TSB26-008-WST
Service Bulletin/Repair Instructions
Service Solution for DT12 Oil Plug Ports
Vehicle report
2015 WESTERN STAR 5700
Service bulletins
416 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CXA 2_25_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
CXA 1_16_DD13 Altitude
Other
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CXA 1_16_GATS2.4
Other
CX Advocate for GATS2.4 being expanding to DD15
CXA 1_16_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
SS778-WST
Other
Service Solution for Power Steering Reservoir Fill Cap Venting
ICI24-031
Other
Important Campaign Information letter for DDC D23M3 - Campaign Reactivated and Extended. Field Service Campaign D23M3 - GHG17 DETROITTM DD16® Vibration Damper Replacement has been extended for an additional 6 months.
CXA 7_24_Oil Suction
Other
CX Advocate for Oil Suction manifolds
SBW83-030
Service Bulletin/Repair Instructions
Updated Western Star Service Bulletin for HVAC Actuator Replacement
ICI22-017
Service Bulletin/Repair Instructions
Important Campaign Information Letter for DDC D21M1 Termination Date Extended. This letter is to inform you that a revised bulletin for Detroit Diesel Field Service Campaign D21M1, DT12 Transmission Drive Shaft Cover Plug Reseal has been EXTENDED for an additional three months. Please use the extended termination date for all work under D21M1 from this point forward. REVISION: D21M1 termination date extended to July 1, 2022.
SBW49-020
Service Bulletin/Repair Instructions
Western Star Service Bulletin for DEF Connector Reinforcement Caps
ICI21-030
Service Bulletin/Repair Instructions
SF626 Western Star Window Replacement Inspection Notification. This letter is to inform you that Field Service Campaign SF626 Western Star Window Replacement Inspection Notification campaign was released.
SS708-WST2021
Service Bulletin/Repair Instructions
Western Star Service Solution for Low Voltage Disconnect (LVD) Troubleshooting: Western Star 5700 and New 4700.
SBW54-080
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Key Fob ID Retention. Key fobs for remote keyless entry on Western Star vehicles are delivered in packages that include a unique ID for the fob. The ID is required when pairing the key fob with a vehicle.
SS701-WST2021
Service Bulletin/Repair Instructions
Service Solution for DT12 Harness Chaffing - PT Can Faults. Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
16TS-08REV
Service Bulletin/Repair Instructions
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
D21M1
Service Bulletin/Repair Instructions
Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal. Daimler Trucks North America LLC, on behalf of its DETROIT Powertrain Division, is initiating Field Service Campaign D21M1 on certain DT12 transmissions in order to reseal the bypass plugs of the drive shaft cover located in front housing.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
WP21-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
DT12 Trans Chafe
Service Bulletin/Repair Instructions
DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions.
WP60-100
Service Bulletin/Repair Instructions
Updated Western Star Parts Technical Bulletin for Universal Design Floor Mats. This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals.
21OEM-06
Service Bulletin/Repair Instructions
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
D21M2
Service Bulletin/Repair Instructions
DDC Field Service Campaign for GHG14 DETROIT DD13 with One-Box Aftertreatment Software Reprogramming. Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005.
ICI21-003
Service Bulletin/Repair Instructions
Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R.
WI21-006
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
WI20-014R
Service Bulletin/Repair Instructions
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
SBW35-018
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
20TS-09
Service Bulletin/Repair Instructions
Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
18SP744
Service Bulletin/Repair Instructions
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit.
SBW26-005
Service Bulletin/Repair Instructions
Revised Western Star Service Bulletin forDT12 PTO Upfit. This bulletin replaces the version dated 09/23/2019. DDCSN and Power Service Literature references have been removed.
SBW54-057
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
JOYSON LTR
Service Bulletin/Repair Instructions
Joyson Safety Systems letter informing DTNA about Hikone Webbing Investigation. JSS is near completion of an initial investigation regarding data integrity issues at the seatbelt webbing manufacturing facility in Hikone, Japan acquired from Takata in April of 2018.
