PB-47-900-WST
Service Bulletin/Repair Instructions
Parts Bulletin for Fluorosilicone Fuel Tank Cap Seals
Vehicle report
2018 WESTERN STAR 5700
Service bulletins
452 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
TSB26-008-WST
Service Bulletin/Repair Instructions
Service Solution for DT12 Oil Plug Ports
CXA 3_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_NOx
Other
CX Advocate for NOx conversion low faults
CXA 2_25_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
CXA 1_16_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
CXA 1_16_DD13 Altitude
Other
CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
CXA 1_16_GATS2.4
Other
CX Advocate for GATS2.4 being expanding to DD15
CXA 1_16_NOx
Other
CX Advocate for NOx conversion low faults
CXA 1_16_Turbo Oil Drain
Other
CX Advocate for turbo oil drain cracking
SS778-WST
Other
Service Solution for Power Steering Reservoir Fill Cap Venting
CXA 11_21_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
WI24-019
Warranty Program/Extension
Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair Time Updates
CXA_10_17_CARB Truck Chec
Other
CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test submissions for the Clean Truck Check.
SS1023366-Detroit
Other
Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
ICI24-031
Other
Important Campaign Information letter for DDC D23M3 - Campaign Reactivated and Extended. Field Service Campaign D23M3 - GHG17 DETROITTM DD16® Vibration Damper Replacement has been extended for an additional 6 months.
CXA 7_24_NOx
Other
CX Advocate for NOx conversion low faults. Update to CXA 6_24_NOx submission.
CXA 06_24_NOx
Other
CX Advocate communication for NOx conversion low faults
TSB35-023-WST
Service Bulletin/Repair Instructions
Technical Service Bulletin for New Final Drive Over Heat Diagnostic
VSWP Customer Letter
Other
Customer letter regarding variable speed water pump.
SBW83-030
Service Bulletin/Repair Instructions
Updated Western Star Service Bulletin for HVAC Actuator Replacement
ICI22-017
Service Bulletin/Repair Instructions
Important Campaign Information Letter for DDC D21M1 Termination Date Extended. This letter is to inform you that a revised bulletin for Detroit Diesel Field Service Campaign D21M1, DT12 Transmission Drive Shaft Cover Plug Reseal has been EXTENDED for an additional three months. Please use the extended termination date for all work under D21M1 from this point forward. REVISION: D21M1 termination date extended to July 1, 2022.
SBW49-020
Service Bulletin/Repair Instructions
Western Star Service Bulletin for DEF Connector Reinforcement Caps
SBW41-002
Service Bulletin/Repair Instructions
Revised Western Star Service Bulletin for Drive Line Vibration. Minor note: added an update of document previously submitted. The related VMRS codes are added
ICI21-030
Service Bulletin/Repair Instructions
SF626 Western Star Window Replacement Inspection Notification. This letter is to inform you that Field Service Campaign SF626 Western Star Window Replacement Inspection Notification campaign was released.
SS708-WST2021
Service Bulletin/Repair Instructions
Western Star Service Solution for Low Voltage Disconnect (LVD) Troubleshooting: Western Star 5700 and New 4700.
SBW54-080
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Key Fob ID Retention. Key fobs for remote keyless entry on Western Star vehicles are delivered in packages that include a unique ID for the fob. The ID is required when pairing the key fob with a vehicle.
SS701-WST2021
Service Bulletin/Repair Instructions
Service Solution for DT12 Harness Chaffing - PT Can Faults. Transmission will not shift into Gear while driving or will not start and trigger multiple PT CAN Fault Codes.
16TS-08REV
Service Bulletin/Repair Instructions
Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
D21M1
Service Bulletin/Repair Instructions
Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal. Daimler Trucks North America LLC, on behalf of its DETROIT Powertrain Division, is initiating Field Service Campaign D21M1 on certain DT12 transmissions in order to reseal the bypass plugs of the drive shaft cover located in front housing.
WI21-009
Service Bulletin/Repair Instructions
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
WI21-008
Service Bulletin/Repair Instructions
Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021.
WP21-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for battery tags. DTNA determined that since adopting the AutoMeter BCT-460DTNA Powernet Assessment Tool (AutoMeter) as the required powernet system tester, not all battery tags have to be retained support Warranty-related claims.
D21M3
Service Bulletin/Repair Instructions
Detroit Field Service Campaign for DT12 Gear Grind During Downshift Software Update.
DT12 Trans Chafe
Service Bulletin/Repair Instructions
DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions.
WP60-100
Service Bulletin/Repair Instructions
Updated Western Star Parts Technical Bulletin for Universal Design Floor Mats. This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals.
TechTalk8157K
Service Bulletin/Repair Instructions
Tech Talk continuing discussion on if HAS ANYONE ELSE SEEN HEAD GASKETS LEAKING.
TechTalk8157
Service Bulletin/Repair Instructions
Tech Talk discussion on HEAD GASKETS LEAKING OIL ON DD16 AT HEAD GASKET TO BLOCK.
21OEM-06
Service Bulletin/Repair Instructions
Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available. Current subscribers of DiagnosticLink 8.11 or 8.12 may upgrade to DiagnosticLink 8.13 at no cost. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
ICI21-003
Service Bulletin/Repair Instructions
Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately. This letter supersedes ICI20-022R.
WI21-006
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes - Claim Guidelines.
WI20-014R
Service Bulletin/Repair Instructions
Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes. Revisions are in blue font.
WI21-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters. Detroit's TechComm team created visual aids for the network and released exploded view posters for DD platform engines. In early 2021, Detroit added multiple DT12 posters.
21TS-01
Service Bulletin/Repair Instructions
Technical Service Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
21TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps. There is a short supply of exhaust clamps, part number DDE A6809950502, used as inlet and outlet exhaust clamps on GHG17 heavy duty engines (DD13, DD15 and DD16) with a 1-Box aftertreatment configuration. Exhaust clamp part number TCX T130158342AC2 may be used as a substitute for DDE A6809950502, but be aware of the different torque specs between the two parts.
