108463
Service Bulletin/Repair Instructions
PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE
Vehicle report
2014 CHRYSLER TOWN AND COUNTRY
Service bulletins
183 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
108464
Service Bulletin/Repair Instructions
PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE
9100456
Service Bulletin/Repair Instructions
Incoming Vehicles with Deployed Active Head Rest (AHR) should have a through enquiry. If there is no Broken Pieces or Electrical failure, Direction to RESET the AHR following the Procedure.
S1408000384
Service Bulletin/Repair Instructions
Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On
9100229
Service Bulletin/Repair Instructions
LIFTER, Hydraulic Roller Deactivating Please do not replace MDS lifters because the disconnecting pin is not lined up, this is normal and not a defect.
9100226
Service Bulletin/Repair Instructions
Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.
93023
Service Bulletin/Repair Instructions
Warranty Bulletin D-16-03 - "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC (Rev. B)
93120
Service Bulletin/Repair Instructions
FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage - 594 / 595 / 596 WCC
93005
Service Bulletin/Repair Instructions
Warranty Bulletin D-22-17 - 2017 - 2023 (Current) Chrysler Pacifica (RU) and 2013 - 2016 Chrysler Town & Country/ 2013 - 2020 Dodge Caravan (RT) - Corrosion - Complete Hood Panel Warranty Claim Simplification (Rev. B)
93019
Service Bulletin/Repair Instructions
FCA Caribbean Warranty Bulletin ID-22-23 - 2017 - 2023 (Current) Chrysler Pacifica (RU) and 2013 - 2016 Chrysler Town & Country/ 2013 - 2020 Dodge Caravan (RT) - Corrosion - Complete Hood Panel Warranty Claim Simplification (Rev. B)
9100196
Service Bulletin/Repair Instructions
Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used
92181
Service Bulletin/Repair Instructions
Warranty Bulletin D-22-17 - 2017-2023 (Current) Chrysler Pacifica (RU) and 2013-2016 Chrysler Town & Country/ 2013-2020 Dodge Caravan (RT) - Corrosion Complete Hood Panel Warranty Claim Simplification (Rev. A)
92186
Service Bulletin/Repair Instructions
FCA Caribbean Warranty Bulletin ID-22-23 - 2017-2023 (Current) Chrysler Pacifica (RU) and 2013-2016 Chrysler Town & Country/ 2013-2020 Dodge Caravan (RT) - Corrosion Complete Hood Panel Warranty Claim Simplification (Rev. A)
0700723
Service Bulletin/Repair Instructions
Water Quality When Mixed With Engine Coolant
1804823
Service Bulletin/Repair Instructions
wiTECH Small Leak Verification Test (SLVT) - P0456-EVAP SYSTEM SMALL LEAK
9003357A
Service Bulletin/Repair Instructions
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
9003357a
Service Bulletin/Repair Instructions
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY review and follow instructions from the latest STAR Online S1809000007 available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
9003357
Service Bulletin/Repair Instructions
ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA.
3100123
Service Bulletin/Repair Instructions
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: **Verify current warranty policy to determine if digital imaging pre authorization is required or Pre Approval is required from Regional Office depending on market.** This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
31-002-22
Service Bulletin/Repair Instructions
Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates. NOTE: Digital imaging pre authorization is required for Smart Warranty Base dealers or Pre Approval is required from Regional Office depending on market. This bulletin involves inspecting and if necessary removing corrosion and refinishing the suspect aluminum panels on the vehicle, hood, door, fenders, hinges, swing gates or liftgate panels.
88094
Service Bulletin/Repair Instructions
Warranty Bulletin D-22-17 2017?2023 (Current) Chrysler Pacifica (RU) and 2013?2016 Chrysler Town & Country/2013?2020 Dodge Caravan (RT) - Corrosion ? Complete Hood Panel Warranty Claim
3100122
Service Bulletin/Repair Instructions
Approved Use of Weld Through Primers This bulletin documents the FCA US LLC position regarding the use of weld through primer when using Squeeze Type Resistance Spot Welding (STRSW) and Gas Metal Arc Welding (GMAW) processes when welding steel body panels and structural components.
9004206
Service Bulletin/Repair Instructions
Remanufactured Transmission Assembly 1. All Promaster (VF) 3.6L/62TE equipped vehicles: a) If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) must be replaced as they are one-time usage. b) Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA. c) Vehicles built on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. Only use the reman 62TE specified in StarParts for each model year - Only use R8210327A$ for 2014 - Feb 28, 2019 VF. - Only use R8453637A$ or R8599680A$ for March 1, 2019 and later VF as they have the revised park system. - R8453637A$ and R8599680A$ are physically and functionally equivalent. Installing a R8453637A$ or R8599680A$ in a 2014 - Feb 28, 2019 VF will result in a core with the original park system being returned. Mopar can no longer convert 62TE core with the original park system to the March 1, 2019 and later version. Continued mis-usage will exacerbate the existing core shortage. Mopar may deny warranty claims where the incorrect version is used in 2014-18 VF. 3. The engine to transmission dowel pins are critical to the longevity of several components. Verify the dowel pins are in the rear face of engine block before installing a replacement transmission. Mopar will add loose dowel pins with remanufactured 62TE. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter. 5. There may be incorrect fluid measurement on the dipstick tool when
S2209000004
Service Bulletin/Repair Instructions
If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
V51
Service Bulletin/Repair Instructions
Customer Satisfaction Notification V51 Reprogram Powertrain Control Module
9004509
Service Bulletin/Repair Instructions
Oil Filter If a Mopar Oil Filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils. Recommended Brands: Wix, Purolator, and NapaGold
S2109000004
Service Bulletin/Repair Instructions
Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement engine has been installed in the vehicle.