TechTalk2039
Service Bulletin/Repair Instructions
Tech Talk Discussion for DD15 GHG14 EGR linkage hex nuts.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
TechTalk3253
Service Bulletin/Repair Instructions
Tech Talk Discussion for a Western Star 5700 fault code 2049-9 and 527-9.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
SBW26-004
Service Bulletin/Repair Instructions
Western Star Service Bulletin for DT12 Transmission Cooler Retrofit.
ICI20-022R
Service Bulletin/Repair Instructions
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
ICI20-022
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerÃÂÃÂÃÂâÃÂÃÂÃÂÃÂÃÂÃÂÃÂÃÂs location to perform a recall or field service campaign.
WI20-012
Service Bulletin/Repair Instructions
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
WI20-014
Service Bulletin/Repair Instructions
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
SBW42-013
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Meritor Steer Axle Drum Brake Squeal. Some Western Star 5700 vehicles equipped with Meritor steer axle drum brakes with a front axle rating less than 13,300 lb (6038 kg) have experienced brake squealing noise when the service brakes are applied at lower speeds. NOTE: This is a nuisance noise issue and not a failure. The solution given in this service bulletin may fix this issue.
SBW31-016
Service Bulletin/Repair Instructions
Western Star Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8âÂÂ18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-10
Service Bulletin/Repair Instructions
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂÃÂÃÂÃÂÃÂî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
20OEM-05
Service Bulletin/Repair Instructions
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
20CSA-09
Service Bulletin/Repair Instructions
Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SBW60-027
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
SBW31-015
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement. On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
20CSA-08
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
SBW72-008REV
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit. The bulletin dated December 4, 2019 has been revised to include 4800 Models. Beginning 04/01/2019 Western Star cab doors were updated to a new style regulator and window. When replacing an older style regulator or window the vehicle must be retrofitted to the new style regulator and window.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
D20M1
Service Bulletin/Repair Instructions
Updated DDC Field Service Campaign for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming. Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005. Certain sections have been updated for clarity.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SBW54-075
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the back-up light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
20CSA-04
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLinkî 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
03.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers.
WP20-002
Service Bulletin/Repair Instructions
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
SBW54-061
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness. Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
SBW54-074
Service Bulletin/Repair Instructions
Service Bulletin for Western Star 5700 Pana-Pacific 540 Radio Controls Not Operating Normally. Pana-Pacific DEA540 radios (A22-74389-000, A22-77161-000) may cease to respond to volume control settings from the steering wheel switches or the controls on the radio faceplate, resulting in erratic volume control.
20CSA-01
Service Bulletin/Repair Instructions
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a 60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
SS1034621
Service Bulletin/Repair Instructions
Service Solution for Western Star vehicles equipped with Hendrickson AIRTEK Axles experiencing a Harsh Ride.
SS1034068
Service Bulletin/Repair Instructions
Service Solution for Meritor Wabco OnGuard Radar Service Alignment. If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
SBW83-020
Service Bulletin/Repair Instructions
Service Bulletin on A/C System Receiver-Drier Replacement Guidelines.
WI19-022
Service Bulletin/Repair Instructions
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
SBW72-008
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit.
SS1034577
Service Bulletin/Repair Instructions
Service Solution to address WST Cab drone / vibration / tapping Under acceleration for vehicles w/Eaton Manual Trans.
SS1034538
Service Bulletin/Repair Instructions
Service Solution concerning Western Star 5700 intermittent headlight issues.
D19R5
Service Bulletin/Repair Instructions
Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel lines. Language was clarified that this only applies to Australia and New Zealand.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
19TL-18
Service Bulletin/Repair Instructions
Tool Letter for updating Cascadia and Western Star 5700 oil-to-air coolers. To be used with service bulletins SB26-051 and SB26004 respectively.