WI21-003
Service Bulletin/Repair Instructions
Warranty Information Letter for Detroit Bearing Failures - Standard Diagnostic Times. DTNA is increasing repair strategies for determining the root cause of Detroit DD heavy duty lower end bearing failures. To support this strategy change, Detroit now has two (2) Standard Diagnostic Times (SDTs), easy and difficult, which can be applied to repair orders.
SBW35-018
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
WP20-018R
Service Bulletin/Repair Instructions
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
WP20-018
Service Bulletin/Repair Instructions
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
20TS-09
Service Bulletin/Repair Instructions
Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
18SP744
Service Bulletin/Repair Instructions
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines Service Kit.
SBW26-005
Service Bulletin/Repair Instructions
Revised Western Star Service Bulletin forDT12 PTO Upfit. This bulletin replaces the version dated 09/23/2019. DDCSN and Power Service Literature references have been removed.
SBW54-057
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
17TS-05REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for Detroit DT12 TCM GHG17 Only; Bootloader Update. On Detroit DT12 equipped vehicles, it may be necessary to complete an additional step in the programming process when updating the TCM software.
20TS-06
Service Bulletin/Repair Instructions
DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts. Some GHG17 DD Platform Heavy Duty oil pans may experience an issue with the oil pan drain plug insert spinning during removal or installation while completing an oil change. Leaking may also be observed at the drain plug and/or other plugs in the oil pan.
18SP736
Service Bulletin/Repair Instructions
Detroit Diesel Special Publication informing about Heavy Duty Friction Style Belt Tensioner Kit. This heavy duty friction style belt tensioner kit contains the belt tensioner and two M10 bolts to correctly pin the friction style belt tensioner. The M10x80mm bolt is used to pin the engine cooling fan drive arm. The M10x50mm bolt is used to pin the engine accessory drive arm.
20TS-03REV2
Service Bulletin/Repair Instructions
Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform. The revision includes additional information on retrofit and service kits.
TechTalk4725
Service Bulletin/Repair Instructions
Tech Talk discussion about power steering fluid.
TechTalk7679
Service Bulletin/Repair Instructions
Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
D20M9
Service Bulletin/Repair Instructions
Detroit Diesel Field Service Campaign for Engine Emission Label Replacement. Certain DETROIT heavy-duty engines installed in various applications will require reprogramming and engine emission label replacement.
TechTalk3253
Service Bulletin/Repair Instructions
Tech Talk Discussion for a Western Star 5700 fault code 2049-9 and 527-9.
20CSA-15
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
WSTCAE176-2020
Service Bulletin/Repair Instructions
Removable Front Tow Hook Changes
SBW26-004
Service Bulletin/Repair Instructions
Western Star Service Bulletin for DT12 Transmission Cooler Retrofit.
ICI20-022R
Service Bulletin/Repair Instructions
Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
ICI20-022
Service Bulletin/Repair Instructions
Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerÃÂÃÂÃÂâÃÂÃÂÃÂÃÂÃÂÃÂÃÂÃÂs location to perform a recall or field service campaign.
WI20-012
Service Bulletin/Repair Instructions
Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
WI20-014
Service Bulletin/Repair Instructions
Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
SBW42-013
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Meritor Steer Axle Drum Brake Squeal. Some Western Star 5700 vehicles equipped with Meritor steer axle drum brakes with a front axle rating less than 13,300 lb (6038 kg) have experienced brake squealing noise when the service brakes are applied at lower speeds. NOTE: This is a nuisance noise issue and not a failure. The solution given in this service bulletin may fix this issue.
SBW31-016
Service Bulletin/Repair Instructions
Western Star Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8âÂÂ18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-10
Service Bulletin/Repair Instructions
Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂÃÂÃÂÃÂÃÂî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
20OEM-05
Service Bulletin/Repair Instructions
OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20TS-05
Service Bulletin/Repair Instructions
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
20CSA-09
Service Bulletin/Repair Instructions
Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SBW60-027
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
SBW31-015
Service Bulletin/Repair Instructions
Western Star Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement. On Freightliner Cascadia and New Cascadia vehicles manufactured before May 20, 2019, and equipped with side-fairings, the magnets that hold the kickplate closed may corrode and prevent the kickplate from staying in the closed position.
20TS-03REV
Service Bulletin/Repair Instructions
Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
20CSA-08
Service Bulletin/Repair Instructions
Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
20TS-03
Service Bulletin/Repair Instructions
Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
SBW72-008REV
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit. The bulletin dated December 4, 2019 has been revised to include 4800 Models. Beginning 04/01/2019 Western Star cab doors were updated to a new style regulator and window. When replacing an older style regulator or window the vehicle must be retrofitted to the new style regulator and window.
WI20-008
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-006
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-007
Service Bulletin/Repair Instructions
Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-005
Service Bulletin/Repair Instructions
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-004
Service Bulletin/Repair Instructions
Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
SBW54-075
Service Bulletin/Repair Instructions
Service Bulletin for Lengthening the Backup Light Harness. Though the back-up light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
20CSA-04
Service Bulletin/Repair Instructions
Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLinkî 8.11 Standard and Professional will be available for download from the Detroit Diesel server.
03.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers.
WP20-002
Service Bulletin/Repair Instructions
Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy, published in DTNA Workshop Manuals, which states that there are very few cases in which welding a heat-treated frame rail is allowed. Therefore, before welding anything on a frame rail, contact the applicable regional service representative for approval.
02.2020 Campaign
Service Bulletin/Repair Instructions
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty managers
SBW54-061
Service Bulletin/Repair Instructions
Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness. Use the guidelines in this bulletin to determine if a damaged electrical harness should be repaired or replaced.
