TSB26-008-WST
Service Bulletin/Repair Instructions
Service Solution for DT12 Oil Plug Ports
Vehicle report
2017 WESTERN STAR 4700
Service bulletins
595 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CXA 3_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
CXA 1_16_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
CXA 1_16_DD13 Altitude
Other
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CXA 1_16_NOx
Other
CX Advocate for NOx conversion low faults
CXA 1_16_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
SS778-WST
Other
Service Solution for Power Steering Reservoir Fill Cap Venting
D24R2-Bulletin
Emissions
Emission Recall for DETROIT DD13 and DD16 ACM Software Reprogramming
D24R2-DLR LTR
Emissions
Emission Recall for DETROIT DD13 and DD16 ACM Software Reprogramming
D24R2-OWN LTR
Emissions
Emission Recall for DETROIT DD13 and DD16 ACM Software Reprogramming
CXA 11_21_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
WI24-019
Warranty Program/Extension
Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair Time Updates
CXA_10_17_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
SS1023366-Detroit
Other
Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
CXA 7_24_NOx
Other
CX Advocate for NOx conversion low faults. Update to CXA 6_24_NOx submission.
CXA 7_24_Oil Suction
Other
CX Advocate for Oil Suction manifolds
CXA 06_24_NOx
Other
CX Advocate communication for NOx conversion low faults
TSB35-023-WST
Service Bulletin/Repair Instructions
Technical Service Bulletin for New Final Drive Over Heat Diagnostic
SS734-WST
Other
Service Solution for Thread Spring Pin Suspension Alignment & Installation
VSWP Customer Letter
Other
Customer letter regarding variable speed water pump.
SS763-WST
Other
Service Solution for DEF Pump Wiring for Cummins CM2450 Engine Controller
FL974
Service Bulletin/Repair Instructions
Revised Emissions Recall: Cummins DEF Sensor Shortage. REVISION: Some vehicles formerly in Group F have been moved to Group G and have been assigned a new part number as specified in Table 1. An SRT for 'Calibration Code Only: Update or Confirm' has been added, as shown in Table 2, to be used when a new DEF header is not required. There have been some other minor changes to the work instructions and SRT times.
ICI24-006
Service Bulletin/Repair Instructions
Important Campaign Information letter for FL974 - Revised Bulletin & Population
SBW83-030
Service Bulletin/Repair Instructions
Updated Western Star Service Bulletin for HVAC Actuator Replacement
SBW49-020
Service Bulletin/Repair Instructions
Western Star Service Bulletin for DEF Connector Reinforcement Caps
CALWS83-001REV
Service Bulletin/Repair Instructions
HVAC Actuator Wiring Harness. Revision History: Service kit part number changed from RDH RD5 17147 0 to WWS RD-3-9069-0 on 12/9/21. The wiring harness of the actuator of the fresh air recirculation door, shown in Fig. 1, on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
ICI21-030
Service Bulletin/Repair Instructions
SF626 Western Star Window Replacement Inspection Notification. This letter is to inform you that Field Service Campaign SF626 Western Star Window Replacement Inspection Notification campaign was released.
CALWS83-001
Service Bulletin/Repair Instructions
Customer Advisory Letter for HVAC Actuator Wiring Harness. The wiring harness of the actuator of the fresh air recirculation door, shown in Fig. 1, on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
SBW54-080
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Key Fob ID Retention. Key fobs for remote keyless entry on Western Star vehicles are delivered in packages that include a unique ID for the fob. The ID is required when pairing the key fob with a vehicle.
SS701-WST2021
Service Bulletin/Repair Instructions
Service Solution for DT12 Harness Chaffing - PT Can Faults. Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
16TS-08REV
Service Bulletin/Repair Instructions
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
WP21-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
WP60-100
Service Bulletin/Repair Instructions
Updated Western Star Parts Technical Bulletin for Universal Design Floor Mats. This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals.
21OEM-06
Service Bulletin/Repair Instructions
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
ICI21-003
Service Bulletin/Repair Instructions
Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R.
WI21-006
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
WI20-014R
Service Bulletin/Repair Instructions
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
WI21-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters. Detroit's TechComm team created visual aids for the network and released exploded view posters for DD platform engines. In early 2021, Detroit added multiple DT12 posters.
21TS-01
Service Bulletin/Repair Instructions
Technical Service Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
21TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps. There is a short supply of exhaust clamps, part number DDE A6809950502, used as inlet and outlet exhaust clamps on GHG17 heavy duty engines (DD13, DD15 and DD16) with a 1-Box aftertreatment configuration. Exhaust clamp part number TCX T130158342AC2 may be used as a substitute for DDE A6809950502, but be aware of the different torque specs between the two parts.
WI21-003
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
SBW35-018
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
SBW54-057
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
17TS-05REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Detroit DT12 TCM GHG17 Only; Bootloader Update. On Detroit DT12 equipped vehicles, it may be necessary to complete an additional step in the programming process when updating the TCM software.
WSTCAE180-2020
Service Bulletin/Repair Instructions
Portland Truck Plant Paint Changes
20TS-06
Service Bulletin/Repair Instructions
DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts. Some GHG17 DD Platform Heavy Duty oil pans may experience an issue with the oil pan drain plug insert spinning during removal or installation while completing an oil change. Leaking may also be observed at the drain plug and/or other plugs in the oil pan.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
WSTCAE177-2020
Service Bulletin/Repair Instructions
Meritor Transfer Case Updates
ICI20-022R
Service Bulletin/Repair Instructions
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
ICI20-022
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerÃÂÃÂÃÂâÃÂÃÂÃÂÃÂÃÂÃÂÃÂÃÂs location to perform a recall or field service campaign.