P&SSep2019
Service Bulletin/Repair Instructions
Parts and Service Committee meeting minutes
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB26-004
Service Bulletin/Repair Instructions
Service Bulletin for DT12 Transmission Cooler Retrofit
SB26-005
Service Bulletin/Repair Instructions
Service Bulletin for DT12 PTO Upfit
SB47-015
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
15CSA-3REV
Service Bulletin/Repair Instructions
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
19CSA-12 BCT
Service Bulletin/Repair Instructions
PowerNet Assessment Tool Repair Procedure
19TL-10 NVH
Service Bulletin/Repair Instructions
Communication to assist the field with service vibration issues on DTNA vehicles
19TL-11
Service Bulletin/Repair Instructions
Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
19TL-13
Service Bulletin/Repair Instructions
Tool Letter for DT12 Seal Protector Sleeve
D18M4
Service Bulletin/Repair Instructions
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
19CSA-13
Service Bulletin/Repair Instructions
Service Systems Development provided document to service locations on price list reflects current charges to engine horsepower ratings for HDEP and MDEG engine platforms.
19-011WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate Detroit Return Changes
19-012WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
19-013WI
Service Bulletin/Repair Instructions
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
19-010WI
Service Bulletin/Repair Instructions
Warranty Information Letter updated to communicate warranty system updates.
0107-19 GHG17
Service Bulletin/Repair Instructions
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
0308-19 PTO
Service Bulletin/Repair Instructions
Service Information Bulletin regarding PTO Dosing. This feature enables Active Regeneration of the DPFs while in PTO mode.
0419-19SPN521030
Service Bulletin/Repair Instructions
Updates to troubleshooting guides in Diagnostic Link with newest version
0607-19
Service Bulletin/Repair Instructions
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
0611-19
Service Bulletin/Repair Instructions
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP726Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP727Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP729Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP730Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TL-9
Service Bulletin/Repair Instructions
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations. The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
19TS-6
Service Bulletin/Repair Instructions
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
SPN 3563 / FMI 2
Service Bulletin/Repair Instructions
HDEP GHG17 engines are not equipped with turbo wastegates. Steps in this troubleshooting involving wastegates were removed.
sb54313
Service Bulletin/Repair Instructions
Service Bulletin provided to customers regarding installation of a new MCM 21-pin jumper harness.
sbw54067
Service Bulletin/Repair Instructions
Service Bulletin sent out to customers regarding ABS solenoids not doing self check. Correction of this failure involves installing a relay jumper assembly.
sbw54072
Service Bulletin/Repair Instructions
Service Bulletin sent out to customers to repair damaged MCM 21-pin connector, terminals, and minor wiring.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
DOC-1034452
Service Bulletin/Repair Instructions
Training Solution created by DTNA to provide guidance to customers when searching for service information for components and systems not owned by Daimler Trucks North America (DTNA).
sb54072
Service Bulletin/Repair Instructions
HDEP MCM 21 Pin Service Jumper Replacement
sbw0015
Service Bulletin/Repair Instructions
Service Bulletin- sbw0015 Vibration and Harsh Ride Troubleshooting
sbw00017
Service Bulletin/Repair Instructions
Reminder: Paper Service Bulletin Mailings Are Discontinued
DOC-1034171
Service Bulletin/Repair Instructions
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
0109-19
Service Bulletin/Repair Instructions
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Detroit DT12
Service Bulletin/Repair Instructions
Detroit DT12 Split Rod Bushing Repair letter to customer
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
sbw0004
Service Bulletin/Repair Instructions
Service Bulletin-sbw0004 Western Star Courtesy Engineering Policy
18TS4Rev DD
Service Bulletin/Repair Instructions
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
sbw26005 DT12 PT
Service Bulletin/Repair Instructions
Service Bulletin- sbw26005 DT12 PTO Upfit
wp54018 EPA10
Service Bulletin/Repair Instructions
Technical Bulletin wp54018 EPA10 Wiring Harness Ordering
18TL17 DDE W7155
Service Bulletin/Repair Instructions
DDE W715589050700 - Pin Drive Wrench
sbw0015 Vibratio
Service Bulletin/Repair Instructions
Vibration and Harsh ride Troubleshooting
HDEP PLV Return
Service Bulletin/Repair Instructions
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Aftertreamtent F
Service Bulletin/Repair Instructions
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
Service Bulletin/Repair Instructions
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
sbw8329 HVAC Fre
Service Bulletin/Repair Instructions
Service Solution for HVAC Fresh Air Intake Water Leak in certaian Western Star models-4700, 4900, and 5700
0805-18 SPN 5210
Service Bulletin/Repair Instructions
Service Information Bulletin
DOC-1033699
Service Bulletin/Repair Instructions
TS 1033699: DT12 Transmission Driver Interview: Shifting Complaint Questionnaire
DOC-1033768
Service Bulletin/Repair Instructions
TS 1033768: Western Star Front Brake Squeal - Burnishing Procedure
TS1033768
Service Bulletin/Repair Instructions
Training Solution for Western Star Front Brake Squeal - Burnishing Procedure. The brake burnishing procedure can be used to help reduce brake related noise or imbalance concerns which may occur in the field.
