Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
33031.6.0
This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
34521.11.1
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36496.10.0
This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.
35503.4.0
This is a Technical Journal: Panoramic sunroof, sealing strip has a gap
35526.1.8
This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
37809.1.1
This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section
34521.10.0
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
37773.1.2
This is a TJ - Text only no attachments - If customer experiences an incorrect ambient temperature reading in DIM (Driver Information Module) or reduced A/C performance, follow the advice under Service. Please refer to the wiring diagram in VIDA to locate the relevant circuit for the ambient temperature sensor (component 7/481) at the passenger door mirror harness.
33183.9.1
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
35842
This is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when turning the steering wheel, follow the advice under Service.
28874
This is a TJ If detected during Pre-delivery inspection or if customer complaints of chipped/cracked/distorted screen/glass within 6 months in service we request more information, follow advise under "Service".
34521
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36902
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
19245
This is a Technical Journal. Vehicle type and platform identification.
TJ36747.1.0-2025-11-12
This is a TJ - 1 document plus one attachment of detailed repair instructions - If the Check Engine Light is illuminated in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". This TJ is a complement to the fault tracing in VIDA. Please follow the steps below.
TJI-527893-1 for TJ 36747
This is a TJ - 1 document plus one attachment of detailed repair instructions - If the Check Engine Light is illuminated in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". This TJ is a complement to the fault tracing in VIDA. Please follow the steps below.
TJ36902.1.0-2025-10-31
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
37428
This is a Tech Journal - If a customer complains that RTTI information is NOT visible in the navigation system when an internet connection is available (globe in the top left corner), follow the instructions under "service". This Technical Journal handles only SENSUS vehicles.
36048
This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
35912
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
36916
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000. Replace the VCM Backup Battery and download the relevant Software.
TJ31514.1.0
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
8501
This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session: •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
36961
This is a Technical Journal: Improved 12V battery test in VIDA. Service: Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
37235
This is a Technical Journal: Changed front fog/cornering lights behavior. This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later
S10303
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customer’s key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
36257
This is a Technical Journal: Climate system heating performance (HVCH). Replace HVCH.
37175
This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory
34647
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
36277
This is a Technical Journal: White patch defect in paint when removed rapgard. Expose vehicle to outside daylight for 48hrs.
37070
This is a Technical Journal: Apple CarPlay Not OK - iPhone with USB-C, SENSUS. The 56 kO resistor ensures safe and appropriate power delivery.
TJ31543
This is a Technical Journal: Software Upgrade / Download Guide. If one control unit is upgraded and not all, it may result in various problems.
37000
This is a Technical Journal: Outer rear view mirror intermittently not folding. May required replacing terminals.
TJ27536.21.1-2024-08-07
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
TJ34647.6.3-2024-08-07
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
TJ36961.2.1-2024-08-07
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
P10263-2024-07-29
Volvo Cars USA LLC on behalf of the Volvo Car Corporation, has voluntarily decided to extend warranty coverage on vehicles exhibiting functionality issues with Apple® CarPlay® for certain model year 2016-2021 XC90 vehicles. The corrective action is to download a Total Software Upgrade.
P10263
Volvo Cars USA LLC on behalf of the Volvo Car Corporation, has voluntarily decided to extend warranty coverage on vehicles exhibiting functionality issues with Apple® CarPlay® for certain model year 2016-2021 XC90 vehicles. The corrective action is to download a Total Software Upgrade.
36845
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ34647.6.2-2024-06-19
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
TJ36845.1.6-2024-06-19
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36895.1.0-2024-06-19
This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control). software is available in VIDA beginning 2024 week 21.
TJ36845.1.5-2024-06-07
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36961.1.0-2024-06-04
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
36202.2.1
This is a Technical Journal: Vibration/shudder while braking. Replace front brake pads
36899.1.0
This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700). Download software.
36916.1.0
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000. Replace the VCM Backup Battery and download the relevant Software.
31698.3.3
This is a Technical Journal. If you experience difficulty programming remote keys on Hybrid vehicles, please follow the advise in Technical Journal under service.