9004330
Service Bulletin/Repair Instructions
PLATE, TORQUE CONVERTER DRIVE For 3.6L with 62TE NOTE: FOR ALL PROMASTER (VF) 3.6L/62TE EQUIPPED VEHICLES: IF THE TRANSMISSION BRACKET TO THE TRANSMISSION CASE FASTENERS ARE REMOVED DURING SERVICING, THE FASTENERS (Part Number 06511385A$) ARE ONE TIME USEAGE & MUST BE REPLACED & PROPERLY TORQUED TO 105NM Replace the eight bolts (8) 06503465 drive plate to crank shaft and the four TC bolts 06504383 as they have sealants Vehicle miles < 30K: Mandatory replacement of transmission and driveplate Vehicle miles > 30K: Replace driveplate only (shot peened)
9004386
Service Bulletin/Repair Instructions
WIRING, Body Before replacing this harness, please contact FCA Redacted Content to see if a repair kit is available for your application. If no response in 15 minutes, proceed with repair. Please email pictures of harness defects to FCA Redacted Content
S1809000007
Service Bulletin/Repair Instructions
Customer Complaint May Include Engine Oil Leak Or Consumption
S1809000007 Rev.
Service Bulletin/Repair Instructions
Customer Complaint May Include Engine Oil Leak Or Consumption
S2008000113
Service Bulletin/Repair Instructions
No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message
S2008000113 Rev.
Service Bulletin/Repair Instructions
No Start Intermittently, Vehicle Requires Multiple Keyless Push To Start Attempts To Start Vehicle, Intermittent Key Not Detected Message
S1821000001
Service Bulletin/Repair Instructions
Gear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
3100121
Service Bulletin/Repair Instructions
Steering System Inspection After a Collision This bulletin documents the FCA US LLC position regarding conditions under which replacement or repair of steering system components are required.
9004009
Service Bulletin/Repair Instructions
Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
S2121000005
Service Bulletin/Repair Instructions
62TE 6-Speed Transmission Cracked Torque Converter (TC) Piston Repair Index, To Aid In Diagnosis And Repair
71060
Service Bulletin/Repair Instructions
Warranty Bulletin D-20-19 (X87) Active Head Restraint - Select 2012-2017 Dodge Grand Caravan/Chrysler Town & Country (RT) (Rev. B)
2303020
Service Bulletin/Repair Instructions
Active Head Restraint (AHR) Inadvertent Deployment - X87 Warranty Extension This bulletin involves inspecting the sled bracket striker pin and possibly replacing a front seat AHR that has inadvertently deployed. Customers may comment on the following:The AHR is deployed on one or both front seats and will not reset.
9004300
Service Bulletin/Repair Instructions
Cooler line, Power steering return The clips that hold the line to the core support are not available at this time and will need to be reused. Use care when opening and re-latching clip.
S1121000006 Rev.
Service Bulletin/Repair Instructions
(Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns
S1121000006RevA
Service Bulletin/Repair Instructions
(Revision A) No Start No Crank ? Starter Will Not Engage And There Are No Related Codes Or Concerns
S2008000093
Service Bulletin/Repair Instructions
Blind Spot Or Park Assist Warnings, False Activation
S2008000081
Service Bulletin/Repair Instructions
Cruise Control Inoperative.
23-015-20
Service Bulletin/Repair Instructions
Disinfectant Solution Recommended for COVID-19
08-049-20
Service Bulletin/Repair Instructions
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
18-039-20
Service Bulletin/Repair Instructions
Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season
S2019000002
Service Bulletin/Repair Instructions
Hands On Steering Wheel Message In EVIC
S1508000480
Service Bulletin/Repair Instructions
Speed Control Operates Intermittently
9004220
Service Bulletin/Repair Instructions
CABLE, Gearshift Control Prior to replacing this component, please contact FCA Redacted Content. If there is no response in 15 minutes, continue with repair.
9004022
Service Bulletin/Repair Instructions
Air Suspension Components Star Parts Catalog has been updated to show individual service parts for the compressor assembly. This will allow service technicians to repair the root cause without over repairing the system. Replace only the part deemed failed by the diagnostics performed. Individual parts include: - Compressor - Valve block - Individual hoses - Temp sensor - Shield - Air line clips NOTE: in most situations when a new compressor is needed, the compressor as a separate part is the correct repair, and the assembly would not be required.
31-003-19
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-004-19
Service Bulletin/Repair Instructions
Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass.
31-005-19
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Service Bulletin/Repair Instructions
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100419
Service Bulletin/Repair Instructions
Authentic Mopar® Glass Replacement This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the recommended usage of Authentic Mopar® Glass.