SBW54-074
Service Bulletin/Repair Instructions
Service Bulletin for Western Star 5700 Pana-Pacific 540 Radio Controls Not Operating Normally. Pana-Pacific DEA540 radios (A22-74389-000, A22-77161-000) may cease to respond to volume control settings from the steering wheel switches or the controls on the radio faceplate, resulting in erratic volume control.
20CSA-01
Service Bulletin/Repair Instructions
Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs) will now have a 60-day expiration, starting on the release day of the bulletin. The intent of a SIB is to notify the service network of a major change to one or more service procedures. Do not save SIBs nor reference them for repairs, as they are uncontrolled and never updated.
SS1034621
Service Bulletin/Repair Instructions
Service Solution for Western Star vehicles equipped with Hendrickson AIRTEK Axles experiencing a Harsh Ride.
SS1034068
Service Bulletin/Repair Instructions
Service Solution for Meritor Wabco OnGuard Radar Service Alignment. If the radar sensor needs to be aligned, the radar sensor mounting system has become damaged or has loosened, or new radar sensor software has been installed, a Radar Sensor Service Alignment will need to be performed.
SBW83-020
Service Bulletin/Repair Instructions
Service Bulletin on A/C System Receiver-Drier Replacement Guidelines.
17TS-12REV
Service Bulletin/Repair Instructions
Technical Service Letter for GHG17 Heavy Duty Engine Platform 1-BOX Aftertreatment System (ATS) Wire Harness experiencing chaffing caused by vibration and dirt collecting in the harness conduit.
WI19-022
Service Bulletin/Repair Instructions
Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment Systems
SBW72-008
Service Bulletin/Repair Instructions
Service Bulletin for Window Regulator Retrofit.
SS1034577
Service Bulletin/Repair Instructions
Service Solution to address WST Cab drone / vibration / tapping Under acceleration for vehicles w/Eaton Manual Trans.
SBW00-004
Service Bulletin/Repair Instructions
Service Bulletin explaining Western Star's courtesy engineering policy.
SS1034538
Service Bulletin/Repair Instructions
Service Solution concerning Western Star 5700 intermittent headlight issues.
D19R5
Service Bulletin/Repair Instructions
Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel lines. Language was clarified that this only applies to Australia and New Zealand.
D19M1
Service Bulletin/Repair Instructions
Field Service Campaign for GHG17 Detroit DD16 software reprogramming.
17TS9
Service Bulletin/Repair Instructions
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found on TechLit.
19TL-18
Service Bulletin/Repair Instructions
Tool Letter for updating Cascadia and Western Star 5700 oil-to-air coolers. To be used with service bulletins SB26-051 and SB26004 respectively.
P&SSep2019
Service Bulletin/Repair Instructions
Parts and Service Committee meeting minutes
DOC-1034500
Service Bulletin/Repair Instructions
Service Solution to fix AC cooling performance due to improper HVAC function.
19TL-15
Service Bulletin/Repair Instructions
Tool Letter for ICC5 Programming Cable
SB26-004
Service Bulletin/Repair Instructions
Service Bulletin for DT12 Transmission Cooler Retrofit
SB26-005
Service Bulletin/Repair Instructions
Service Bulletin for DT12 PTO Upfit
SB35-016
Service Bulletin/Repair Instructions
Service Bulletin for Hub Oil Level in Final Drive (NFD) Top Performance Axles on Decked Vehicles
SB47-015
Service Bulletin/Repair Instructions
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
SBW54-073
Service Bulletin/Repair Instructions
Service Bulletin for Powernet Distribution Box Functional Changes
15CSA-3REV
Service Bulletin/Repair Instructions
Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
19CSA-12 BCT
Service Bulletin/Repair Instructions
PowerNet Assessment Tool Repair Procedure
19TL-10 NVH
Service Bulletin/Repair Instructions
Communication to assist the field with service vibration issues on DTNA vehicles
19TL-11
Service Bulletin/Repair Instructions
Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
19TL-12
Service Bulletin/Repair Instructions
Tool Letter for New Final Drive Pinion Cover Install Tool
19TL-13
Service Bulletin/Repair Instructions
Tool Letter for DT12 Seal Protector Sleeve
19TL-14
Service Bulletin/Repair Instructions
Tool Letter for New Final Drive Driver Controlled Differential Lock Spring Compressor. These new axles require a new tool to compress the Driver Controlled Differential Lock (DCDL) spring. To remove and install the DCDL spring, the tool DSN0FDA17001 is needed.
19CSA-13
Service Bulletin/Repair Instructions
Service Systems Development provided document to service locations on price list reflects current charges to engine horsepower ratings for HDEP and MDEG engine platforms.
19-011WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate Detroit Return Changes
19-012WP
Service Bulletin/Repair Instructions
Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
19-013WI
Service Bulletin/Repair Instructions
Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized Demonstrator Program
19-010WI
Service Bulletin/Repair Instructions
Warranty Information Letter updated to communicate warranty system updates.
0107-19 GHG17
Service Bulletin/Repair Instructions
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
0305-19 SPN 2000
Service Bulletin/Repair Instructions
Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC Heartbeat Message is no Longer Arriving)
0308-19 PTO
Service Bulletin/Repair Instructions
Service Information Bulletin regarding PTO Dosing. This feature enables Active Regeneration of the DPFs while in PTO mode.
0419-19SPN521030
Service Bulletin/Repair Instructions
Updates to troubleshooting guides in Diagnostic Link with newest version
0607-19
Service Bulletin/Repair Instructions
Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine Electrical section.
0609-19
Service Bulletin/Repair Instructions
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
0611-19
Service Bulletin/Repair Instructions
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
18SP725Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP726Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP727Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP729Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
18SP730Rev
Service Bulletin/Repair Instructions
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket, P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
19-008WI
Service Bulletin/Repair Instructions
Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
19TL-9
Service Bulletin/Repair Instructions
DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations. The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.