D18M1 GHG14 Heav
Service Bulletin/Repair Instructions
Field Service Campaign: GHG14 Heavy Duty Engine Platform Vocational Application Programming
sbw0014
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
DOC-1033273
Service Bulletin/Repair Instructions
SS - 1033273: WST 5700XE Sun Visor Cracks - Mounting Screws Loose
DOC-1033315
Service Bulletin/Repair Instructions
SS 1033315 - WST 5700 Exhaust Pipe Installation Bracket Improvements
DOC-1033403
Service Bulletin/Repair Instructions
SS 1033403 - WST Wiper Motor not Parking Issues
DOC-1033446
Service Bulletin/Repair Instructions
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
DOC-1033462
Service Bulletin/Repair Instructions
SS 1033462 - WST Cab Mounted Mekra Mirror Cover Chrome Peeling
DOC-1033464
Service Bulletin/Repair Instructions
SS: 1033464 - WST 5700XE Sun Visor ? LED Skirt Marker Valance Lights water ingress.
FL756
Service Bulletin/Repair Instructions
FL756 Brake Light Pressure Switches
GHG14 18R3
Service Bulletin/Repair Instructions
GHG14_18R3_bulletin_07-MAY-2018a Emission Recall D18R3
GHG14-18R3
Service Bulletin/Repair Instructions
GHG14-18R3 bulletin-07-MAY-2018a-Emission Recall D18R3
ICI18-016 FL756
Service Bulletin/Repair Instructions
ICI18-016 FL756 ? Automotive Connector Terminal Removal Tool
owner18R3
Service Bulletin/Repair Instructions
owner18R3 Emission Recall D18R3
sbw0005
Service Bulletin/Repair Instructions
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label. Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Labl or OWI." Fillout the form, then select "Review."
sbw31013
Service Bulletin/Repair Instructions
sbw31013 Fifth Wheel Outboard Angle Mount Fastener Change
sbw8329
Service Bulletin/Repair Instructions
In some operating conditions, water may leak into the cab onto the passenger floor through the HVAC fresh air intake on the frontwall on 47,00,4900, and 5700 models.