3100519
Service Bulletin/Repair Instructions
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Service Bulletin/Repair Instructions
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
9003220
Service Bulletin/Repair Instructions
RADIO [RES] - New and/or Service Exchange For RES radio concerns. Use the wiTECH 2.0 and inspect the radio part number and serial number under the Radio/ECU Details tab. Please verify that the radio part number and/or serial number is not "FFFF". If either field shows "FFFF", please contact Mike Wielgat at 248-576-6696 or Rohan Negandhi at 248-421-9608 If no response in 15 minutes, proceed with repair.
9002706
Service Bulletin/Repair Instructions
VALVE KIT, A/C Expansion For concern of noise while AC is running, prior to replacing this part, please call Thomas Rolo at (248) 931-0484. If no response in 15 minutes, proceed with repair.
TS-WI-0290
Service Bulletin/Repair Instructions
Service Bulletin sent to all dealers to inspect L-track bolts for correct torque and to incorporate torque check as part of regular maintenance
9003735
Service Bulletin/Repair Instructions
Cam Phasers, Oil Control Valve For Malfunction Indicator Light (MIL) issues related to 2012-2017 3.6L Pentastar engines, please note that there is a new diagnostic procedure available in DealerCONNECT for P-codes in relationship to cam phasers. Please use this new information for trouble shooting of cam phasers and oil control valves for MIL on issues.
9003355
Service Bulletin/Repair Instructions
3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If a cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people. First: Joe Lovell - Cell (734) 309-6467 joe.lovell@fcagroup.com Second: Kevin Refalo - Cell (248) 260-0738 Kevin.refalo@facgroup.com If no response in 15 minutes, proceed with repair.
9003681
Service Bulletin/Repair Instructions
Restraints Information Sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
9003747
Service Bulletin/Repair Instructions
Load Floor Cover Assembly For bent or damaged hinges, MOPAR now offers a Hinge Kit separate from load floor. Kit number is 68306694AA and can be used for all load floor hinges.
9003109
Service Bulletin/Repair Instructions
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: Check if float sensor is rotated off location from the bottle anti-rotation features that surround the SENSOR. Check to determine if the issue has been resolved. Continue with repair if necessary. Please contact Chris Koch at cell (248) 248-622-6417 if you have questions or need additional information.
9003694
Service Bulletin/Repair Instructions
Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob.jackson@fcagroup.com, or Joe Lovell (734) 309-6467 joe.lovell@fcagroup.com before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump replacement and hold part for return to FCA via Fastrack system
9003687
Service Bulletin/Repair Instructions
Restraints Remove I-Sheet from packaging. Correct information sheet (I-Sheet) has been added to Star Parts. Print I-Sheet for technician use.
05152029
Service Bulletin/Repair Instructions
Washer Fluid Level Sensor Prior to replacing this part due to "Low Washer Fluid" tell tale light on the dash and the washer fluid bottle is full, please perform the this inspection. Inspect the sensor for a fluid coating on the sensor pins. Orange colored rain repellant can cause this fluid build-up. Clean the pins, drain the reservoir, and fill with Mopar approved washer fluid. Check to determine if the issue has been resolved. Continue with repair if necessary. Also, please inform the customer not to use Rain-X in the system to avoid this issue. Please contact Chuck Hood at cell (248) 613-7591 if you have questions or need additional information. Thank you.
23027
Service Bulletin/Repair Instructions
Return: Wiring Assy - Engine You have been identified as either having stock, or have stock in transit to your dealership. Please return stock packaged before 2016/07/31 (31 July, 2016)of follow ing part numbers:68176457AF, 68176459AF. Please return suspect parts back to your facing depot using Return Code 02, before 13 September, 2016.
23104
Service Bulletin/Repair Instructions
05182535AD - Lamp Assy ?Tail Light LT You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 05182535AD . See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
23137
Service Bulletin/Repair Instructions
Inspect and Return: Trim Cover Assy - A-Pillar Rt/Lt You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1ZA04DX9AE, 1ZA05DX9AE. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 12 September, 2016.
20244
Service Bulletin/Repair Instructions
CBXDP361AA Return: Spacer Kit - Visor You have been identified as either having stock, or have stock in transit to your dealership. Please return stock of part number CBXDP361AA. Replacement part number is CBXDP361AB w hich is in stock and available for order. Please return suspect parts back to your facing depot using Return Code 02, before 16 September, 2016.
Volume 2, Issue
Service Bulletin/Repair Instructions
Warranty Operations Newsletter Updates from Warranty Operations
22867
Service Bulletin/Repair Instructions
Inspect and Return: Solenoid Module - Transmission You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of follow ing part numbers:52120000AA, 52119435AF, 05078709AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
22892
Service Bulletin/Repair Instructions
Return: Lamp Assy - CHMSL& Cargo Light You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of follow ing part numbers:55372082AE, 55372082AD, 55372082AC, 55372082AB, 55372082AA. Replacement part number is 55372082AF w hich is in stock and available. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
22958
Service Bulletin/Repair Instructions
1NT30XDVAC - Inspect and Return: Panel - Instrument Panel You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part number 1N T30XDVAC. See attachments for identifying suspect stock. Replacement part can be obtained by reordering the same part number. Please return suspect parts back to your facing depot using Return Code 02, before 07 September, 2016.
20616
Service Bulletin/Repair Instructions
P/N CBSZR068AA: Inspect & Return: Module Kit - Occupant Restraint You have been identified as either having stock, or have stock in transit to your dealership. Please return part number CBSZR068AA as per the QIR attached. Replacement part can be obtained by ordering the same part number (CBSZR068AA) Please return suspect parts back to your facing depot using Return Code 02, before 02 September, 2016.
