Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
22B05 S1
Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion and MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection REASON FOR THIS SUPPLEMENT ⢠Updated Ranger Technical Information to include images of a pass and fail airbag inflator inspection for 2007-2011 model years.
SSM 51536
For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.
22B05
Certain 2005-2014 Mustang, 2005-2006 GT, 2004-2011 Ranger, 2006-2012 Fusion & MKZ/Zephyr, 2006-2011 Milan, and 2007-2010 Edge & MKX Vehicles Driver & Passenger Airbag Module Quality Control Inspection: Ford Motor Company has determined that some vehicles claimed by dealers as repaired under Takata Airbag Safety Recalls 15S21, 17S42, 18S02, 19S01, and 21S12 may not have received the claimed repairs. The propellant in certain Takata airbag inflators can experience an alteration over time with exposure to certain climate conditions. A combination of time, high temperature fluctuations, and humidity contribute to the degradation of the propellant in the inflators. This degradation can cause the propellant to burn too quickly, creating high pressure inside the inflator, and in extreme cases causing the inflator to rupture in the event of a crash necessitating airbag deployment. A ruptured inflator can send inflator parts toward vehicle occupants resulting in serious injury or death. Additional information regarding Takata recalls can be found at www.nhtsa.gov and www.safercar.gov.
TSB 20-2233
This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.
TSB 19-2026
Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition
SSM 47331
Various vehicles equipped with a 4.6L, 5.4L, 6.8L modular 3 valve engine built on or before 8-Jan-2016 may exhibit symptoms that may include upper end engine noise, rough running, misfire and/or engine damage. If diagnosis leads to only camshaft/camshaft roller follower(s) requiring replacement, replace all of the camshaft roller followers on both banks/cylinder heads with part number 3L3Z-6564-A, not just the faulty roller follower(s). When replacing the camshaft roller followers, refer to Workshop Manual (WSM), Section 303-01.
SSM 47201
Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Lincoln vehicle. Only approved Genuine Ford accessories or originally installed systems are supported and certified to function correctly with other vehicle systems. If you suspect a system has been modified, the following resources can be used to verify original equipment: Monroney Label (Window Sticker), Professional Technician Society (PTS) OASIS tab select SYNC or HVBOM. For Genuine Ford accessories use: PTS Workshop Tab select Dealer Installed Accessory or Accessory Installation.
SSM 46332
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR LINCOLN VEHICLE. ONLY APPROVED GENUINE FORD ACCESSORIES OR ORIGINALLY INSTALLED SYSTEMS ARE SUPPORTED AND CERTIFIED TO FUNCTION CORRECTLY WITH OTHER VEHICLE SYSTEMS. IF YOU SUSPECT A SYSTEM HAS BEEN MODIFIED, THE FOLLOWING RESOURCES CAN BE USED TO VERIFY ORIGINAL EQUIPMENT: MONRONEY LABEL (WINDOW STICKER), PROFESSIONAL TECHNICIAN SOCIETY (PTS) OASIS TAB SELECT SYNC OR HVBOM. FOR GENUINE FORD ACCESSORIES USE: PTS WORKSHOP TAB SELECT DEALER INSTALLED ACCESSORY OR ACCESSORY INSTALLATION.
SSM 46085
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate when reading these PIDs and cannot display quickly enough to validate a concern. The PCM automatically monitors these inputs more accurately and will set diagnostic trouble codes (DTCs) when appropriate. Using these PIDs for diagnostics will lead to inaccurate results and improper ETB replacements. If a concern is intermittent and no DTCs are present, refer to historical DTCs and the PC/ED, Section 3 No DTCs Present Index chart for further information.
