Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
DOR-X6W2U-06
This SKU is a Clock Spring. The customer communication requested return of unsold inventory to inspect the internal spring. If the internal spring is not seated, the electrical circuit for the horn is disconnected and the horn will not function. The horn electrical circuit does not affect the airbag circuit.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
R2118796A
Valve Body. These may cause over drive cycling.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
22
REPROGRAM PCM AND INSPECT CATALYTIC CONVERTER. *KB
1100605
ILLUMINATED MIL AS THE RESULT OF A DIAGNOSTIC TROUBLE CODE (DTC) P0420 - CATALYST EFFICIENCY, OR MAY HAVE FAILED A CALIFORNIA SMOG OR STATE I/M TEST BUT WITHOUT AN ILLUMINATED MIL, OR A RATTLING SOUND FROM THE UNDERSIDE OF THE VEHICLE. CATALYTIC CONVERTER EXTENDED WARRANTY TO REPLACE THE CATALYTIC CONVERTER. *TT
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
0200600
SUBJECT REGARDING UPPER CONTROL ARM BUSHING SERVICE. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
233400
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
082400
ON SOME VEHICLES THE ENGINE CRANKS BUT DOES NOT START OR STARTS AND STALLS. *TT
020500
SOME CUSTOMERS MAY COMMENT ABOUT A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
020699A
THIS BULLETIN MENTIONS THAT THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT
080699A
CUSTOMERS MAY COMPLAIN OF RADIO INTERFERENCE TO / FROM TWO WAY RADIO RECEIVERS. *TT
242099A
A CONDITION MAY OCCUR WHILE IN BI-LEVEL MODE, AIR FLOW FROM PANEL VENTS IS LESS THAN THAT OF THE FLOOR VENTS. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
235299
SUBJECT REGARDING A SQUEAK HEARD COMING FROM THE WINDOW AREA AS THE WINDOW IS ROLLED DOWN. *TT
021599
EXPERIENCING A SQUEAK NOISE COMING FROM REAR LEAF SPRING. *TT
242099
SUBJECT REGARDING VEHICLES THAT EXPERIENCE WHILE IN BI-LEVEL MODE, AIR FLOW FROM PANEL VENTS IS LESS THAT THAT OF THE FLOOR VENTS. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
030199A
CONDITIONS WITH TWO-PIECE PROPELLER SHAFT BOOT TORN. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
020599
EXPERIENCING SQUEAKING OR CREAKING FROM FRONT WHEEL AREA AT LOW SPEEDS. *TT
020699
ON SOME VEHICLES THE FRONT WHEEL BEARINGS MAY INCORRECTLY BE DIAGNOSED AS FAULTY DUE TO THE EVIDENCE OF WHEEL BEARING GREASE ON THE BEARING SEAL AREAS. *TT
030499
CONDITIONS WITH DIFFERENTIAL GEAR LUBRICANT WEEPING FROM THE FRONT DIFFERENTIAL VENT. *TT
210899
VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED. *TT
050399
INFORMATION REGARDING FRONT BRAKE CALIPER MOUNTING TO STEERING KNUCKLE THREAD REPAIR. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
184898
SUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION. *AK
110798
OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE/BREAK. *AK
085298
INFORMATION REGARDING THE FOG LAMP SERVICE. *YC
235098
CONDITIONS WITH REAR BOX TIE DOWN BRACKET ATTACHMENT BOLTS ARE RUSTED. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
070598