WI20-012
Service Bulletin/Repair Instructions
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
WI20-014
Service Bulletin/Repair Instructions
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
SBW31-016
Service Bulletin/Repair Instructions
Western Star Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8âÂÂ18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-10
Service Bulletin/Repair Instructions
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂÃÂÃÂÃÂÃÂî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
20OEM-05
Service Bulletin/Repair Instructions
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
20CSA-09
Service Bulletin/Repair Instructions
Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SBW60-027
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
20CSA-08
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
SBW72-008REV
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit. The bulletin dated December 4, 2019 has been revised to include 4800 Models. Beginning 04/01/2019 Western Star cab doors were updated to a new style regulator and window. When replacing an older style regulator or window the vehicle must be retrofitted to the new style regulator and window.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SBW54-075
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the back-up light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
20CSA-04
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLinkî 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
03.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers.
WP20-002
Service Bulletin/Repair Instructions
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
SS1034179
Service Bulletin/Repair Instructions
Service Solution on Western Star speedometers. For certain speedometers the speedometer may drop out or the odometer may reset to zero.
SBW54-061
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness. Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
20CSA-01
Service Bulletin/Repair Instructions
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a 60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
SS1034615
Service Bulletin/Repair Instructions
Service Solution for Western Star Velvac Door Mirror Seal Curling. The rubber that is rolling back is actually a rubber tape. Originally, the mirrors did not have this tape. Velvac added the tape to address some whistling complaints from customers.
SS1034607
Service Bulletin/Repair Instructions
Service Solution for WST 4700 In Cab Floor Raceway Cover Corrosion. Some Western Star 4700 trucks experience rust through of the steel raceway covers located on the cab floor. This is typically seen in applications where the truck is run in environments where harsh chemicals are used such as salt in snowplow applications.
SBW83-020
Service Bulletin/Repair Instructions
Service Bulletin on A/C System Receiver-Drier Replacement Guidelines.
17TS-12REV
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 Heavy Duty Engine Platform 1-BOX Aftertreatment System (ATS) Wire Harness experiencing chaffing caused by vibration and dirt collecting in the harness conduit.
WI19-022
Service Bulletin/Repair Instructions
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
SBW72-008
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit.
SS1034577
Service Bulletin/Repair Instructions
Service Solution to address WST Cab drone / vibration / tapping Under acceleration for vehicles w/Eaton Manual Trans.
SBW00-004
Service Bulletin/Repair Instructions
Service Bulletin explaining Western Star's courtesy engineering policy.
SBW32-018
Service Bulletin/Repair Instructions
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement.
SBW41-002
Service Bulletin/Repair Instructions
Service Bulletin for midship bearing replacement. This procedure applies to all vehicles built with driveshafts SPL140, SPL170 or SPL250 with first order driveline vibration.
SS1034499
Service Bulletin/Repair Instructions
Service Solution on failing RX modules in Western Star vehicles.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
P&SSep2019
Service Bulletin/Repair Instructions
Parts and Service Committee meeting minutes
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB47-015
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
SBW54-073
Service Bulletin/Repair Instructions
Service Bulletin for Powernet Distribution Box Functional Changes
15CSA-3REV
Service Bulletin/Repair Instructions
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
19CSA-12 BCT
Service Bulletin/Repair Instructions
PowerNet Assessment Tool Repair Procedure
19TL-10 NVH
Service Bulletin/Repair Instructions
Communication to assist the field with service vibration issues on DTNA vehicles
19TL-11
Service Bulletin/Repair Instructions
Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
19TL-12
Service Bulletin/Repair Instructions
Tool Letter for New Final Drive Pinion Cover Install Tool
19TL-13
Service Bulletin/Repair Instructions
Tool Letter for DT12 Seal Protector Sleeve
19TL-14
Service Bulletin/Repair Instructions
Tool Letter for New Final Drive Driver Controlled Differential Lock Spring Compressor. These new axles require a new tool to compress the Driver Controlled Differential Lock (DCDL) spring. To remove and install the DCDL spring, the tool DSN0FDA17001 is needed.
D18M4
Service Bulletin/Repair Instructions
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
19CSA-13
Service Bulletin/Repair Instructions
Service Systems Development provided document to service locations on price list reflects current charges to engine horsepower ratings for HDEP and MDEG engine platforms.
0107-19 GHG17
Service Bulletin/Repair Instructions
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
0305-19 SPN 2000
Service Bulletin/Repair Instructions
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat Message is no Longer Arriving)
0308-19 PTO
Service Bulletin/Repair Instructions
Service Information Bulletin regarding PTO Dosing. This feature enables Active Regeneration of the DPFs while in PTO mode.
0419-19SPN521030
Service Bulletin/Repair Instructions
Updates to troubleshooting guides in Diagnostic Link with newest version
0607-19
Service Bulletin/Repair Instructions
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
0611-19
Service Bulletin/Repair Instructions
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP726Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP730Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TL-9
Service Bulletin/Repair Instructions
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations. The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
19TS-6
Service Bulletin/Repair Instructions
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
SPN 3563 / FMI 2
Service Bulletin/Repair Instructions
HDEP GHG17 engines are not equipped with turbo wastegates. Steps in this troubleshooting involving wastegates were removed.
sb54313
Service Bulletin/Repair Instructions
Service Bulletin provided to customers regarding installation of a new MCM 21-pin jumper harness.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
DOC-1034452
Service Bulletin/Repair Instructions
Training Solution created by DTNA to provide guidance to customers when searching for service information for components and systems not owned by Daimler Trucks North America (DTNA).