55111275A
Service Bulletin/Repair Instructions
Sun Sensor Multi zone Auto Climate Control systems. Left and right outlet temperatures do not match when system is in "sync" . Occupants will experience being cold ( winter time), on either passenger or driver side, even though the temperature setting is the same. Root cause: Suspect sun senors ( PN 55111274AA and 55111275AA). THERE WILL BE NO DTC FOR THE SUN SENSOR active or stored. The issue is diagnosed by using an INCANDESCENT (not LED) shop lamp. Shine the shop lamp on the left side of the sensor, then on the right side of the sensor, while monitoring sensor output with STARSCAN. The reading should change from 0 (or near zero) to about 20 to 40. The important thing is that the left and right readings are the same, and that they change when the lamp is shone on it.
18-086-16
Service Bulletin/Repair Instructions
Flash: Powertrain Diagnostic and System ImprovementsThis bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience the following symptom or conditions or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following (DTCs):JC Vehicles equipped with a 2.4L engine (Sales Code ED3 or ED7):· **P0335 - Crankshaft Position Sensor Circuit. · P050B - Cold Start Ignition Timing Performance.· P2299 - Brake Pedal Position / Accelerator Pedal Position Incompatible.**· U0140 - Lost Communication With Body Control Module. Attempting to clear the DTC may be unsuccessful.· P0456 - Evap purge system small leak.· 2-1 downshift improvement.· Charging system duty cycle enhancement to improve starting performance in low ambient temperatures.· P219A - Bank 1 Air-Fuel Ratio Imbalance.· Enhanced Automatic Oil Change Indicator (EAOCI) system enhancements that forcethe use of the severe duty cycle algorithm anytime the PCM is replaced. The vehicleduty cycle information used in the EAOCI calculation is stored in the PCM and cannot be recovered/transferred when the controller is replaced. As a result, the severe duty cycle is used in these scenarios to ensure the customer receives a timely oil change required message.· Mode 6 data accuracy enhancement for generic scan tools. JC Vehicles equipped with a 3.6L engine (Sales Code ERB):· **P0335 - Crankshaft Position Sensor Circuit.· P2610 - PCM Internal Engine Off Timer Performance.**· U0140 - Lost Communication With Body Control Module. Attempting to clear theDTC may be unsuccessful.· Enhanced Automatic Oil Change Indicator (EAOCI) system enhancements that forcethe use of the severe duty cycle algorithm anytime the PCM is replaced. The vehicleduty cycle information used in the EAOCI calculation is stored in the PCM and cannot be recovered/transferred when the controll
68141352A$
Service Bulletin/Repair Instructions
3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 Ron.dallison@fcagroup.com ~ Second: Joe Lovell - Cell (734) 309-6467 joe.lovell@fcagroup.com~ If a response is not received within 15 mins, then proceed with the necessary repair.
24-005-16 REV. B
Service Bulletin/Repair Instructions
Blend Door Stuck In Full Heat Mode (X64 Warranty Extension) This bulletin involves re-calibrating or replacing the right side Heating, Ventilation, Air Conditioning (HVAC) Blend Door actuator. Customers may describe one or more of the following conditions: · Not being able to adjust the HVAC system temperature to their comfort level regardless of blend door/temperature setting. · Feeling hot air coming out of the right side vents.
24-005-16 REV. A
Service Bulletin/Repair Instructions
BLEND DOOR STUCK IN FULL HEAT MODE (X64 WARRANTY EXTENSION) THIS BULLETIN INVOLVES RE-CALIBRATING OR REPLACING THE RIGHT SIDE HEATING, VENTILATION, AIR CONDITIONING (HVAC) BLEND DOOR ACTUATOR. CUSTOMERS MAY DESCRIBE ONE OR MORE OF THE FOLLOWING CONDITIONS: · NOT BEING ABLE TO ADJUST THE HVAC SYSTEM TEMPERATURE TO THEIR COMFORT LEVEL REGARDLESS OF BLEND DOOR/TEMPERATURE SETTING. · FEELING HOT AIR COMING OUT OF THE RIGHT SIDE VENTS.
68105583A$
Service Bulletin/Repair Instructions
PENTASTAR OIL FILTER ADAPTER BEFORE REPLACING THIS PART, PLEASE CALL ANY ONE OF THE FOLLOWING PEOPLE. ENGINEERING IS SEEKING INFORMATION REGARDING THIS PART.~ DYE MUST BE USED TO DETERMINE WHERE THE LEAK IS COMING FROM BEFORE REPLACING. ALSO PLEASE CHECK THE RECENTLY UPDATED SERVICE BULLETIN NUMBER 09-008-15. ~ FIRST: NICK MORAND CELL (248) 410-5078 - NICK.MORAND@FCAGROUP.COM SECOND: BOB JACKSON CELL (248) 944-0466 - BOB.JACKSON@FCAGROUP.COM THIRD: JOE LOVELL CELL (734 309-6467 - JOE.LOVELL@FCAGROUP.COM IF A RESPONSE IS NOT RECEIVED WITHIN 15 MINS, THEN PROCEED WITH THE NECESSARY REPAIR.