19TS-6
Service Bulletin/Repair Instructions
The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
SPN 3563 / FMI 2
Service Bulletin/Repair Instructions
HDEP GHG17 engines are not equipped with turbo wastegates. Steps in this troubleshooting involving wastegates were removed.
sb54313
Service Bulletin/Repair Instructions
Service Bulletin provided to customers regarding installation of a new MCM 21-pin jumper harness.
sbw54067
Service Bulletin/Repair Instructions
Service Bulletin sent out to customers regarding ABS solenoids not doing self check. Correction of this failure involves installing a relay jumper assembly.
sbw54072
Service Bulletin/Repair Instructions
Service Bulletin sent out to customers to repair damaged MCM 21-pin connector, terminals, and minor wiring.
19-009WI
Service Bulletin/Repair Instructions
Warranty Information Letter - Expanded guidelines for paint-related claims sent out to Freightliner, Western star, Thomas Built Bus, Export and Direct warranty customers
DOC-1034452
Service Bulletin/Repair Instructions
Training Solution created by DTNA to provide guidance to customers when searching for service information for components and systems not owned by Daimler Trucks North America (DTNA).
sb54072
Service Bulletin/Repair Instructions
HDEP MCM 21 Pin Service Jumper Replacement
sbw0015
Service Bulletin/Repair Instructions
Service Bulletin- sbw0015 Vibration and Harsh Ride Troubleshooting
sbw54071
Service Bulletin/Repair Instructions
sbw54071 ICU Odometer Programming
sbw00017
Service Bulletin/Repair Instructions
Reminder: Paper Service Bulletin Mailings Are Discontinued
DOC-1034171
Service Bulletin/Repair Instructions
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
0109-19
Service Bulletin/Repair Instructions
Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
Detroit DT12
Service Bulletin/Repair Instructions
Detroit DT12 Split Rod Bushing Repair letter to customer
FL794
Service Bulletin/Repair Instructions
Brake Caliper Mounting Bolts
FL794 REV
Service Bulletin/Repair Instructions
FL794 Recall Campaign- Brake Caliper Mounting Bolts
ICI19-003 FL794
Service Bulletin/Repair Instructions
FL794 - Revised Bulletin Brake Caliper Mounting Bolts
1208-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
1212-18
Service Bulletin/Repair Instructions
Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
1213-18
Service Bulletin/Repair Instructions
Service Information Bulletin
18TL18
Service Bulletin/Repair Instructions
30mm Air Disc Brake Caliper Bolt Torque Adapter DSNCHA018005
sbw0004
Service Bulletin/Repair Instructions
Service Bulletin-sbw0004 Western Star Courtesy Engineering Policy
18TS4Rev DD
Service Bulletin/Repair Instructions
18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
D18M2
Service Bulletin/Repair Instructions
Field Service Campaign-D18M2 - REVISION 1 GHG17 Detroit DD13® Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc. (MCI®)
GHG17
Service Bulletin/Repair Instructions
Letter to customer on Coverage Extension GHG17 After Treatment
aeoD18M2
Service Bulletin/Repair Instructions
Field Service Campaign D18M2 GHG17 GHG17 Detroit DD13® Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc. (MCI®)
sbw26005 DT12 PT
Service Bulletin/Repair Instructions
Service Bulletin- sbw26005 DT12 PTO Upfit
1001-18 Engine R
Service Bulletin/Repair Instructions
Engine Replacement Procedures
18TL17 DDE W7155
Service Bulletin/Repair Instructions
DDE W715589050700 - Pin Drive Wrench
sbw0015 Vibratio
Service Bulletin/Repair Instructions
Vibration and Harsh ride Troubleshooting
18-032-NoDefectF
Service Bulletin/Repair Instructions
Warranty Bulletin for charge back exemtions
18TS3 DT12 Exhau
Service Bulletin/Repair Instructions
DT12 Exhaust Port Splash Shield
FL766 Western St
Service Bulletin/Repair Instructions
Recall Bulletin FL766- Western Star Power Cable Studs
ICI18-031 FL766
Service Bulletin/Repair Instructions
Important Campaign Information- FL766 Interim Recall Ending ? Final Recall to Begin
Emission Recall
Service Bulletin/Repair Instructions
Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California Onboard Diagnostics
HDEP PLV Return
Service Bulletin/Repair Instructions
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
D18M2 GHG17 Detr
Service Bulletin/Repair Instructions
Field Service Campaign D18M2 GHG17 Detroit? DD13® Software Reprogramming and Emission Label Replacement for Motor Coach Industries, Inc. (MCI®)
Aftertreamtent F
Service Bulletin/Repair Instructions
Service Information Bulletin for Aftertreamtent Failure Guide
DD13, DD15, DD16
Service Bulletin/Repair Instructions
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
18-029 Auto Mete
Service Bulletin/Repair Instructions
Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and Claim Filing
FL772 Brake Cali
Service Bulletin/Repair Instructions
FL772-Dealer bulletin for Brake Caliper Mounting Bolts recall
0803-18 SPN 3031
Service Bulletin/Repair Instructions
Service Information Bulletin
0804-18 SPN 1483
Service Bulletin/Repair Instructions
Service Information Bulletin
0805-18 SPN 5210
Service Bulletin/Repair Instructions
Service Information Bulletin
DOC-1033699
Service Bulletin/Repair Instructions
TS 1033699: DT12 Transmission Driver Interview: Shifting Complaint Questionnaire
DOC-1033768
Service Bulletin/Repair Instructions
TS 1033768: Western Star Front Brake Squeal - Burnishing Procedure
TS1033768
Service Bulletin/Repair Instructions
Training Solution for Western Star Front Brake Squeal - Burnishing Procedure. The brake burnishing procedure can be used to help reduce brake related noise or imbalance concerns which may occur in the field.
