Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
CS2312_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) did receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
SC340_TSB_R5
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA II 2.4L GDI EMISSIONS: ECM LOGIC IMPROVEMENT (SC340 REVISION 5) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Electronic Control Module ‘ECM’ system software for certain 2016-2020MY Optima, 2016-2020MY Sorento, 2017-2022MY Sportage vehicles equipped with 2.4L Theta II engines listed in the table below. Kia has become aware that certain 2016-2022MY vehicles equipped with 2.4L Theta II engines may have engine calibrations that were not optimized for emissions standards under certain specific conditions. These calibrations may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect your health and welfare from the dangers of air pollution.
SC340_OWNR_JF&JFA_104
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC340 FLIGHT 104 ) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) for certain 2016-2020 MY Optima vehicles equipped with 2.4L Gas Direct Injection (GDI) engines to ensure compliance with emissions regulations.
SC340_TSB_R4
Emissions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA II 2.4L GDI EMISSION SECM LOGIC IMPROVEMENT (SC340 REV 4) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Electronic Control Module ‘ECM’ system software for certain 2016-2022MY vehicles equipped with 2.4L Theta II engines listed in the table below. Kia has become aware that certain 2016-2022MY vehicles equipped with 2.4L Theta II engines may have engine calibrations that were not optimized for emissions standards under certain specific conditions. These calibrations may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect your health and welfare from the dangers of air pollution.
TSB_CS2312_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whole Integrated Body control Unit (IBU) / Body Control Module (BCM) did receive the Ant-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
SC340_OWNR_JF103
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC340 FLIGHT 103 / JF) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) for certain 2016-2020 MY Optima vehicles equipped with 2.4L Gas Direct Injection (GDI) engines to ensure compliance with emissions regulations.
TSB_CS2312
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 19, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) did receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.
CS2312_OWNR
Other
CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION (CS2312) - This document is the owner notification advising that Kia is conducting Customer Satisfaction Campaign. A software upgrade that addresses the social media theft method has been made available to owners of eligible Kia model vehicles free of charge at authorized Kia dealers since 2023. In addition to the anti-theft software, a new zinc-reinforced ignition cylinder protector hardware upgrade has been developed and can be installed at the ignition cylinder location to provide additional protection against the social media theft method. Because the subject Kia vehicles were not factory-equipped with an engine immobilizer and were previously eligible for the software upgrade, these vehicles are eligible until March 31, 2027, to have the ignition cylinder protector installed—if requested—at no cost through an authorized Kia dealership. (Mailing of these notifications to vehicle owners will be completed from December 17, 2025 through February 27, 2026)
PS797
Other
PITSTOP: TECHNICAL OPERATIONS: EXTERNAL DAMAGE TO ULTRASONIC SENSOR: This Pitstop provides information related to Parking Distance Warning (PDW) alerts and repairs involving ultrasonic sensors. The PDW system alerts the driver while parking, by calculating distance based on the difference in signal transmission and reception times between the vehicle (ultrasonic sensor) and an object. The membrane film of the ultrasonic sensor is used for object detention and can be damaged by stone chips or foreign substances while driving. Damage to the cover of the ultrasonic sensor can also lead to damage to the internal circuit. As a result of this external damage, the PDW system may not receive the proper signal from the ultrasonic sensor. In some cases, the system may cause a false alarm, no alert, or phantom warnings by a “Warning Lamp’ to be displayed on the cluster. The ultrasonic sensor membrane film should be always inspected for external damage and if any part replacement should be treated as a general repair, not as a warranty claim repair for this concern. (Please note that this Pitstop only applies to models/trims that are equipped with the ultrasonic sensors.)
SC340_OWNR_JF101
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC340 FLIGHT 101 / JF) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) for certain 2016-2020 MY Optima vehicles equipped with 2.4L Gas Direct Injection (GDI) engines to ensure compliance with emissions regulations.
SC340_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA II 2.4L GDI EMISSIONS ECM LOGIC IMPROVEMENT (SC340) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Electronic Control Module ‘ECM’ system software for certain 2016-2022MY vehicles equipped with 2.4L Theta II engines listed in the table below. Kia has become aware that certain 2016-2022MY vehicles equipped with 2.4L Theta II engines may have engine calibrations that were not optimized for emissions standards under certain specific conditions. These calibrations may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect your health and welfare from the dangers of air pollution.
SC340_OWNR_JF102
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC340 FLIGHT 102 / JF) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) for certain 2016-2020 MY Optima vehicles equipped with 2.4L Gas Direct Injection (GDI) engines to ensure compliance with emissions regulations.
SC340_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: THETA II 2.4L GDI EMISSIONS ECM LOGIC IMPROVEMENT (SC340) - This bulletin has been revised to include additional information. New / revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Electronic Control Module ‘ECM’ system software for certain 2016-2022MY vehicles equipped with 2.4L Theta II engines listed in the table below. Kia has become aware that certain 2016-2022MY vehicles equipped with 2.4L Theta II engines may have engine calibrations that were not optimized for emissions standards under certain specific conditions. These calibrations may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect your health and welfare from the dangers of air pollution.
SC340_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA II 2.4L GDI EMISSIONS ECM LOGIC IMPROVEMENT (SC340) - This bulletin provides information to upgrade the Electronic Control Module ‘ECM’ system software for certain 2016-2022MY vehicles equipped with 2.4L Theta II engines listed in the table below. Kia has become aware that certain 2016-2022MY vehicles equipped with 2.4L Theta II engines may have engine calibrations that were not optimized for emissions standards under certain specific conditions. These calibrations may cause the vehicle to release air pollutants which exceed Federal and California standards. These standards were established to protect your health and welfare from the dangers of air pollution.
SC340_DP
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO (SC340) - This document is the announcement to the dealer principals advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations in certain 2017-2022 MY Sportage vehicles manufactured from December 10, 2015, through December 7, 2021, certain 2016-2020 MY Optima vehicles manufactured from August 28, 2015, through June 23, 2020, and certain 2016-2020 MY Sorento vehicles manufactured from October 27, 2014, through November 4, 2020, equipped with 2.4L Theta GDI engines.
SC340_DPSM
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO (SC340) - This document is the announcement to the dealer Parts and Service managers advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions software logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations in certain 2017-2022 MY Sportage vehicles manufactured from December 10, 2015, through December 7, 2021, certain 2016-2020 MY Optima vehicles manufactured from August 28, 2015, through June 23, 2020, and certain 2016-2020 MY Sorento vehicles manufactured from October 27, 2014, through November 4, 2020, equipped with 2.4L Theta GDI engines.
SC340_POC
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: SC340_POC: PROOF OF CORRECTION CARD
SC340_QA
Emissions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER (SC340) - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign SC340.
SC340_STKR
Emissions
SC340_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION LABEL/STICKER
TSB_TRA046_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.
TSB_ENG222_R8
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the table on pages 9 and 10 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ENG222_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2024MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
TSB_CLI057
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) BLOWER MOTOR FUSE RELOCATION - This bulletin provides the procedure to relocate the Heating, Ventilation, and Air Conditioning (HVAC) blower motor 40-ampere fuse on some 2016-2020MY Optima (JFa) vehicles produced from August 28, 2015 through June 23, 2020 which may experience an inoperative blower motor due to a blown multi-fuse at position #3. The HVAC system provides cooling and heating to help maintain a comfortable environment inside the vehicle cabin. The blower motor provides primary airflow for the HVAC system. Extended use of the HVAC system at high fan speeds may cause damage to the multi-fuse terminals for the HVAC blower motor circuit, which can cause the blower motor to become inoperative, resulting in reduced heat and air conditioning.
CS2303_TSB_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2011-2015MY Optima (TF), 2012-2015MY Optima (QF) and 2016-2020MY Optima (JF, JFa) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.
TSB_TRA046_R4
Service Bulletin/Repair Instructions
This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced.
PI1802YZ_TSB_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement"; equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
TSB_TRA072_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units.
CS2310_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 7. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.
CS2303C_OWNR2
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
CS2303D_OWNR2
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of the original letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to the vehicle to discourage a break-in.
CS2303_TSB_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2011-2015MY Optima (TF), 2012-2015MY Optima (QF) and 2016-2020MY Optima (JF, JFa) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
CS2310_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin provides information to update the software logic in the Kia Genuine Remote Start Control Module on certain 2012-2022MY model vehicles listed on page 6. Vehicles equipped with a Kia Genuine Remote Start feature and have had the Anti-Theft software logic (CS230*) applied to the Integrated Body Control Unit (IBU) or Body Control Module (BCM) may experience five (5) inadvertent honks after starting the vehicle with the remote start feature.
TSB_TRA072_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units.
CS2303_TSB_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2011-2015MY Optima (TF), 2012-2015MY Optima (QF) and 2016-2020MY Optima (JF, JFa) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked.
CS2303D_OWNR
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of this letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to your vehicle to discourage a break-in.
CS2303_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2011-2015MY Optima (TF), 2012-2015MY Optima (QF) and 2016-2020MY Optima (JF, JFa) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
CS2303C_OWNR
Service Bulletin/Repair Instructions
CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system should a locked vehicle be the subject of a break-in and theft attempt without the key. This software upgrade will be available to the customer free of charge for eighteen (18) months from the date of this letter. When the software upgrade is complete, Kia will also provide the customer with window stickers that can be applied to your vehicle to discourage a break-in.
CS2303_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Module (BCM) system on certain 2011-2015MY Optima (TF), 2012-2015MY Optima (QF) and 2016-2020MY Optima (JF, JFa) vehicles produced within the dates outlined on page 10, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation.
