
V-265-002
Service Bulletin/Repair Instructions
TSB-Charge Air Cooler t-clamp install.
SMB00-108C
Service Bulletin/Repair Instructions
Expendable Items Parts List.
CBR-2201
Service Bulletin/Repair Instructions
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Service Bulletin/Repair Instructions
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
KC-561
Service Bulletin/Repair Instructions
11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
KC-750
Service Bulletin/Repair Instructions
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
KC-751
Service Bulletin/Repair Instructions
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
KC-2112
Service Bulletin/Repair Instructions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2119
Service Bulletin/Repair Instructions
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
KC-2143
Service Bulletin/Repair Instructions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
KC-405
Service Bulletin/Repair Instructions
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
KC-2028
Service Bulletin/Repair Instructions
AMT Control Housing Bench Testing - False Failures
KC-2174
Service Bulletin/Repair Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
KC-435
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion
KC-732
Service Bulletin/Repair Instructions
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party Electronic Log Device Not Reporting Certain Data
KC-734
Service Bulletin/Repair Instructions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions, Model Year 2008 And Newer
KC-735
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
KC-736
Service Bulletin/Repair Instructions
(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) - US17 And Newer Emissions (Common Rail Fuel System)
KC-2107
Service Bulletin/Repair Instructions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
KC-2116
Service Bulletin/Repair Instructions
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2149
Service Bulletin/Repair Instructions
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
KC-2157
Service Bulletin/Repair Instructions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
Service Bulletin/Repair Instructions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
Service Bulletin/Repair Instructions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-726
Service Bulletin/Repair Instructions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
KC-2158
Service Bulletin/Repair Instructions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-695
Service Bulletin/Repair Instructions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
KC-687
Service Bulletin/Repair Instructions
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
KC-662
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
KC-639
Service Bulletin/Repair Instructions
Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
KC-640
Service Bulletin/Repair Instructions
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
KC-642
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
KC-647
Service Bulletin/Repair Instructions
Volvo Chassis Ghost Codes Due To Poor Grounding
KC-649
Service Bulletin/Repair Instructions
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
KC-650
Service Bulletin/Repair Instructions
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
KC-660
Service Bulletin/Repair Instructions
Volvo Chassis - PTO Pump Speed Calculator
KC-635
Service Bulletin/Repair Instructions
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
KC-636
Service Bulletin/Repair Instructions
Volvo Fault Code MID 144 PSID 204 FMI 9
SNV22-003
Service Bulletin/Repair Instructions
The Diagnostic Process
KC-623
Service Bulletin/Repair Instructions
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
KC-634
Service Bulletin/Repair Instructions
Model Year 2017, 2018 - US17 Emission Engines - The ( Donaldson ) Fuel Filter - Part Number P550529 - " Cannot " Be Used
KC-743
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD15, US14+OBD16 (Common Model Years 2016 And 2017), US17+OBD16 And Newer ( Common Rail Fuel System, Model Year 2018)
KC-778
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P02FA US17+OBD16 And US17+OBD18 (GHG17) Emissions
KC-784
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
KC-123
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD15 And US14+OBD16 Emissions, Common Model Years 2016 And 2017
KC-547
Service Bulletin/Repair Instructions
Volvo Chassis - Technical Service Bulletin V-284 - 069, Exhaust Particulate Sensor, Repair
KC-816
Service Bulletin/Repair Instructions
(Back Office Only) Volvo Chassis - VN Model - Front Brake Squeal - US14 And Newer
SLV22-002
Service Bulletin/Repair Instructions
Volvo Monthly Bulletin Release Letter - Feb 2022
S7617
Service Bulletin/Repair Instructions
Forward Looking Radar Shortage - Plug Inspection
356EN01
Service Bulletin/Repair Instructions
VIDA QR Scanner Mobile App
Service Manager
Service Bulletin/Repair Instructions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
KC-478
Service Bulletin/Repair Instructions
Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
KC-450
Service Bulletin/Repair Instructions
Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure - REPLACES GUIDED DIAGNOSTICS IN PREMIUM TECH TOOL ( PTT ) - US10+OBD2013 to US14+OBD2016 (Non-Common Rail) Emissions, Commonly Model Years 2014 To 2017
KC-408
Service Bulletin/Repair Instructions
Volvo Chassis - Bendix Lane Departure Warning System ( LDWS ) Audible Alarm Does Not Deactivate When The Turn Signal Is Switched On - US16; Model Year ( MY ) 2017
KC-415
Service Bulletin/Repair Instructions
Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate Warning - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
KC-422
Service Bulletin/Repair Instructions
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
KC-423
Service Bulletin/Repair Instructions
Volvo Chassis US13 And Up Pre-trip Assistant Enable
KC-392
Service Bulletin/Repair Instructions
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle Measurement - Model Year 1996 And Newer
KC-398
Service Bulletin/Repair Instructions
Chassis Equipped With An AMT-F (I-Shift, mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At Low Speed; Information And Repair - Build Date Beginning Of Production 2017 To February 2018
KC-325
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And Newer Emissions, Common Year Models 2015 And Newer
KC-304
Service Bulletin/Repair Instructions
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007 And Newer Model Years
KC-305
Service Bulletin/Repair Instructions
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model Year 2008 And Newer
KC-226
Service Bulletin/Repair Instructions
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
KC-216
Service Bulletin/Repair Instructions
Front Accessory Drive noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - MY 2017 And Newer
KC-72
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With An Automated Manual Transmission (I- Shift, AMT) AMT-C, AMT-D Or AMT-F - Transmission Oil Specifications - Model Years 2010 To 2020
KC-167
Service Bulletin/Repair Instructions
Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error 43 Displayed - US10+OBD13 And Newer Emissions, Common Model Year 2014 And Newer
KC-316
Service Bulletin/Repair Instructions
Dynamometer Testing On 2016-17 Volvo Chassis
KC-998
Service Bulletin/Repair Instructions
Diagnostic Trouble Code (DTC) U3017 - OBD2015/16 Model Year ( MY ) 2016/2017 Vehicles
KC-161
Service Bulletin/Repair Instructions
Volvo Chassis - Equipped With A Cummins Engine - Cummins Fuel Pump Timing Correction to Reduce Engine Noise; Drone Noise at 1500 RPM and Increases With Engine Load - US10 And Newer Emissions, Common Model Year 2014 And Newer
KC-163
Service Bulletin/Repair Instructions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-277
Service Bulletin/Repair Instructions
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVER
KC-124
Service Bulletin/Repair Instructions
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-114
Service Bulletin/Repair Instructions
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC, Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
KC-102
Service Bulletin/Repair Instructions
Volvo Chassis - Performance Bonus OBD13 And Newer
KC-105
Service Bulletin/Repair Instructions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P05EB, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16 (Commonly Model Years 2016 And 2017)
KC-99
Service Bulletin/Repair Instructions
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
KC-2114
Service Bulletin/Repair Instructions
3rd Party NOx Sensor Identification
KC-2123
Service Bulletin/Repair Instructions
Volvo Chassis - Model VNR With RH Side Fairing Only - Heat/Splash Shield Loose, Possible DTC P204800 And/Or P204713
KC-544
Service Bulletin/Repair Instructions
Model Year 2017, 2018 - ** Tech Tip ** TT - 000 - 2017 GPS Inoperative Message In DID ( Driver Information Display ) - Telematics Gateway ( TGW )
KC-2018
Service Bulletin/Repair Instructions
Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.