36845.1.4
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
36865.1.1
This is a Technical Journal: Squeak noise from second row outer seats over bumps. Apply PFPE Anti squeak spray, p/n 30749880 spray.
34295.7.1
This is a Technical Journal: High Voltage Battery repairs. Always repair the battery according to the methods in VIDA.
36845.1.3
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
35924.1.4
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time. Use had held tester.
36845.1.2
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
CBR-2014 202402
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer.
36376.4.0
This is a Technical Journal: SR PHEV Cell Module Replacement. Updated BECM software was released
36693.2.1
This is a Technical Journal: WPC, none or unstable charging. recalibrate the WPC by performing a WPC reload.
34647.6.1
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
26745.13.14
This is a Technical Journal: 12V Battery Testing Method
34102.3.1
This is a Technical Journal: Unnecessary Replacements of TurboCord Charge Cable (PN 31419235)
35912.5.0
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
36814.1.0
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
TJ35912.4.0
Updated Chassis Range.
TJ36048.2.0
Alleged issues with Intellisafe functionality.
C00009
COMPLIMENTARY UPGRADE C00009 DESCRIPTION.
TJ34936110
No internet connection and intermittent.
TJ3637610
high-voltage battery cell module in a PHEV.
36678.1.0
This is a Technical Journal. Recovering control modules stuck in ânot respondingâ after failed SW download. Connect VIDA to read-out the car. Follow steps outlined in this TJ.
TJ3656330
Rubber cushion
TJ36202.2.0
Vibration/shudder while braking
TJ36415A
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
TJ3551120
Creaking noise from Steering Wheel Module (SWM)
TJ3641530
Electrical rear axis drive
TJ3655550
Creaking noise from right engine pad
TJ36415
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
TJ3656310
Creaking noise from right engine pad
TJ32525A
DIM message ?Parking brake service required?
TJ35511
Creaking noise from Steering Wheel Module (SWM)
TJ3654810
OHC replaced too often due to CEM U134187 download software prior replacement
TJ36548
OHC replaced too often due to CEM U134187,download software prior replacement
TJ36257
Climate system heating performance (HVCH)
TJ31423
Blown fuse, compressor - air suspension
TJ34102-2
Unnecessary Replacements of BEV and PHEV Charging Cables
TJ34102b
Unnecessary Replacements of BEV and PHEV Charging Cables
TJ34102-1
Unnecessary Replacements of BEV and PHEV Charging Cables
TJ34102a
Unnecessary Replacements of BEV and PHEV Charging Cables
TJ34102
Unnecessary Replacements of BEV and PHEV Charging Cables
TJ34295
PHEV High Voltage Battery Repairs
TJ19245
Vehicle type and platform identification
TJ35902
Connectivity services activation - PSIM issues
TJ36455
Volvo Cars App Android, no climate setting button
TJ36224
No bass function (High Performance Audio)
SMB87-001
Climate system heating performance.
SMB00-108C
Expendable Items Parts List.
CBR-2201
Engine Control Module (EMS) Software (MSW) Information â August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions
KC-145
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
Special Tools Bu
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and repair methods evolve.
Service Manager
ICUP/Google Built-In Diagnostic Operations
356EN01
VIDA QR Scanner Mobile App
TJ Instruction V
Steering column cover, squeaking noise
KC-159
Trucks Equipped With A Cummins Engine - Engine Preheat Icon Does Not Illuminate In The Instrument Cluster (IC) During Engine Pre-heat (Intake Air Heater) Operation - Vehicles With 2018 Instrument Cluster Update, Model Year 2018 And Newer
TJ3566220
Headlamp condensation.
KC-99
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
SMB00027
Emission Warranty Update.
TJ 35507 6 0
Outer rear view mirror glass incorrect position after reversing.
TJ 35901 4 0
Driving, Twin Engine/Propulsion using electric motor not possible.
TJ 34647 6 0
Perform a software upgrade in accordance with TJ 31543.
TJ3595620
If the check engine lamp may appear in the DIM (Driver Information Module) and the listed DTC is
TJ3595610
If the check engine lamp may appear in the DIM (Driver Information Module) and the listed DTC is
TJ3544050
latest version software needs to update.