TSB_ELE273
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: HIGH-VOLTAGE BATTERY SAFETY PLUG FUSE INSPECTION AND REPLACEMENT - This bulletin provides information associated with the "Hybrid System Warranty Extension Program" (WTY029) to inspect and, if necessary, replace the High Voltage Battery (HVB) Safety Plug Fuse Assembly or Main Fuse on 2013-2016MY Optima Hybrid (TF HEV) vehicles produced from September 27, 2012 through July 22, 2015.
TSB_TRA046_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2.
WTY028_TSB_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FUEL PUMP FILTER INSPECTION/REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information associated with the 'Warranty Extension Program' (WTY028) to inspect and, if necessary, replace the fuel pump filter assembly on 2016-2020MY Optima (JFa) vehicles produced from August 28, 2015 through June 23, 2020, for repairs that may be necessary to address a low-pressure fuel pump failure to be covered for 15 years / 150,000 miles, whichever comes first starting from the date the vehicle was first put into service. The affected vehicles may exhibit an intermittent reduction in engine power, contain an active or stored DTC P1233 and/or exhibit a 'No Start' condition due to a cracked fuel pump filter housing.
WTY028_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: FUEL PUMP FILTER INSPECTION/REPLACEMENT - This bulletin provides information associated with the 'Warranty Extension Program' (WTY028) to inspect and, if necessary, replace the fuel pump filter assembly on 2016-2020MY Optima (JFa) vehicles produced from August 28, 2015 through June 23, 2020, for repairs that may be necessary to address a low-pressure fuel pump failure to be covered for 15 years / 150,000 miles, whichever comes first starting from the date the vehicle was first put into service. The affected vehicles may exhibit an intermittent reduction in engine power, contain an active or stored DTC P1233 and/or exhibit a 'No Start' condition due to a cracked fuel pump filter housing.
TSB_ENG219_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
TSB_SST067_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: BEARING CLEARANCE TESTER (BCT) PROCEDURES - This bulletin provides information regarding test procedure of the Bearing Clearance Tester (BCT) Special Service Tool (SST). The SST comes pre-calibrated from the supplier however, in some cases, due to variable shop compressor air pressure, the SST may need to be re-calibrated to ensure that the tool provides accurate readings when testing the engine rod bearing wear. The calibration and BCT measuring point maintenance is included in this bulletin.
SC205_OWNR
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to update the software programming on your vehicle's Engine Control Module (SC205).
SC205_DP
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals that Kia is conducting a Voluntary Emissions Service Campaign on 2016-2020 MY Kia Optima vehicles equipped with the 2.0L Turbo-GDI engine to update the emission related logic of the Engine Control Module "ECM" with an improved version to ensure compliance with emissions regulations.
SC205_DPSM
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers that Kia is conducting a Voluntary Emissions Service Campaign on 2016-2020 MY Kia Optima vehicles equipped with the 2.0L Turbo-GDI engine to update the emission related logic of the Engine Control Module "ECM" with an improved version to ensure compliance with emissions regulations.
SC205_POC
Service Bulletin/Repair Instructions
SC205_POC: PROOF OF CORRECTION CARD
SC205_QA
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign (SC205).
SC205_STKR
Service Bulletin/Repair Instructions
SC205_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION STICKER
SC205_TSB
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA 2.0L T-GDI ULEV LOGIC IMPROVEMENT FOR EMISSIONS (SC205) - This bulletin provides the procedure to update the emissions-related logic of the Engine Control Unit (ECU) on some 2016-2020MY Optima (JFa) ULEV vehicles, equipped with 2.0L T-GDI Theta engines, produced from April 21, 2015 through May 22, 2020, in order to improve fuel quantity learning to decrease the deterioration of the rear Oxygen Sensor.
WTY028_OWNR
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: OWNER NOTIFICATION - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage for repairs related to low-pressure fuel pump failure in 2016-2020 MY Optima vehicles manufactured at a Kia assembly plant in the U.S. from 5 years / 60,000 miles to 15 years / 150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY028_DP
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals that Kia is extending the New Vehicle Limited Warranty coverage for repairs related to low-pressure fuel pump failure for 2016-2020 MY Optima vehicles manufactured at a Kia assembly plant in the U.S. from 5 years/60,000 miles to 15 years/ 150,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address certain concerns related to the potential failure of the low-pressure fuel pump.
WTY028_DPSM
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers that Kia is extending the New Vehicle Limited Warranty coverage for repairs related to low-pressure fuel pump failure for 2016-2020 MY Optima vehicles manufactured at a Kia assembly plant in the U.S. from 5 years/60,000 miles to 15 years/ 150,000 miles, whichever comes first, starting from the date the vehicle was first put into service. This warranty extension is to address certain concerns related to the potential failure of the low-pressure fuel pump.
WTY028_QA
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension (WTY028).
WTY028_REIMB
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: REIMBURSEMENT FORM - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension program launch.
PS720
Service Bulletin/Repair Instructions
PITSTOP: INJECTOR HARNESS ROUTING FOR PI1802Y/Z AND PI1803Y/Z ENGINE REPLACEMENTS - This bulletin provides information to address a no-start or hard start with poor running condition after engine replacement under PI1802Y/Z or PI1803Y/Z. Some replacement long blocks may come with pre-installed fuel rail, injectors, and injector wiring harness. If the condition is present, it is possible that the injector harness was not installed correctly. The connections may be swapped from cylinder No. 1 and cylinder No. 4, and from cylinder No. 2 and cylinder No. 3.
WTY023_TSB
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MDPS WARNING LAMP DIAGNOSTIC INSPECTION & SINGLE PARTS REPLACEMENT - This bulletin provides information regarding the diagnosis of Motor Driven Power Steering (MDPS), also known as Electronic Power Steering (EPS), and parts replacement associated with the âÂÂWarranty Extension Programâ (WTY023) on 2016-2017MY Optima (JF/JFa), 2017MY Optima HEV/PHEV (JF P/HEV), 2016-2017MY Sorento (UMa) vehicles produced in the ranges listed below. The affected vehicles may exhibit the MDPS (also known as EPS) warning lamp âÂÂONâÂÂ. The warranty coverage for repairs related to the MDPS unit due to illumination of the MDPS warning lamp has been extended to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
TSB_ENG222_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
WTY023_OWNR_JF
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: OWNER NOTIFICATION - This document is the notification to owners of the warranty extension program for WTY023. Kia is extending the New Vehicle Limited Warranty coverage for repairs related to the Motor Driven Power Steering (MDPS) unit, also known as Electronic Power Steering (EPS) unit, due to illumination of the EPS warning light for all 2016-2017 MY Optima vehicles from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY023_REIMB_JF
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: REIMBURSEMENT FORM - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extension program launch.
TSB_ENG222_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
WTY023_DP
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals of the warranty extension program for WTY023. Kia America, Inc., is extending the New Vehicle Limited Warranty coverage for the Motor Driven Power Steering (MDPS) unit, also known as Electronic Power Steering (EPS) unit, from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY023_DPSM
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers of the warranty extension program for WTY023. Kia America, Inc., is extending the New Vehicle Limited Warranty coverage for the Motor Driven Power Steering (MDPS) unit, also known as Electronic Power Steering (EPS) unit, from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
WTY023_QA
Service Bulletin/Repair Instructions
WARRANTY EXTENSION: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the warranty extension (WTY023). Kia America, Inc., is extending the New Vehicle Limited Warranty coverage for the Motor Driven Power Steering (MDPS) unit, also known as Electronic Power Steering (EPS) unit, from 5 years/60,000 miles to 15 years/150,000 miles, whichever comes first, starting from the date the vehicle was first put into service.
PI1802YZ_TSB_R6
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement" equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
TSB_ENG222_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2021MY vehicles (refer to the tables on pages 8-9 for applicable models and engine), which may exhibit a symptom of excessive oil consumption.
PI1802YZ_TSB_R5
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published PI1802 titled "Knock Sensor Detection System - ECU Logic Improvement" equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
TSB_SST067_R1
Service Bulletin/Repair Instructions
This bulletin provides information regarding test procedure of the Bearing Clearance Tester (BCT) Special Service Tool (SST). The SST comes pre-calibrated from the supplier however, in some cases, due to variable shop compressor air pressure, the SST may need to be re-calibrated to ensure that the tool provides accurate readings when testing the engine rod bearing wear. The calibration and BCT measuring point maintenance is included in this bulletin.
TSB_CHA084_R8
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit. On some vehicles when the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly and does not affect the steering effort.
TSB_BOD055_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to some Kia models that may exhibit fogging, condensation, and/or moisture inside a headlamp assembly. Generally, a fogging condition is considered normal and can be eliminated by turning on the headlamps with the engine running for up to 30 minutes or during normal driving conditions. Headlamp assembly replacement WILL NOT be necessary in most cases.
TSB_ENG222_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
TSB_TRA083_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed in the table below, equipped with the 7 Speed Dual Clutch Transmission (DCT), which might exhibit clutch judder when accelerating from a stop.
TSB_TRA098
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 7-SPEED DUAL CLUTCH TRANSMISSION (DCT) ANTI-JUDDER LOGIC IMPROVEMENT - This bulletin provides the procedure to update the software logic of the Dual Clutch Transmission (DCT) system on some 2016-2020MY Optima (JFa) vehicles produced from August 28, 2015 through June 1, 2020, equipped with Gamma 1.6L T-GDI engine and 7-speed DCT, which might exhibit clutch judder when accelerating from a stop.
TSB_CHA106
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF THE DUAL PINION MOTOR DRIVER POWER STEERING SYSTEM - This bulletin provides information regarding the availability of partial repair (depending on faulty components) of the Dual Pinion Motor Driven Power Steering (DP-MDPS) system on some 2016-2021MY~ Kia vehicles (refer to the table below) in order to enhance customer satisfaction by promoting a cost-effective repair/replacement of a faulty related part, instead of replacement of the complete DP-MDPS assembly.
