Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
DOR-X6W2U-06
This SKU is a Clock Spring. The customer communication requested return of unsold inventory to inspect the internal spring. If the internal spring is not seated, the electrical circuit for the horn is disconnected and the horn will not function. The horn electrical circuit does not affect the airbag circuit.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
9002849
Part Description: Insulator on Lever Assy Manual Valve - Valve Body - RWD Transmission Issue Description: The manual valve insulator, attaching rivet and instruction sheet are now available as a kit. If the insulator requires replacement please order kit 68253161AA. Insulator only used on Auto-RWD transmission Note: The color of the insulator is not relevant for service.
22
REPROGRAM PCM AND INSPECT CATALYTIC CONVERTER. *KB
2401305
AIR CONDITIONING (A/C) COOLING COIL ODOR. *TT
2100202
SUBJECT REGARDING REVISION IN DIAGNOSTIC PROCEDURES AND LABOR OPERATION TIMES FOR RE TRANSMISSIONS. *TT
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
1801702
SUBJECT REGARDING FLASH: MALFUNCTION INDICATOR LAMP ILLUMINATION FOR INJECTOR CIRCUIT FAULT. *SLC
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2500401
SUBJECT REGARDING ADDITIONAL DIAGNOSTIC FOR DIAGNOSTIC TROUBLE CODES CAUSED BY AN EVAPORATIVE SYSTEM LEAK. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2303400A
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
180500G
SOME VEHICLES MAY EXHIBIT A LIGHT TO MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
0200600
SUBJECT REGARDING UPPER CONTROL ARM BUSHING SERVICE. *TT
233400
SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT. *TT
180500F
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT-TO-MODERATE SPARK KNOC CONDITION DURING ACCELERATION (UNDER LOAD). *TT
082400
ON SOME VEHICLES THE ENGINE CRANKS BUT DOES NOT START OR STARTS AND STALLS. *TT
180500E
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT-TO-MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
180500A
SUBJECT REGARDING 1998 MODEL YEAR ENGINE SPARK KNOCK. *TT
180500
SOME VEHICLE ENGINES MAY EXHIBIT A LIGHT-TO-MODERATE SPARK KNOCK CONDITION DURING ACCELERATION (UNDER LOAD). *TT
020500
SOME CUSTOMERS MAY COMMENT ABOUT A SQUEAKING / CLICKING NOISE FROM REAR LEAF SPRINGS. *TT
210300
SOME CUSTOMERS MAY COMPLAIN OF A RED-IN-COLOR OIL SEEPAGE FROM UNDER THE VEHICLE. THE OIL SEEPAGE MAY BE LOCALIZED TO THE SECTOR SHAFT SEAL OF THE TRANSFER CASE. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
090500
EXPERIENCING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
020699A
THIS BULLETIN MENTIONS THAT THE FRONT WHEEL BEARING GREASE IS EVIDENT ON THE BEARING SEAL AREA. *TT
080699A
CUSTOMERS MAY COMPLAIN OF RADIO INTERFERENCE TO / FROM TWO WAY RADIO RECEIVERS. *TT
242099A
A CONDITION MAY OCCUR WHILE IN BI-LEVEL MODE, AIR FLOW FROM PANEL VENTS IS LESS THAN THAT OF THE FLOOR VENTS. *TT
212299
CUSTOMER COMPLAINT OF NV-242 AND NV-242HD SECTOR SHAFT SEAL OIL SEEPAGE FROM UNDER THE VEHICLE. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
235299
SUBJECT REGARDING A SQUEAK HEARD COMING FROM THE WINDOW AREA AS THE WINDOW IS ROLLED DOWN. *TT
021599
EXPERIENCING A SQUEAK NOISE COMING FROM REAR LEAF SPRING. *TT
242099
SUBJECT REGARDING VEHICLES THAT EXPERIENCE WHILE IN BI-LEVEL MODE, AIR FLOW FROM PANEL VENTS IS LESS THAT THAT OF THE FLOOR VENTS. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090699
SUBJECT REGARDING SPARK KNOCK AND ENGINE OIL CONSUMPTION DUE TO INTAKE MANIFOLD PAN GASKET OIL LEAK. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
233299
CONCERNS WITH THE CENTER CONSOLE / ARMEST LID HINGE BEING BENT. *TT
030199A
CONDITIONS WITH TWO-PIECE PROPELLER SHAFT BOOT TORN. *TT
030299A
SOME VEHICLES MAY EXPERIENCE A HIGH-SPEED DRIVELINE VIBRATION. *TT
831
EMISSIONS RECALL TO REPROGRAM YOUR VEHICLE'S POWERTRAIN CONTROL MODULE. *TT
