Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
0804000
INFORMATION ON NEW COMPONENTS AND A REPAIR PROCEDURE DEVELOPED TO REPLACE FAILED SEAT SLIDE MOTORS. *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
182699
SOME VEHICLES MAY EXPERIENCE NOX EMISSION FAILURE WHEN PERFORMING AN ASM TYPE INSPECTION / MAINTENANCE (I/M) EMISSION TEST. *TT
235699
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE BUTYL USED FOR HOLDING THE DOOR WEATHER SHIELD IN PLACE DRIPS FROM THE LOWER DOOR EDGE. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
211599
SUBJECT ON TRANSAXLE SEEPAGE MIS-DIAGNOSIS- CASE POROSITY. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090799
INFORMATION REGARDING 2.5L V-6 HEAD GASKET APPLICATION. *TT
090899
TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT
210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
020799
CONDITIONS WITH LIGHT KNOCKING NOISE FROM THE REAR SHOCK AREA. *TT
9920
INFORMATION ON FAST FEEDBACK FLEET - INSTALLATION OF 2000 MODEL YEAR 41TE TRANSAXLES. *TT
9917
CUSTOMER MAY COMPLAIN OF HARSH RIDE, VEHICLE LEAD OR PULL AND PERCEIVED BRAKE SHUDDER. *TT
020299
VEHICLES EXHIBITING FRONT COIL SPRING CREAKING, POPPING, OR SQUEAKING. *TT
210699
CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT
9913
VEHICLES MAY EXPERIENCE FAULTS RELATED TO THE TRANSMISSION RANGE SENSOR (TRS). *TT
210599
SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT
190199
PROCEDURES ON ALIGNING THE POWER STEERING BELT. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
050898
EXHIBITTING A CONDITON WHERE THE STEERING WHEEL SHAKES OR THE BRAKE PEDAL PULSATES DUE TO PREMATURE WEAR OF FRONT BRAKE ROTORS AND PADS. *AK
236098
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE SUNSHADE FABRIC DELAMINATES FROM THE SUBSTRATE ALONG THE EDEGES OF THE SUNSHADE. *YC
#9864
SUBJECT ON FRONT FASCIA PROTECTOR REMOVAL. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
#9850
CONDITIONS REGARDING PAINT SPLATTER, BELVIDERE RAIL HEAD STORAGE YARD. *YC
083298
NEW VEHICLE PREP PROCEDURES - COMPASS CALIBRATION / HVAC OPERATION. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.