Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
23-014-15
Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.
9002519
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
0803006
POWERTRAIN CONTROL MODULE INITIALIZATION. *KB
1900805
REVISED POWER STEERING SYSTEM BLEEDING PROCEDURES. *SC
0801505
POWERTRAIN CONTROL MODULE INITIALIZATION. *SC
0300604
FRONT HUB/HALF SHAFT CLICK/POP SOUND. *TT
1900204
STEERING COLUMN CLICK SOUND. *TT
1900702
LOWER STEERING COLUMN CLICK SOUND. *TT
0801003
SEAT BELT CINCH BAR SERVICE FOR VARIOUS MODELS INCLUDING 2004 MODELS. *TT
2301502
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *SLC
1801701A
SOME VEHICLES MAY EXHIBIT ENGINE IDLE UNDERSHOOT/PERFORMANCE. *TT
2302701
SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT. *TT
2400101B
SOME VEHICLES MAY EXPERIENCE AN AUDIBLE A/C NOISE. *SLC
1801701
ON SOME VEHICLES, THE ENGINE MAY UNDERSHOOT THE NORMAL IDLE SPEED WHEN BRAKING THE VEHICLE TO A STOP WITH THE CLUTCH DEPRESS AND / OR EXHIBIT ENGINE ROUGHNESS IMMEDIATELY AFTER MANUALLY SWITCHING THE A/C SYSTEM OFF. *TT
2200501
EXPERIENCING RATTLE NOISE COMING FROM THE WHEEL COVER OVER BUMPS. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
2601200
INFORMATION ON SERVICE PUBLICATION UPDATES. *JB
1801900
SOME VEHICLES MAY EXHIBIT HIGH ALTITUDE ENGINE HESITATION FROM A STANDING START, HIGH LOAD BUMP / SURGE, ENGINE BUCK BOBBLE OR BOUNCE AND SHAKE, LIGHT LOAD SURGE AND / OR HEAVY LOAD SURGE. *TT
220200
SOME VEHICLES MAY EXPERIENCE A RATTLING NOISE COMING FROM THE WHEEL COVER OVER BUMPS ON VEHICLES WITH 14 INCH STEEL WHEELS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
082000
A CONDITION MAY EXIST WHERE WATER MAY ENTER THE HORN INTERIOR AND CAUSE DAMAGE. THE HORN MAY NOT WORK OR THE CUSTOMER MAY REPORT THAT THE HORN SOUNDS QUIETER THAN BEFORE. *TT
082100
SUBJECT REGARDING ANTENNA MAST INSTALLATION FOR 2000 - 2001 MODEL YEAR VEHICLES. *TT
240400
SUBJECT REGARDING AN A/C CLUNK TYPE SOUND AT INITIAL ENGINE STARTUP. *TT
081200
CONCERNS WITH THE INSTRUMENT CLUSTER GAUGE POINTERS ON WRONG SIDE OF POINTER STOPS. *TT
0016
SOME VEHICLES MAY EXPERIENCE DELAYED TRANSAXLE ENGAGEMENT ON A COLD START. *TT
080800
CONCERNS WITH AN INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
090600
SUBJECT PERTAINS TO CHANGES TO THE TIMING BELT TENSIONER COMPONENTS. *TT
190200
BRIEF INFORMATION REGARDING IGNITION LOCK CYLINDER SERVICE. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
230600
SUBJECT REGARDING WATER LEAK FROM THE TOP EDGE OF THE RIGHT AND / OR LEFT FRONT DOOR. *TT
030100
SUBJECT PERTAINING TO DRIVESHAFT REMOVAL INFORMATION. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
230200
DAIMLERCHRYSLER CORPORATION IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTION VEHICLES. *TT
235599
A CONDITION MAY EXIST WHERE THE B-PILLAR APPLIQUE USED ON DOORS HAS A BROWN HAZE OR APPEARS DISCOLORED. *TT
190799
THIS BULLETIN INCLUDES INFORMATION TO DIAGNOSE AND REPAIR A POWER STEERING NOISE. *TT
235399
CONCERNS WITH WATER LEAKING FROM TOP EDGE OF RIGHT FRONT DOOR. *TT
084199
SUBJECT REGARDING CD MECHANISM SHIPPING PROCEDURE. *TT
235199
A CONDITION MAY EXIST WHERE THE OUTBOARD EDGES OF THE INSTRUMENT PANEL TOP COVER DO NOT STAY PROPERLY SEATED. *TT
242399
SUBJECT ON THE REVISED AIR CONDITIONING SUCTION LINE AND UNIFIED LINE INSTALLATION INSTRUCTIONS. *MJS
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
235099
SOME VEHICLES MAY EXHIBIT A CREAKING NOISE WHILE THE VEHICLE IS DRIVEN THROUGH SUDDEN / QUICK TURNS OR OVER BUMPS. *TT
234599
SUBJECT REGARDING DECK LID RATTLE, WATER LEAKS INTO TRUNK FROM DECK LID SEAL AND / OR DUST INTRUSION INTO TRUNK. *TT
234699
ADDRESSING CONCERNS WITH HIGH EFFORT REQUIRED TO ADJUST THE FRONT SEATS FORWARD FROM THE REAR POSITION. *TT
190299REVA
VEHICLES MAY EXPERIENCE CLUNKING OR RATTLE IN STEERING WHEEL/STEERING COLUMN. *MJS
211699
NEW AUTOMATIC TRANSMISSION FLUID USAGE (ATF +4 TYPE 9602). *MJS
083399
SUBJECT ON THE INSTRUMENT CLUSTER GAUGE POINTERS ON WRONG SIDE OF POINTER STOPS. *MJS
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090899
TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT
210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
8331/8332
EMISIONS RECALL 8331/8332 REGARDING EXCESS HYDROCARBONS. *TT
182099
EXPERIENCING A HARSH A/C INITIAL ENGAGEMENT - CLUNK NOISE. *TT
232099A
DAIMLER CHRYSLER IS NOW OFFERING INTERNAL EMERGENCY TRUNK RELEASES FOR SELECTED VEHICLES. *TT
081699A
CONDITIONS WITH INOPERATIVE OR INTERMITTENT REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT
020499
SUBJECT REGARDING STABILIZER BAR LINK BOLT SERVICE INFORMATION. *TT
9902B
SUPPLEMENTAL INFORMATION ON POWER DOOR LOCK / REMOTE KEYLESS ENTRY (RKE) SHIPPING MODE DEACTIVATION. *TT
090199A
EXPERIENCING A SHAKE IN THE STEERING WHEEL AND / OR SEAT AT IDLE. *TT
231699
CONDITIONS WITH DECKLID DOES NOT OPEN WITH FIRST CYCLE OF KEY FOB OPERATION. *TT
231399
CONCERNS WITH HIGH WINDOW CRANKING EFFORTS OR SLOW POWER WINDOW OPERATION. *TT
090199
CONCERNS WITH SHAKING IN STEERING WHEEL AND / OR SEAT AT IDLE. *TT
9910
SERVICE ACTION REGARDING INCORRECT NAME BADGE ON FRONT DOOR. *TT
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.