PS704
Service Bulletin/Repair Instructions
PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in the Forward Collision-Avoidance Assist (FCA)/Smart Cruise Control (SCC) system.
TSB_CHA084_R7
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Steering Column Housing, or Worm Gear Assembly. When the steering wheel is rotated a scraping noise can be heard originating from the lower bearing on the Worm Gear Assembly on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
TSB_BOD300
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: WINDOW REGULATOR DRUM GEAR REPLACEMENT - This bulletin provides the procedure to replace the window regulator drum gear on some 2016-2017MY Optima (JFa) vehicles, produced from September 01, 2015 through July 31, 2016, which may exhibit an inoperative window regulator due to a drum gear separating and/or breaking.
TSB_ENG222_R2
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
TSB_ENG222_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information on diagnosing and/or repairing some 2011-2019MY vehicles (refer to table below for applicable model and engine), which may exhibit a symptom of excessive oil consumption.
TSB_FUE049
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: COMBINATION TSB / SERVICE ACTION: AIR FILTER AND NVLD REPLACEMENT (SA447) - This bulletin provides the procedure to perform an evaporative leak test and replace the Fuel Tank Air Filter, and, if necessary, the Natural Vacuum Leak Detector (NVLD) on some 11-16MY Kia vehicles listed in the table below, which may experience an evaporative leak concern with DTC P0456.
TSB_TRA083
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed on the table below, equipped with the 7 Speed Dual Clutch Transmission (DCT), which might exhibit clutch judder when accelerating from a stop. If the vehicle body vibrates without the steering wheel shuddering when performing creep driving test (driving the vehicle up to 3mph), the vehicle is exhibiting clutch judder. The creep test can be conducted by driving at a speed slower than 5 mph after releasing the brake.
TSB_CHA084_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PI1802YZ_TSB_R4
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled âÂÂKnock Sensor Detection System - ECU Logic Improvementâ equipped w/THETA II engine. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
TSB_CHA084_R5
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU), Worm Gear Assembly or Steering Column Housing on some 2010MY~ Kia models listed on page 8, equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PS663
Service Bulletin/Repair Instructions
PITSTOP: MFC, CONCERNS FOR DISABLED OPERATION - This Pitstop provides information regarding concerns with disabled operation of Multi-Function Camera (MFC) on some Kia vehicles. When normal operation is not possible due to certain outside environment conditions (such as sunlight glare, heavy rain, sunlight, snow, fog and/or substance/debris) causing a temporary concern. This stops operation causing Warning Lamp ON and/or Pop-up Message displayed on the cluster. This is a normal operation of the ADAS and once environment conditions improve and/or substance/debris are removed, the system will clear itself and operate normally.
PS299_R4
Service Bulletin/Repair Instructions
PITSTOP: CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. When servicing windshield wipers on the below listed vehicles, including during PDI, ensure to raise the wiper arms to a vertical position to avoid damaging the paint on the rear edge of the hood.
PS675
Service Bulletin/Repair Instructions
PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.
TSB_CHA098_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: IBAU SYSTEM REPAIR FOR NOISE AND AIR BLEEDING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the repair procedure for the Integrated Brake Actuation Unit (iBAU) system on some 2014-2019MY EV/Hybrid/Plug-In Hybrid vehicles listed (see table), which may exhibit a "honking" (Hissing) noise due to air remaining in the brake fluid system.
PI1802_TSB_R12
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT - TSB_PI1802_R2 - Knock Sensor Detection System - ECU Logic Improvement - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
TSB_ENG219
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin provides information on setting the "Service Interval Reminder" feature available on most Kia vehicles. If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance.
PI1802YZ_TSB_R3
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN - ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z_Rev3) - This bulletin has been revised to include additional information. - This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled "Knock Sensor Detection System - ECU Logic Improvement".
TSB_BOD208
Service Bulletin/Repair Instructions
TSB - This bulletin provides the procedure to perform a partial repair on the trunk latch base sub assembly on the certain Forte, Rio and Optima vehicles, which may exhibit a difficult-to-close/latch concern with the trunk lid.
PI1802YZ_TSB_R2
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN - ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z_Rev2) - This bulletin has been revised to include additional information. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled "Knock Sensor Detection System - ECU Logic Improvement".
PI1802_TSB_R11
Service Bulletin/Repair Instructions
TSB: PRODUCT IMPROVEMENT CAMPAIGN : KNOCK SENSOR DETECTION SYSTEM (KSDS) LOGIC IMPROVEMENT (PI1802_R11) - This bulletin has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
PS608_R1
Service Bulletin/Repair Instructions
PITSTOP: UPDATED SPARK PLUG FOR 2.0T THETA-II - This bulletin has been revised to include additional information. This Pitstop provides information regarding the updated spark plug for vehicles listed below, equipped with 2.0T Theta-II engines, which may not yet be available in the Electronic Parts Catalog (EPC). If not available, the updated spark plug must be ordered manually. This updated spark plug has been improved with the thread shoulder lengthened to enhance protection of the insulator from combustion heat.
TSB_ENG205_C
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: WIRING SIGNAL INTERFERENCE CHECK & ENGINE NOISE INSPECTION (SA379) - CLOSED - SUPERSEDED BY PI1802YZ/1803YZ.
TSB_TRA046_R1
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures.
PI1802YZ_TSB_R1
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled "Knock Sensor Detection System - ECU Logic Improvement". Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below return to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
PI1802WX_TSB_R7C
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: TSB_R7 - ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802W/X) - CLOSED - SUPERSEDED BY PI1802Y/Z.
TSB_BOD201
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PANORAMIC SUNROOF BUZZING NOISE REPAIR - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to September 26, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed.
PI1802YZ_TSB
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: TSB - ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802 Rev 10, 03/16/2020) titled Knock Sensor Detection System - ECU Logic Improvement. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below return to the dealer with Diagnostic Trouble Code (DTC) P1326 (Knock Signal Range/Performance).
PI1802_TSB_R10
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: TSB - REV 10 - KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) - This bulletin has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
PI1802_TSB_R9
Service Bulletin/Repair Instructions
TSB - PRODUCT IMPROVEMENT CAMPAIGN - KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) Rev.9 - This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
TSB_ELE148
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: HALOGEN HEAD LAMP LOW BEAM BULB CONNECTOR REPLACEMENT - This bulletin provides information regarding the procedure to repair the bulb connector on some 2010MY~ vehicles listed on the table below, which may exhibit a bulb connector concern. To correct this concern, replace the connector with a new and improved part.
PI1802WX_TSB_R7
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802W/X) - This bulletin has been revised to include additional information.This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802, Rev 6, 01/31/2019) titled "Knock Sensor Detection System - ECU Logic Improvement". Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (DTC), P1326.
TSB_TRA072_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed in this bulletin. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units.
PS638
Service Bulletin/Repair Instructions
PITSTOP 638: HVAC TEMPERATURE BLEND DOOR INOPERATIVE, TICKING AND/OR MAKING A POPPING NOISE - This Pitstop provides information regarding an inoperative, or clicking and popping noise concern from the heater box blend door.
PI1802_OWN#3_OPT
Service Bulletin/Repair Instructions
Owner Letter - PRODUCT IMPROVEMENT CAMPAIGN (PI1802) **THIRD NOTICE** - Dear Kia Optima Owner: Kia Motors America, Inc. is conducting an important Product Improvement Campaign to perform a software update on some 2014 MY Optima vehicles equipped with 2.4L Gasoline Direct Injection ("GDI") engines, and all 2015-2018 MY Optima vehicles equipped with 2.4L GDI and 2.0L Turbocharged GDI ("T-GDI") engines to protect the engine from excessive connecting rod bearing damage. The update will be done free of charge and will only involve the addition of newly developed computer software for the Engine Control Unit ("ECU").
TSB_TRA085
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: DCT ACTUATOR ROD LENGTH ADJUSTMENT - This bulletin provides the procedure to adjust the Dual Clutch Transmission (DCT) actuator rod lengths using the applicable SST on some 2016MY~ vehicles equipped with 6 speed DCT (D6KF1) or 7 speed DCT (D7UF1) in order to prevent unnecessary replacement of both the DCT clutch actuator and clutch set together.
TSBCHA084_R4
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power Steering (C-MDPS) unit. Follow the MDPS Flowchart (page 2) along with the MDPS DTC Table (page 3) procedure outlined in this bulletin before replacing the C-MDPS Motor, ECU or Steering Column Housing.
PI1802WX_TSB_R6
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN PI1802W/X (Rev 6) - PRODUCT IMPROVEMENT CAMPAIGN - ENGINE REPLACEMENT INSTRUCTIONS - This bulletin has been revised to include additional information. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802, Rev 6, 01/31/2019) titled 'Â"Knock Sensor Detection System - ECU Logic Improvement"ÂÂ. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code ("ÂÂDTC"ÂÂ), P1326.
PI1802_TSB_R8
Service Bulletin/Repair Instructions
TSB - Product Improvement Campaign: KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) - This bulletin has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
TSBCHA084_R3
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN TSB084_R3: PARTIAL REPAIR OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information.This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on some 2010MY~ Kia models listed on page 5 equipped with a Column Motor Driven Power Steering (C-MDPS) unit.