SF561
Service Bulletin/Repair Instructions
Field Service Campaign- SF561 Cummins Green House Gas 2017 Engine Aftertreatment System Retrofit
sbw0015
Service Bulletin/Repair Instructions
Service Bulletin- sbw0015 Vibration and Harsh Ride Troubleshooting
sbw00017
Service Bulletin/Repair Instructions
Reminder: Paper Service Bulletin Mailings Are Discontinued
DOC-1034171
Service Bulletin/Repair Instructions
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
CALWS32-001
Service Bulletin/Repair Instructions
Customer Advisory Letter on Transverse Track Rod Tower Bracket
FL750-FR
Service Bulletin/Repair Instructions
Emissions Recall: Ambient Air Temperature Sensors French translation
FL750-SP
Service Bulletin/Repair Instructions
Emissions Recall: Ambient Air Temperature Sensors Spanish translation
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
sbw54070
Service Bulletin/Repair Instructions
Service Bulletin- Chassis ECU Programming
sbw0004
Service Bulletin/Repair Instructions
Service Bulletin-sbw0004 Western Star Courtesy Engineering Policy
18TS4Rev DD
Service Bulletin/Repair Instructions
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
ICI18-035 FL766
Service Bulletin/Repair Instructions
Important Campaign Information to Dealer on FL766 - Final Remedy Temporarily Suspended
1001-18 Engine R
Service Bulletin/Repair Instructions
Engine Replacement Procedures
sbw0015 Vibratio
Service Bulletin/Repair Instructions
Vibration and Harsh ride Troubleshooting
18-032-NoDefectF
Service Bulletin/Repair Instructions
Warranty Bulletin for charge back exemtions
FL766 Western St
Service Bulletin/Repair Instructions
Recall Bulletin FL766- Western Star Power Cable Studs
ICI18-031 FL766
Service Bulletin/Repair Instructions
Important Campaign Information- FL766 Interim Recall Ending ? Final Recall to Begin
sbw8329 HVAC Fre
Service Bulletin/Repair Instructions
Service Solution for HVAC Fresh Air Intake Water Leak in certaian Western Star models-4700, 4900, and 5700
DOC-1033768
Service Bulletin/Repair Instructions
TS 1033768: Western Star Front Brake Squeal - Burnishing Procedure
TS1033768
Service Bulletin/Repair Instructions
Training Solution for Western Star Front Brake Squeal - Burnishing Procedure. The brake burnishing procedure can be used to help reduce brake related noise or imbalance concerns which may occur in the field.
sbw0014
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
0508-18
Service Bulletin/Repair Instructions
0508-18 Aftertreatment
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
0504-18
Service Bulletin/Repair Instructions
0504-18 Fuel System - Fuel Injectors
0503-18
Service Bulletin/Repair Instructions
0503-18 Relative Cylinder Compression Test
0502-18
Service Bulletin/Repair Instructions
0502-18 Symptom Diagnostics - Low Engine Coolant Temperature
0501-18
Service Bulletin/Repair Instructions
0501-18 Aftertreatment Control Module (ACM)
18SP734
Service Bulletin/Repair Instructions
18SP734 18SP734?GHG14 DD15AT Turbocharger
DOC-1033403
Service Bulletin/Repair Instructions
SS 1033403 - WST Wiper Motor not Parking Issues
DOC-1033446
Service Bulletin/Repair Instructions
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
DOC-1033462
Service Bulletin/Repair Instructions
SS 1033462 - WST Cab Mounted Mekra Mirror Cover Chrome Peeling
DOC-1033463
Service Bulletin/Repair Instructions
SS 1033463 - WST 4700 Transmission Oil Cooler Lines Routing Improvements
FL756
Service Bulletin/Repair Instructions
FL756 Brake Light Pressure Switches
FL766
Service Bulletin/Repair Instructions
FL766 Western Star Power Cable Studs
ICI18-016 FL756
Service Bulletin/Repair Instructions
ICI18-016 FL756 ? Automotive Connector Terminal Removal Tool
MY18M4
Service Bulletin/Repair Instructions
MY18M4_Bulletin_02-MAY-2018 Field Service Campaign D18M4
aeo18M4
Service Bulletin/Repair Instructions
aeo18M4 Field Service Campaign D18M4
sbw0005
Service Bulletin/Repair Instructions
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label. Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Labl or OWI." Fillout the form, then select "Review."
sbw31013
Service Bulletin/Repair Instructions
sbw31013 Fifth Wheel Outboard Angle Mount Fastener Change
sbw8329
Service Bulletin/Repair Instructions
In some operating conditions, water may leak into the cab onto the passenger floor through the HVAC fresh air intake on the frontwall on 47,00,4900, and 5700 models.
wp00002
Service Bulletin/Repair Instructions
wp00002 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
ICI18-014
Service Bulletin/Repair Instructions
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0404-18
Service Bulletin/Repair Instructions
0404-18 GHG17 DD8 - Aftertreatment Systems - Diesel Particulate Filter End Cap
0402-18
Service Bulletin/Repair Instructions
0402-18 SPN 625 (CPC) (GHG14)
0401-18
Service Bulletin/Repair Instructions
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
FL750
Service Bulletin/Repair Instructions
FL750 Emissions Recall - Ambient Air Temperature Sensors
DOC-1033354
Service Bulletin/Repair Instructions
SS 1033354 Remanufactured Engine Blocks with Closed Fuel Cooler Return Ports DD Engines
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033333
Service Bulletin/Repair Instructions
SS 1033333 - WST ECC Replacement Jumper Harness Installation.