TJ 35978 1 0
New Software Products (SP) have been developed to convert a Care Key to a standard key.
SMB00-015-2021-0
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form
TJ35944.1.0-2021
This is a Technical Journal: Ghost DTC set, VCU1-U210782. does not affect any of the functions in the car.
PB23-S10066-2021
This is a Service Action S10066. Create Parts Bulletin using attached file.
S10066-2021-04-2
Volvo Car USA LLC and Volvo Car Canada Ltd on behalf of Volvo Car Corporation, has decided to launch Service Action S10066 on certain Volvo S60, V90CC, XC60, V60CC, V60, XC90, S90L, and V90 Model Year 2019-2020 vehicles. Volvo has identified that a malfunction in the Dual Purge check valve impacts the purge ejector function at high loads and the flow diagnostics will trigger a DTC and MIL. No impact on drive-ability or emissions. The corrective action is to replace the Dual Purge pipe.
TJ33867.1.3-2021
This is a Technical Journal: we find with automobiles. Radial force variation ( RFV ) is a condition where excessive run out will create the same symptom as an unbalanced tire. Tire balancing should be checked and corrected as needed but is not always the solution. Road Force balancing detects assembly run out measured under load simulating real world driving conditions and will provide a solution to match mount the tire and rim to minimize loaded run out.
P10064-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Series, 2016-2020 XC90 and 2018-2020 XC60 models. Volvo has determined that there is the potential for a malfunction caused by a valve inside the compressor which may contain residue from an anti-corrosive agent.
ST-248-2021-04-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Series, 2016-2020 XC90 and 2018-2020 XC60 models. Volvo has determined that there is the potential for a malfunction caused by a valve inside the compressor which may contain residue from an anti-corrosive agent.
TJ33183.7.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ35907.1.0-2021
This is a Technical Journal: DTC SODL/R-C106057 after replaced SOD
TJ35912.1.0-2021
This is a Technical Journal: AC evaporator repair, additional parts needed
TJ35440.4.0-2021
This is a Technical Journal: Echo heard on phone call, Improved IHU software that will correct this issue is under development and will be released in June of 2020.
TJ31558.10.0-202
If the rear Parking Assistance System (PAS) is not working and there is a message in DIM about ?Parking Assistance System service required? displayed in DIM, then it is possible that there is water ingress into rear park assist sensors and connectors caused by splices in the rear cable harness. If the sensors and connectors have water ingress then follow method in VIDA
P10064-2021-03-1
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Series, 2016-2020 XC90 and 2018-2020 XC60 models. Volvo has determined that there is the potential for a malfunction caused by a valve inside the compressor which may contain residue from an anti-corrosive agent.
TJ35902.1.1-2021
This is a Technical Journal: Connectivity services activation - PSIM issues
TJ31423.18.1-202
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA.
TJ33183.6.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
P10064-2021-02-2
Volvo Car USA LLC and Volvo Car Canada LTD (Volvo) on behalf of Volvo Car Corporation, has voluntarily decided to extend warranty coverage on the Rear Suspension Air Compressor for certain model year 2017-2020 S90 Series, 2017-2020 V90 Series, 2016-2020 XC90 and 2018-2020 XC60 models. Volvo has determined that there is the potential for a malfunction caused by a valve inside the compressor which may contain residue from an anti-corrosive agent.
TJ35507.5.0-2021
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ34241.2.3-2021
This is a Technical Journal: 12V battery message and DTC CEM-B129F96
TJ35507.4.0-2021
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ35867.1.0-2021
This is a Technical Journal: AWD DTC DEM-P188919. Reset the DTC.
TJ33183.5.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ35842.1.0-2021
This is a Technical Journal: Noise when turning steering wheel. Check rubber gromet in firewall
TJ34857.6.0-2021
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
TJ33031.5.0-2021
This is a Technical Journal: If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
TJ33183.4.0-2021
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ33617.2.1-2021
This is a Technical Journal: Front seat heater, function control. If not working check the heating grid wiring.
