03148
Service Bulletin/Repair Instructions
NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT
Vehicle report
1995 FORD AEROSTAR
Service bulletins
82 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
02221
Service Bulletin/Repair Instructions
ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ
870197
Service Bulletin/Repair Instructions
INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT
02176
Service Bulletin/Repair Instructions
LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ
02142
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION AND A 4.0L OHV ENGINE MAY EXHIBIT A NOISE / VIBRATION, NO DRIVE, UNUSUAL NOISE DURING CRANKING OR A NO CRANK CONDITION. *TT
01246
Service Bulletin/Repair Instructions
ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT
01197
Service Bulletin/Repair Instructions
SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT
01181
Service Bulletin/Repair Instructions
BRAKE SHIFT INTERLOCK.*JB
01156
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC
01157
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC
01124
Service Bulletin/Repair Instructions
ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT
002310
Service Bulletin/Repair Instructions
SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT
8164
Service Bulletin/Repair Instructions
INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR
0015
Service Bulletin/Repair Instructions
INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS
99235
Service Bulletin/Repair Instructions
DURING EXTREME COLD AMBIENT TEMPERATURES AND UNDER CERTAIN DRIVING CONDITIONS, MOISTURE IN THE CRANKCASE MAY ENTER THE PCV SYSTEM, FREEZE AND CAUSE PRESURE IN THE ENGINE CRANKCASE. THE PCV FITTING IN THE UPPER INTAKE MANIFOLD MAY FREEZE OR THE FRESH AIR LINE MAY BECOME BLOCKED. IT IS ALSO POSSIBLE, BUT LESS LIKELY, THAT ICE MAY BUILD UP ON THE THROTTLE PLATE OR THE THROTTLE BODY AND CAUSE THROTTLE STICKING. *TT
99222
Service Bulletin/Repair Instructions
SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT
99194
Service Bulletin/Repair Instructions
INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT
99196
Service Bulletin/Repair Instructions
INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT
99183
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT
13180
Service Bulletin/Repair Instructions
INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS
6997
Service Bulletin/Repair Instructions
SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT
13118
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
6896
Service Bulletin/Repair Instructions
SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT
99152
Service Bulletin/Repair Instructions
INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT
99139
Service Bulletin/Repair Instructions
CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT
99129
Service Bulletin/Repair Instructions
EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT
99-8-15
Service Bulletin/Repair Instructions
SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT
99816
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT
98246
Service Bulletin/Repair Instructions
FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC
98L20
Service Bulletin/Repair Instructions
SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT
982310
Service Bulletin/Repair Instructions
MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK
98233
Service Bulletin/Repair Instructions
CONCERNS WITH FRONT DRIVE AXLE FLUID MAY LEAK OUT OF THE VENT UNDER SOME DRIVING MODES ON SOME VEHICLES. *YC
982010
Service Bulletin/Repair Instructions
EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC
9888
Service Bulletin/Repair Instructions
INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC
9852
Service Bulletin/Repair Instructions
INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC
9873
Service Bulletin/Repair Instructions
EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT
9864
Service Bulletin/Repair Instructions
INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT
985A11
Service Bulletin/Repair Instructions
SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC
985A12
Service Bulletin/Repair Instructions
RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT
985A13
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE. *YC
985A5
Service Bulletin/Repair Instructions
HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC
985A52
Service Bulletin/Repair Instructions
THIS BULLETIN CONTAINS SERVICE TIPS WHEN SERVICING ANY BRAKE RELATED ROUGHNESS / PULL CONCERNS. *TT
9845
Service Bulletin/Repair Instructions
AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC
983080
Service Bulletin/Repair Instructions
INFORMATION REGARDING TRANSFER CASE REAR HOUSING AND DRIVESHAFT REPLACEMENT. *TT
9832
Service Bulletin/Repair Instructions
FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC
98112
Service Bulletin/Repair Instructions
SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT
9814
Service Bulletin/Repair Instructions
SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT
97111097234
Service Bulletin/Repair Instructions
VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC
97090297189
Service Bulletin/Repair Instructions
EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC
BC2431970501
Service Bulletin/Repair Instructions
AEROSTAR E4WD MODELS MAY EXPERIENCE FRONT AXLE LUBRICANT LEAKAGE FROM THE VENT TUBE UNDER SOME DRIVING CONDITIONS. *TW
97610
Service Bulletin/Repair Instructions
BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD
9768
Service Bulletin/Repair Instructions
FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD
97511
Service Bulletin/Repair Instructions
FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD
9747
Service Bulletin/Repair Instructions
FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD
BC1019997230
Service Bulletin/Repair Instructions
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
BC3485972301
Service Bulletin/Repair Instructions
4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD
BC0324970201
Service Bulletin/Repair Instructions
COLD ENGINE KNOCK/TICK NOISE. *JD
962612
Service Bulletin/Repair Instructions
TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962616
Service Bulletin/Repair Instructions
SLIDING DOOR - DAMAGED OR MISADJUSTED LATCH MECHANISM. *TW
962617
Service Bulletin/Repair Instructions
BRAKES - BRAKE SERVICE - SERVICE TIPS. *TW
96246
Service Bulletin/Repair Instructions
WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
96249
Service Bulletin/Repair Instructions
TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
BC0407961115
Service Bulletin/Repair Instructions
INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW
BC0324961101
Service Bulletin/Repair Instructions
COLD ENGINE KNOCK/TICK NOISE. *TW
BC0678961025
Service Bulletin/Repair Instructions
INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
96221
Service Bulletin/Repair Instructions
WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
96222
Service Bulletin/Repair Instructions
BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
96223
Service Bulletin/Repair Instructions
LONG CRANK - STICKING IDLE AIR CONTROL (IAC) VALVE - VEHICLES BUILT FROM 11/1/94 THROUGH 3/30/96 -STALL - AFTER STARTING WHEN ENGINE ALLOWED TO SOAK FROM 1-4 HOURS - STICKING IDLE AIR CONTROL (IAC) VALVE. *TW
96225
Service Bulletin/Repair Instructions
MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
96226
Service Bulletin/Repair Instructions
AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
BC0766961016
Service Bulletin/Repair Instructions
CONCERNS OF A/C GOING TO DEFROST MODE WHEN CLIMBING GRADES OR ACCELERATING ARE LIKELY CAUSED BY VACUUM LEAKS. *TT
BC0822961010
Service Bulletin/Repair Instructions
CONCERNS W/ LIFTGATE OPENING EFFORTS &/OR THE LIFTGATE NOT STAYING OPEN, ESPECIALLY IN COLD AMBIENT TEMPS. *TT
BC9666961001
Service Bulletin/Repair Instructions
2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT
96719
Service Bulletin/Repair Instructions
EXPERIENCING A RAPPING OR CLANGING NOISE WHEN THE STEERING WHEEL IS TURNED RAPIDLY OR WHEN TURNING ON A BUMPY ROAD SURFACE. *TT
95212
Service Bulletin/Repair Instructions
THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
BC1383950906
Service Bulletin/Repair Instructions
VEHICLE MAY EXHIBIT A MOAN WHEN TURNING - TO CORRECT THIS CONDITION, REPLACE THE HIGH PRESSURE HOSE WITH A TUNED HOSE. *TW
BC4380950906
Service Bulletin/Repair Instructions
AVAILABILITY OF HIGH ALTITUDE TRANSMISSION. *TW
951012
Service Bulletin/Repair Instructions
TRANSFER CASE MAY LEAK FLUID FROM THE CASE VENT TUBE. *TW
BC2701950503
Service Bulletin/Repair Instructions
LIGHT CLICKING SENSATION OR LOOSENESS AS THE STEERING WHEEL IS TURNED. *TW
95715
Service Bulletin/Repair Instructions
MIL LAMP MAY TURN ON OR FLASH INTERMITTENTLY MAY BE DUE TO THE POWERTRAIN CONTROL MODULE (PCM) INCORRECTLY CALCULATING THE VEHICLE ENGINE LOAD DURING LIGHT THROTTLE. *TW
9524
Service Bulletin/Repair Instructions
NEW RADIATOR MANUFACTURING PROCESS/MODIFICATION. *TW
94239
Service Bulletin/Repair Instructions
EXCESSIVE CLUTCH AIR GAP ON FS-10 A/C COMPRESSORS CAN ALLOW THE CLUTCH DISC TO MOVE AWAY FROM THE PULLEY. *TW
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.