0701-18
Service Bulletin/Repair Instructions
TCM update
sbw0014
Service Bulletin/Repair Instructions
Operating Hours for the Customer Assistance Center
0508-18
Service Bulletin/Repair Instructions
0508-18 Aftertreatment
0505-18
Service Bulletin/Repair Instructions
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
0504-18
Service Bulletin/Repair Instructions
0504-18 Fuel System - Fuel Injectors
0503-18
Service Bulletin/Repair Instructions
0503-18 Relative Cylinder Compression Test
0502-18
Service Bulletin/Repair Instructions
0502-18 Symptom Diagnostics - Low Engine Coolant Temperature
0501-18
Service Bulletin/Repair Instructions
0501-18 Aftertreatment Control Module (ACM)
18SP734
Service Bulletin/Repair Instructions
18SP734 18SP734?GHG14 DD15AT Turbocharger
DOC-1033273
Service Bulletin/Repair Instructions
SS - 1033273: WST 5700XE Sun Visor Cracks - Mounting Screws Loose
DOC-1033315
Service Bulletin/Repair Instructions
SS 1033315 - WST 5700 Exhaust Pipe Installation Bracket Improvements
DOC-1033403
Service Bulletin/Repair Instructions
SS 1033403 - WST Wiper Motor not Parking Issues
DOC-1033446
Service Bulletin/Repair Instructions
Vehicles with Meritor drivelines bene from a softer durometer center bearing support. Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
DOC-1033462
Service Bulletin/Repair Instructions
SS 1033462 - WST Cab Mounted Mekra Mirror Cover Chrome Peeling
DOC-1033464
Service Bulletin/Repair Instructions
SS: 1033464 - WST 5700XE Sun Visor ? LED Skirt Marker Valance Lights water ingress.
FL756
Service Bulletin/Repair Instructions
FL756 Brake Light Pressure Switches
FL766
Service Bulletin/Repair Instructions
FL766 Western Star Power Cable Studs
ICI18-016 FL756
Service Bulletin/Repair Instructions
ICI18-016 FL756 ? Automotive Connector Terminal Removal Tool
MY18M4
Service Bulletin/Repair Instructions
MY18M4_Bulletin_02-MAY-2018 Field Service Campaign D18M4
aeo18M4
Service Bulletin/Repair Instructions
aeo18M4 Field Service Campaign D18M4
sbw0005
Service Bulletin/Repair Instructions
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label. Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Labl or OWI." Fillout the form, then select "Review."
sbw31013
Service Bulletin/Repair Instructions
sbw31013 Fifth Wheel Outboard Angle Mount Fastener Change
sbw31014
Service Bulletin/Repair Instructions
sbw31014 Airliner Rear Suspension Crossmember Fastener Change
sbw8329
Service Bulletin/Repair Instructions
In some operating conditions, water may leak into the cab onto the passenger floor through the HVAC fresh air intake on the frontwall on 47,00,4900, and 5700 models.
wp00002
Service Bulletin/Repair Instructions
wp00002 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
ICI18-014
Service Bulletin/Repair Instructions
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
0405-18
Service Bulletin/Repair Instructions
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0404-18
Service Bulletin/Repair Instructions
0404-18 GHG17 DD8 - Aftertreatment Systems - Diesel Particulate Filter End Cap
0402-18
Service Bulletin/Repair Instructions
0402-18 SPN 625 (CPC) (GHG14)
0401-18
Service Bulletin/Repair Instructions
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
0312-18
Service Bulletin/Repair Instructions
0312-18 Installation Output Shaft Seal
0311-18
Service Bulletin/Repair Instructions
0311-18 Installation of the Main Shaft Speed Sensor
DOC-1033322
Service Bulletin/Repair Instructions
SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
MY18M1
Service Bulletin/Repair Instructions
MY18M1a 05-MAR-2018 Vocational
aeo18M1
Service Bulletin/Repair Instructions
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
sbw5464
Service Bulletin/Repair Instructions
sbw5464 Fuel Level Sending Unit Retrofit
fsbw42009
Service Bulletin/Repair Instructions
fsbw42009 Diagnostic de fuite d'air
fsbw42010
Service Bulletin/Repair Instructions
fsbw42010 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
fsbw49019
Service Bulletin/Repair Instructions
fsbw49019 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du raccordement du doseur
ssbw42010
Service Bulletin/Repair Instructions
ssbw42010 Inspección de fugas de aire del transportista concesionario
ssbw49019
Service Bulletin/Repair Instructions
ssbw49019 Manguera de presión del líquido de escape diésel (DEF) desconectada en la conexión del dosificador
DOC-1033304
Service Bulletin/Repair Instructions
SS 1033304 -Western Star 5700 Side Window Defrost Performance
FL758
Service Bulletin/Repair Instructions
FL758 Brake Mounting Caliper Bolts
17CSA22r
Service Bulletin/Repair Instructions
17CSA22r Release of DiagnosticLink® 8.07
17TL25
Service Bulletin/Repair Instructions
17TL25 TruckCam? Alignment System
42-010
Service Bulletin/Repair Instructions
Transport Dealer Air Leak Inspection
49-019
Service Bulletin/Repair Instructions
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
1112-17
Service Bulletin/Repair Instructions
Installation of the Transmission
1111-17
Service Bulletin/Repair Instructions
Removal of the Transmission
1110-17
Service Bulletin/Repair Instructions
Exhaust and Exhaust Gas Recirculation
1109-17
Service Bulletin/Repair Instructions
Power Take-Off
1108-17
Service Bulletin/Repair Instructions
Power Take-Off
1107-17
Service Bulletin/Repair Instructions
SPN 521483 (TCM)
1105-17
Service Bulletin/Repair Instructions
EPA10, GHG14 and GHG17 Diesel Particulate Filters
1104-17
Service Bulletin/Repair Instructions
SPN 520960 (TCM)
1102-17
Service Bulletin/Repair Instructions
SPN 157 (MCM) (GHG17)
1101-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Noisy One-Box Aftertreatment
14CSA23
Service Bulletin/Repair Instructions
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
sbw31012
Service Bulletin/Repair Instructions
Towing Procedures
sbw54066
Service Bulletin/Repair Instructions
ICU4Me Low Air Pressure Warning Change
DOC-1033174
Service Bulletin/Repair Instructions
DOC-1033174 WST 5700 Aux Mirror Does Not Fold
DOC-1033215
Service Bulletin/Repair Instructions
DOC-1033215 Windshield Aesthetic Inside Trim not Secured Correctly or Loose
FL742
Service Bulletin/Repair Instructions