wp00002
Service Bulletin/Repair Instructions
wp00002 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
ICI18-014
Service Bulletin/Repair Instructions
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0402-18
Service Bulletin/Repair Instructions
0402-18 SPN 625 (CPC) (GHG14)
0401-18
Service Bulletin/Repair Instructions
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033322
Service Bulletin/Repair Instructions
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
MY18M1
Service Bulletin/Repair Instructions
MY18M1a 05-MAR-2018 Vocational
aeo18M1
Service Bulletin/Repair Instructions
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
fsbw42009
Service Bulletin/Repair Instructions
fsbw42009 Diagnostic de fuite d'air
fsbw42010
Service Bulletin/Repair Instructions
fsbw42010 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
fsbw49019
Service Bulletin/Repair Instructions
fsbw49019 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du raccordement du doseur
ssbw42010
Service Bulletin/Repair Instructions
ssbw42010 Inspección de fugas de aire del transportista concesionario
ssbw49019
Service Bulletin/Repair Instructions
ssbw49019 Manguera de presión del líquido de escape diésel (DEF) desconectada en la conexión del dosificador
DOC-1033304
Service Bulletin/Repair Instructions
SS 1033304 -Western Star 5700 Side Window Defrost Performance
17TL26
Service Bulletin/Repair Instructions
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
17TL27
Service Bulletin/Repair Instructions
17TL27 Injector Cup Tool DSN930E17001
17TL28
Service Bulletin/Repair Instructions
17TL28 Fuel Injector Removal Tool DSN930E17004
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
42-010
Service Bulletin/Repair Instructions
Transport Dealer Air Leak Inspection
49-019
Service Bulletin/Repair Instructions
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
1112-17
Service Bulletin/Repair Instructions
Installation of the Transmission
1111-17
Service Bulletin/Repair Instructions
Removal of the Transmission
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
1109-17
Service Bulletin/Repair Instructions
Power Take-Off
1108-17
Service Bulletin/Repair Instructions
Power Take-Off
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
1104-17
Service Bulletin/Repair Instructions
SPN 520960 (TCM)
1102-17
Service Bulletin/Repair Instructions
SPN 157 (MCM) (GHG17)
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
17TS17Rev
Service Bulletin/Repair Instructions
Instructions for CSC Diagnostic Support
17-023
Service Bulletin/Repair Instructions
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
sbw31012
Service Bulletin/Repair Instructions
Towing Procedures
sbw54066
Service Bulletin/Repair Instructions
ICU4Me Low Air Pressure Warning Change
DOC-1033174
Service Bulletin/Repair Instructions
DOC-1033174 WST 5700 Aux Mirror Does Not Fold
17TL19
Service Bulletin/Repair Instructions
Meritor Wabco Bench Programming Kit DWA4008509600
0903-17
Service Bulletin/Repair Instructions
Engine Manufacturer Diagnostics
0902-17
Service Bulletin/Repair Instructions
SPN 3556 (ACM) (GHG14)
sbw0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
sbw5464
Service Bulletin/Repair Instructions
Fuel Level Sending Unit Retrofit
0609-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0608-17
Service Bulletin/Repair Instructions
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
Service Bulletin/Repair Instructions
SPN 96 (MCM) (GHG17)
0606-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0604-17
Service Bulletin/Repair Instructions
SPN 712 (CPC) (GHG17)
0603-17
Service Bulletin/Repair Instructions
Fuel System Integrity Check Routine - Two-Filter Fuel System
0602-17
Service Bulletin/Repair Instructions
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
0601-17
Service Bulletin/Repair Instructions
SPN 3464 (MCM) (GHG14)
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
17TL7Rev
Service Bulletin/Repair Instructions
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
17TS11
Service Bulletin/Repair Instructions
Detroit? DT12? Transmission Proper Moving Procedure
sbw49017
Service Bulletin/Repair Instructions
Magnetized Fill Neck for Six-Gallon DEF Tanks
0412-17
Service Bulletin/Repair Instructions
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
17TS10
Service Bulletin/Repair Instructions
Detroit? DT12? Split Rod Bushing Repair
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
Service Bulletin/Repair Instructions
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0406-17
Service Bulletin/Repair Instructions
SPN 521221 (TCM)
0405-17
Service Bulletin/Repair Instructions
SPN 521222 (TCM)
0401-17
Service Bulletin/Repair Instructions
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
0315-17
Service Bulletin/Repair Instructions
GHG14 - Intake Manifold Pressure Too Low
0314-17
Service Bulletin/Repair Instructions
GHG14 Intake Manifold Pressure Too Low
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0303-17
Service Bulletin/Repair Instructions
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17
Service Bulletin/Repair Instructions
0301-17 Contaminated Fluids
sbw60026
Service Bulletin/Repair Instructions
Roof Fairing Support, 82-Inch Sleeper Cab
ICI17-002
Service Bulletin/Repair Instructions
FL721 Interim Recall Ending ? Final Recall to Begin
0202-17
Service Bulletin/Repair Instructions
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
FL721
Service Bulletin/Repair Instructions
FL721 CNG Fuel Tank and CPDM Mounting Location
FL725
Service Bulletin/Repair Instructions
FL725 Western Star Seat Belt Anchor Plates
0137-17
Service Bulletin/Repair Instructions
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17
Service Bulletin/Repair Instructions
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17
Service Bulletin/Repair Instructions
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0115-17
Service Bulletin/Repair Instructions
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
0106-17
Service Bulletin/Repair Instructions
0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
1213-16
Service Bulletin/Repair Instructions
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
1207-16
Service Bulletin/Repair Instructions
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
SBW98003
Service Bulletin/Repair Instructions
Paint Peeling, Hood.