R4880213A$
Service Bulletin/Repair Instructions
SHAFT - AXLE HALF NOTE: THE JOINT BETWEEN THE SPLINES ON THE HALFSHAFT AND THE HUB AND BEARING IS AN INTERFERENCE FIT. THE HALFSHAFT NUT IS TO BE USED TO DRAW THE HUB AND BEARING ONTO THE HALFSHAFT SPLINES. THIS IS PARTICULARLY TRUE IF HUB AND BEARING IS ALSO BEING REPLACED
68105583A
Service Bulletin/Repair Instructions
Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15. ~ First: Nick Morand Cell (248) 410-8078 - Nick.morand@fcagroup.com Second: Bob Jackson Cell (248) 944-0466 - bob.jackson@fcagroup.com Third: Joe Lovell Cell (734 309-6467 - joe.lovell@fcagroup.com If a response is not received within 15 mins, then proceed with the necessary repair.~
24-005-16
Service Bulletin/Repair Instructions
Blend Door Stuck In Full Heat Mode (X64 Warranty Extension) This bulletin involves re-calibrating or replacing the right side Heating, Ventilation, Air Conditioning (HVAC) Blend Door actuator. Customers may describe one or more of the following conditions: · Not being able to adjust the HVAC system temperature to their comfort level regardless of blend door/temperature setting. · Feeling hot air coming out of the right side vents.
2400516
Service Bulletin/Repair Instructions
Blend Door Stuck In Full Heat Mode (X64 Warranty Extension) This bulletin involves re-calibrating or replacing the right side Heating, Ventilation, Air Conditioning (HVAC) Blend Door actuator. Customers may describe one or more of the following conditions: · Not being able to adjust the HVAC system temperature to their comfort level regardless of blend door/temperature setting. · Feeling hot air coming out of the right side vents.
D-16-11
Service Bulletin/Repair Instructions
To announce an extended warranty on the HVAC Blend Door Actuator on the following vehicles: ? 2014-2015 Dodge Grand Caravan and Chrysler Town & Country (RT) To announce an extended warranty on the HVAC Blend Door Actuator on the following vehicles: ? 2014-2015 Dodge Grand Caravan and Chrysler Town & Country (RT)
68141352A
Service Bulletin/Repair Instructions
3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 Ron.dallison@fcagroup.com ~ Second: Joe Lovell - Cell (734) 309-6467 joe.lovell@fcagroup.com~ If a response is not received within 15 mins, then proceed with the necessary repair.~
68144206A
Service Bulletin/Repair Instructions
Caliper assembly. Rear disc brake.
55113664A
Service Bulletin/Repair Instructions
Side door Upper and lower hinge, All side doors
55113664A$
Service Bulletin/Repair Instructions
Side door Upper and lower hinge, All side doors
68225378A
Service Bulletin/Repair Instructions
3.0L V6 Turbo Diesel - Sales Code EXF
Z5091195A
Service Bulletin/Repair Instructions
RES / RHA / REB radio that supports Bluetooth and Hands-Free
Z5091195A$
Service Bulletin/Repair Instructions
RES / RHA / REB radio that supports Bluetooth and Hands-Free
68206429A
Service Bulletin/Repair Instructions
Pad, Seat Cushion
68277402A
Service Bulletin/Repair Instructions
Adaptive Cruise Control Sensor
1804216
Service Bulletin/Repair Instructions
This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest
04753183A
Service Bulletin/Repair Instructions
Transmission, Oil Pump, Torque Convertor, and Flexplate
1PH98RXFA
Service Bulletin/Repair Instructions
Parts.
68037593A
Service Bulletin/Repair Instructions
Beam, Upper Load Path & Beam, Inner Load Path
68253737A
Service Bulletin/Repair Instructions
DEF Tank
05137133A
Service Bulletin/Repair Instructions
Dual Electric Fan Assembly
55372070A
Service Bulletin/Repair Instructions
Mirror, Outside Rearview
68302824A
Service Bulletin/Repair Instructions
Auxiliary Lamp, Outside Mirror
68302828A
Service Bulletin/Repair Instructions
Turn Signal, Outside Rearview Mirror
68192621A
Service Bulletin/Repair Instructions
Transmission - Pan, Pan Gasket
68234120A
Service Bulletin/Repair Instructions
Panasonic 8.4" CTP/FCTP Radio, Update Failure
68234120A$
Service Bulletin/Repair Instructions
Panasonic 8.4" CTP/FCTP Radio, Update Failure
D-16-03
Service Bulletin/Repair Instructions
Can/Am Warranty coverage
D1603
Service Bulletin/Repair Instructions
Can/Am Warranty coverage
1801216
Service Bulletin/Repair Instructions
Powertrain Diagnostic and System Improvements.
5LC23DX9A
Service Bulletin/Repair Instructions
Load Floor Handle.
68018095A
Service Bulletin/Repair Instructions
HVAC Distribution Housing
68143886A
Service Bulletin/Repair Instructions
RADIATOR, Engine Cooling
68143886A$
Service Bulletin/Repair Instructions
RADIATOR, Engine Cooling
68227808A
Service Bulletin/Repair Instructions
Rear Differential or Rear Differential Actuation Motor
RL108213A$
Service Bulletin/Repair Instructions
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
R2108213A
Service Bulletin/Repair Instructions
W5A580 (NAG1) Valve Body - complete
R2108213A$
Service Bulletin/Repair Instructions
W5A580 (NAG1) Valve Body - complete
R62
Service Bulletin/Repair Instructions
The right side blend air door on about 161,800 of the above vehicles may experience binding. This could result in the loss of the vehicle?s interior temperature control.