TJ35511.1.0-2021
This is a Technical Journal: Creaking noise from Steering Wheel Module
TJ32985.5.0-2020
This is a Technical Journal: Seat belt front, may not retract fully
TJ35460.1.8-2020
This is a Technical Journal: Check Engine Light (BCM2 requesting MIL). A service solution is under development
TJ30621.1.1-2020
VOLVO CARS SERVICE AND PARTS BUSINESS Technical Journal TITLE : Sunroof shade hanging down REF NO : ISSUING DEPARTMENT : CAR MARKET : United States and Canada TJ 30621 Technical Service PARTNER : ISSUE DATE : 3 US 7510 Volvo Cars North America YEAR MONTH DAY 2015 07 20 FUNC GROUP : FUNC DESC : 8360 Roof hatch Page 1 of 3 Attachment File Name File Size Movie clip 1 . mp4 5.3850 MB Movie clip 2 . mp4 5.4659 MB Vehicle Type Eng Struc Week Type Eng Sales Body Gear Steer Model Year Plant Chassis range Desc Range 256 2016 - 9999 21 0000001 - 9999999 201505 - 999952 CSC Customer Symptom Codes Code Description VJ Sun / moon / convertible roof / Fits poorly SC Sun / moon / convertible roof / Hard / impossible to open / close VST Operation Number VST Operation Number Description 83612 - 2 Sun shade / inner panel sun roof replace 99400 - 2 General reimbursement acc . to TJ / QB DTC Diagnostic Trouble Codes ? Right first time in Time ? Produced in the USA and available as an electronic document . Hard copy documents are printed in USA on recycled paper containing a minimum of 50 % wastepaper and 10 % post - consumer waste . © 2015 VOLVO CARS OF NORTH AMERICA , LLC Technical Journal 30621 Text DESCRIPTION : If the sunroof shade is hanging down in the vehicle , follow advice under ? Service ? . The installation procedure in the VIDA removal , replacement and installation instructions for the Sun visor / Inner cover sun roof ( VCC - 371003 - 6 ) will be updated later . The two movie clips add this information meanwhile . Vehicle Report : Please submit a Vehicle Report of all cases with hanging sunroof shade . Use concern area ? Vehicle Report ? and sub concern area ? Support not needed ? , use function group 8360 . Service : 1 . Preparation of Sun visor / Inner cover sunroof spare part ( Movie clip 1 ) . After unpacking the spare part with P / N 39824859 ( Blonde ) or P / N 39824857 ( Charcoal ) please do the following steps : Note : Always use clean gloves when h
TJ35583.1.1-2020
This is a Technical Journal: Panoramic sunroof, roller blind hanging loose
TJ31423.18.0-202
This is a Technical Journal: Blown fuse, compressor - air suspension. Perform Total Upgrade, replace fuse and compressor according to VIDA.
SMB00-015-2020-1
This is a Service Manager Bulletin : Volvo Electric Vehicle Technical De-Energization Permit to Work Form
TJ34286.5.0-2020
This is a Technical Journal: Info request: Pull & drift or steering wheel misaligned, feedback needed.
TJ34803.2.0-2020
This is a Technical Journal: Title II-TPMS calibration after SW upgrade In the new SW, released May 2019, the picture in the Centre Display for I-TPMS is showing a "spinning wheel", while calibration is ongoing. The calibration function itself is not changed compared to previous SW versions, it is only how it is presented in the center display that has been changed.A new calibration will start automatically as soon as the VDDM SW is upgraded.
TJ34241.2.2-2020
This is a Technical Journal: 12V battery message and DTC CEM-B129F96
TJ35560.3.0-2020
This is a Technical Journal: Headlight DTC?s after software upgrade
ST-001-2020-09-1
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
TJ32985.4.0-2020
This is a Technical Journal: Seat belt front, may not retract fully
TJ35560.2.0-2020
This is a Technical Journal: Headlight DTC?s after software upgrade
TJ35583.1.0-2020
This is a Technical Journal: Panoramic sunroof, roller blind hanging loose
TJ35460.1.6-2020
This is a Technical Journal: Check Engine Light (BCM2 requesting MIL). A service solution is under development
TJ35507.2.0-2020
This is a Technical Journal: Outer rear view mirror glass incorrect position after reversing
TJ35514.1.0-2020
This is a Technical Journal: Prior Approval for VCM Replacement
SMB39-015-2020-0
This is a Service Manager Bulletin: Prior Approval for VCM Replacement
PB30-S10020-2020
Parts Bulletin for S10020 - Brake Control Module (BCM) may stop diagnostic communication in case of an altered bus communication rate, due to an error (bug) in the diagnostics system. Download software is required. Parts for software download listed.