16TL20
Service Bulletin/Repair Instructions
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
1021-16
Service Bulletin/Repair Instructions
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16
Service Bulletin/Repair Instructions
1018-16 SYMPTOM DIAGNOSTICS - NOISE
1017-16
Service Bulletin/Repair Instructions
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL17
Service Bulletin/Repair Instructions
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
18SP713REV 18SP7
Service Bulletin/Repair Instructions
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
FL718
Service Bulletin/Repair Instructions
FL718 FRONT AXLE HUB RATING
SBW0004
Service Bulletin/Repair Instructions
SBW0004 WESTERN STAR COURTESY ENGINEERING POLICY
16-032
Service Bulletin/Repair Instructions
16-032_DETROIT STANDARD DIAGNOSTIC TIME FOR GHG14 AFTERTREATMENT DEVICE CHECKLIST UPDATED
16 TS-18
Service Bulletin/Repair Instructions
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
09 09-16
Service Bulletin/Repair Instructions
0909-16 EXCESSIVE OIL CONSUMPTION
09 06-16
Service Bulletin/Repair Instructions
0906-16 LOW PRESSURE FUEL PUMP
09 02-16
Service Bulletin/Repair Instructions
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
08 09-16
Service Bulletin/Repair Instructions
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
16 TS-14
Service Bulletin/Repair Instructions
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
54-55
Service Bulletin/Repair Instructions
SBW5455 VIRTUAL TECHNICIAN RETROFIT
SF524AB
Service Bulletin/Repair Instructions
DAIMLER TRUCKS NORTH AMERICA LLC, ON BEHALF OF ITS WHOLLY OWNED SUBSIDIARY, WESTERN STAR TRUCKS SALES INC., IS INITIATING FIELD SERVICE CAMPAIGN SF524AB TO MODIFY THE VEHICLES MENTIONED ABOVE. CERTAIN VEHICLES ARE EXPERIENCING WATER LEAKS AT THE WINDSHIELD AND THE ROOF CAP TO CAB/SLEEPER JOINT. ADDITIONAL SEALANT WILL BE ADDED TO THESE AREAS.
06 12-16
Service Bulletin/Repair Instructions
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 11-16
Service Bulletin/Repair Instructions
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 10-16
Service Bulletin/Repair Instructions
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 09-16
Service Bulletin/Repair Instructions
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
06 08-16
Service Bulletin/Repair Instructions
0608-16 SPN 715 (CPC) (EPA07;EPA10); SPN 715 (CPC) (GHG14); SPN 715 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
16-022
Service Bulletin/Repair Instructions
NEW DETROIT DIESEL EXHAUST FLUID AWNING STANDARD REPAIR TIME
06 05-16
Service Bulletin/Repair Instructions
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
06 01-16
Service Bulletin/Repair Instructions
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0502-16
Service Bulletin/Repair Instructions
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
0504-16
Service Bulletin/Repair Instructions
Inspection of the DD13 Turbocharger
0507-16
Service Bulletin/Repair Instructions
FMI 5 Oil Pressure Sensor Stuck High
0510-16 SPN 2623
Service Bulletin/Repair Instructions
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
0511-16
Service Bulletin/Repair Instructions
FMI 2 CPC Clock Data Invalid
0513-16
Service Bulletin/Repair Instructions
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
0514-16
Service Bulletin/Repair Instructions
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
0519-16
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (EPA10;GHG14)
0521-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 1 13 Circuit
0524-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 3 10 Circuit
0526-16
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 3 12 Circuit
0527-17
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 1 13 Circuit
18SP726rev
Service Bulletin/Repair Instructions
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
sbw2501
Service Bulletin/Repair Instructions
Vehicles equipped with an Eaton Fuller manual transmission may experience clutch release bearing failure due to a blocked throw-out grease hose.