PS616
Service Bulletin/Repair Instructions
PITSTOP: LOWER ENGINE SERVICE COVER BOLT LOCATIONS - This Pitstop provides information on the correct bolt location of the lower engine service cover on 2016-2020MY Optima 2.4L and 2.0L equipped vehicles. The lower engine service cover is secured by seven (7) retaining bolts. Installation of the two (2) long bolts in the incorrect location may cause puncture or damage to the oil pan in the event that the vehicle is bottomed out while driving. If the oil pan is damaged or punctured, the engine oil may leak, possibly causing engine damage. This
TSBCHA100
Service Bulletin/Repair Instructions
TECHNICAL SERVICE BULLETIN (TSBCHA100): SERVICE ACTION: AUTONOMOUS EMERGENCY BRAKE (AEB) LOGIC IMPROVEMENT (SA400) - This bulletin provides the procedure to improve the logic of the Autonomous Emergency Brake (AEB) control unit on some 2016-2017MY Optima (JFa), and 2017MY Sorento (UMa), Forte (YDm), and Sedona (YP) vehicles, which may experience unexpected AEB activation in certain circumstances.
PI1802_TSB_R7
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN - KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) - This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage. The KSDS detects vibrations indicating the onset of excessive connecting rod bearing wear. It is designed to alert the driver at an early stage of bearing wear before the occurrence of severe engine damage, including engine failure. If vibrations caused by bearing wear start to occur, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Limp Home Mode. This will reduce further damage to the engine and ensure that the vehicle occupants are not exposed to the risk of a more severe engine failure. At that time, Diagnostic Trouble Code (âÂÂDTCâÂÂ) P1326, specific to the KSDS, will be recorded in the ECU. The vehicle can continue to be operated for a limited time in Limp Home Mode, but it will accelerate slowly and have a reduced maximum speed. Also, engine RPMs will be limited to approximately 1800-2000 RPM.
TSBENG206
Service Bulletin/Repair Instructions
TSB: 1.6T GDI ULEV MIL ON LOGIC IMPROVEMENT FOR P0128 - This bulletin provides the procedure to improve the logic of the ECU (Electronic Control Unit) on some 2016-2017MY Optima (JFa) 1.6T GDI ULEV DCT vehicles, produced from September 28, 2015 through September 03, 2016, which exhibit a MIL (Malfunction Indicator Lamp) illuminated with DTC P0128, even though there are no system faults.
TSBCHA084_R2
Service Bulletin/Repair Instructions
TSB: REPLACEMENT OF C-MDPS MOTOR, ECU AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor, Electronic Control Unit (ECU) or Steering Column Housing on the Kia models listed on the chart below with a column mounted C-MDPS unit.
TSBTRA078
Service Bulletin/Repair Instructions
TSB: TRANSMISSION LOGIC IMPROVEMENT - This bulletin provides the procedure to optimize the logic of the Transmission Control Unit (TCU) on 2017-2018MY Soul (PS) and Forte (YDm) and 2016-2018MY Optima (JFa) vehicles equipped with 1.6T GDI that have one of the following three components replaced: Dual Clutch Transmission (DCT) assembly; Transmission Control Unit (TCU), and Double Clutch Set.The friction material of the double clutch set has been changed and a TCU logic optimization must be performed in order to prevent initial shift shock.
PI1802_OWNR2_OPT
Service Bulletin/Repair Instructions
PI1802_OWNR2_OPT: Kia Motors America, Inc. is conducting an important Product Improvement Campaign to perform a software update on some 2014 MY Optima vehicles equipped with 2.4L Gasoline Direct Injection ("ÂGDI"Â) engines, and all 2015-2018 MY Optima vehicles equipped with 2.4L GDI and 2.0L Turbocharged GDI ("ÂT-GDI"Â) engines to protect the engine from excessive connecting rod bearing damage. The update will be done free of charge and will only involve the addition of newly developed computer software for the Engine Control Unit ("ÂECU"Â).
PS600
Service Bulletin/Repair Instructions
PITSTOP: OUTSIDE MIRROR GLASS CONTROL INOPERATIVE - This Pitstop provides information on the repair procedure for an inoperative mirror glass on the outside door mirrors for 2016-2019MY Optima (JFa) and Sorento (UMa) vehicles.
TSBELE170
Service Bulletin/Repair Instructions
TSB: ANTENNA CAP REPLACEMENT - This bulletin provides the procedure to replace the antenna cover that is loose and/or has separated from the antenna base on some 2016-2017MY Optima (JFa) vehicles, produced from August 25, 2015 through May 2, 2017.
PI1802WX_TSB_R5
Service Bulletin/Repair Instructions
TSB: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802W/X) - This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802, Rev 6, 01/31/2019) titled "Knock Sensor Detection System - ECU Logic Improvement". Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code ("DTC"), P1326.
TSBENG205_R1
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: WIRING SIGNAL INTERFERENCE CHECK & ENGINE NOISE INSPECTION (SA379) - This bulletin provides information related to an expanded diagnostic test that is now required on a number of vehicles previously diagnosed with Diagnostic Trouble Code ("DTC") P1326. Using the procedures published in TSB PI1802W/X and PI1803W/X, the subject vehicles were diagnosed and determined to require an engine replacement and are currently being held at dealers pending repair. As a result of additional field data collection and analysis, the initial diagnosis method has been updated to improve test result accuracy. Prior to performing an engine replacement on any of the VINs affected by this Service Action, the engine condition needs to be re-assessed utilizing an updated/expanded diagnostic process.
TSBENG205
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: WIRING SIGNAL INTERFERENCE CHECK & ENGINE NOISE INSPECTION (SA379) - This bulletin provides information related to an expanded diagnostic test that is now required on a number of vehicles previously diagnosed with Diagnostic Trouble Code ("DTC") P1326. Using the procedures published in TSB PI1802W/X and PI1803W/X, the subject vehicles were diagnosed and determined to require an engine replacement and are currently being held at dealers pending repair. As a result of additional field data collection and analysis, the initial diagnosis method has been updated to improve test result accuracy. Prior to performing an engine replacement on any of the VINs affected by this Service Action, the engine condition needs to be re-assessed utilizing an updated/expanded diagnostic process.
PI1802WX_TSB_R4
Service Bulletin/Repair Instructions
TSB: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802W/X) - This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802, Rev 6, 01/31/2019) titled "Knock Sensor Detection System - ECU Logic Improvement". Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code ("DTC"), P1326.
VPI1802WX_TSB_R3
Service Bulletin/Repair Instructions
VEHICLE PRODUCT IMPROVEMENT: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802W/X)- This bulletin has been revised to include additional information This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802, Rev 6, 01/31/2019) titled ?Knock Sensor Detection System - ECU Logic Improvement?. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (?DTC?), P1326..
VPI1802_TSB_R6
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN:KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) - This bulletin has been revised to include additional information.This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
VPI1802WX_TSB_R2
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802W/X) - This bulletin has been revised to include additional information. This bulletin provides information related to the Technical Service Bulletin previously published in July 2018 (PI1802, Rev 5, 12/20/2018) titled ?Knock Sensor Detection System - ECU Logic Improvement?. Specifically, this bulletin provides instructions on which procedures to follow if, after installation of the KSDS, any one of the subject vehicles below returns to the dealer with Diagnostic Trouble Code (?DTC?), P1326.
DC_20190125
Service Bulletin/Repair Instructions
RECENT KIA MEDIA REPORTS, January 25, 2019 Update - Dear Kia Retailer, At Kia, safety is a top priority and we wrote to you last August and again last October to provide you with updates regarding news reports about non-collision fires in Kia vehicles and the status of Kia?s cooperative work with NHTSA.
TSBENG083_R1
Service Bulletin/Repair Instructions
TSB: SPECIAL SERVICE INFORMATION & SPECIFICATIONS FOR GDI HIGH PRESSURE FUEL SYSTEM - This bulletin has been revised to include additional information. This bulletin provides information relating to all Kia vehicles equipped with Gasoline Direct Injection (GDI) engines. In these engines highly pressurized gasoline is injected via a common fuel rail and injectors that deliver fuel directly into the combustion chamber of each cylinder. In comparison, in a conventional Multi-Point Fuel Injection (MPI) engine, the gasoline is injected into the intake port of each cylinder at a relatively low pressure. Due to high fuel pressure in a GDI system, servicing the GDI system requires special attention and handling procedures. This bulletin provides special service information and specifications for the GDI fuel system components.
TSBCHA084_R1
Service Bulletin/Repair Instructions
TSB: REPLACEMENT OF C-MDPS MOTOR AND/OR ECU - This bulletin has been revised to include additional information. This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor and/or Electronic Control Unit (ECU) on the listed Kia models with a column mounted C-MDPS unit.
VPI1802_TSB_R5
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN - This bulletin has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage.
VPI1802_TSB_R4
Service Bulletin/Repair Instructions
PRODUCT IMPROVEMENT CAMPAIGN - This TSB has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage
VPI1802_TSB_R3
Service Bulletin/Repair Instructions
VEHICLE PRODUCT IMPROVEMENT CAMPAIGN - KNOCK SENSOR DETECTION SYSTEM - ECU LOGIC IMPROVEMENT (PI1802) - This bulletin has been revised to include additional information. This bulletin provides information related to a software update to the Engine Control Unit (ECU) to install the Knock Sensor Detection System (KSDS) in order to protect the engine from excessive connecting rod bearing damage
VPI1802_OWNER_OP
Service Bulletin/Repair Instructions
Dear Kia Optima Owner: Kia Motors America, Inc. is conducting an important Product Improvement Campaign to perform a software update on all 2016-2018 MY Optima vehicles equipped with 2.4L Gasoline Direct Injection (?GDI?) and 2.0L Turbocharged GDI (?T-GDI?) engines to protect the engine from excessive connecting rod bearing damage. The update will be done free of charge and will only involve the addition of newly developed computer software for the Engine Control Unit (?ECU?).
TSBCHA091
Service Bulletin/Repair Instructions
TSB: STEERING GEAR YOKE PLUG AND ASSEMBLY REPLACEMENT - This bulletin provides the procedure to replace the steering gear box yoke plug and assembly on some models listed below, which may exhibit a ticking noise while turning the steering wheel with the vehicle stopped. This condition is caused by a worn lining on the steering gear box yoke assembly. Follow the procedure outlined in this bulletin to replace the steering gear box yoke plug and assembly with updated parts.
