Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
R2118796A
Valve Body. These may cause over drive cycling.
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
0804000
INFORMATION ON NEW COMPONENTS AND A REPAIR PROCEDURE DEVELOPED TO REPLACE FAILED SEAT SLIDE MOTORS. *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
084699
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE DOOR AJAR WARNING LIGHT AND DOME LIGHT MAY WORK INTERMITTENTLY OR MAY BECOME INOPERATIVE. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090799
INFORMATION REGARDING 2.5L V-6 HEAD GASKET APPLICATION. *TT
090899
TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT
210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
020299
VEHICLES EXHIBITING FRONT COIL SPRING CREAKING, POPPING, OR SQUEAKING. *TT
210699
CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT
210599
SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT
190199
PROCEDURES ON ALIGNING THE POWER STEERING BELT. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
050898
EXHIBITTING A CONDITON WHERE THE STEERING WHEEL SHAKES OR THE BRAKE PEDAL PULSATES DUE TO PREMATURE WEAR OF FRONT BRAKE ROTORS AND PADS. *AK
234998
SOME VEHICLES EXHIBIT A WHISTLE ( WINDNOISE) COMING FROM THE " A " PILLAR AREA. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
9841
SOME VEHICLES MAY EXHIBIT A WHINE OR MOAN NOISE COMING FROAM THE FUEL TANK AREA. *YC
210298
INFORMATION ON DIAGNOSTIC / DRIVEABILITY IMPROVEMENTS, TRANSAXLE THAT INCORPORATES A TRANSMISSION RANGE SENSOR (TRS) ONLY. REDUCES A SHUDDER CONDITION THAT MAY BE EXPERIENCED DURING LIGHT THROTTLE 1-2 UPSHIFT. *AK
020798
CONDITIONS WITH LIGHT KNOCKING OR TAPPING NOISE BEING HEARD FROM THE REAR SHOCK REAR WHILE TRAVELING OVER BUMPS. *YC
232398
INFORMATION ON REMOTE KEYLESS ENTRY PROGRAMMING. *YC
210798
SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK
020298
A SQUEAKING OR HARD RUBBING NOISE MAY BE HEARD FROM THE REAR OF THE VEHICLE WHEN TRAVELING OVER BUMPS. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
180598
DISCUSSION: REGARDING IDLER AIR FLOW TEST FOR ABOVE MODELS LISTED MAY INDICATE AN ERRONEOUS FAILURE DUE TO INABILITY OF POWERTRAIN CONTROL MODULE TO HOLD THE IDLE AIR CONTROL MOTOR STABLE DURING TEST SEQUENCE. *AK
090997
INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
233897
KEYLESS ENTRY TRANSMITTER DIAGNOSTICS. *TW
182297
MIL ILLUMINATION WITH HEX CODE $3A. *TW
220197
INFORMATION ON TIRE AND WHEEL RUNOUT. *NLM
082097
INFORMATION REGARDING GARAGE DOOR OPENER. *NLM
210997
INFORMATION ON 41TE/42LE SERVICE INFORMATION. *NLM
070397
CONCERNS WITH ENGINE COOLANT USAGE. *NLM
181897
CONCERNS WITH OBDII READINESS CODE RETENTION, FRDERAL PACKAGES. *NLM
181697
CONCERNS ON ERRONEOUS MI; ILLUMINATION WITH HEX CODES $6A, ERRONEOUS PCM RESETS, SHIFT CYCLING, COLD ENGINE STUMBLE. *NLM
190597
CONCERNS WITH POWER STEERING BELT ALIGNMENT. *NLM
210597
CONCERNS WITH 41TE/42LE TRANSAXLE SHUDDER DURING AN EMCC (ELECTRONICALLY MODULATED CONVERTER CLUTCH) SHIFT. *NLM
970314210597