D17M1
Service Bulletin/Repair Instructions
D17M1 17M1 GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
D17M2
Service Bulletin/Repair Instructions
D17M2 17M2-REV GHG17 Heavy Duty Engine Platform Front Engine Lifter Bracket
D17M2-REV
Service Bulletin/Repair Instructions
D17M2-REV GHG17 Heavy Duty Engine Platform Front Engine Lifter Bracket
MY18M1
Service Bulletin/Repair Instructions
MY18M1a 05-MAR-2018 Vocational
aeo18M1
Service Bulletin/Repair Instructions
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
sbw4206
Service Bulletin/Repair Instructions
sbw4206 Brake Shimmy?Meritor® SteeLite X30? Brake Drum With Excessive Runout
sbw5439
Service Bulletin/Repair Instructions
sbw5439 RX Module Fault Codes
fsbw42009
Service Bulletin/Repair Instructions
fsbw42009 Diagnostic de fuite d'air
fsbw42010
Service Bulletin/Repair Instructions
fsbw42010 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
fsbw49019
Service Bulletin/Repair Instructions
fsbw49019 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du raccordement du doseur
ssbw42010
Service Bulletin/Repair Instructions
ssbw42010 Inspección de fugas de aire del transportista concesionario
ssbw49019
Service Bulletin/Repair Instructions
ssbw49019 Manguera de presión del líquido de escape diésel (DEF) desconectada en la conexión del dosificador
17TL26
Service Bulletin/Repair Instructions
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
Service Bulletin/Repair Instructions
17TL27 Injector Cup Tool DSN930E17001
17TL28
Service Bulletin/Repair Instructions
17TL28 Fuel Injector Removal Tool DSN930E17004
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
42-010
Service Bulletin/Repair Instructions
Transport Dealer Air Leak Inspection
49-019
Service Bulletin/Repair Instructions
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
FL746
Service Bulletin/Repair Instructions
Western Star Battery Cable Routing
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
FL742
Service Bulletin/Repair Instructions
Freightliner and Western Star Tow Hooks
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
1102-17
Service Bulletin/Repair Instructions
SPN 157 (MCM) (GHG17)
1101-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Noisy One-Box Aftertreatment
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Service Bulletin/Repair Instructions
Instructions for CSC Diagnostic Support
17-023
Service Bulletin/Repair Instructions
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
sbw31012
Service Bulletin/Repair Instructions
Towing Procedures
DOC-1033195
Service Bulletin/Repair Instructions
DOC-1033195 WST Doors Locking Immediately After Locking or Closing the Door
DOC-1033215
Service Bulletin/Repair Instructions
DOC-1033215 Windshield Aesthetic Inside Trim not Secured Correctly or Loose
DOC-1033220
Service Bulletin/Repair Instructions
DOC-1033220 WST 4700 Headlight Bezel Chrome Wrinkling
DOC-1033223
Service Bulletin/Repair Instructions
DOC-1033223 WST 4700 with Cummins Engine Hood Strap Wrapping Around AC Pressure Switch
0904-17
Service Bulletin/Repair Instructions
Aftertreatment Systems - Diesel Exhaust Fluid Pump Module and Components
0903-17
Service Bulletin/Repair Instructions
Engine Manufacturer Diagnostics
0902-17
Service Bulletin/Repair Instructions
SPN 3556 (ACM) (GHG14)
17TS12Rev1
Service Bulletin/Repair Instructions
17TS12Rev1 GHG17 Heavy Duty Engine Platform 1-BOX? Aftertreatment System ATS Wire Harness
0806-17
Service Bulletin/Repair Instructions
0806-17 SPN 101 (MCM)(GHG17)
0803-17
Service Bulletin/Repair Instructions
0803-17 SPN 411 (MCM) (GHG17)
sbw54065
Service Bulletin/Repair Instructions
sbw54065 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure Guage
0701-17
Service Bulletin/Repair Instructions
SPN 168 (CPC3) (GHG17)
RVSD-MY17M1
Service Bulletin/Repair Instructions
Bulletin_Revised_09May17 GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
sbw0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
sbw5464
Service Bulletin/Repair Instructions
Fuel Level Sending Unit Retrofit
0609-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0608-17
Service Bulletin/Repair Instructions
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
Service Bulletin/Repair Instructions
SPN 96 (MCM) (GHG17)
0606-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0604-17
Service Bulletin/Repair Instructions
SPN 712 (CPC) (GHG17)
0603-17
Service Bulletin/Repair Instructions
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Service Bulletin/Repair Instructions
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
17TL7Rev
Service Bulletin/Repair Instructions
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
17TS11
Service Bulletin/Repair Instructions
Detroit? DT12? Transmission Proper Moving Procedure
17TL8Rev1
Service Bulletin/Repair Instructions
Vehicle Interface Module
sbw42008
Service Bulletin/Repair Instructions
Rear Axle S-Cam Support Bracket Replacement
sbw49017
Service Bulletin/Repair Instructions
Magnetized Fill Neck for Six-Gallon DEF Tanks
0412-17
Service Bulletin/Repair Instructions
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
0411-17
Service Bulletin/Repair Instructions
SPN 5741 (ACM) (GHG17)
0410-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Hard Start No Start
17TS10
Service Bulletin/Repair Instructions
Detroit? DT12? Split Rod Bushing Repair
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
Service Bulletin/Repair Instructions
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0407-17
Service Bulletin/Repair Instructions
GHG17 Heavy Duty- Exhaust & EGR - EGR Actuator Coolant Lines
0406-17
Service Bulletin/Repair Instructions
SPN 521221 (TCM)
0405-17
Service Bulletin/Repair Instructions
SPN 521222 (TCM)
0403-17
Service Bulletin/Repair Instructions
SPN 677 FMI 2 Starter Switch Inconsistent Diagnostics
0402-17
Service Bulletin/Repair Instructions
SPN 1322 (MCM) (GHG17)
0401-17
Service Bulletin/Repair Instructions
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