R62 COMBO
Service Bulletin/Repair Instructions
The right side blend air door on vehicles may experience binding. This could result in the loss of the vehicles interior temperature control. The Heater Ventilation Air Conditioning (HVAC) control module must be reprogrammed with new software. Vehicles found with damaged actuators must have them replaced under normal warranty.
68210304A
Service Bulletin/Repair Instructions
Fuel Tank
18-069-15 REV A
Service Bulletin/Repair Instructions
Flash: 3.6L Powertrain Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience the following symptom or conditions or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Code: ? U0140 - Lost Communication With Body Control Module (BCM). ? Garage shift engagements into D may be harsh at times after shutdowns of 10-30 minute duration. ? Harsh upshifts generated by backing out of the accelerator pedal. ? Harsh shifts can be felt after acceleration/deceleration driving maneuvers from a stop. ? P0606 - Internal Control Processor. ? Accuracy improvements for the Automatic Oil Change Indicator (AOCI) system.
08-115-15
Service Bulletin/Repair Instructions
Hands Free Feature Inoperative This bulletin involves updating the Hands Free Module (HFM) software. The customer may notice that the hands free feature (Bluetooth) does not work. On further inspection Diagnostic Trouble Code (DTC), U0197 - Lost Communication With Hands Free Phone Module may be found.
24-006-15
Service Bulletin/Repair Instructions
Flash: HVAC System Improvements This bulletin involves selectively erasing and reprogramming the HVAC Module with new software. The customer may describe one or more of the following conditions: ? Feeling hot air coming out of the passenger side vents. ? HVAC system intermittently blows cold regardless of blend door/temperature setting.
18-071-15
Service Bulletin/Repair Instructions
Unable to Program Keys After Wireless Ignition Node Replacement
1807115
Service Bulletin/Repair Instructions
Unable to Program Keys After Wireless Ignition Node Replacement
SB-18-071-15
Service Bulletin/Repair Instructions
2014 TOWN & COUNTRY/GRAND CARAVAN: 200/AVENGER: ORIGINAL VEHICLE KEYS DON'T FUNCTION PROPERLY AFTER REPLACEMENT OF THE WIRELESS IGNITION NODE. *CN
18-069-15
Service Bulletin/Repair Instructions
Flash: 3.6L Powertrain Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience the following symptom or conditions or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Code: ? Garage shift engagements into D may be harsh at times after shutdowns of 10-30 minute duration. ? Harsh upshifts generated by backing out of the accelerator pedal. ? Harsh shifts can be felt after acceleration/deceleration driving maneuvers from a stop. ? P0606 - Internal Control Processor. ? Accuracy improvements for the Automatic Oil Change Indicator (AOCI) system.
SB-18-069-15
Service Bulletin/Repair Instructions
2014 CHRYSLER TOWN & COUNTRY; DODGE GRAND CARAVAN; DODGE JOURNEY: MALFUNCTION INDICATOR LAMP ILLUMINATED. PROCEDURE ON SELECTIVELY ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE WITH NEW SOFTWARE *CN
SB-09-008-15
Service Bulletin/Repair Instructions
VARIOUS VEHICLES ARE EXPERIENCING LOSS OF OIL, AND POSSIBLY AN OIL LEAKAGE POOLING IN ENGINE VALLEY AND POSSIBLY NEED REPLACING OIL FILTER HOUSING. MODEL 2014. *PE
18-054-15
Service Bulletin/Repair Instructions
Mil Illumination: P2453,P2454,P2455 or P2463 Active or Stored This bulletin involves determining if the Differential Pressure Sensor and its Connector require repair. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following Diagnostic Trouble Codes (DTCs). ? P2453 - Diesel Particulate Filter Differential Pressure Sensor Circuit Performance ? P2454 - Diesel Particulate Filter Differential Pressure Sensor Circuit Low ? P2455 - Diesel Particulate Filter Differential Pressure Sensor Circuit High ? P2463 - Diesel Particulate Filter - Soot Accumulation
08-038-15
Service Bulletin/Repair Instructions
RBZ Or RHB Radio Software Enhancements This bulletin involves upgrading the software on the RBZ or RHB Radio. The customer may experience one or more of the following. ? When changing the language on the radio, the navigation may still display English. ? Help prevent navigation lockup. ? Ghost image of the vehicle?s brand logo on the display screen. ? Digital photos loaded onto the hard drive intermittently get lost. ? Sirius audio pop on power up. ? HFM audio pop on power up. ? HFM Mode resume with no information. SYMPTOM/CONDITION FOR RHB RADIOS ONLY: ? Trip planner does not save a route after is was created. ? Route guidance does not activate after the vehicle shuts down. ? Longitude entry does not allow enough digits. ? CD/DVD will not play. ? Navigation accept screen will not clear. ? Navigation shows ?acquiring signal? for an extended period of time. ? New navigation graphics.
08-034-15
Service Bulletin/Repair Instructions
Wire Harness Hanging Down From Rear Bumper Fascia This bulletin involves attaching the park assist and/or blind spot detection wire harness to the rear bumper fascia. The customer may describe a wire harness hanging down from the rear bumper fascia.
