PB-47-900-WST
Service Bulletin/Repair Instructions
Parts Bulletin for Fluorosilicone Fuel Tank Cap Seals
Vehicle report
2020 WESTERN STAR 4700
Service bulletins
155 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB-32-020-WST
Service Bulletin/Repair Instructions
Technical Service Bulletin for TufTrac M12 Bolts
CXA_10_25_Conmet Oil Pan
Other
CX Advocate for ConMet Oil Pan Insert Additional Issues
PB33-005-WST
Service Bulletin/Repair Instructions
Parts Bulletin for Tie Rod Assembly Part Breakdown
TSB26-008-WST
Service Bulletin/Repair Instructions
Service Solution for DT12 Oil Plug Ports
CXA 3_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 1_16_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
CXA 1_16_NOx
Other
CX Advocate for NOx conversion low faults
SS778-WST
Other
Service Solution for Power Steering Reservoir Fill Cap Venting
CXA 11_21_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
WI24-019
Warranty Program/Extension
Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair Time Updates
CXA_10_17_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
SS1023366-Detroit
Other
Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
CXA 8_24_Conmet Oil Pan
Other
CX Advocate for ConMet Oil Pan Insert Additional Failures
CXA 7_24_Conmet Oil Pan
Other
CX Advocate for ConMet Oil Pan Insert Additional Failures
CXA 7_24_NOx
Other
CX Advocate for NOx conversion low faults. Update to CXA 6_24_NOx submission.
CXA 06_24_Clutch Bolts
Other
CX Advocate communication for clutch bolts
CXA 06_24_NOx
Other
CX Advocate communication for NOx conversion low faults
TSB35-023-WST
Service Bulletin/Repair Instructions
Technical Service Bulletin for New Final Drive Over Heat Diagnostic
SS734-WST
Other
Service Solution for Thread Spring Pin Suspension Alignment & Installation
VSWP Customer Letter
Other
Customer letter regarding variable speed water pump.
SS763-WST
Other
Service Solution for DEF Pump Wiring for Cummins CM2450 Engine Controller
SS3144-FTL
Service Bulletin/Repair Instructions
Service Solution for DEF Pump Wiring for Cummins CM2450 Engine Controller
FL974
Service Bulletin/Repair Instructions
Revised Emissions Recall: Cummins DEF Sensor Shortage. REVISION: Some vehicles formerly in Group F have been moved to Group G and have been assigned a new part number as specified in Table 1. An SRT for 'Calibration Code Only: Update or Confirm' has been added, as shown in Table 2, to be used when a new DEF header is not required. There have been some other minor changes to the work instructions and SRT times.
ICI24-006
Service Bulletin/Repair Instructions
Important Campaign Information letter for FL974 - Revised Bulletin & Population
SBW83-030
Service Bulletin/Repair Instructions
Updated Western Star Service Bulletin for HVAC Actuator Replacement
SBW49-020
Service Bulletin/Repair Instructions
Western Star Service Bulletin for DEF Connector Reinforcement Caps
SBW41-002
Service Bulletin/Repair Instructions
Revised Western Star Service Bulletin for Drive Line Vibration. Minor note: added an update of document previously submitted. The related VMRS codes are added
SBW54-074
Service Bulletin/Repair Instructions
Revised Western Star Service Bulletin for Pana-Pacific 540 Radio Controls Not Operating Normally. Minor note: added an update of document previously submitted. The related VMRS codes are added
CALWS83-001REV
Service Bulletin/Repair Instructions
HVAC Actuator Wiring Harness. Revision History: Service kit part number changed from RDH RD5 17147 0 to WWS RD-3-9069-0 on 12/9/21. The wiring harness of the actuator of the fresh air recirculation door, shown in Fig. 1, on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
ICI21-030
Service Bulletin/Repair Instructions
SF626 Western Star Window Replacement Inspection Notification. This letter is to inform you that Field Service Campaign SF626 Western Star Window Replacement Inspection Notification campaign was released.
CALWS83-001
Service Bulletin/Repair Instructions
Customer Advisory Letter for HVAC Actuator Wiring Harness. The wiring harness of the actuator of the fresh air recirculation door, shown in Fig. 1, on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
SBW54-080
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Key Fob ID Retention. Key fobs for remote keyless entry on Western Star vehicles are delivered in packages that include a unique ID for the fob. The ID is required when pairing the key fob with a vehicle.