sbw3215
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16TL4
Service Bulletin/Repair Instructions
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS9
Service Bulletin/Repair Instructions
16TS9 DD Platform High Pressure Fuel Lines
16TS8
Service Bulletin/Repair Instructions
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16TL5
Service Bulletin/Repair Instructions
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16TL3
Service Bulletin/Repair Instructions
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16_TL-2
Service Bulletin/Repair Instructions
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0308-16
Service Bulletin/Repair Instructions
0308-16 TCM Programming Instruction
0307-16 SPN 723
Service Bulletin/Repair Instructions
0307-16 SPN 723 (MCM) March
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
16TS5
Service Bulletin/Repair Instructions
16TS5 Release of the DD Platform Bearing Failure Guide
0306-16
Service Bulletin/Repair Instructions
0306-16 TCM SPN 520970 FMI 7
0305-16
Service Bulletin/Repair Instructions
0305-16 TCM SPN 520999 FMI 7 March
0304-16 SPN 2791
Service Bulletin/Repair Instructions
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0302-16
Service Bulletin/Repair Instructions
Contaminated Fluids
0301-16 SPN 625
Service Bulletin/Repair Instructions
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
0303-16
Service Bulletin/Repair Instructions
Hydrocarbon Doser Coolant Lines
SF522
Service Bulletin/Repair Instructions
Western Star 5700 HVAC Fresh Air Inlets
SF525
Service Bulletin/Repair Instructions
Certain vehicles equipped with a Webasto Air Top 2000 auxiliary heater specified an incorrect 7.5-amp fuse rating when a 15-amp fuse is required.
1210-14
Service Bulletin/Repair Instructions
1210-14 Cylinder Head
1207-15
Service Bulletin/Repair Instructions
1207-15 Updated procedures with adding EPA10 to the GHG14 title
1205-15
Service Bulletin/Repair Instructions
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
15TL24
Service Bulletin/Repair Instructions
15TL24 OTC 1750 Revolver Engine Stand
15TS4
Service Bulletin/Repair Instructions
15TS4_Rev2_ EPA07 DD15 Piston Kits
1202-15
Service Bulletin/Repair Instructions
1202-15 Symptom Diagnostics - ATD Checklist
15TS16
Service Bulletin/Repair Instructions
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1201-15
Service Bulletin/Repair Instructions
1201-15 Crankshaft and Bearings
sb1518
Service Bulletin/Repair Instructions
39MT Starter Pinion Teeth Change for 2016 DD13 15 16
sbu1504
Service Bulletin/Repair Instructions
39MT Starter Pinion Teeth Change for 2016 DD13 15 16
sbw1505
Service Bulletin/Repair Instructions
39MT Starter Pinion Teeth Change for 2016 DD13/15/16
14TS16REV
Service Bulletin/Repair Instructions
14TS16REV EXCESSIVE OVERHEAD ENGINE NOISE ON GHG14 DD PLATFORM ENGINES
15M1
Service Bulletin/Repair Instructions
FINAL_15M1_BULLETIN GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
18SP718
Service Bulletin/Repair Instructions
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720
Service Bulletin/Repair Instructions
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP722
Service Bulletin/Repair Instructions
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
AEO15M1
Service Bulletin/Repair Instructions
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
AEO15M3
Service Bulletin/Repair Instructions
AEO15M3 GHG14 DD PLATFORM MODEL YEAR 2015 SOFTWARE REPROGRAMMING
COPY 15M3
Service Bulletin/Repair Instructions
COPY OF TO_BE_POSTED_15M3_SNL_11-NOV-2015
15TL21
Service Bulletin/Repair Instructions
15TL21 GHG17 Diagnostic Connector Update
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
15TS17
Service Bulletin/Repair Instructions