TSBCHA095
Service Bulletin/Repair Instructions
TSB: FRONT STRUT FLANGE NUT REPLACEMENT - This bulletin provides the procedure to replace the front strut flange nut on some 2016MY Optima (JF) vehicles, produced from February 2, 2016 through May 19, 2016, which may exhibit a noise coming from the front strut area while driving on uneven surfaces or a bumpy road. Diagnose the noise complaint and once confirmed to be emanating from the front strut area, follow the procedure in this bulletin to replace the front strut flange nut.
TSBCHA084
Service Bulletin/Repair Instructions
TSB: REPLACEMENT OF C-MDPS MOTOR AND/OR ECU - This bulletin provides information regarding the partial repair of the Motor Driven Power Steering (MDPS) Motor and/or Electronic Control Unit (ECU) on the listed Kia models with a column mounted C-MDPS unit. Follow the procedure outlined in this bulletin.
PS299_R3
Service Bulletin/Repair Instructions
PITSTOP - CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - When servicing the windshield wipers on the listed vehicles below during PDI, make sure to use the procedure outlined below to raise the wiper arms to the fully vertical position in order to avoid damaging the paint on the rear edge of the hood. It is important to note that the wipers on these vehicles are recessed under the hood to provide better appearance and reduced wind noise characteristics. This procedure applies to both key start and SMK type ignition systems.
PS299_R2
Service Bulletin/Repair Instructions
PITSTOP - CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - When servicing the windshield wipers on 2015MY~ K900 (KH), 2016MY~ Optima (JFa/JF), and 2018MY~ Stinger (CK) vehicles during PDI, make sure to use the procedure outlined below to raise the wiper arms to the fully vertical position in order to avoid damaging the paint on the rear edge of the hood. It is important to note that the wipers on these vehicles are recessed under the hood to provide better appearance and reduced wind noise characteristics.
VPI1802_QA
Service Bulletin/Repair Instructions
Q & A - This document is the Q & A for the new Product Improvement Campaign to provide information regarding a software update to the Engine Control Unit (ECU) to protect the engine from excessive connecting rod bearing damage.
VPI1802_DP
Service Bulletin/Repair Instructions
DEALER PRINCIPAL NOTICE - This notice advised the dealer principal of the new Product Improvement Campaign to perform a software update to the Engine Control Unit (ECU) to protect the engine from excessive connecting rod bearing damage.
VPI1802_DSM
Service Bulletin/Repair Instructions
DEALER SERVICE MANAGER NOTICE - This notice advised the dealer service manager of the new Product Improvement Campaign to perform a software update to the Engine Control Unit (ECU) to protect the engine from excessive connecting rod bearing damage.
TSBENG175_R3
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin has been revised to include additional information. This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
PS539
Service Bulletin/Repair Instructions
PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed during engine repairs should be considered serviceable, and should be thoroughly cleaned and transferred to the new engine.
TSBELE143
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: OUTSIDE REAR COMBINATION LAMP HARNESS REPLACEMENT (SA334) - This bulletin provides the procedure to replace the outside rear combination lamp harness on some 2016-2017MY Optima (JFa) vehicles, produced from September 25, 2016 through March 16, 2017, which may exhibit an intermittent inoperative brake light with the possibility of a ?Check brake light? warning on the instrument cluster display.
TSBTRA047_R2
Service Bulletin/Repair Instructions
TSB - DRIVESHAFT SERVICEABILITY - This bulletin has been revised most recently to include additional information. This bulletin provides information regarding axle shaft serviceability for Kia vehicles equipped with a six-speed automatic transmission.
TSBTRA072A_R2
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: INHIBITOR SWITCH - REPLACEMENT (SA317A) - This bulletin has been revised to include additional information. - This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the following concerns: ? Malfunction Indicator Lamp (MIL) ON with DTC P0705 - Transmission Range Sensor (TRS) Circuit Malfunction (active or history) ? CAN-related DTCs (For both Hybrids: CAN DTC C2243); ? Intermittent no crank/no start ? Erratic or harsh shifting; ? EPB and Hold lights illuminated intermittently; ? ?Key OFF? indicated after placing the selector lever into the ?P? position and depressing the Start/Stop button.Note: When this condition occurs, the ?P? position is not indicated on the instrument cluster.
TSBENG175_R2
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin has been revised to include additional information. This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
TSBBOD164R1
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: PANORAMIC SUNROOF INSPECTION AND REPAIR (SA270) REV 1 - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to September 26, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed, a popping or clicking noise when driving over bumps or turning, and/or a loose folding cover, depending on the vehicle production date.
PS524
Service Bulletin/Repair Instructions
PITSTOP - OPTIMA TRUNK TORSION BAR ADJUSTMENT - On some 2016-2018MY Optima (JFa) vehicles, there may be a concern with the trunk not opening as designed when using transmitter key fob or Smart Trunk feature. This may be caused by improper assembly of the trunk torsion bar (A) and trunk lid hinge. Follow the procedure in this publication to correct this concern.
TSBENG174
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: AIR INTAKE HOSE REPLACEMENT & ECU UPGRADE (SA303) - This bulletin provides the procedure to replace the air intake hose and/or improve the logic of the Electronic Control Unit (ECU) on some 2016-2017MY Optima (JFa), produced from September 4, 2015 through April 14, 2017, and some 2016-2017MY Sorento (UMa) vehicles, produced from November 19, 2014 through May 1, 2017, equipped with a 2.0T engine, which may exhibit an impaired air intake hose.
TSBENG175R1
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - REVISED - This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
TSBENG175
Service Bulletin/Repair Instructions
TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
TSBENG159R2
Service Bulletin/Repair Instructions
TSB - E-CVVT COVER AND MOTOR PLUG REPLACEMENT - REVISED - This bulletin provides information about the replacement of the E-CVVT cover and motor plug on some 2016MY Optima (JFa), produced from August 29, 2015 to June 14, 2016, and 2016-2017MY Sorento (UMa) vehicles, produced from October 27, 2014 to June 14, 2016, which may exhibit a MIL ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicle models equipped with 2.4L GDI or 2.0 T-GDI engines.
TSBENG161R1
Service Bulletin/Repair Instructions
TSB - DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC16) - REVISED - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California.
PS474
Service Bulletin/Repair Instructions
PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
TSBELE126R1
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: REAR PERSONAL LAMP REPAIR (SA273) - This bulletin provides information related to the rear personal lamp on some 2016MY Optima (JFa) vehicles, produced from September 11, 2015 to August 13, 2016, which may experience a blown Interior Lamp 10A fuse resulting in inoperative interior lamps. Follow the procedure outlined in this bulletin to increase the bulb circuit and the bulb reflector clearances to prevent internal shorting of the lamp assembly resulting in a blown Interior Lamp 10A fuse, and if necessary, replace the Interior Lamp 10A fuse. Replace the lamp only if housing deformation is noticed during the repair procedure.
TSBENG168R1
Service Bulletin/Repair Instructions
TSB: COMBINATION TSB / SERVICE ACTION: IDLE STABILITY & SHIFT QUALITY IMPROVEMENT (SA294A) - This bulletin provides the procedure to improve the logic of the Electronic Control Unit (ECU) and the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) vehicles, produced from September 3, 2015 through October 6, 2016, which may experience a vibration and/or hesitation when releasing the brake pedal after coming to stop, and/or a shift quality concern, such as a harsh downshift, upshift, and/or shift delay. To correct this concern, apply the improved logic to the ECU and TCU using KDS download as described in this bulletin.
TSBTRA069R1
Service Bulletin/Repair Instructions
TSB: COMBINATION TSB / SERVICE ACTION: SHIFT QUALITY IMPROVEMENT (SA292A) - This bulletin provides the procedure to improve the logic of the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) 2.0T, produced from September 11, 2015 through October 6, 2016, 2016MY Sorento (UMa) 2.0T, produced from October 23, 2014 through April 18, 2016, Sorento (UMa) 2.4L, produced from November 18, 2014 through January 19, 2016, and Sorento (UMa) 3.3L vehicles, produced from October 23, 2014 through April 18, 2016, which may experience a shift quality concern, such as a harsh downshift, upshift, and/or shift delay. To correct this concern, apply the improved logic to the TCU using the KDS download as described in this bulletin.
PS496
Service Bulletin/Repair Instructions
PITSTOP: CUSTOMER TIP: ACCELERATOR PEDAL FUNCTION/DESCRIPTION - On all K900 (KH), Cadenza (VG, YG), and Optima (JF, JFa, JF-HEV, JF-PHEV) vehicles, the accelerator pedal features a small detent with a spring to provide increased resistance to help avoid unnecessary fuel consumption when applying full throttle. When the driver depresses the pedal beyond the resistance where the detent is felt (above 85% WOT), the pedal will easily reach WOT and kickdown shift will occur accordingly. For additional information, refer to the individual vehicle?s Owner?s Manual under section ?Driving Your Vehicle? ? Automatic Transmission (Drive).
TSBENG168
Service Bulletin/Repair Instructions
TSB: COMBINATION TSB/SERVICE ACTION: IDLE STABILITY & SHIFT QUALITY IMPROVEMENT (SA294) - This bulletin provides the procedure to improve the logic of the Electronic Control Unit (ECU) and the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) vehicles, produced from September 3, 2015 through November 22, 2016, which may experience a vibration and/or hesitation when releasing the brake pedal after coming to stop, and/or a shift quality concern, such as a harsh downshift, upshift, and/or shift delay. To correct this concern, apply the improved logic to the ECU and TCU using KDS download as described in this bulletin.
