Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
36863.4.0
This is a Technical Journal: DIM Message and DTC IEM P0C0500. 1. Erase the DTC 2. Test drive the vehicle in electrical mode and accelerate until the vehicle reaches a minimum of 30 km/h (19 mph). 3. Perform a new VIDA readout If the DTC IEM P0C0500 does not return, do not replace any parts. Release the car to customer.
32010.3.0
This is a Technical Journal: Plus 2 attachments 1- TJI-497587-1 and 1 MP4 Speaker Grill -It may be possible for the rear door lock switch to get stuck in the speaker grille. This can lead to a drained battery. Applies only for cars with Premium or High Performance stereo. Service: Check for/remove edges in the hole for the button in the speaker grille. Follow attached method "TJ 32010.pdf" or the video "Speaker_Grill.mp4".
33031.6.0
This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
37545.4.0
This is a TJ no attachments - If customer complains of creaking or squeaking noise coming from the door stop when opening/closing the door, follow advice under "Service". Before replacing any parts, follow the instruction below.
34521.11.1
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36376.6.0
This is a Technical Journal: Text only no attachments - Before replacing a cell module, make sure the latest BECM software is downloaded. This is important for utilizing the VIDA method described here and receiving the correct cell balancing diagnostics after the replacement.
36496.10.0
This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.
35503.4.0
This is a Technical Journal: Panoramic sunroof, sealing strip has a gap
35526.1.8
This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
37809.1.1
This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section
34521.10.0
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
37773.1.2
This is a TJ - Text only no attachments - If customer experiences an incorrect ambient temperature reading in DIM (Driver Information Module) or reduced A/C performance, follow the advice under Service. Please refer to the wiring diagram in VIDA to locate the relevant circuit for the ambient temperature sensor (component 7/481) at the passenger door mirror harness.
34295.9.0
This is a Technical Journal: Text plus 2 attachments 1 PDF and 1 PNG - High Voltage Battery repairs. Always repair the battery according to the methods in VIDA. This TJ is a guide to the kinds of repairs that can be done instead of a complete HV battery replacement. Parts, methods, and tools are now available to repair almost all faults within the High Voltage Battery.
33183.9.1
This is a Technical Journal: If a vehicle with panorama roof shows symptom of a rattling noise when opening, follow the description under Service. If the analysis shows that the rattling noise comes from the roller blind, similar to the noise in the attached file, replace the roller blind according to VIDA.
36376.5.1
This is a Technical Journal: Text only no attachments - Before replacing a cell module, make sure the latest BECM software is downloaded. This is important for utilizing the VIDA method described here and receiving the correct cell balancing diagnostics after the replacement.
35842
This is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when turning the steering wheel, follow the advice under Service.
34521
This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp
36902
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
37624
This is a TJ - Text only no attachments If a decision is taken to replace a cell module and the vehicle has VDN code CK04, please follow information under "Service." f you are replacing a cell module and the vehicle has VDN code CK04, please install the SP listed below before you replace the cell module.
19245
This is a Technical Journal. Vehicle type and platform identification.
TJ36902.1.0-2025-10-31
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
AC pressure check
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice under service.
TJ34648.5.0-2025-10-29
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice under service.
TJI VCC-517278-1
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice under service.
37428
This is a Tech Journal - If a customer complains that RTTI information is NOT visible in the navigation system when an internet connection is available (globe in the top left corner), follow the instructions under "service". This Technical Journal handles only SENSUS vehicles.
36048
This is a Technical Journal: Alleged issues with Intellisafe functionality. Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
35912
This is a Technical Journal: AC evaporator repair, additional parts needed. Add resister in line jumper cable.
36916
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000. Replace the VCM Backup Battery and download the relevant Software.
35755
This is a Technical Journal: BEV and LR-PHEV SW Update for High Voltage Battery Balancer. The Balancer software must be upgraded to version OTG_192-411899-H00-029 or higher
36814
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting. This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
TJ31514.1.0
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
37345
This is a Technical Journal: AC System Intermittent Knocking Noise. If the symptom is confirmed, proceed with adding a rubber sleeve on isolated low pressure line (also, connect low pressure line and high pressure line with a cable tie) according to the attachement.
8501
This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session: •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
36961
This is a Technical Journal: Improved 12V battery test in VIDA. Service: Don´t charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
TJ 34295
This is a Technical Journal: High Voltage Battery repairs. Always repair the battery according to the methods in VIDA.
37235
This is a Technical Journal: Changed front fog/cornering lights behavior. This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later
S10303
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customer’s key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
36257
This is a Technical Journal: Climate system heating performance (HVCH). Replace HVCH.
37175
This is a Technical Journal: Vehicle/Connectivity report checklist. To provide timely and high-quality feedback to the appropriate department or factory
34647
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
36277
This is a Technical Journal: White patch defect in paint when removed rapgard. Expose vehicle to outside daylight for 48hrs.
37070
This is a Technical Journal: Apple CarPlay Not OK - iPhone with USB-C, SENSUS. The 56 kO resistor ensures safe and appropriate power delivery.
TJ31543
This is a Technical Journal: Software Upgrade / Download Guide. If one control unit is upgraded and not all, it may result in various problems.
36863
This is a Technical Journal: DIM Message and DTC IEM P0C0500. 1. Erase the DTC 2. Test drive the vehicle in electrical mode and accelerate until the vehicle reaches a minimum of 30 km/h (19 mph). 3. Perform a new VIDA readout
TJ19245
This is a Technical Journal. Vehicle type and platform identification.
37000
This is a Technical Journal: Outer rear view mirror intermittently not folding. May required replacing terminals.
36929
This is a Technical Journal: Check Engine Light and ECM P0CD900. Performed total software update.
37048
This is a Technical Journal: Difficulty clearing SODx DTCs. put the car in usage mode "Driving" and continue the erasing process
TJ27536.21.1-2024-08-07
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
TJ34647.6.3-2024-08-07
This is a Technical Journal: DIM message about parking brake. Manually order and download software part number 32429456
TJ36961.2.1-2024-08-07
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
36845
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ34647.6.2-2024-06-19
This is a Technical Journal: DIM message about parking brake. Download the available total upgrade software.
TJ36845.1.6-2024-06-19
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36895.1.0-2024-06-19
This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control). software is available in VIDA beginning 2024 week 21.
TJ36845.1.5-2024-06-07
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide. After capturing a NEW VIDA readout, conduct the steps in VIDA.
TJ36961.1.0-2024-06-04
This is a Technical Journal: Improved 12V battery test in VIDA. Improved 12V battery test in VIDA
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.