S10020-2020-06-0
Quality Bulletin for Brake Control Module (BCM) may stop diagnostic communication in case of an altered bus communication rate, due to an error (bug) in the diagnostics system. Download software is required.
TJ33183.3.0-2020
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
TJ34787.2.1-2020
This is a Technical Journal: Ping noise from exhaust when cooling down
SMB17-023-2020-0
Over the past month, Volvo Car USA and Volvo Car Canada Limited have implemented a number of measures to help minimize the impact the COVID-19 stay-at-home orders has had on our retailer partners and their service departments. Effective as of the release of this Service Manager Bulletin, Volvo Cars is introducing the Temporary Stock Maintenance Assistance Program.
TJ35460.1.5-2020
This is a Technical Journal: Check Engine Light (BCM2 requesting MIL). A service solution is under development
TJ35460.1.4-2020
This is a Technical Journal: Check Engine Light (BCM2 requesting MIL). A service solution is under development
SMB00-006-2020-0
This is a Service Manager Bulletin: Service 2.0 Software & Total Upgrade Reminder
TJ34857.4.2-2020
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
TJ34857.4.0-2020
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
TJ20803.21.1-202
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
SMB00-321-2020-0
Volvo Complimentary Factory Scheduled Maintenance 'FSM330' MY2013 and later. Factory Scheduled Maintenance up to the first 3 years or 36,000 miles (whichever comes first) as recommended in the Volvo Warranty and Maintenance Information booklet.
SJ1000167-2020-0
This is a Service Journal: Coolant Filling Equipment Tool
ST-001-2020-01-2
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
TJ34740.1.3-2020
This is a Technical Journal: 4 Cylinder VEP engine: Castrol Edge Professional V 0W-20 Synthetic oil.
SMB22-005-2020-0
This is a Service Manager Bulletin: Volvo Engine Petrol (VEP4 2.0L) Oil Viscosity Requirement
SMB00-444-2020-0
This is a Service Manager Bulletin: Windshield Cleaning Operation Service Interval Change. Will only be performed at 20k
TJ20803.21.0-202
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
TJ34857.3.0-2019
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
TJ35058.1.3-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions
TJ32892.2.0-2019
This is a Technical Journal: PAC 360 side camera, intermittent no image
TJ35340.1.0-2019
This is a Technical Journal: "Ghost" DTCs set: SODL-U210052 and SODR-U210052
TJ35344.1.1-2019
This is a Technical Journal: Removal of "SiriusXM Subscription has Expired" Message
ST-235-2019-11-2
This is a Special Tool Bulletin: Mandatory tool allocation
TJ35058.1.2-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions
SMB00-006-2019-1
Software Installation Policy changes.
SMB00-438-2019-1
This is a Service Manager Bulletin: Technician Skillset Requirments
TJ34857.2.0-2019
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
ST-001-2019-10-1
Mandatory Tool List bulletin: Volvo mandatory Special Tools are necessary for technicians to properly diagnose and repair Volvo cars. They are used in development of Volvo labor operations and repair methods, and promote safety and quality repairs in a timely manner. Tools are classified as mandatory because associated repairs and/or diagnostics cannot be completed properly without them.
TJ20803.20.1-201
This is a Technical Journal: In case of complaint of Noise, some "tools" have been created to help you to do a better and more precise fault tracing
TJ35058.1.1-2019
This is a Technical Journal: Sensus/Sensus Connect Navigation Base Map Versions
TJ33442
Left engine pad click sound
TJ34922 1 0 2019
If there is message in the DIM about ?Sensor Blocked? and the car has DTC CEM B1B3629 and/or B1B4029, follow instructions under ?Service?.