TSBTRA069
Service Bulletin/Repair Instructions
TSB: COMBINATION TSB / SERVICE ACTION: SHIFT QUALITY IMPROVEMENT (SA292) - This bulletin provides the procedure to improve the logic of the Transmission Control Unit (TCU) on some 2016MY Optima (JFa) 2.0T, produced from August 28, 2015 through October 7, 2016, Sorento (UMa) 2.0T, produced from October 29, 2014 through December 9, 2016, and Sorento (UMa) 3.3L vehicles, produced from October 27, 2014 through December 22, 2016, which may experience a shift quality concern, such as a harsh downshift, upshift, and/or shift delay. To correct this concern, apply the improved logic to the TCU using the KDS download as described in this bulletin.
TSBCLI038
Service Bulletin/Repair Instructions
TSB: HVAC CONTROL UNIT LOGIC IMPROVEMENT - This bulletin provides the procedure to apply a HVAC control unit logic improvement on some 2016MY Optima (JFa) vehicles, produced from August 28, 2015 through September 30, 2016, and some 2016MY Optima (JF) vehicles, produced from February 2, 2016 through November 23, 2016, equipped with Fully Automatic (FATC) or Manual Temperature (MTC) Controls, which may experience a concern with the evaporator icing under specific driving and ambient temperature and/or humidity conditions. Follow the procedure outlined in this bulletin to apply the HVAC control unit logic improvement to either A/C units using KDS download. For confirmation that the latest reflash has been applied to a vehicle you are working on, verify the ROM ID using the table on page 2 of this bulletin.
TSB-ENG159R1
Service Bulletin/Repair Instructions
TSB: E-CVVT COVER AND MOTOR PLUG REPLACEMENT - This bulletin provides information about the replacement of the E-CVVT cover and motor plug on some 2016MY Optima (JF/JFa), produced from August 29, 2015 to June 14, 2016, 2017MY Sportage (QL) vehicles, produced from December 10, 2015 to June 15, 2016, and 2016-2017MY Sorento (UMa), produced from October 27, 2014 to June 14, 2016, which may exhibit a MIL ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicle models equipped with 2.4L GDI or 2.0 T-GDI engines.
PS493
Service Bulletin/Repair Instructions
TSB: DEFOGGING LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Starting with 2010MY, all Kia vehicles, except Rio (JB), incorporate a defogging logic to prevent the interior windows from becoming excessively fogged. Depending on the specific model, the HVAC control head monitors ambient temperature and/or cabin humidity to determine which settings will best prevent the windows from fogging. If the system detects lower ambient temperature or higher cabin humidity, the defogging logic may automatically switch ON the A/C, and/or set the air intake mode to Fresh Air. If the user changes these settings, the defogging logic will take control again after 3 to 5 minutes, depending on the procedure in this publication.
PS481
Service Bulletin/Repair Instructions
PS481: DUAL CLUTCH TRANSMISSION (DCT) CHARACTERISTICS - All models with a 1.6L Turbo engine may come equipped with a 7-speed Dual Clutch Transmission (DCT), except the 2017MY~ Niro (DE) with a 1.6L Atkinson engine comes equipped with a 6-speed Dual Clutch Transmission (DCT). This automatic transmission is unlike the conventional automatic transmission found in the complete line up of Kia vehicles. The new DCT improves fuel efficiency and can also provide a sportier feel. Certain aspects of this technology may lead to customer concerns if they are unfamiliar with it. To help maximize owner satisfaction on this new technology, Kia would like all dealership sales and service personnel to be familiar with the characteristics of this new transmission.
TSB-ELE130
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: ANTENNA INSPECTION AND/OR REPLACEMENT (SA272) - This bulletin provides the procedure to inspect and/or replace the antenna assembly on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to June 1, 2016, which may experience an antenna cover separation/loss or looseness.
TSB-BOD164
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: PANORAMIC SUNROOF INSPECTION AND REPAIR (SA270) - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to August 8, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed, a popping or clicking noise when driving over bumps or turning, and/or a loose folding cover, depending on the vehicle production date. For details regarding each type of inspection/repair, refer to its respective section below. Before conducting the procedure, verify that the vehicle is included in the list of affected VINs.
TSB-ELE126
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: REAR PERSONAL LAMP REPAIR (SA273) - This bulletin provides information related to the rear personal lamp on some 2016MY Optima (JFa) vehicles, produced from September 11, 2015 to August 13, 2016, which may experience a blown Interior Lamp 10A fuse resulting in inoperative interior lamps.
PS469
Service Bulletin/Repair Instructions
PITSTOP: MANUAL EVAPORATIVE EMISSIONS TEST FOR HARD TO FIND/SMALL LEAKS - If the malfunction indicator lamp (MIL) is illuminated with DTC(s) P0442, P0455, P0456, or P0457 (Evaporative Emissions System-Leak detected) and the evaporative (EVAP) leak self-test resulted in NTF, a manual EVAP test is recommended.
TSB-GEN085R1
Service Bulletin/Repair Instructions
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners, which are designed to lock into place once fully attached, are utilized in various Kia models and are strictly intended for ?one time use.? Some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.? It is critical for technicians to be aware that ALL such locking fasteners, regardless of type, are for ?one time use? only.
TSB-BOD161
Service Bulletin/Repair Instructions
TSB - LUGGAGE SIDE TRIM REPLACEMENT - This bulletin provides the procedure to replace the luggage side trims on 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to August 16, 2016, which may experience a concern with high cabin pressure. This concern is caused by the isolation pads of the luggage side trim assemblies blocking the extractor vents. Follow the procedure outlined in this bulletin to replace the left and right luggage side trims.
TSB-ENG158R2
Service Bulletin/Repair Instructions
TSB: VCM LOGIC IMPROVEMENT - DTC P200A00 (SA240A) - This bulletin provides information related to the ECM software upgrade and inspection of the VCM motor (Actuation Test) of some 2016MY Optima (JFa) vehicles, produced from August 28, 2015 through February 15, 2016, and some 2016MY Sorento (UMa) vehicles, produced from November 17, 2014 through February 3, 2016, which may experience a malfunction indicator lamp (MIL) illuminated with the Electronic Control Module (ECM) system-related DTC: P200A00.
PS472R1
Service Bulletin/Repair Instructions
PITSTOP: HVAC VENTILATION LOGIC OPERATION - Starting with 14MY Soul (PS) (with the exception of PSEV) and complete new models such as K900 (KH), Sedona (YP), Sorento (UMa), Optima (JFa), Sportage (QL), and 17MY Forte (YD, YDm), etc., equipped with a sunroof, a ventilation logic has been applied in order to prevent exhaust gases flowing into the vehicle due to the pressure difference (inside vs outside) that is generated when driving with the sunroof open. This logic allows the system to automatically switch from RECIRCULATION to FRESH mode when the sunroof is open.
TSB-BOD148R1
Service Bulletin/Repair Instructions
TSB: SUNROOF BUZZING NOISE - This bulletin provides information on some 2016MY Optima (JFa) vehicles, produced from September 28, 2015 to June 20, 2016, which may exhibit a buzzing noise that may increase with intensity in conjunction with the HVAC fan speed. This concern is caused by a loose sunroof weather strip vibration due to air leakage past the sunroof seal. To correct this concern, follow the procedure outlined in this bulletin to apply adhesive to the weather strip base.
TSB-TRA060R1
Service Bulletin/Repair Instructions
TSB: SERVICE ACTION: AXLE DRIVESHAFT REPLACEMENT (SA241) - This bulletin provides information on some 2016MY Optima (JF) vehicles, produced in South Korea from March 24, 2016 to April 8, 2016, which may exhibit a noise originating from the axle driveshaft during acceleration.
TSB-ENG161
Service Bulletin/Repair Instructions
TSB: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC16) - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, GDS/KDS screenshots will allow the capture of relevant parameters.
TSB-GEN085
Service Bulletin/Repair Instructions
TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners utilized in various Kia models are strictly intended for ?one time use?. Though not limited to the following, some examples are: axle shaft nuts with stake collar, cotter pins, washers with locking tabs and other similar hardware, including threaded fasteners with pre-applied ?thread-locking adhesives.?
PS475
Service Bulletin/Repair Instructions
PITSTOP: AUTONOMOUS EMERGENCY BRAKING (AEB) OPERATION - An increasing number of Kia?s latest models are now equipped with Autonomous Emergency Braking (AEB). Some customers may have interest and/or questions regarding this new technology, including what type of feedback they can expect from this system. The information provided below is a brief reference. The service information found on KGIS including the Owner?s Manual will provide more detailed information.
PS266R1
Service Bulletin/Repair Instructions
PITSTOP: HVAC RECEIVER/DRYER - DESICCANT REPLACEMENT - IN THE EVENT OF A HVAC SYSTEM CONCERN IN WHICH METAL PARTICLES OR SHARDS HAVE CONTAMINATED THE SYSTEM, THE DESICCANT OR THE ENTIRE A/C RECEIVER/DRYER ASSEMBLY MAY NEED TO BE REPLACED. THIS IS DUE TO THE FACT THAT IT MAY BE IMPOSSIBLE TO REMOVE ALL METAL CONTAMINANTS FROM THE RECEIVER/DRYER DURING THE A/C FLUSHING PROCEDURE. REFER TO THE INCLUDED TABLE FOR DETAILED INFORMATION ON COMPONENT REPLACEMENT BY MODEL. IF YOU SUSPECT A PLUGGED EXPANSION VALVE, THE INLET SCREENS CAN BE CLEANED. IF THE VALVE IS NOT EQUIPPED WITH AN INLET SCREEN AND IS RESTRICTED, THE EXPANSION VALVE MAY ALSO NEED TO BE REPLACED.