FL742 Freightliner and Western Star Tow Hooks
17TL19
Service Bulletin/Repair Instructions
Meritor Wabco Bench Programming Kit DWA4008509600
17CSA16
Service Bulletin/Repair Instructions
17CSA16 Release of DiagnosticLink® 8.06 Service Pack 1
17TS12Rev1
Service Bulletin/Repair Instructions
17TS12Rev1 GHG17 Heavy Duty Engine Platform 1-BOX? Aftertreatment System ATS Wire Harness
0806-17
Service Bulletin/Repair Instructions
0806-17 SPN 101 (MCM)(GHG17)
0805-17
Service Bulletin/Repair Instructions
0805-17 Contaminated Fluids
0803-17
Service Bulletin/Repair Instructions
0803-17 SPN 411 (MCM) (GHG17)
0802-17
Service Bulletin/Repair Instructions
0802-17 SPN 521485 (TCM)
0801-17
Service Bulletin/Repair Instructions
0801-17 Symptom Diagnostics: Coolant Loss
sbw54065
Service Bulletin/Repair Instructions
sbw54065 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure Guage
0706-17
Service Bulletin/Repair Instructions
Counter Shaft Brake Valve
0705-17
Service Bulletin/Repair Instructions
Diagnostics
0704-17
Service Bulletin/Repair Instructions
Diagnostics
0703-17
Service Bulletin/Repair Instructions
Diagnostics
0702-17
Service Bulletin/Repair Instructions
Diagnostics
0701-17
Service Bulletin/Repair Instructions
SPN 168 (CPC3) (GHG17)
sbw0002
Service Bulletin/Repair Instructions
Technical Publications Ordering
0612-17
Service Bulletin/Repair Instructions
Power Take-Off Position Switch
0611-17
Service Bulletin/Repair Instructions
Power Take-Off Output Seal
0610-17
Service Bulletin/Repair Instructions
Power Take-Off Air Connection Fitting
0609-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0608-17
Service Bulletin/Repair Instructions
Diagnostic tests - Two Filter System - FSIC Leak Test
0607-17
Service Bulletin/Repair Instructions
SPN 96 (MCM) (GHG17)
WSTCAE149-2017
Service Bulletin/Repair Instructions
Air-to-Oil Coolers for DT12 in 5700
0606-17
Service Bulletin/Repair Instructions
SPN 3226 (ACM) (GHG17)
0605-17
Service Bulletin/Repair Instructions
Power Take-Off Air Solenoid
0604-17
Service Bulletin/Repair Instructions
SPN 712 (CPC) (GHG17)
SS1033094
Service Bulletin/Repair Instructions
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
17TL7Rev
Service Bulletin/Repair Instructions
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
17TS11
Service Bulletin/Repair Instructions
Detroit? DT12? Transmission Proper Moving Procedure
17TL8Rev1
Service Bulletin/Repair Instructions
Vehicle Interface Module
sbw49017
Service Bulletin/Repair Instructions
Magnetized Fill Neck for Six-Gallon DEF Tanks
0412-17
Service Bulletin/Repair Instructions
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
0411-17
Service Bulletin/Repair Instructions
SPN 5741 (ACM) (GHG17)
0410-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Hard Start No Start
17TS10
Service Bulletin/Repair Instructions
Detroit? DT12? Split Rod Bushing Repair
0409-17
Service Bulletin/Repair Instructions
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
0408-17 SPN 5242
Service Bulletin/Repair Instructions
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
0407-17
Service Bulletin/Repair Instructions
GHG17 Heavy Duty- Exhaust & EGR - EGR Actuator Coolant Lines
0406-17
Service Bulletin/Repair Instructions
SPN 521221 (TCM)
0405-17
Service Bulletin/Repair Instructions
SPN 521222 (TCM)
0403-17
Service Bulletin/Repair Instructions
SPN 677 FMI 2 Starter Switch Inconsistent Diagnostics
0402-17
Service Bulletin/Repair Instructions
SPN 1322 (MCM) (GHG17)
0401-17
Service Bulletin/Repair Instructions
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
0329-17
Service Bulletin/Repair Instructions
Symptom Diagnostics - Oil Leaks
0328-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0327-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0326-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0325-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0324-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0323-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0322-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0321-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0320-17
Service Bulletin/Repair Instructions
(MCM)(GHG17)
0319-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0318-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0317-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0316-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0314-17
Service Bulletin/Repair Instructions
GHG14 Intake Manifold Pressure Too Low
0313-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0312-17
Service Bulletin/Repair Instructions
(MCM) GHG17
0311-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0310-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0309-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
TS1033014
Service Bulletin/Repair Instructions
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
0308-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0307-17 SPN
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0306-17
Service Bulletin/Repair Instructions
(ACM) (GHG17)
0305-17
Service Bulletin/Repair Instructions
Diagnostic Tests
0304-17
Service Bulletin/Repair Instructions
Contaminated Fluids Diagnostic Tests
0303-17
Service Bulletin/Repair Instructions
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17
Service Bulletin/Repair Instructions
0301-17 Contaminated Fluids
0302-17
Service Bulletin/Repair Instructions
(CPC)(GHG17)
0346-17
Service Bulletin/Repair Instructions
(CPC) (GHG17)
0356-17
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0356-17 SPN
Service Bulletin/Repair Instructions
(MCM) (GHG17)
0208-17 SPN 412
Service Bulletin/Repair Instructions
0208-17 SPN 412 (MCM) (GHG17)
0206-17 SPN 5210
Service Bulletin/Repair Instructions
0206-17_ SPN 521049 (MCM) (GHG17)
0205-17 SPN 5210
Service Bulletin/Repair Instructions
0205-17 SPN 521052 (MCM) (GHG17)
0204-17 SPN 5210
Service Bulletin/Repair Instructions
0204-17 SPN 521050 (MCM) (GHG17)
0203-17 SPN 5741
Service Bulletin/Repair Instructions
0203-17 SPN 5741 FMI 13 (GHG17) (MCM)
18SP733
Service Bulletin/Repair Instructions
18SP733 GHG17 Medium Duty DD8 Oil Filter Kit