CONDITION WITH TRANAXLE SHUDDER DURING A 3RD GEAR TO 3RD GEAR PARTIAL EMCC ( ELECTRONICALLY MODULATED CONVERTER CLUTCH) ENGAGEMENT, 3RD GEAR PARTIAL EMCC TO 4TH GEAR PARTIAL EMCC ENGAGEMENT, OR 4TH GEAR TO 4TH GEAR EMCC ENGAGEMENT. *YC
180897
SAG/HESITATION ON ACCELERATION, OR ENGINE MISS. *TW
180997
VEHICLE SHUDDER DURING TORQUE CONVERTER EMCC (LOCK UP) OPERATION/DIAGNOSTIC TROUBLE CODE 38. *TW
181097
INTERMITTENT SINGLE CYLINDER MISFIRE AND/OR MIL ILLUMINATED. *TW
230797
DOOR TRIM DEFROSTER GARNISH SERVICE. *TW
230297
SUNROOF SUNSHADE BINDING OR COMING OUT OF TRACK. *TW
230397
DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW
020197
A LIGHT THUMP, CHUCKLE, OR CREAK NOISE MAY BE HEARD FORM THE REAR OF THE VEHICLE WHILE DRIVING OVER SMALL TO MEDIUM BUMPS- THIS NOISE COMES FROM THE INSIDE SHOCK. *JD
183595
BULLETIN APPLIES TO 1996 VEHICLES EQUIPPED W/ A 2.0L ENGINE (AVENGER/ SEBRING/TALON BUILT PRIOR TO NOV. 10, 1995 MDH (11-10-XX)) (NEON BUILT PRIOR TO NOV. 14, 1995 MDH (11-14-XX)). INTERMITTENT REAR O2 SENSOR FAULT, DIAGNOSTIC TROUBLE CODE (DTC) #129 W/ MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION. REPAIR INVOLVES SELECTIVELY ERASING AND REPROGRAMMING THE POWERTRAIN CONTROL MODULE (PCM) W/ NEW SOFTWARE (CALIBRATIONS CHANGES).
184095
BULLETIN APPLIES TO '96 VEHICLES EQUIPPED W/ 2.5L ENGINE (AVENGER/SEBRING/ TALON BUILT PRIOR TO NOV. 10, 1995 MDH [11-10-XX]) (CIRRUS/STRATUS BUILT PRIOR TO SEPT. 25, 1995 MDH [9-25-XX]). INTERMITTENT SPEED CONTROL CUTOUT DURING NORMAL OPERATION. REPAIR INVOLVES SELECTIVELY ERASING AND PREPROGRAM- MING THE POWERTRAIN CONTROL MODULE (PCM) W/ NEW SOFTWARE (CALIBRATION CHANGES).
081695REVA
BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 08-16-95, DATED APR. 14, 1995. IF THE VEHICLE OPERATOR **REPEATEDLY** PRESSES AND RELEASES THE SET BUTTON WITH THEIR FOOT OFF OF THE ACCELERATOR (A 'LIFT FOOT SET' TO BEGIN SPEED CONTROL OPERATION), THE VEHICLE MAY ACCELERATE AND EXCEED THE DESIRED SET SPEED BY UP TO 5 MPH (8 KM/H) AND THEN DECELERATE TO LESS THAN THE DESIRED SET SPEED BEFORE FINALLY ACHIEVING THE DESIRED SET SPEED.
084495
BULLETIN APPLIES TO TALON MODELS BUILT PRIOR TO JUN 1, 1995 (MDH 06-01-XX) AND AVENGER/SEBRING MODELS BUILT PRIOR TO AUGUST 2, 1995 (MDH 08-02-XX). SOME VEHICLES MAY EXHIBIT AN INTERMITTENT OR RANDOM ACTIVATION OF THE THEFT ALARM WHEN THE DOORS, TRUNK, AND HOOD ARE ALL CLOSED. THIS MAY OCCUR DURING HIGH WIND OR AMBIENT TEMPERATURE CONDITIONS. A HOOD THAT IS OVER FLUSH MAY ALSO CONTRIBUTE TO THE CONDITION. BULLETIN INVOLVES ADDING SHIMS TO THE SWITCH FOR TALON MODELS OR ADDING A FOAM SHIM TO THE INNER HOOD FOR AVENGER/SEBRING MODELS.
183195
NEW IN STOCK VEHICLES MAY EXHIBIT HARD STARTS, MISS-FIRE, OR ROUGH IDLE DUE TO SPARK PLUG FOULING. THIS CAN BE CAUSED BY INFREQUENT ENGINE OPERATION DURING THE TRANSPORTATION PROCESS. BULLETIN INVOLVES CLEANING THE SPARK PLUGS PRIOR TO DELIVERY.
250297
CUSTOMER MAY COMPLAIN OF POPPING/KNOCKING NOISE IN ENGINE COMPARTMENT. *NLM
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.