14B09
FORD: SOME 2005-2006 FORD GT AND 2005-2008 MUSTANG VEHICLES WILL BE RECEIVING DRIVER AIRBAG INFLATOR REPLACEMENTS. *TA
14B04
FORD: 2005-2006 FORD GT, 2005-2008 MUSTANG, AND 2004-2005 RANGER VEHICLES OPERATED IN FLORIDA, HAWAII, PUERTO RICO, OR THE U.S VIRGIN ISLANDS ARE IN NEED OF AN AIRBAG INFLATOR REPLACEMENT. 06/11/15 *TA.
ASI-44352
FORD: DUE TO VEHICLES, WITH CARBON FIBER CLUTCHES, A CHATTER OR MOAN/GROAN NOISE IS HEARD WHILE MAKING SHARP TURNS, AT LOW SPEED AND IS CHARACTERISTIC OF HEAVY DUTY/RACING TYPE LIMITED SLIP DIFFERENTIAL. MODEL 2007-2014 MUSTANG GT500, GT, BULLITT. *PE
TSB-12-7-4
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
AS-21769
FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
TSB-10-23-8
FORD: 2007-2009 MUSTANG. A WIRING HARNESS CONNECTION MAY BE CAUSING THE AIR BAG LIGHT TO ILLUMINATE IN VEHICLES WITH SIDE AIR BAGS. *RM
TSB-09-19-11
FORD: SOME VEHICLES (SHELBY GT 500) MAY EXHIBIT THE FOLLOWING CLUTCH/TRANSMISSION SYMPTOMS: HARD TO DISENGAGE OR ENGAGE 1ST AND REVERSE, HARD TO SHIFT ANY GEAR, VEHICLE CREEPS WITH TRANSMISSION IN GEAR AND CLUTCH PEDAL FULLY DEPRESSED WITHOUT BRAKE PEDAL APPLICATION. *PE
TSB-08-26-7
FORD: VEHICLE MAY EXHIBIT A DIFFICULT TO DIAGNOSE WATER LEAK IN THE FRONT FLOOR AREA. MAY BE CAUSED BY LOOSE GROMMETS AND/OR SEALER SKIPS AROUND THE COWL AREA, LOOSE A-PILLAR WINDOW WEATHERSTRIP RETAINER. *PE
ASI-08-26-07
FORD; SOME VEHICLES MAY EXHIBIT A DIFFICULT TO DIAGNOSE WATER LEAK IN FRONT FLOOR AREA. THIS MAY BE CAUSED BY LOOSE GROMMETS AND/OR SEALER SKIPS AROUND COWL AREA, LOOSE A PILLAR WINDOW WEATHERSTRIP RETAINER. *PE
20523
FORD: AIRBAG LIGHT-PRETENSIONER PIGTAIL KIT AVAILABLE. VEHICLES MAY EXHIBIT AIRBAG LIGHT WITH B2292 HARD FAULT CODE POINTING TOWARD SEAT BELT PRETENSIONER. REPLACE BODY WIRING HARNESS CONNECTOR. *PE
TSB-08-9-2
FORD: UN-COMMANDED PERIMETER LIGHTING. VEHICLES MAY EXHIBIT UN-COMMANDED PERIMETER LIGHTING FEATURE (HEAD, PARK AND SIDE MARKER LAMPS) DUE TO WATER INDUCED SHORT TO GROUND IN THE DOOR DISARM SWITCH. *PE
TSB-08-9-6
FORD: 4.6L WITH TR3650 MANUAL TRANSMISSION; CLASH OR RASPY FEEL; SHIFTING INTO 2ND AND/OR 3RD GEAR. CONDITION MAY BE MORE PRONOUNCED WHEN THE TRANSMISSION IS COLDER THAN 40 DEGREES F (5 DEGREES C). *PE
19997
MUSTANG VEHICLES EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS CAN NOT BE RETROFITTED NOR DAYTIME RUNNING LAMPS (DRL) ENABLED. *NJ
TSB-07-14-6
FORD: IN SOME VEHICLES THERE MAY EXHIBIT A DIFFICULT DIAGNOSE OF A WATER LEAK IN THE FRONT FLOOR AREA. *PE
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.