0131-17
Service Bulletin/Repair Instructions
0131-17 SPN 521054 (CPC3) (GHG17)
0132-17
Service Bulletin/Repair Instructions
0132-17 SPN 521005 (CPC3) (GHG17)
0133-17
Service Bulletin/Repair Instructions
0133-17 SPN 625 (CPC) (GHG17)
0134-17
Service Bulletin/Repair Instructions
0134-17 Medium Duty - DD5 GHG17 - Exhaust and EGR - EGR Cooler Lower Bracket
0135-17
Service Bulletin/Repair Instructions
0135-17 Diagnostic Test - Engine Brake Test Procedure
0136-17
Service Bulletin/Repair Instructions
0136-17 GHG17 DD5 Medium Duty - Exhaust and EGR - Turbocharger Oil
0137-17
Service Bulletin/Repair Instructions
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0138-17
Service Bulletin/Repair Instructions
0138-17 GHG17 DD5 Medium Duty - Exhaust and EGR - EGR Delivery
0139-17
Service Bulletin/Repair Instructions
0139-17 Coolant Housing
0140-17
Service Bulletin/Repair Instructions
0140-17 Turbocharger Compressor Outlet Pipe
0130-17
Service Bulletin/Repair Instructions
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0129-17
Service Bulletin/Repair Instructions
0129-17 SPN 102 (MCM) (GHG17)
0127-17
Service Bulletin/Repair Instructions
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0126-17
Service Bulletin/Repair Instructions
0126-17 SPN 520295 (MCM) (GHG17) - Smart Remote Actuator 1
0125-17
Service Bulletin/Repair Instructions
0125-17 SPN 4817 (MCM) (GHG17)
0124-17
Service Bulletin/Repair Instructions
0124-17 SPN 3720 FMI 14 - (MCM) (GHG17)
0123-17
Service Bulletin/Repair Instructions
0123-17 SPN 1483 (CPC3) (GHG17)
0122-17
Service Bulletin/Repair Instructions
0122-17 SPN 521058 (CPC3) (GHG17)
0121-17
Service Bulletin/Repair Instructions
0121-17 SPN 521050 (CPC3) (GHG17)
0120-17
Service Bulletin/Repair Instructions
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0119-17
Service Bulletin/Repair Instructions
0119-17 SPN 3217 (MCM) (GHG17)
0117-17
Service Bulletin/Repair Instructions
0117-17 SPN 5928 (MCM) (GHG17) - EGR H Bridge circuit diagnostics
0116-17
Service Bulletin/Repair Instructions
0116-17 SPN 4752 (MCM) (GHG17) - EGR Cooler Efficiency Fault Codes
0111-17
Service Bulletin/Repair Instructions
0111-17 SPN 1077 (MCM)(GHG17)
0107-17
Service Bulletin/Repair Instructions
0107-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
0106-17
Service Bulletin/Repair Instructions
0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
sbw01017
Service Bulletin/Repair Instructions
Retrofitting Trelleborg Engine Mounts for EPA07 and Newer
sbw35014
Service Bulletin/Repair Instructions
Detroit Drive Axle Lubrication
SBW98003
Service Bulletin/Repair Instructions
Paint Peeling, Hood.
0504-16
Service Bulletin/Repair Instructions
Inspection of the DD13 Turbocharger
0513-16
Service Bulletin/Repair Instructions
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
0514-16
Service Bulletin/Repair Instructions
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
0527-17
Service Bulletin/Repair Instructions
FMI 3,4,5 Digital Output 1 13 Circuit
18SP726rev
Service Bulletin/Repair Instructions
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
sbw3215
Service Bulletin/Repair Instructions
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left. While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
15TS3
Service Bulletin/Repair Instructions
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
16-010
Service Bulletin/Repair Instructions
Warranty Recognition Program Suspension
16-011
Service Bulletin/Repair Instructions
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
16TS7
Service Bulletin/Repair Instructions
16TS7 Reman Diesel Particulate Filter Serial Number
16-008
Service Bulletin/Repair Instructions
New Detroit Bearing Failure Analysis Standard Diagnostic Time
16-009R
Service Bulletin/Repair Instructions
16-009R_OWL Enhancements
16-007
Service Bulletin/Repair Instructions
Canadian Warranty Parts Return Address Change
15TL21
Service Bulletin/Repair Instructions
15TL21 GHG17 Diagnostic Connector Update
15-028A
Service Bulletin/Repair Instructions
15-028 New Detroit Coolant Line SRTs
15-029
Service Bulletin/Repair Instructions
_Warranty Recognition Program - Coming Soon
901-15
Service Bulletin/Repair Instructions
901-15 Oil Breather Vent
sbw5401
Service Bulletin/Repair Instructions
sbw5401 Turn Signal and Brake Override Circuit
sbw8325
Service Bulletin/Repair Instructions
sbw8325 Side Window Defroster and Cooling Improvement Retrofit
sbw5457
Service Bulletin/Repair Instructions
sbw5457 Powernet Troubleshooting Guide: Batteries, Path, Alternator
sbw5463
Service Bulletin/Repair Instructions
sbw5463 Nexiq USB-Link Upgrade and Diagnostic Connector
15-017
Service Bulletin/Repair Instructions
15-017 Detroit: Updated Fuel Injector SDTs
15-015
Service Bulletin/Repair Instructions
15-015 Warranty Exclusions Reminder
15-016
Service Bulletin/Repair Instructions
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
15CSA10
Service Bulletin/Repair Instructions
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9
Service Bulletin/Repair Instructions
15CSA9 Release of DiagnosticLink® 8.02
15CSA4
Service Bulletin/Repair Instructions
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15TS10
Service Bulletin/Repair Instructions
15TS10Rev DD Engine Platform Coolant Filter
14TL-7
Service Bulletin/Repair Instructions
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
15TL6
Service Bulletin/Repair Instructions
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
15-010
Service Bulletin/Repair Instructions
15-010-DLR Transmission Cooler Line Photos
15-009
Service Bulletin/Repair Instructions
15-009 New Detroit Standard Diagnostic Times
15-009 - Detroit
Service Bulletin/Repair Instructions
15-009_Detroit_New_SDTs
15TL5
Service Bulletin/Repair Instructions
15TL5 DAVCO Shop Pro® FXP 95
15TL4
Service Bulletin/Repair Instructions
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
sbw0116
Service Bulletin/Repair Instructions
sbw0116 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
98-1
Service Bulletin/Repair Instructions
98-1 - Paint Finish Standards
14TL8
Service Bulletin/Repair Instructions
14TL8 TorcUP? Non-Impacting Torque Tool.