08-022-15
Service Bulletin/Repair Instructions
CHRYSLER 2014 JEEP WRANGLER, DODGE CARAVAN CHRYSLER TOWN & COUNTRY: BULLETIN INFORMATION INVOLVING PERFORMING A WI-TECH MISC-FUNCTION ROUTINE. *LJ
CHRYSLER
Service Bulletin/Repair Instructions
The customer may experience the blind spot monitor indicator in either outside mirror maybe flashing or on continuously.
SB-08-020-15
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
2300815
Service Bulletin/Repair Instructions
Rattle Noise From The Right Or Left Rear Sliding Door While Driving Over Bumps This bulletin involves modifying the rubber bumper located at the rear end of the rear sliding door upper track. Rattle noise that sounds like metal against metal coming from the right or left rear sliding door area while driving over bumps.
08-112-14
Service Bulletin/Repair Instructions
Hands Free Feature Inoperative This bulletin involves updating the Hands Free Module (HFM) software. The customer may notice that the hands free feature (Bluetooth) does not work. On further inspection Diagnostic Trouble Code (DTC), U0197 - Lost Communication With Hands Free Phone Module may be found.
0811214
Service Bulletin/Repair Instructions
Hands Free Feature Inoperative
05-005-14 REV. A
Service Bulletin/Repair Instructions
Steering Wheel And/Or Seat Vibration - Front Brake Rotors This bulletin involves inspecting the Julian date and if necessary, replacing the front brake rotors. The customer may describe a shake and/or vibration in the steering wheel and/or the seat while driving at highway speeds without the brakes applied. This vibration may be caused by out of balance front brake rotors.
05-005-14REV.A
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
0500514
Service Bulletin/Repair Instructions
Steering Wheel And/Or Seat Vibration - Front Brake Rotors This bulletin involves inspecting the Julian date and if necessary, replacing the front brake rotors. The customer may describe a shake and/or vibration in the steering wheel and/or the seat while driving at highway speeds without the brakes applied. This vibration may be caused by out of balance front brake rotors.
0500514REVA
Service Bulletin/Repair Instructions
Steering Wheel And/Or Seat Vibration - Front Brake Rotors This bulletin involves inspecting the Julian date and if necessary, replacing the front brake rotors. The customer may describe a shake and/or vibration in the steering wheel and/or the seat while driving at highway speeds without the brakes applied. This vibration may be caused by out of balance front brake rotors.
9003104
Service Bulletin/Repair Instructions
Part Description: Mirror, Side View Issue Description: New mirror now includes a grommet on the electrical wire. If the mirror being removed from the vehicle does not have a grommet and the new mirror does, this is not an issue. Install the new mirror and grommet.
08-046-14 REV. B
Service Bulletin/Repair Instructions
Service Bulletin 08-046-14 REV. A Superseded By Customer Satisfaction Notification (CSN) P25 Refer to service procedures outlined in CSN P25.
08-046-14REV.B
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
0804614
Service Bulletin/Repair Instructions
Service Bulletin 08-046-14 REV. A Superseded By Customer Satisfaction Notification (CSN) P25 Refer to service procedures outlined in CSN P25.
0804614REVB
Service Bulletin/Repair Instructions
Service Bulletin 08-046-14 REV. A Superseded By Customer Satisfaction Notification (CSN) P25 Refer to service procedures outlined in CSN P25.
05-005-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
1805414
Service Bulletin/Repair Instructions
Intermittent Extended Crank, Long Crank Time.
9003153
Service Bulletin/Repair Instructions
Part Description: Hinge Kit, Load Floor Issue Description: Please note that if you are looking into getting a DOOR ASSEMBLY - LOAD FLOOR part due to a damage in the hinges only then you can just order the hinges per kit PN 68257765AA.
9002503
Service Bulletin/Repair Instructions
RHR Radio Issue Description: Issue 1: While performing RHR radio reflash (software update), on rare occasions, the flash can fail to properly update the radio resulting in the radio running in Emergency IFS mode. This error condition can occur due to interrupting the software update, background radio operations interfering with the reflash process, etc. The radio will reboot, but with limited functionality ( may include but are not limited to: NAV, Voice Recognition, Bluetooth, or AUX jack are inop, no available space shown on HDD, etc.). The radio can still be properly updated by simply reinserting the software update disc and performing the reflash procedure again. To assist in the verification that the radio is running Emergency IFS perform the 1. Power on radio~ 2. Press MENU H/K~ 3. Press System Setup S/K~ 4. Press Manage HDD S/K~ 5. Press Display Available Space on HDD S/K~ 6. When running Emergency IFS, all items under Used, Available, and Capacity report as dashes Issue 2: If you are having troubles connecting a phone or a MP3 player, try removing the battery on the device and then going through the pairing/connection procedure again. If you cannot remove the battery on the device, perform a reboot. Each manufacturer has a different series of buttons to hold down to perform a reboot. If the problem still persists, try the device on another like vehicle with the same radio. If you are having the same connection issues on another like vehicle, the device may be faulty or it may not be compatible with the RHR radio. Go to www.chrysler.com/hostb/crossbrand/owners/en and click on ?Bluetooth Phone Compatibility Test Results? link for a list of phones that are compatible. For MP3 players and media storage devices, only .wma, .aac, .mp3, .sacd, .jpeg & .jpg files are supported. Remove all other file types and reevaluate the concern. Issue 3: If upgrading a vehicle from a low line radio that has factory installed UConnect
08-067-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
08-065-14
Service Bulletin/Repair Instructions
Thatcham Installation This bulletin involves the installation of the Thatcham Engine Compartment kit.