EXPERIENCING ENGINE COOLING FAN NOISES. *YC
030498
CONDITION WITH TWO-PIECE PROPSHAFT BOOT BEING TORN. *YC
08!798
DISCUSSION ON AIRBAG ON- OFF SWITCHES FOR SELECTED VEHICLES *AK
182498
SOME VEHICLES MAY EXHIBIT LIGHT SPARK KNOCK WITH A WARM ENGINE UNDER LOAD. *YC
232498
CENTER ARM REST/CONSOLE UPPER INERTITIA LATCH COVER ON DRIVER'S SIDE HINGE IS BROKEN. *AK
082998
GRINDING/CREAKING NOISE HEARD WHEN FRONT WINDSHIELD WIPERS ARE ACTIVATED. *AK
020498
LOWER BALL JOINT SERVICE INFORMATION. *AK
140398
SUBJECT ON FUEL PRESSURE GAUGE ADAPTER USAGE. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
181998
SOME VEHICLES MAY EXPERIENCE BUCKING DURING WIDE OPEN THROTTLE (WOT) ACCELERATION. *YC
181098
CONDITION WITH GASOLINE ENGINES WILL NOT ILLUMINATE THE MIL PROPERLY WHEN MISFIRE IS DETECTED. *YC
236597
A LOUD POPPING NOISE IS HEARD COMING FROM THE REAR OF THE CAB AS THE VEHICLE IS TURNED ONTO A STEEP INCLINE SUCH AS A DRIVEWAY APPROACH. *YC
083997
VEHICLE MAY EXPERIENCE REMOTE KEYLESS ENTRY TRANSMITTER BATTERIES DISCHARGE PREMATURELY. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
191297
CONCERNS WITH CLUNK/RATTLE FELT IN STEERING COLUMN/WHEEL. *NLM
241397
INFORMATION ON A/C REFRIGERANT LEAKS. *NLM
082797A
VEHICLE MAY EXPEREIENCE INOPERATIVE CD PLAYER SALES CODE RAZ RADIO. *NLM
970926082797
THE CD PLAYER MAY BECOME INOPERATIVE, AND WILL NOT ACCEPT THE CD WHEN ATTEMPTING TO INSERT THE DISK INTO THE RADIO. *YC
0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM
970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC
234597
THIS BULLETIN INVOLVES MUD AND DEBRIS ACCUMULATION ON LOWER SILL AREA. *NLM
241297
INFORMATIO ON CLIMATE CONTROL. *NLM
082697
CONCERNS WITH AIRBAG WARNING LAMP STAYS DIMLY ILLUMINATED. *NLM
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
081897
CLICKING AND TAPPING NOISE COMING FROM UNDER THE INSTRUMENT PANEL. *YC
081897A
INFORMATION REGARDING CLICKING/TAPPING NOISE COMING FOM UNDER INSTRUMENT PANEL. *NLM
090797
TIMING CHAIN NOISE. *TW
181397A
COLD ENGINE IDLE FLUCTUATION. *TW
220197
INFORMATION ON TIRE AND WHEEL RUNOUT. *NLM
082197
INFORMATION REGARDING NO START - ENGIN FAILED TO CRANK. *NLM
233197
CONCERNS WITH CENTER ARMREST/CONSOLE UPPER INERTIA LATCH COVER BROKEN. *NLM
070397
CONCERNS WITH ENGINE COOLANT USAGE. *NLM
970502081897
CONDITIONS OF CLICKING OR TAPPING NOISE WHEN THE SPREED CONTROL IS ENGAGED. *YC
240497
LOW HEATER PERFORMANCE DUE TO IMPROPERLY DIRECTED HEATER AIR FLOW. *TW
181297
CONCERNS WITH ERRONEOUS MIL ILLUMINATION. DRIVABILITY IMPROVEMENT. *NLM
181397
EXHIBITING AN IDLE FLUCTUATION FOLLOWING A COLD ENGINE START. *YC
080997
AIR BAG WARNING LABELS. *TW
230697
HINGE BEZEL ON FRONT SEAT CENTER CONSOLE/ARMREST BROKEN. *TW
080797
CONCERNS WITH REMOTE KEYLESS ENTRY (RKE) HORN CHIP FEATURE DISABLED. *NLM
080397
INOPERATIVE GUAGES. *TW
080597
SQUEAK DURING WINDSHIELD WIPER OPERATION. *TW
230397
DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK. *TW
080197
JTEC POWERTRAIN CONTROL MODULE WIRING HARNESS CONNECTOR REPAIR PACKAGES. *JD
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.