14-038
Service Bulletin/Repair Instructions
14-038 Additional Detroit Standard Repair Times
14-038A
Service Bulletin/Repair Instructions
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039
Service Bulletin/Repair Instructions
14-039 New Detroit Standard Diagnostic Times
14-039A
Service Bulletin/Repair Instructions
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14-040
Service Bulletin/Repair Instructions
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
14-040A
Service Bulletin/Repair Instructions
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA22
Service Bulletin/Repair Instructions
14CSA22 DTNA Chassis Wiring Diagrams
14WO-9
Service Bulletin/Repair Instructions
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9
Service Bulletin/Repair Instructions
14TL9 Special Tool Warranty Program.
14TL7
Service Bulletin/Repair Instructions
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
14CSA21
Service Bulletin/Repair Instructions
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
1010-14
Service Bulletin/Repair Instructions
1010-14 SPN 2623 (CPC) (GHG14)
14CSA20
Service Bulletin/Repair Instructions
14CSA20 EGR Valve Actuator Kit P/N E23539699
1009-14
Service Bulletin/Repair Instructions
1009-14 SPN 5016 (ACM) (GHG14)
1008-14
Service Bulletin/Repair Instructions
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1007-14
Service Bulletin/Repair Instructions
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14
Service Bulletin/Repair Instructions
1006-14 SPN 4374 (ACM) (GHG14)
1005-14
Service Bulletin/Repair Instructions
1005-14 Oil Coolant Module
1003-14
Service Bulletin/Repair Instructions
1003-14 Rough Running or Stalling.
18SP684REV4
Service Bulletin/Repair Instructions
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705REV5
Service Bulletin/Repair Instructions
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
sb2080
Service Bulletin/Repair Instructions
sb2080 Australian CST M1400 Isolated Radiator Retrofit
14-017R
Service Bulletin/Repair Instructions
14-017R Revised: Detroit Addition of Admin Time
18SP703
Service Bulletin/Repair Instructions
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
14TL2
Service Bulletin/Repair Instructions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TL5
Service Bulletin/Repair Instructions
14TL5 ABS Power Line Carrier Converter Available Through PDC
14-028
Service Bulletin/Repair Instructions
14-028 Remy Extended Coverage Direct File
14TS19
Service Bulletin/Repair Instructions
14TS19 DD Platform High Pressure Fuel Lines
14-027
Service Bulletin/Repair Instructions
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-026
Service Bulletin/Repair Instructions
14-026-DLR SelecTruck Warranty Enhancements
715-14
Service Bulletin/Repair Instructions
715-14 Symptom Diagnostics - Coolant Los
14-022
Service Bulletin/Repair Instructions
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
14-023
Service Bulletin/Repair Instructions
14-023 Detroit Axles Pre-Approval Changes
14-024
Service Bulletin/Repair Instructions
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
714-14
Service Bulletin/Repair Instructions
714-14 Symptom Diagnostics - Low Engine Compression
713-14
Service Bulletin/Repair Instructions
713-14 Symptom Diagnostics - Combustion Gas in Coolant
712-14
Service Bulletin/Repair Instructions
712-14 Engine Coolant Temperature
0228-14
Service Bulletin/Repair Instructions
0228-14 Engine Oil Leaks - Oil Dye Method
0224-14
Service Bulletin/Repair Instructions
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0219-14
Service Bulletin/Repair Instructions
0219-14 Metal in Fuel
0215-14
Service Bulletin/Repair Instructions
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0202-14
Service Bulletin/Repair Instructions
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0229-14
Service Bulletin/Repair Instructions
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14
Service Bulletin/Repair Instructions
0233-14 SPN 51 FMI 2 - All Years
0237-14
Service Bulletin/Repair Instructions
0237-14 Engine Brake Solenoid
0238-14
Service Bulletin/Repair Instructions
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0239-14
Service Bulletin/Repair Instructions
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
12-039
Service Bulletin/Repair Instructions
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
12-040
Service Bulletin/Repair Instructions
12-040-DLR Roof Fairing Removal Program
12-043
Service Bulletin/Repair Instructions
12-043-DLR Helpline Available For Additional Support
12-038
Service Bulletin/Repair Instructions
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
12-027
Service Bulletin/Repair Instructions
12-027-DLR Detroit and Alliance like Batteries are now interchangeable
12-022
Service Bulletin/Repair Instructions
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.