GHG14 DD Platform Engines With Code SPN: 3216 FMI: 18, SCR Inlet NOx Sensor Drift Low
901-15
Service Bulletin/Repair Instructions
901-15 Oil Breather Vent
sbw6025 60-25
Service Bulletin/Repair Instructions
- Adding Fasteners to a Cab-to-Sleeper Transition Panel, 5700 Models
805-15
Service Bulletin/Repair Instructions
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
803-15
Service Bulletin/Repair Instructions
803-15 Removal of the Camshaft Housing
802-15
Service Bulletin/Repair Instructions
802-15 SPN 520970 FMI 7 (TCM)
801-15
Service Bulletin/Repair Instructions
801-15 SPN 520999 FMI 7 (TCM)
SB-54-1
Service Bulletin/Repair Instructions
WESTERN STAR: BRAKE SIGNAL OVERRIDES TURN SIGNAL UNDER NORMAL OPERATIONS, DUE TO TURN SIGNAL SWITCHES AND STOP/TURN LAMPS ARE SHARING SAME FILAMENT AND SOME TRUCKS WANT 4 WAY FLASHERS TO OVERRIDE SELF CANCELLING TURN SIGNAL SWITCHES. NO MODEL YEARS LISTED. CONSTELLATION, HERITAGE, 4700, 4800, 4900, 5700, 5900, 6900. *PE
sbw5401
Service Bulletin/Repair Instructions
sbw5401 Turn Signal and Brake Override Circuit
sbw8325
Service Bulletin/Repair Instructions
sbw8325 Side Window Defroster and Cooling Improvement Retrofit
15TS15
Service Bulletin/Repair Instructions
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
711-15
Service Bulletin/Repair Instructions
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
15TS14 GHG14
Service Bulletin/Repair Instructions
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15
Service Bulletin/Repair Instructions
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
706-15
Service Bulletin/Repair Instructions
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
703-15
Service Bulletin/Repair Instructions
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
702-15
Service Bulletin/Repair Instructions
702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
704-15
Service Bulletin/Repair Instructions
704-15 SPN 4364 (ACM)(EPA10)
sbw3512
Service Bulletin/Repair Instructions
sbw3512 Differential Lubrication, Detroit Model 6 Axles
sbw5457
Service Bulletin/Repair Instructions
sbw5457 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sbw5463
Service Bulletin/Repair Instructions
sbw5463 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
18SP716
Service Bulletin/Repair Instructions
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
FL680
Service Bulletin/Repair Instructions
FL680 Kidde Fire Extinguishers
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15-009
Service Bulletin/Repair Instructions
15-009 New Detroit Standard Diagnostic Times
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
sbw0116
Service Bulletin/Repair Instructions
sbw0116 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
98-1
Service Bulletin/Repair Instructions
98-1 - Paint Finish Standards
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
14-029
Service Bulletin/Repair Instructions
14-029 New Detroit Standard Diagnostic Times
18SP703
Service Bulletin/Repair Instructions
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14TS19
Service Bulletin/Repair Instructions
14TS19 DD Platform High Pressure Fuel Lines
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
16 TS-12
Service Bulletin/Repair Instructions
DETROIT APPROVED PRIMING TOOLS FOR THE KM63 GEN2 FUEL SYSTEMDETROIT APPROVED PRIMING
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-043
Service Bulletin/Repair Instructions
12-043-DLR Helpline Available For Additional Support
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
12-027
Service Bulletin/Repair Instructions
12-027-DLR Detroit and Alliance like Batteries are now interchangeable
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.