0329-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Oil Leaks
0328-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0327-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0326-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0325-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0324-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0323-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0322-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0321-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0320-17
Service Bulletin/Repair Instructions
(MCM)(GHG17)
0319-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0318-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0317-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0316-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0315-17
Service Bulletin/Repair Instructions
GHG14 - Intake Manifold Pressure Too Low
0314-17
Service Bulletin/Repair Instructions
GHG14 Intake Manifold Pressure Too Low
0313-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0312-17
Service Bulletin/Repair Instructions
(MCM) GHG17
0311-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0310-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0309-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0308-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17 SPN
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0306-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0305-17
Service Bulletin/Repair Instructions
Diagnostic Tests
0304-17
Service Bulletin/Repair Instructions
Contaminated Fluids Diagnostic Tests
0303-17
Service Bulletin/Repair Instructions
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17
Service Bulletin/Repair Instructions
0301-17 Contaminated Fluids
0302-17
Service Bulletin/Repair Instructions
(CPC)(GHG17)
0346-17
Service Bulletin/Repair Instructions
(CPC) (GHG17)
0356-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0356-17 SPN
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0208-17 SPN 412
Service Bulletin/Repair Instructions
0208-17 SPN 412 (MCM) (GHG17)
0206-17 SPN 5210
Service Bulletin/Repair Instructions
0206-17_ SPN 521049 (MCM) (GHG17)
0205-17 SPN 5210
Service Bulletin/Repair Instructions
0205-17 SPN 521052 (MCM) (GHG17)
0204-17 SPN 5210
Service Bulletin/Repair Instructions
0204-17 SPN 521050 (MCM) (GHG17)
0203-17 SPN 5741
Service Bulletin/Repair Instructions
0203-17 SPN 5741 FMI 13 (GHG17) (MCM)
18SP733
Service Bulletin/Repair Instructions
18SP733 GHG17 Medium Duty DD8 Oil Filter Kit
0131-17
Service Bulletin/Repair Instructions
0131-17 SPN 521054 (CPC3) (GHG17)
0132-17
Service Bulletin/Repair Instructions
0132-17 SPN 521005 (CPC3) (GHG17)
0133-17
Service Bulletin/Repair Instructions
0133-17 SPN 625 (CPC) (GHG17)
0134-17
Service Bulletin/Repair Instructions
0134-17 Medium Duty - DD5 GHG17 - Exhaust and EGR - EGR Cooler Lower Bracket
0135-17
Service Bulletin/Repair Instructions
0135-17 Diagnostic Test - Engine Brake Test Procedure
0136-17
Service Bulletin/Repair Instructions
0136-17 GHG17 DD5 Medium Duty - Exhaust and EGR - Turbocharger Oil
0137-17
Service Bulletin/Repair Instructions
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0138-17
Service Bulletin/Repair Instructions
0138-17 GHG17 DD5 Medium Duty - Exhaust and EGR - EGR Delivery
0139-17
Service Bulletin/Repair Instructions
0139-17 Coolant Housing
0140-17
Service Bulletin/Repair Instructions
0140-17 Turbocharger Compressor Outlet Pipe
0130-17
Service Bulletin/Repair Instructions
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0129-17
Service Bulletin/Repair Instructions
0129-17 SPN 102 (MCM) (GHG17)
0127-17
Service Bulletin/Repair Instructions
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0126-17
Service Bulletin/Repair Instructions
0126-17 SPN 520295 (MCM) (GHG17) - Smart Remote Actuator 1
0125-17
Service Bulletin/Repair Instructions
0125-17 SPN 4817 (MCM) (GHG17)
0124-17
Service Bulletin/Repair Instructions
0124-17 SPN 3720 FMI 14 - (MCM) (GHG17)
0123-17
Service Bulletin/Repair Instructions
0123-17 SPN 1483 (CPC3) (GHG17)
0122-17
Service Bulletin/Repair Instructions
0122-17 SPN 521058 (CPC3) (GHG17)
0121-17
Service Bulletin/Repair Instructions
0121-17 SPN 521050 (CPC3) (GHG17)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0119-17
Service Bulletin/Repair Instructions
0119-17 SPN 3217 (MCM) (GHG17)
0117-17
Service Bulletin/Repair Instructions
0117-17 SPN 5928 (MCM) (GHG17) - EGR H Bridge circuit diagnostics
0116-17
Service Bulletin/Repair Instructions
0116-17 SPN 4752 (MCM) (GHG17) - EGR Cooler Efficiency Fault Codes
0115-17
Service Bulletin/Repair Instructions
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0111-17
Service Bulletin/Repair Instructions
0111-17 SPN 1077 (MCM)(GHG17)
0107-17
Service Bulletin/Repair Instructions
0107-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0106-17
Service Bulletin/Repair Instructions
0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
sbw01017
Service Bulletin/Repair Instructions
Retrofitting Trelleborg Engine Mounts for EPA07 and Newer
1213-16
Service Bulletin/Repair Instructions
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
1207-16
Service Bulletin/Repair Instructions
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
SBW98003
Service Bulletin/Repair Instructions
Paint Peeling, Hood.
16TL20
Service Bulletin/Repair Instructions
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
Service Bulletin/Repair Instructions
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
16TS21
Service Bulletin/Repair Instructions
16TS21 GHG17 DD PLATFORM ENGINES WITH CODE SPN: 3217 FMI: 2, SCR INLET NOX SENSOR LAMBDA DRIFT LOW OR CODE SPN: 3227 FMI: 2, SCR OUTLET NOX SENSOR LAMBDA DRIFT LOW
1018-16
Service Bulletin/Repair Instructions
1018-16 SYMPTOM DIAGNOSTICS - NOISE
16TL18
Service Bulletin/Repair Instructions
16TL18 GHG17 MEDIUM DUTY (MD) TEST ELECTRONIC CONTROL UNITS (ECUS)