PS457
Service Bulletin/Repair Instructions
PITSTOP: VARIANT CODING INTEGRATED BRAKE ACTUATION UNITS (IBAU) - WHEN REPLACING THE INTEGRATED BRAKE ACTUATION UNIT, IT IS NECESSARY TO PERFORM VARIANT CODING OF THE NEW MODULE. FOR ADDITIONAL INFORMATION RELATED TO VARIANT CODING CLICK THE VARIANT CODES LINK ON THE KGIS HOME PAGE. (SEE PAGE 2 FOR SAMPLE SCREEN SHOT.)
TSBENG159
Service Bulletin/Repair Instructions
TSB: E-CVVT COVER AND MOTOR PLUG REPLACEMENT - THIS BULLETIN PROVIDES INFORMATION ABOUT THE REPLACEMENT OF THE E-CVVT COVER AND MOTOR PLUG ON SOME 2016MY SORENTO (UMA), PRODUCED FROM OCTOBER 27, 2014 TO JUNE 14, 2016, 2016MY OPTIMA (JF/JFA), PRODUCED FROM AUGUST 29, 2015 TO JUNE 14, 2016, AND 2017MY SPORTAGE (QL) VEHICLES, PRODUCED FROM DECEMBER 10, 2015 TO JUNE 15, 2016, WHICH MAY EXHIBIT A MIL ON WITH DTC P001000 AND/OR OIL LEAKAGE IN THE E-CVVT MOTOR PLUG OF APPLICABLE VEHICLE MODELS EQUIPPED WITH 2.4L GDI OR 2.0 T-GDI ENGINES. FOLLOW THE PROCEDURE OUTLINED IN THIS BULLETIN TO REPLACE THE E-CVVT COVER AND MOTOR PLUG TO CORRECT THE CONCERN.
PS465
Service Bulletin/Repair Instructions
PITSTOP: RECALIBRATION OF BLIND SPOT DETECTION AFTER COLLISION REPAIRS - THIS PITSTOP PROVIDES INFORMATION RELATING TO SOME VEHICLES EQUIPPED WITH BLIND SPOT DETECTION (BSD), WHICH MAY EXHIBIT A CHECK BSD SYSTEM MESSAGE WITH DTCS: C270254 AND C270354: C270254: CONTROL MODULE MASTER MISSING CALIBRATION / C270354: CONTROL MODULE SLAVE MISSING CALIBRATION
TSBBOD147
Service Bulletin/Repair Instructions
TSB: SUNROOF POPPING NOISE REPAIR - THIS BULLETIN PROVIDES INFORMATION ON SOME 2016MY OPTIMA (JFA) VEHICLES, PRODUCED FROM SEPTEMBER 28, 2015 TO FEBRUARY 23, 2016, WHICH MAY EXPERIENCE A POP OR CLICK NOISE WHEN DRIVING OVER BUMPS OR TURNING. THIS NOISE IS CAUSED BY CONTACT BETWEEN THE DECORATIVE TRIM AND THE SUNROOF FRAME AS THE CHASSIS FLEXES AND IS MORE COMMON AS THE VEHICLE HEATS UP, CAUSING THERMAL EXPANSION OF THE MATERIAL. TO CORRECT THIS CONCERN, LUBRICATE THE CONTACT AREAS BY REFERRING TO THE PROCEDURE BELOW.
TSBBOD148
Service Bulletin/Repair Instructions
TSB: SUNROOF BUZZING NOISE - THIS BULLETIN PROVIDES INFORMATION ON SOME 2016MY OPTIMA (JFA) VEHICLES, PRODUCED FROM SEPTEMBER 28, 2015 TO JUNE 20, 2016, WHICH MAY EXHIBIT A BUZZING NOISE THAT MAY INCREASE WITH INTENSITY IN CONJUNCTION WITH THE HVAC FAN SPEED. THIS CONCERN IS CAUSED BY A LOOSE SUNROOF WEATHER STRIP VIBRATION DUE TO AIR LEAKAGE PAST THE SUNROOF SEAL. TO CORRECT THIS CONCERN, FOLLOW THE PROCEDURE OUTLINED IN THIS BULLETIN TO APPLY ADHESIVE TO THE WEATHER STRIP BASE.
TSBELE113R1
Service Bulletin/Repair Instructions
TSB: ANDROID AUTO/APPLE CARPLAY SOFTWARE DOWNLOAD - THIS BULLETIN PROVIDES THE PROCEDURE FOR UPGRADING AVN 4.0 AND UVO 3.0 AUDIO SYSTEM SOFTWARE TO INCLUDE ANDROID AUTO AND APPLE CARPLAY SOFTWARE.
TSBELE100R3
Service Bulletin/Repair Instructions
COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - THIS BULLETIN PROVIDES THE PROCEDURE FOR UPGRADING THE UVO SYSTEM ON SOME 2014~2016MY SOUL (PS), SORENTO (XMA)/(UMA), OPTIMA (TF HEV), FORTE (YD), SPORTAGE (SL) 2015~2016MY SEDONA (YP), AND 2014-2015(MY) OPTIMA (QT/TF) VEHICLES TO ADDRESS INCOMING RING VOLUME TOO LOUD COMPLAINTS WHEN USING CERTAIN SMARTPHONES (NON-IPHONE). ADDITIONALLY, IN 2014MY VEHICLES THE UPGRADE WILL ALSO IMPROVE BLUETOOTH CONNECTIVITY AND VOICE RECOGNITION (VR). FOR VEHICLES NOT ON THE AFFECTED VEHICLES LIST, BUT WITH A CUSTOMER CONCERN AS DESCRIBED ABOVE, PERFORM THE FOLLOWING PROCEDURE OUTLINED IN THIS BULLETIN AND SUBMIT A WARRANTY CLAIM PER "CUSTOMER CONCERN" (STANDARD TSB) CLAIM INFORMATION ON PAGE 10.
TSBELE104R1
Service Bulletin/Repair Instructions
TSB: APPLE CARPLAY ROLLOUT AND TROUBLESHOOTING GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATED TO THE ROLLOUT OF APPLE CARPLAY AND ANDROID AUTO ON 2017MY SORENTO (UMA) AND THE LAUNCH OF APPLE CARPLAY ON 2016MY OPTIMA (JFA) AND 2017MY SPORTAGE (QL) VEHICLES, EQUIPPED WITH PREMIUM NAVIGATION (AVN 4.0) OR UVO ESERVICES (UVO 3.0) SYSTEMS.
PS452
Service Bulletin/Repair Instructions
PITSTOP: ANDROID AUTO/UVO eSERVICES CONNECTIVITY ISSUES AFTER ANDROID 6.0 UPDATE - This article provides diagnostic information in regards to: ANDROID AUTO will not launch when a Samsung Android phone is connected to the vehicle. UVO eServices setup fails and the head unit displays a smartphone connection error.
TSB-ELE-104
Service Bulletin/Repair Instructions
TSB: APPLE CARPLAY ROLLOUT AND TROUBLESHOOTING GUIDE - THIS BULLETIN PROVIDES INFORMATION RELATED TO THE ROLLOUT OF APPLE CARPLAY AND ANDROID AUTO ON VEHICLES EQUIPPED WITH PREMIUM NAVIGATION (AVN 4.0) OR UVO ESERVICES (UVO 3.0) SYSTEMS.
TSBELE104
Service Bulletin/Repair Instructions
TSB - APPLE CARPLAY ROLLOUT AND TROUBLESHOOTING GUIDE - This bulletin provides information related to the rollout of Apple CarPlay and Android Auto on vehicles equipped with Premium Navigation (AVN 4.0) or UVO eServices (UVO 3.0) systems.
TSB-ELE-100R2
Service Bulletin/Repair Instructions
COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - THIS BULLETIN PROVIDES THE PROCEDURE FOR UPGRADING THE UVO SYSTEM ON SOME 2014~2016MY SOUL (PS), SORENTO (XMA), OPTIMA (TF/QF), FORTE (YD) AND SPORTAGE (SL) VEHICLES TO ADDRESS INCOMING RING VOLUME TOO LOUD COMPLAINTS WHEN USING CERTAIN SMARTPHONES (NON-IPHONE). ADDITIONALLY, IN 2014MY VEHICLES THE UPGRADE WILL ALSO IMPROVE BLUETOOTH CONNECTIVITY AND VOICE RECOGNITION. FOR VEHICLES NOT ON THE AFFECTED VEHICLES LIST, BUT WITH A CUSTOMER CONCERN AS DESCRIBED ABOVE, PERFORM THE FOLLOWING PROCEDURE OUTLINED IN THIS BULLETIN AND SUBMIT A WARRANTY CLAIM PER "CUSTOMER CONCERN" (STANDARD TSB) CLAIM INFORMATION ON PAGE 10.
TSB-SC-131
Service Bulletin/Repair Instructions
VOLUNTARY SAFETY RECALL CAMPAIGN: DRIVERS FRONTAL AIRBAG MODULE REPLACEMENT (SC131) - THIS BULLETIN PROVIDES THE PROCEDURE TO REPLACE THE DRIVERS FRONTAL AIRBAG MODULE OF SEVENTEEN (17) 2016 MY OPTIMA VEHICLES, PRODUCED FROM NOVEMBER 10, 2015 THROUGH FEBRUARY 12, 2016. A SECONDARY CHEMICAL ENHANCER REQUIRED FOR THE PROPER DEPLOYMENT OF SECOND-STAGE FRONTAL AIRBAG WAS NOT LOADED DURING THE AIRBAG INFLATOR BUILD AT THE SUPPLIER. AS A RESULT, THE SECOND STAGE OF THE DRIVERS FRONTAL AIRBAG WILL NOT DEPLOY IF THE VEHICLE IS INVOLVED IN A CRASH THAT TRIGGERS THE SECOND-STAGE DEPLOYMENT OF THE DRIVERS FRONTAL AIRBAG. TO CORRECT THIS CONDITION, KIA IS REQUESTING THE COMPLETION OF THIS VOLUNTARY SAFETY RECALL ON ALL AFFECTED VEHICLES. BEFORE CONDUCTING THE PROCEDURE, VERIFY THE VEHICLE IS INCLUDED IN THE LIST OF 17 AFFECTED VINS (LISTED ON PAGE 7).