SS701-WST2021
Service Bulletin/Repair Instructions
Service Solution for DT12 Harness Chaffing - PT Can Faults. Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
TechTalk12347K
Service Bulletin/Repair Instructions
Tech Talk discussion on dash lights not working
TechTalk12331K
Service Bulletin/Repair Instructions
Tech Talk discussion on dash lights not working.
WP21-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
D21M3
Service Bulletin/Repair Instructions
Detroit Field Service Campaign for DT12 Gear Grind During Downshift Software Update.
WP60-100
Service Bulletin/Repair Instructions
Updated Western Star Parts Technical Bulletin for Universal Design Floor Mats. This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals.
20TS-07REV
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Cold Weather Faults on GHG17/21 DD13 with MCM Software Version 14. Due to colder weather, there may be an increase in the frequency of faults, noted below, on GHG17/21 DD13 trucks built after June 5th 2019. This is due to a calibration issue in the current MCM software (14.1.1.5 or 14.2.1.3). New software is scheduled for release in the first quarter of 2021 that will address these faults.
21OEM-06
Service Bulletin/Repair Instructions
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
ICI21-003
Service Bulletin/Repair Instructions
Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R.
WI21-005
Service Bulletin/Repair Instructions
Warranty Information Letter for Body Builder/Truck Equipment Manufacturer Demonstration Program.
WI21-006
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
WI20-014R
Service Bulletin/Repair Instructions
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
WI21-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters. Detroit's TechComm team created visual aids for the network and released exploded view posters for DD platform engines. In early 2021, Detroit added multiple DT12 posters.
TechTalk7155
Service Bulletin/Repair Instructions
Tech Talk discussion on 2020 Western Star, TRW Power Steering Whine.
CALShackle
Service Bulletin/Repair Instructions
Customer Advisory Letter for Threaded Pin and Bushing. Western Star Trucks built in 2020 with threaded pins and bushings have been found with loose shackles on the rear of the steering axle suspension. The pins are seizing from lack of lube causing the shackle to rotate on the pin.
SBW35-018
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
SBW42-014
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Access to Front Brake Zerk Fittings. Certain vehicles with Detroit front axles and Meritor EX-L front air disc brakes do not have access to the front brake zerk fittings for lubrication.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
SBW54-057
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
17TS-05REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Detroit DT12 TCM GHG17 Only; Bootloader Update. On Detroit DT12 equipped vehicles, it may be necessary to complete an additional step in the programming process when updating the TCM software.
20TS-07
Service Bulletin/Repair Instructions
Technical Service Letter for Cold Weather Faults on GHG17/21 DD13 with MCM Software Version 14. Due to colder weather, there may be an increase in the frequency of faults, noted below, on GHG17/21 DD13 trucks built after June 5th 2019. This is due to a calibration issue in the current MCM software (14.1.1.5 or 14.2.1.3). New software is scheduled for release in the first quarter of 2021 that will address these faults.
SBW54-077
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Ordering Options for Aftermarket Power Distribution Modules (PDMs). For certain Western Star 4700 or 5700 vehicles, power distribution modules (PDMs) are typically ordered in the aftermarket by serial number and populated with fuses and circuit breakers. It may take up to three weeks for a serial number specific PDM to be processed, made, and shipped to a dealership. In order to reduce the down time of a vehicle, an alternative PDM may be ordered fully populated with fuses and circuit breakers and delivered the next day. A cost increase may be associated with this option.
SS1034783REV
Service Bulletin/Repair Instructions
Revised Service Solution for 20K Detroit Axle King Pin Lube Access. Western Star trucks equipped with 20k Detroit front axles and disc brakes built up to 8/17/2020 do not have sufficient room to access the king pin grease zerk.
WSTCAE180-2020
Service Bulletin/Repair Instructions
Portland Truck Plant Paint Changes
20TS-06
Service Bulletin/Repair Instructions
DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts. Some GHG17 DD Platform Heavy Duty oil pans may experience an issue with the oil pan drain plug insert spinning during removal or installation while completing an oil change. Leaking may also be observed at the drain plug and/or other plugs in the oil pan.