1017-16
Service Bulletin/Repair Instructions
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
1016-16
Service Bulletin/Repair Instructions
1016-16 DIAGNOSTIC TEST - ENGINE OIL LEAKS
16TL17
Service Bulletin/Repair Instructions
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
1005-16
Service Bulletin/Repair Instructions
1005-16 SPN 4364 (ACM) (GHG17)
16TL14REV
Service Bulletin/Repair Instructions
16TL14REV GHG17 CAMSHAFT TIMING TOOL SET W470589062300
1004-16
Service Bulletin/Repair Instructions
1004-16 SPN 3511 (ACM) (GHG17)
1003 SPN 3509
Service Bulletin/Repair Instructions
SPN 3509 (ACM) (GHG17)
1002-16
Service Bulletin/Repair Instructions
1002-16 SPN 3512 (ACM) (GHG17)
1001-16
Service Bulletin/Repair Instructions
1001-16 SPN 3719 (ACM) (GHG17)
18SP713REV 18SP7
Service Bulletin/Repair Instructions
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
FL718
Service Bulletin/Repair Instructions
FL718 FRONT AXLE HUB RATING
SBW0004
Service Bulletin/Repair Instructions
SBW0004 WESTERN STAR COURTESY ENGINEERING POLICY
16 CSA-20
Service Bulletin/Repair Instructions
NEW DIAGNOSTICLINK®ORDER SYSTEM DEAUTHORIZATION FEATURE
16 CSA-19
Service Bulletin/Repair Instructions
RELEASE OF DIAGNOSTICLINK® SPANISH LANGUAGE PACK
09 11-16
Service Bulletin/Repair Instructions
0911-16 SPN 1761 (ACM) (GHG17)
09 10-16
Service Bulletin/Repair Instructions
0910-16 SPN 3251 (ACM) (GHG17)
09 09-16
Service Bulletin/Repair Instructions
0909-16 EXCESSIVE OIL CONSUMPTION
09 06-16
Service Bulletin/Repair Instructions
0906-16 LOW PRESSURE FUEL PUMP
09 05-16
Service Bulletin/Repair Instructions
0905-16 SPN 100 (MCM) (GHG17)
09 02-16
Service Bulletin/Repair Instructions
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
09 01-16
Service Bulletin/Repair Instructions
0901-16 SPN 5927 (MCM) (GHG17)
18SP732
Service Bulletin/Repair Instructions
GHG17 MEDIUM DUTY OIL FILTER KIT SPECIAL NOTICE
16 TL-15
Service Bulletin/Repair Instructions
16TL15 GHG17 HEAVY DUTY (HD) TEST ELECTRONIC CONTROL UNITS (ECUS)
16 CSA-18
Service Bulletin/Repair Instructions
16CSA18 RELEASE OF DIAGNOSTICLINK® 8.04 SERVICE PACK 2
16 TS-17
Service Bulletin/Repair Instructions
16TS17 GHG17 DD PLATFORM AMBIENT AIR TEMPERATURE SENSOR AND FAULT CODES
08 14-16
Service Bulletin/Repair Instructions
0814-16 SPN 5016 (ACM) (GHG17)
08 13-16
Service Bulletin/Repair Instructions
0813-16 SPN 3251 (ACM) (GHG17)
08 11-16
Service Bulletin/Repair Instructions
0811-16 CAMSHAFT AND IDLER GEAR
08 10-16
Service Bulletin/Repair Instructions
0810-16 SYMPTOM DIAGNOSTIC NOISE
16 TS-16
Service Bulletin/Repair Instructions
16TS16 DETROIT DT12 TRANSMISSION OIL AND OIL FILL/DRAIN PLUG WASHERS
08 09-16
Service Bulletin/Repair Instructions
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
08 07-16
Service Bulletin/Repair Instructions
0807-16 SPN 524279 (CPC) (GHG17)
08 05-16
Service Bulletin/Repair Instructions
0808-16 SYMPTOM DIAGNOSTICS - ENGINE BRAKE
08 04-16
Service Bulletin/Repair Instructions
0804-16 SPN 5444 (MCM) (GHG17)
08 03-16
Service Bulletin/Repair Instructions
0803-16 SYMPTOM DIAGNOSTICS - COOLANT LOSS
54-55
Service Bulletin/Repair Instructions
SBW5455 VIRTUAL TECHNICIAN RETROFIT
06 24-16
Service Bulletin/Repair Instructions
0624-16 SPN 527 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 23-16
Service Bulletin/Repair Instructions
0623-16 SPN 3645 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 21-16
Service Bulletin/Repair Instructions
0621-16 SPN 3847 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 20-16
Service Bulletin/Repair Instructions
0620-16 SPN 602 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 19-16
Service Bulletin/Repair Instructions
0619-16 SPN 629 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 18-16
Service Bulletin/Repair Instructions
0618-16 SPN 4364 (ACM) (GHG17) DIAGNOSTIC PROCEDURE
06 17-16
Service Bulletin/Repair Instructions
0617-16 SPN 972 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
06 16-16
Service Bulletin/Repair Instructions
0616-16 SPN 70 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 15-16
Service Bulletin/Repair Instructions
0615-16 SPN 1243 (CPC)(GHG17) DIAGNOSTIC PROCEDURE
06 14-16
Service Bulletin/Repair Instructions
0614-16 SPN 1592 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
16 TS-13
Service Bulletin/Repair Instructions
GHG17 DD ENGINE PLATFORM WITH WATER-IN-FUEL FAULT CODES SPN: 97 AND MULTIPLE FMI
06 13-16
Service Bulletin/Repair Instructions
0613-16 SPN 1590 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
ICI16-011
Service Bulletin/Repair Instructions
ALLISON TECH TIP #TT7831EN TRANSMISSION PROGRAMMING
06 12-16
Service Bulletin/Repair Instructions
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 11-16
Service Bulletin/Repair Instructions
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 10-16
Service Bulletin/Repair Instructions
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 09-16
Service Bulletin/Repair Instructions
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
06 08-16
Service Bulletin/Repair Instructions
0608-16 SPN 715 (CPC) (EPA07;EPA10); SPN 715 (CPC) (GHG14); SPN 715 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
06 06-16
Service Bulletin/Repair Instructions
0606-16 SPN 630 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
06 05-16
Service Bulletin/Repair Instructions
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 01-16
Service Bulletin/Repair Instructions
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
20-28
Service Bulletin/Repair Instructions
SURGE TANK CRACKS AT FILLER NECK
16TS11
Service Bulletin/Repair Instructions
GHG17 DD Platform Engines And Coolant Temperature Sensor Codes
16TL10
Service Bulletin/Repair Instructions
Engine Barring Tool W904589046300 Usage on GHG17 Heavy Duty Engines
0501-16
Service Bulletin/Repair Instructions
SPN 84 (MCM & CPC) (GHG17)
0502-16
Service Bulletin/Repair Instructions
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