ST-234-2019-08-2
This is a Special Tool Bulletin: Mandatory tool allocation
SPJ34549 2 0-201
This is a Service Product Journal: Template Bumperskin Towbar Hitch, a template needs to be used to make the cut.
SMB00 438 2019-0
This is a Service Manager Bulletin: Technician Skillset Requirments
SMB00 006 2019-0
Software Installation Policy changes.
SMB84 001 2019-0
This is a Service Manager Bulletin: Windshield replacement products.
SMB171
Retail Car Delivery Process
PB22012
All model year 2019 and 2020* vehicles are delivered from the factory with Castrol EDGE Pro V 0w-20 Synthetic oil. Castrol EDGE Pro V 0W20 is specifically co-engineered for the Volvo VEP4 2.0L engine to maximize fuel efficiency and engine performance.
TJ34763
New Model Year 2020; Initial quality reporting
TJ34650 1 0-2019
This is a Technical Journal: SPA Condensation water drops in around pedals area
TJ34857 1 0-2019
This is a Technical Journal: ECM-P04F000, Evap System, High Pressure Purge Line
TJ34567 1 0-2019
This is a Technical Journal: DTC SRS-B15381B High Voltage battery loop control. The resistance of the circuit can be monitored using the SRS parameter "High voltage battery power supply disconnect"
SMB30-001-2019-0
This is a Service Managers Bulletin: Volvo Cars is constantly developing the in-car systems and the services offered to customers, so that their cars give them the best experience possible . As of May 13th, 2019, when the software in your customer's vehicle is updated via Service 2.0 or Total Upgrade (TJ 31543), the customer will have access to the functions and improvements
SPJ34864 2 0-201
This is a Service Product Journal: Information Notice. We process the personal data that you provide in connection with the creation of your VIDA account. The purpose of our processing is to administer your VIDA account (from registration to eventual termination of the account), to provide you with all the functionality related to VIDA, to allow access to VIDA and to communicate updates related to VIDA. Log data generated when using VIDA is processed as necessary or appropriate to safeguard the security and functionality of VIDA for example against malware or unauthorized access.
TJ3482012-2019-0
This is a Technical Journal: Updates to the customer's software, May 2019
SPJ3484110-2019-
This is a Service Product Journal: Electric wiring diagram missing in VIDA. Model year 2020
SPJ3224230-2019-
This is a Service Product Journal: Digital Head Light Instrument for L.E.D., Halogen, Xenon vehicles
SPJ3475710-2019-
This is a Service Product Journal: Unable to set SPA/CMA vehicle into programming mode - P2P
SPJ3479010-2019-
This is a Service Product Journal: VIDA VOC Access Functionality and Instruction
TJ3478111-2019-0
This is a Technical Journal: Changing DIM trip computer value
PB77-006-2019-05
Winter Wheel Applications including rim sizes, steel wheel parts numbers and wheel cover part numbers
TJ3429510-2019-0
This is a Technical Journal: High Voltage Battery repairs
SMB17-2020-2019-
This is a Service Manager Bulletin: Retail Car Delivery Process MY 2020
TJ33442a
Left engine pad click sound
TJ33442b
Left engine pad click sound
TJ34126
New S60; Initial quality reporting.
TJ31602
Infotainment System Reboots while driving (blank screen)
TJ32033a
Audio switches on steering wheel, no function
TJ33284
Floor hatch compartment, hard to open or handle too loose
TJ32033
Audio switches on steering wheel, no function
TJ33442d
Left engine pad click sound
TJ33514
End pieces available for luggage cover.
TJ32025
Seat hard to push back, second row seat (7 seater)
TJ32728
Front side door, water intrusion
TJ32185
Voice recognition database upgrades
TJ32903
T8 DTC BECM?P0CE100 Coolant Control Valve ?A? Stuck On.
TJ31698
Difficulty to add/program remote key,
SPJ31410
Unhandled script error in VIDA XC90(16-)
STB216
News Letter 70
STB215
News Letter 69
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.