TechTalk7774
Service Bulletin/Repair Instructions
Tech Talk discussion on SS 1034711 HADLEY MIRROR
18SP736
Service Bulletin/Repair Instructions
Detroit Diesel Special Publication informing about Heavy Duty Friction Style Belt Tensioner Kit. This heavy duty friction style belt tensioner kit contains the belt tensioner and two M10 bolts to correctly pin the friction style belt tensioner. The M10x80mm bolt is used to pin the engine cooling fan drive arm. The M10x50mm bolt is used to pin the engine accessory drive arm.
20TS-03REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform. The revision includes additional information on retrofit and service kits.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
WSTCAE177-2020
Service Bulletin/Repair Instructions
Meritor Transfer Case Updates
SS1034783
Service Bulletin/Repair Instructions
Service Solution for 20K Detroit Axle King Pin Lube Access. WST trucks equipped with 20k Detroit front axles and disc brakes built up to 8/17/2020 do not have sufficient room to access the king pin grease zerk.
WSTCAE176-2020
Service Bulletin/Repair Instructions
Removable Front Tow Hook Changes
ICI20-022R
Service Bulletin/Repair Instructions
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
ICI20-022
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerÃÂÃÂÃÂâÃÂÃÂÃÂÃÂÃÂÃÂÃÂÃÂs location to perform a recall or field service campaign.
WI20-012
Service Bulletin/Repair Instructions
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
WI20-014
Service Bulletin/Repair Instructions
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
SBW31-016
Service Bulletin/Repair Instructions
Western Star Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8âÂÂ18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-10
Service Bulletin/Repair Instructions
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂÃÂÃÂÃÂÃÂî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
20OEM-05
Service Bulletin/Repair Instructions
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
20CSA-09
Service Bulletin/Repair Instructions
Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SBW60-027
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
20OEM-04
Service Bulletin/Repair Instructions
OEM and distributor announcement for Running Change to ACM Software for MY2020. There is an upcoming running change (RC1) for ACM software that will be installed when OEMs or distributors program with DiagnosticLink. The hardware part number for the ACM module will remain the same (A 000 446 97 54). OEMs are instructed to continue ordering the same ACM hardware part number.
20TS-03REV
Service Bulletin/Repair Instructions
Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
20CSA-08
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
WI20-009
Service Bulletin/Repair Instructions
Warranty Information Letter for a Warranty Service Replacement Engine Program Clarification. Detroit established the Warranty Service Replacement Engine Program to support an unrepairable catastrophic engine failure due to manufacturing defect. To improve understanding and utilization of the program, DTNA is clarifying eligibility and engine returns.
CALABSECU
Service Bulletin/Repair Instructions
Customer Advisory Letter for ABS ECU Software Update. The Enhanced Stability Control (ESC) function within the ABS module that applies to the vehicles in your possession needs to be updated for the axle spread values. The ESC with the current values functions as it should, but should be updated to ensure proper calibration in the future.
20TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
SBW72-008REV
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit. The bulletin dated December 4, 2019 has been revised to include 4800 Models. Beginning 04/01/2019 Western Star cab doors were updated to a new style regulator and window. When replacing an older style regulator or window the vehicle must be retrofitted to the new style regulator and window.
SS1034711
Service Bulletin/Repair Instructions
Service Solution for Hadley Upper Mirror Glass Vibration. The following suggestions are not guaranteed to eliminate or fix the Hadley mirror vibration concern. We have had mixed results in field-testing. In some cases, these solutions eliminate or reduce the vibration and in others, it does not seem to make a difference. DTNA continues to work on a permanent solution to this concern.
SBW54-074REV
Service Bulletin/Repair Instructions
Revision for Service Bulletin for Western Star 4700/5700 Pana-Pacific 540 Radio Controls Not Operating Normally. This bulletin replaces the version dated 03/25/2020. Pana-Pacific DEA540 radios (A22-74389-000, A22-77161-000) may cease to respond to volume control settings from the steering wheel switches or the controls on the radio faceplate, resulting in erratic volume control. This bulletin replaces the version dated March 26, 2020.The procedure to check the current software version of the radio is updated.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SBW54-075
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the back-up light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
CALFTLWS000-01
Service Bulletin/Repair Instructions
Customer Advisory Letter for GWR Label Correction. Freightliner 108SD/114SD, Coronado, New Cascadia, and Business Class M2 vehicles and Western Star 4700 and 4900 vehicles equipped with a certain tire rating have the wrong Component GWR label. DTNA is requesting the current Component GWR label be replaced with the correct label.