0504-16
Service Bulletin/Repair Instructions
Inspection of the DD13 Turbocharger
0506-16
Service Bulletin/Repair Instructions
SPN 168 (ACM) (GHG17)
0507-16
Service Bulletin/Repair Instructions
FMI 5 Oil Pressure Sensor Stuck High
0508-16
Service Bulletin/Repair Instructions
SPN 108 (ACM) (GHG17)
0509-10
Service Bulletin/Repair Instructions
SPN 3716 (MCM) (GHG17)
0510-16 SPN 2623
Service Bulletin/Repair Instructions
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
0512-16
Service Bulletin/Repair Instructions
GHG17 Diesel Oxidation Catalyst Face Cleaning
0513-16
Service Bulletin/Repair Instructions
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
0514-16
Service Bulletin/Repair Instructions
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
0515-16
Service Bulletin/Repair Instructions
Exhaust Gas Recirculation Valve
0516-16
Service Bulletin/Repair Instructions
SPN 3511 (CPC)(GHG17)
0517-16
Service Bulletin/Repair Instructions
SPN 168 (ACM) (GHG17)
0518-16
Service Bulletin/Repair Instructions
SPN 5443 (ACM)(GHG17) and SPN 520372 (ACM)(GHG17)
0520-16
Service Bulletin/Repair Instructions
SPN 609 (CPC)(GHG17) and SPN 609 (CPC) (GHG14)
0521-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 1 13 Circuit
0522-16
Service Bulletin/Repair Instructions
SPN 709 (CPC)(GHG17)
0523-16
Service Bulletin/Repair Instructions
SPN 710 (CPC)(GHG17)
0526-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 3 12 Circuit
0529-16
Service Bulletin/Repair Instructions
SPN 711 (CPC)(GHG17)
0530-16
Service Bulletin/Repair Instructions
SPN 712 (CPC)(GHG17)
0531-16
Service Bulletin/Repair Instructions
SPN 714 (CPC)(GHG17)
0532-16
Service Bulletin/Repair Instructions
SPN 524286 (TCM)
0533-16
Service Bulletin/Repair Instructions
SPN 716 (CPC)(GHG17)
sbw3215
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
18SP731
Service Bulletin/Repair Instructions
18SP731 GHG17 Heavy Duty Flywheel Special Notice
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
Service Bulletin/Repair Instructions
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
Service Bulletin/Repair Instructions
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
15CSA24
Service Bulletin/Repair Instructions
15CSA24 GHG17 RAPID WARRANTY PARTS RETURN
18SP722
Service Bulletin/Repair Instructions
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
AEO15M1
Service Bulletin/Repair Instructions
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
SBW2027
Service Bulletin/Repair Instructions
SBW2027 GENTECH COOLANT-LEVEL SENSOR TESTING
SBW2603
Service Bulletin/Repair Instructions
SBW2603 EATON TRANSMISSION POPPING OUT OF GEAR
15TL21
Service Bulletin/Repair Instructions
15TL21 GHG17 Diagnostic Connector Update
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
901-15
Service Bulletin/Repair Instructions
901-15 Oil Breather Vent
sbw5401
Service Bulletin/Repair Instructions
sbw5401 Turn Signal and Brake Override Circuit
sbw8325
Service Bulletin/Repair Instructions
sbw8325 Side Window Defroster and Cooling Improvement Retrofit
sbw9801
Service Bulletin/Repair Instructions
sbw9801 Paint Finish Standards
711-15
Service Bulletin/Repair Instructions
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
708-15
Service Bulletin/Repair Instructions
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
703-15
Service Bulletin/Repair Instructions
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
Service Bulletin/Repair Instructions
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
Service Bulletin/Repair Instructions
704-15 SPN 4364 (ACM)(EPA10)
sbw5457
Service Bulletin/Repair Instructions
sbw5457 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sbw5463
Service Bulletin/Repair Instructions
sbw5463 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
sbw2024
Service Bulletin/Repair Instructions
sbw2024 OAT Coolant Replaces NOAT Coolant in Detroit Engines
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
sbw2023
Service Bulletin/Repair Instructions
sbw2023 Modine Copper/Brass Bolted Downflow Radiator Rebuilding
sbw3110
Service Bulletin/Repair Instructions
sbw3110 Step Clamps Are Not Reusable
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
326-15
Service Bulletin/Repair Instructions
326-15 Main Shaft Speed Sensor
324-15
Service Bulletin/Repair Instructions
324-15 External Component Repair
323-15
Service Bulletin/Repair Instructions
323-15 Symptom Diagnostics ? Noise
15-009
Service Bulletin/Repair Instructions
15-009 New Detroit Standard Diagnostic Times
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
308-15
Service Bulletin/Repair Instructions
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
304-15
Service Bulletin/Repair Instructions
304-15 Diagnostic Tests
303-15
Service Bulletin/Repair Instructions
303-15 Contaminated Fluids
302-15
Service Bulletin/Repair Instructions
302-15 Crankshaft Oil Seals
sbw0116
Service Bulletin/Repair Instructions
sbw0116 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
sbw5430
Service Bulletin/Repair Instructions
sbw5430 Disconnecting or Connecting Daytime Running Lights
sbw5461
Service Bulletin/Repair Instructions
sbw5461 Guidelines for Repairing or Replacing an Electrical Harness
20-22
Service Bulletin/Repair Instructions
20-22 - Premature Belt Wear on Cummins ISL
98-1
Service Bulletin/Repair Instructions
98-1 - Paint Finish Standards
0107-15
Service Bulletin/Repair Instructions
0107-15 Enhanced Steam Clean
102-15
Service Bulletin/Repair Instructions
102-15 High Pressure Fuel Pump - Two-Filter System
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TS30
Service Bulletin/Repair Instructions
14TS30 Aftertreatment Harness Diagnostics
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
14TS21
Service Bulletin/Repair Instructions
14TS21 HDEP Camshaft Position Sensor Change
812-14
Service Bulletin/Repair Instructions
812-14 FMI 3, 4: Engine Aux. Shutdown Input Failed High and Low
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