241199
SUBJECT ON AIR CONDITIONER COOLING PERFORMANCE DETERIORATING AFTER A FEW MINUTES OF OPERATION. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
020599
EXPERIENCING SQUEAKING OR CREAKING FROM FRONT WHEEL AREA AT LOW SPEEDS. *TT
020699
ON SOME VEHICLES THE FRONT WHEEL BEARINGS MAY INCORRECTLY BE DIAGNOSED AS FAULTY DUE TO THE EVIDENCE OF WHEEL BEARING GREASE ON THE BEARING SEAL AREAS. *TT
030499
CONDITIONS WITH DIFFERENTIAL GEAR LUBRICANT WEEPING FROM THE FRONT DIFFERENTIAL VENT. *TT
180799
EXHIBITING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $A8 (P1763) GOVERNOR PRESSURE SENSOR VOLTS TOO HIGH. *TT
210899
VEHICLES EXHIBITING BUZZ, WHINING, OR MOANING LIKE NOISE FROM COLD TRANSMISSION WHEN REVERSE GEAR IS SELECTED. *TT
050399
INFORMATION REGARDING FRONT BRAKE CALIPER MOUNTING TO STEERING KNUCKLE THREAD REPAIR. *TT
231299
CONCERNS WITH CENTER CONSOLE / ARMREST COVER WILL NOT LATCH. *TT
030299
SUBJECT REGARDING HIGH-SPEED DRIVELINE VIBRATION. *TT
180499
SOME VEHICLES MAY EXHIBIT A ROUGH IDLE, SAG / HESITATION, START & STALL, AND LIGHT SPARK KNOCK. *TT
180399
SUBJECT REGARDING ERRONEOUS MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE $24 (PO107). *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
184898
SUBJECT REGARDING IGNITION SYSTEM CROSS FIRE/ SECONDARY IGNITION WIRE INDUCTION. *AK
110798
OUTER EXHAUST MANIFOLD STUDS MAY FATIGUE/BREAK. *AK
235098
CONDITIONS WITH REAR BOX TIE DOWN BRACKET ATTACHMENT BOLTS ARE RUSTED. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
084398
HEADLAMPS DO NOT ACTIVATE WHEN PANIC MODE HAS BEEN ACTIVATED BY THE PANIC BUTTON ON THE RKE TRANSMITTER. *AK
980801260898
SERVICE MANUAL REVISIONS. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
070598
EXPERIENCING ENGINE COOLING FAN NOISES. *YC
030498
CONDITION WITH TWO-PIECE PROPSHAFT BOOT BEING TORN. *YC
130198
VEHICLE LIFTING INFORMATION. *YC
232498
CENTER ARM REST/CONSOLE UPPER INERTITIA LATCH COVER ON DRIVER'S SIDE HINGE IS BROKEN. *AK
082998
GRINDING/CREAKING NOISE HEARD WHEN FRONT WINDSHIELD WIPERS ARE ACTIVATED. *AK
020498
LOWER BALL JOINT SERVICE INFORMATION. *AK
140398
SUBJECT ON FUEL PRESSURE GAUGE ADAPTER USAGE. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
190298
COMPLAINTS WITH CLICKING NOISE COMING FROM STEERING COLUMN SHROUD WHEN GEAR SELECTOR IS OPERATED. *YC
181998
SOME VEHICLES MAY EXPERIENCE BUCKING DURING WIDE OPEN THROTTLE (WOT) ACCELERATION. *YC
030298
SUBJECT REGARDING AXLE LUBRICANT AND SEALING REQUIREMENTS. *YC
181098
CONDITION WITH GASOLINE ENGINES WILL NOT ILLUMINATE THE MIL PROPERLY WHEN MISFIRE IS DETECTED. *YC
9807
SOME VEHICLES HAVE INCORRECT DIPSTICK INSTALLATION. *YC
250198
A KNOCKING SOUND COMING FROM THE ENGINE COMPARTMENT. *YC
183497
ENGINE MAY SPARK/KNOCK WHEN WARM UNDER MODERATE TO HEAVY ACCELERATION. *AK
183597
CONDITION WITH SAGGING OR HESITATION WHILE ACCELERATING FROM A STOP WITH A COLD ENGINE OR AFTER A PARTIAL COOL DOWN. *AK
183697
CONCERNS ON INCORRECT FAULT MATURE TIME - DTC $B7 LEAK DETECTION PUMP SOLENOID CIRCUIT. *NLM
236597
A LOUD POPPING NOISE IS HEARD COMING FROM THE REAR OF THE CAB AS THE VEHICLE IS TURNED ONTO A STEEP INCLINE SUCH AS A DRIVEWAY APPROACH. *YC
083997
VEHICLE MAY EXPERIENCE REMOTE KEYLESS ENTRY TRANSMITTER BATTERIES DISCHARGE PREMATURELY. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
191297
CONCERNS WITH CLUNK/RATTLE FELT IN STEERING COLUMN/WHEEL. *NLM
241397
INFORMATION ON A/C REFRIGERANT LEAKS. *NLM
0832097
INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *NLM
970919083297
AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY. *YC
182697
SUBJECT PERTAINING TO OBD II MISFIRE INDICATOR. *YC
182697A
CONCERNS WITH OBD II MISFIRE INDICATOR. *NLM
241297
INFORMATIO ON CLIMATE CONTROL. *NLM
241197
CONCERNS WITH A/C EVAPORATOR ODOR. *NLM
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.