08-060-14
Service Bulletin/Repair Instructions
Cruise Control System Slow To Respond To Cruise Control Switch Inputs This bulletin involves upgrading the software in the Powertrain Control Module (PCM). A customer may experience, slow response to cruise control switch activations.
23-011-14 REV. A
Service Bulletin/Repair Instructions
Left Rear Sliding Door Weatherstrip Seal Sticks Out At Bottom Of C-Pillar Door Opening This bulletin involves replacing the left rear C-pillar cut line sliding door seal. .
23-011-14REV.A
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
24-004-14 REV. A
Service Bulletin/Repair Instructions
Flash: HVAC System Intermittently Blows Cold Regardless of Setting This bulletin involves selectively erasing and reprogramming the HVAC Module with new software. Customers may experience the following condition: HVAC system intermittently blows cold regardless of blend door/temperature setting.Updating the HVAC software will correct this condition.This SB includes improved software over what was originally released with SB 24-004-14.
24-004-14REV.A
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
9003118
Service Bulletin/Repair Instructions
Sliding Door Trim Panel If a contact condition with the exterior quarter panel occurs, please engage the dual lock in the center of the trim to the door inner module.
18-034-14 REV. A
Service Bulletin/Repair Instructions
P0520- Engine Oil Pressure Sensor Circuit This bulletin involves replacing the oil pressure sensor with a revised part. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Code (DTC) has been set: P0520 - Engine Oil Pressure Sensor Circuit
23-016-14
Service Bulletin/Repair Instructions
Rattle Noise From The Right Rear Sliding Door While Driving Over Bumps This bulletin involves modifying the rubber bumper located at the rear end of the right rear sliding door upper track. Rattle noise that sounds like metal against metal coming from the right rear sliding door area while driving over bumps.
23-014-14
Service Bulletin/Repair Instructions
Sliding Door Trim Contacting Vehicle Rear Quarter This bulletin depending on production date, involves either installing or engaging an additional door panel retention point to prevent the door panel from bowing and contacting the body when the sliding door is opened. The customer may experience a door trim panel contacting the quarter panel on either side when opening either of the sliding doors.
23-013-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SB-18-034-14
Service Bulletin/Repair Instructions
ON SOME MODEL VEHICLES AND JEEPS, (MY 2013-2014)MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES AND DIAGNOSTIC TROUBLE CODE (DTC) IS SET REGARDING ENGINE OIL PRESSURE SENSOR CIRCUIT. *PE
24-004-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
2400414
Service Bulletin/Repair Instructions
HVAC System Intermittently Blows Cold Regardless of Setting
0804614-1
Service Bulletin/Repair Instructions
Power Window-Vent Switch - Interim CSN Repair
23-011-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
0802414
Service Bulletin/Repair Instructions
RHW RHP Radio Software Enhancements
08-042-14
Service Bulletin/Repair Instructions
Flash: Dead Battery This Bulletin involves updating the Fold and Stow Module (FSM) with new software because the FSM stays awake resulting in a continuous electrical draw. The customer may experience a dead battery.
9003081
Service Bulletin/Repair Instructions
Dielectric Grease This product is no longer approved for use on ignition coil and spark plug boots. Current plug boot material(silicone) is not compatible with this grease and can cause deterioration over time.
24-002-14
Service Bulletin/Repair Instructions
Driver And Passenger HVAC Blower Air Temperatures Are Not The Same When ?Sync? Setting Mode Is Selected And Headlamps Always Stay On. This bulletin involves selectively replacing the solar sensor. Customers may experience the following condition: When using the Automatic Temperature Control ?SYNC? mode, left and right outlet temperatures do not match regardless of the desired temperature setting is the same. Occupants will experience being cold (winter time), on either passenger or driver side, even though the temperature setting is the same. Headlamps are always staying on, when they are set to Auto mode.
2400214
Service Bulletin/Repair Instructions
Setting Mode Is Selected And Headlamps Always Stay On
18-009-14
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
08-007-14
Service Bulletin/Repair Instructions
Incorrect Switch Installed On The Steering Wheel This bulletin involves installing the correct Non Electronic Vehicle Information Center (EVIC) steering wheel switch. Customer and or dealer may notices that the steering wheel has the incorrect switch assembly installed. The installed switch is for vehicles that are equipped with an EVIC.
23-038-13
Service Bulletin/Repair Instructions
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
WB-D-11-60
Service Bulletin/Repair Instructions
CHRYSLER GROUP: VEHICLE RESTRICTION PROGRAM ENTITLED ENHANCED CUSTOMER SATISFACTION (ECS), DESIGNS TO USE BOTH THE TECHNICAL SERVICE OPERATION AND CUSTOMER CARE, TO PROACTIVELY REACH OUT, TO CUSTOMERS, AND REPAIR THE CUSTOMER'S VEHICLE. *PE
9002519
Service Bulletin/Repair Instructions
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.