811-14
Service Bulletin/Repair Instructions
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
810-14
Service Bulletin/Repair Instructions
810-14 Clutch Position Sensor
809-14
Service Bulletin/Repair Instructions
809-14 FMI 3, 4, 5, 31: Diesel Exhaust Fluid System Circuit Failed
14TS20
Service Bulletin/Repair Instructions
14TS20 GHG14 Auto-Elevate Feature
807-14
Service Bulletin/Repair Instructions
807-14 FMI 8 SCR Inlet Temperature Signal Spike
804-14
Service Bulletin/Repair Instructions
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14
Service Bulletin/Repair Instructions
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
802-14
Service Bulletin/Repair Instructions
802-14 FMI 3, 4: Diesel Exhaust Fluid Pressure Sensor Circuit Failed High and low
18SP703
Service Bulletin/Repair Instructions
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
801-14
Service Bulletin/Repair Instructions
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14TS18
Service Bulletin/Repair Instructions
14TS18 GHG14 DD Engine EGR System Fault Code
14TS19
Service Bulletin/Repair Instructions
14TS19 DD Platform High Pressure Fuel Lines
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
719-14
Service Bulletin/Repair Instructions
719-14 SPN 84 (CPC) (GHG14)
716-14
Service Bulletin/Repair Instructions
716-14 SPN 4077 (MCM)(EPA07 EPA10;GHG14
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
711-14
Service Bulletin/Repair Instructions
711-14 SPN 107 (CPC) (GHG14
710-14
Service Bulletin/Repair Instructions
710-14 SPN 96 (CPC) (GHG14)
709-14
Service Bulletin/Repair Instructions
709-14 SPN 3216 (MCM) (GHG14)
707-14
Service Bulletin/Repair Instructions
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
706-14
Service Bulletin/Repair Instructions
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
705-14
Service Bulletin/Repair Instructions
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
704-14
Service Bulletin/Repair Instructions
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
703-14
Service Bulletin/Repair Instructions
703-14 SPN 3556 (ACM) (EPA10)
702-14
Service Bulletin/Repair Instructions
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
18SP701
Service Bulletin/Repair Instructions
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
18SP709
Service Bulletin/Repair Instructions
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP710
Service Bulletin/Repair Instructions
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
701-14
Service Bulletin/Repair Instructions
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
16 TS-12
Service Bulletin/Repair Instructions
DETROIT APPROVED PRIMING TOOLS FOR THE KM63 GEN2 FUEL SYSTEMDETROIT APPROVED PRIMING
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
49-13
Service Bulletin/Repair Instructions
49-13 - DEF Return Line Fitting Heater, 6-Gallon Tanks
49-14
Service Bulletin/Repair Instructions
49-14 - DEF Tank Coolant Valve O-Ring Kit
54-57
Service Bulletin/Repair Instructions
54-57 - Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
33-4
Service Bulletin/Repair Instructions
33-4- Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-11
Service Bulletin/Repair Instructions
35-11 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
54-56
Service Bulletin/Repair Instructions
54-56 - Plastic Battery Box Cover Retainer Clip
717-13
Service Bulletin/Repair Instructions
717-13 Oil Pan
712-13
Service Bulletin/Repair Instructions
712-13 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
711-13
Service Bulletin/Repair Instructions
711-13 SPN 100-FMI 4 - ALL YEARS
710-13
Service Bulletin/Repair Instructions
710-13 Metal in the Fuel System - Three-Filter Fuel System
707-13
Service Bulletin/Repair Instructions
707-13 Description and Operation of the HC Doser Fuel Supply Pressure Control Valve - Two Filter System
705-13
Service Bulletin/Repair Instructions
705-13 Test-E Three-Filter Fuel System
702-13
Service Bulletin/Repair Instructions
702-13 Test E Two-Filter Fuel System
sbw5455
Service Bulletin/Repair Instructions
sbw5455 Virtual Technician Retrofit
608-13
Service Bulletin/Repair Instructions
608-13 High Pressure Fuel Flange-Two-Filter System
530-13
Service Bulletin/Repair Instructions
530-13 Low Pressure Fuel Pump ? Two-Filter Fuel System
529-13
Service Bulletin/Repair Instructions
529-13 Operation of the Fuel System - Two-Filter Fuel System
525-13
Service Bulletin/Repair Instructions
525-13 SPN 2791-FMI 7 ? ALL YEARS
sbw3510
Service Bulletin/Repair Instructions
sbw3510 Axle Alignment Specifications
sbw0001
Service Bulletin/Repair Instructions
sbw0001Validity List Western Star
sbw2019
Service Bulletin/Repair Instructions
sbw2019 Kysor Fan Clutch Rocking Runout Inspection
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-043
Service Bulletin/Repair Instructions
12-043-DLR Helpline Available For Additional Support
ICI12-027
Service Bulletin/Repair Instructions
ICI12-027-DLR Interim FL631 Ending - Final Recall to Begin
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
PAB054
Service Bulletin/Repair Instructions
PAB054, USA-ONLY GM MOBILITY AID FORM
Body SRT
Service Bulletin/Repair Instructions
Body SRT Updates -2012.12.12
FL631
Service Bulletin/Repair Instructions
FL631-DLR Perpendicular Aluminum Air Tank Mounting Brackets
sbw4713
Service Bulletin/Repair Instructions
sbw4713 Crank No Start, Loss of Engine Prime on Decked Vehicles
sbw3109
Service Bulletin/Repair Instructions
sbw3109 Huck-Spin 2 Changeover
12-027
Service Bulletin/Repair Instructions
12-027-DLR Detroit and Alliance like Batteries are now interchangeable
sbw4205
Service Bulletin/Repair Instructions
sbw4205 Bendix Air Disc Brake Thermal Overload Issues
sbw4910
Service Bulletin/Repair Instructions
sbw4910 Gentech DEF Coolant-Flow Solenoid, Testing and Replacement
sbw4911
Service Bulletin/Repair Instructions
sbw4911 DEF Gauge Reading Incorrectly
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.