CALWS54-002
Service Bulletin/Repair Instructions
Customer Advisory Letter for 6TS RP1226 Dash Harness Circuit Correction. Western Star model 4700 and 5700 vehicles may have reversed terminals 1 and 7 in the 14 pin connector on the A66-12703-000 harness for 6TS that offers the RP1226 connector in the dash.
20CSA-04
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLinkî 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
03.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers.
WP20-002
Service Bulletin/Repair Instructions
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
20CSA-03
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 2 for Diagnostic Link 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
20TS-02
Service Bulletin/Repair Instructions
Technical Service Letter for DD Platform Heavy Duty, Metal in the Oil and Oil Filter. Some engine component failures can cause metallic debris to circulate throughout the engine lubrication system. Although the oil filter will capture most of this debris, some debris may enter the clean side of the lubrication system during oil filter bypass. Detroit has created a lubrication system cleaning and flushing procedure to address this problem.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
SS1034179
Service Bulletin/Repair Instructions
Service Solution on Western Star speedometers. For certain speedometers the speedometer may drop out or the odometer may reset to zero.
SBW54-061
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness. Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
WP20-001REV
Service Bulletin/Repair Instructions
Revision to a Warranty Policy Letter announcing the One Stop Supplier Extended Program Launch. The One Stop Supplier Extended Program streamlines the claim filing process because with One Stop Supplier Extended, the service network will file claims for some supplier-supported coverages in OWL. Revisions are in blue.
20CSA-01
Service Bulletin/Repair Instructions
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a 60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
20CSA-02
Service Bulletin/Repair Instructions
Customer Service Announcement reminding service locations to update their DiagnosticLink software. To maintain access to the Detroit server, all DiagnosticLink computers must be updated with the current version of DiagnosticLink software. all DiagnosticLink 8.08 installed versions will be disabled as of Tuesday, January 28, 2020.
WSTCAE172-2020
Service Bulletin/Repair Instructions
Tractor Reflective Devices
SS1034615
Service Bulletin/Repair Instructions
Service Solution for Western Star Velvac Door Mirror Seal Curling. The rubber that is rolling back is actually a rubber tape. Originally, the mirrors did not have this tape. Velvac added the tape to address some whistling complaints from customers.
SS1034607
Service Bulletin/Repair Instructions
Service Solution for WST 4700 In Cab Floor Raceway Cover Corrosion. Some Western Star 4700 trucks experience rust through of the steel raceway covers located on the cab floor. This is typically seen in applications where the truck is run in environments where harsh chemicals are used such as salt in snowplow applications.
WP20-001
Service Bulletin/Repair Instructions
Warranty Policy Letter announcing the One Stop Supplier Extended Program Launch. The One Stop Supplier Extended Program streamlines the claim filing process because with One Stop Supplier Extended, the service network will file claims for some supplier-supported extended coverages in OWL.
SS1034606
Service Bulletin/Repair Instructions
Service Solution for WST for some Western Star 4700 trucks equipped with PTO where when the driver's door is opened the PTO will disengage.
SBW83-020
Service Bulletin/Repair Instructions
Service Bulletin on A/C System Receiver-Drier Replacement Guidelines.
17TS-12REV
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 Heavy Duty Engine Platform 1-BOX Aftertreatment System (ATS) Wire Harness experiencing chaffing caused by vibration and dirt collecting in the harness conduit.
WI19-022
Service Bulletin/Repair Instructions
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
SBW72-008
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit.
CAL WST 32-002
Service Bulletin/Repair Instructions
Customer Advisory Letter for Airliner welded axle seats. The welded axle seats were installed incorrectly on the rear most drive axle for specific vehicles resulting in an incorrect axle pinion angle. The existing welded axle seats will be removed and replaced with new axle seats installed in the correct orientation.
SS1034577
Service Bulletin/Repair Instructions
Service Solution to address WST Cab drone / vibration / tapping Under acceleration for vehicles w/Eaton Manual Trans.
SS1034579
Service Bulletin/Repair Instructions
Service Solution for prematurely failing coolers on WST Models equipped with Allison Transmissions and Rocore Transmission coolers (07-23256-001) with tow pin front X-member. Part number 07-25266-000 is a direct replacement of the failing coolers and requires no modifications or plumbing changes.
SBW00-004
Service Bulletin/Repair Instructions
Service Bulletin explaining Western Star's courtesy engineering policy.
CALWS15-001
Service Bulletin/Repair Instructions
Customer Advisory Letter for Allison flex plate mounting bolts. The incorrect flex plate mounting bolts were installed for certain vehicles.
TS1034570
Service Bulletin/Repair Instructions
Training Solution provides information related to the new Microgateway (MGW) found on Western Star 4700 Cummins Applications.
SBW32-018
Service Bulletin/Repair Instructions
Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement.
SB98-015
Service Bulletin/Repair Instructions
Service Bulletin for paint finish standards. Delfleet One has been added for aftermarket use. This version replaces service bulletin dated May 5, 2017.
WP19-019
Service Bulletin/Repair Instructions
Warranty Policy letter announcing service locations have 90 calendar days from delivery to open a repair order which Identifies and addresses discrepancies from the sales order.
SS1034499
Service Bulletin/Repair Instructions
Service Solution on failing RX modules in Western Star vehicles.
19-016WP
Service Bulletin/Repair Instructions
WARRANTY POLICY LETTER- Hold disposition for Parts has been eliminated
19-018WI
Service Bulletin/Repair Instructions
WARRANTY INFORMATION LETTER for coverage validation
CAL_WS_42001
Service Bulletin/Repair Instructions
Customer Advisory Letter for WABCO HP air dryer turbo cut-off valve replacement.
SBW98-1
Service Bulletin/Repair Instructions
Service bulletin updating the Important Information section and adding instructions for proper visual inspection distance for paint finish standards.
SS1034531
Service Bulletin/Repair Instructions
Service Solution for WABCO HP air dryer turbo cut-off valve replacement.
19TS-4REV
Service Bulletin/Repair Instructions
Technical Service Letter Revision on heavy duty coolant oil module and oil filter change. Older modules will not be compatible with newer module.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
19-015WP
Service Bulletin/Repair Instructions
Warranty Policy Letter- To assist customers and the service network regarding the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
19CSA-16
Service Bulletin/Repair Instructions
Customer Service Announcement that eParts is being retired and that PartsPro should be used instead for Detroit Engine Parts Information.
19TL-19
Service Bulletin/Repair Instructions
Tool Letter for DAVCO Shop Pro FXP 95-230V compatible for Chile and Italy Electrical Systems
19TL-20
Service Bulletin/Repair Instructions
Tool Letter for DAVCO Shop Pro FXP 95-230V compatible for Australia Electrical Systems.
P&SSep2019
Service Bulletin/Repair Instructions
Parts and Service Committee meeting minutes
DOC-1034500
Service Bulletin/Repair Instructions
Service Solution to fix AC cooling performance due to improper HVAC function.
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB00-08
Service Bulletin/Repair Instructions
Service Bulletin for Dealer Product Report
SB47-015
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
SBW54-073
Service Bulletin/Repair Instructions
Service Bulletin for Powernet Distribution Box Functional Changes
WP19-014
Service Bulletin/Repair Instructions
Warranty Policy Change for Delivery-Related Changes: Electronic Proof of Delivery and Loose Component Claim Filing
15CSA-3REV
Service Bulletin/Repair Instructions
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
CAL WS 46-001
Service Bulletin/Repair Instructions
Customer Advisory Letter for Steering Column Pinch Bolt Inspection
WSTCAE171-2019
Service Bulletin/Repair Instructions
Allison FuelSense 2.0
WSTCAE169-2018
Service Bulletin/Repair Instructions
Electronic Stability Control Requirement for US and Canadian Tractors
TS1033768
Service Bulletin/Repair Instructions
Training Solution for Western Star Front Brake Squeal - Burnishing Procedure. The brake burnishing procedure can be used to help reduce brake related noise or imbalance concerns which may occur in the field.
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
SBW98003
Service Bulletin/Repair Instructions
Paint Peeling, Hood.
TSN 88-07
Service Bulletin/Repair Instructions
Western Star 4700 non removable bug screen with additional coverage to the bumper - TSN
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.