TSBELE100R2
Service Bulletin/Repair Instructions
TSB - COMBINATION TSB / SERVICE ACTION: UVO SYSTEM UPGRADE (SA222) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure for upgrading the UVO system on some 2014~2016MY Soul (PS), Sorento (XMa), Optima (TF/QF), Forte (YD) and Sportage (SL) vehicles to address "Incoming ring volume too loud" complaints when using certain smartphones (non-iPhone). Additionally, in 2014MY vehicles the upgrade will also improve Bluetooth connectivity and voice recognition.
PS443
Service Bulletin/Repair Instructions
TSB - USE OF AFTERMARKET USB CHARGING CABLES IN USB/12V PORTS - This article provides information regarding the use of USB ports and 12V power outlets to connect/charge mobile phones. Customers may experience issues with their head units that may be related to the use of aftermarket USB charging cables, including; * Electrical interference and limited or no functionality when attempting to play music, or when charging a device through the USB port * Excessive static or noise when listening to the audio source * Malfunctions and screen freeze of the head unit screen * Slow down of the system response while device is plugged in * Music will not play from iPhone 5 or 6 with Kia iPod cable and aftermarket adapter * No or limited functionality when trying to play music from an Apple device
TSB BOD131_SA219
Service Bulletin/Repair Instructions
THIS BULLETIN DESCRIBES THE PROCEDURE TO REPLACE THE REAR SEAT LATCH MANUAL RELEASE CABLE ON SOME 2016 MY OPTIMA (JFA) VEHICLES, PRODUCED FROM AUGUST 28, 2015 TO DECEMBER 15, 2015, WHICH MAY EXPERIENCE DETERIORATION OF THE PLASTIC HANDLE ON THE REAR SEAT RELEASE LATCH. FOLLOW THE PROCEDURE OUTLINED IN THIS BULLETIN TO INSPECT AND, IF NECESSARY, REPLACE THE AFFECTED SEAT RELEASE LATCH ASSEMBLY WITH AN IMPROVED PART.
TSBBOD131
Service Bulletin/Repair Instructions
SERVICE ACTION: REAR SEAT LATCH CABLE INSPECTION AND/OR REPLACEMENT (SA 219) - THIS BULLETIN DESCRIBES THE PROCEDURE TO REPLACE THE REAR SEAT LATCH MANUAL RELEASE CABLE ON SOME 2016MY OPTIMA (JFA) VEHICLES, PRODUCED FROM AUGUST 28, 2015 TO DECEMBER 15, 2015, WHICH MAY EXPERIENCE DETERIORATION OF THE PLASTIC HANDLE ON THE REAR SEAT RELEASE LATCH. FOLLOW THE PROCEDURE OUTLINED BELOW TO INSPECT AND, IF NECESSARY, REPLACE THE AFFECTED SEAT RELEASE LATCH ASSEMBLY WITH AN IMPROVED PART. KIA IS REQUESTING THE COMPLETION OF THIS SERVICE ACTION ON ALL AFFECTED VEHICLES.
TSB BOD134_SA225
Service Bulletin/Repair Instructions
THIS BULLETIN PROVIDES THE PROCEDURE TO INSPECT OR REPLACE THE HEADLINER ON SOME 2016 MY OPTIMA (JFA) VEHICLES, PRODUCED FROM FEBRUARY 8, 2016 THROUGH FEBRUARY 17, 2016, WHICH MAY EXHIBIT A DELAMINATING HEADLINER. FOLLOW THE INSPECTION PROCEDURE IN THIS BULLETIN, AND IF NECESSARY, REPLACE THE HEADLINER ASSEMBLY TO CORRECT THE CONDITION.
TSBBOD134
Service Bulletin/Repair Instructions
SERVICE ACTION: HEADLINER INSPECTION AND/OR REPLACEMENT (SA 225) - THIS BULLETIN PROVIDES THE PROCEDURE TO INSPECT OR REPLACE THE HEADLINER ON SOME 2016MY OPTIMA (JFA) VEHICLES, PRODUCED FROM FEBRUARY 8, 2016 THROUGH FEBRUARY 17, 2016, WHICH MAY EXHIBIT A DELAMINATING HEADLINER. FOLLOW THE INSPECTION PROCEDURE IN THIS BULLETIN, AND IF NECESSARY, REPLACE THE HEADLINER ASSEMBLY TO CORRECT THE CONDITION. KIA IS REQUESTING THE COMPLETION OF THIS SERVICE ACTION ON ALL AFFECTED VEHICLES.
OWNERSC128
Service Bulletin/Repair Instructions
OWNER NOTIFICATION LETTER (SC128) - DEAR KIA OPTIMA OWNER: KIA MOTORS AMERICA, INC. IS CONDUCTING A VOLUNTARY EMISSIONS RECALL CAMPAIGN TO REPLACE THE AIR CLEANER AND/OR EVAPORATIVE CANISTER IN YOUR VEHICLE.
DEALERPSC128
Service Bulletin/Repair Instructions
DEALER PRINCIPAL MEMO (SC128) - KIA MOTORS AMERICA, INC. IS CONDUCTING A VOLUNTARY EMISSIONS RECALL CAMPAIGN (SC128) ON CERTAIN 2016 MY KIA OPTIMA VEHICLES EQUIPPED WITH EITHER THE 2.0 L TURBO ENGINE (ULEV 50 STATE EMISSIONS), OR THE 2.4 L GDI SULEV CALIFORNIA EMISSIONS) ENGINE. SOME OF THE 2.0L TURBO ENGINE MODELS WERE BUILT WITH THE AIR CLEANER AND EVAPORATIVE CANISTER FOR THE 2.4L SULEV MODEL AND SOME OF THE 2.4L SULEV VEHICLES WERE BUILT WITH THE WRONG AIR CLEANER. KIA IS RECALLING THESE VEHICLES TO CORRECT THE MISBUILD BY INSTALLING THE PROPER COMPONENTS AS ORIGINALLY INTENDED.
DEALERPSMSC128
Service Bulletin/Repair Instructions
DEALER PARTS AND SERVICE MANAGER MEMO (SC128) - KIA MOTORS AMERICA, INC. IS CONDUCTING A VOLUNTARY EMISSIONS RECALL CAMPAIGN (SC128) ON CERTAIN 2016 MY KIA OPTIMA VEHICLES EQUIPPED WITH EITHER THE 2.0 L TURBO ENGINE (ULEV 50 STATE EMISSIONS), OR THE 2.4 L GDI (SULEV CALIFORNIA EMISSIONS) ENGINE, AND PRODUCED FROM JOB 1 THROUGH JANUARY 15. 2016. SOME OF THE 2.0L TURBO ENGINE MODELS WERE BUILT WITH THE AIR CLEANER AND EVAPORATIVE CANISTER FOR THE 2.4L SULEV MODEL AND SOME OF THE 2.4L SULEV VEHICLES WERE BUILT WITH THE WRONG AIR CLEANER. KIA IS RECALLING THESE VEHICLES TO CORRECT THE MISBUILD BY INSTALLING THE PROPER COMPONENTS AS ORIGINALLY INTENDED.
QASC128
Service Bulletin/Repair Instructions
QUESTIONS AND ANSWERS (SC128) 2016 MY KIA OPTIMA IMPROPER EMISSIONS PARTS INSTALLED VOLUNTARY EMISSIONS RECALL CAMPAIGN Q AND A
TSB SC128
Service Bulletin/Repair Instructions
THIS BULLETIN PROVIDES THE PROCEDURE TO REPLACE THE AIR CLEANER BOX AND/OR THE EVAPORATIVE CANISTER OF SOME 2016 MY KIA OPTIMA (JFA) 2.0L TURBO (ULEV - 50 STATE EMISSIONS) AND THE 2.4 L GDI (SULEV VEHICLES - CALIFORNIA EMISSIONS), PRODUCED FROM JOB #1 THROUGH JANUARY 15, 2016. SOME OF THESE VEHICLES WERE BUILT WITH THE WRONG AIR CLEANER AND/OR EVAPORATIVE CANISTER. KIA IS RECALLING THESE VEHICLES TO CORRECT THE MISBUILD BY INSTALLING THE PROPER COMPONENTS, AS ORIGINALLY INTENDED. PRIOR TO PERFORMING THE PROCEDURE, REFER TO THE TABLE IN THE BULLETIN TO IDENTIFY WHICH COMPONENTS REQUIRE REPLACEMENT BY ENGINE TYPE.
TSBSC128
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS RECALL: 2016MY OPTIMA IMPROPER EMISSIONS PARTS INSTALLED VOLUNTARY EMISSIONS RECALL (SC 128) - THIS BULLETIN PROVIDES THE PROCEDURE TO REPLACE THE AIR CLEANER BOX AND/OR THE EVAPORATIVE CANISTER OF SOME 2016MY KIA OPTIMA (JFA) 2.0L TURBO (ULEV 50 STATE EMISSIONS) AND 2.4L GDI (SULEV VEHICLES CALIFORNIA EMISSIONS), PRODUCED FROM JOB #1 THROUGH JANUARY 15, 2016. SOME OF THESE VEHICLES WERE BUILT WITH THE WRONG AIR CLEANER AND/OR EVAPORATIVE CANISTER. KIA IS RECALLING THESE VEHICLES TO CORRECT THE MISBUILD BY INSTALLING THE PROPER COMPONENTS, AS ORIGINALLY INTENDED. PRIOR TO PERFORMING THE PROCEDURE, REFER TO THE TABLE BELOW TO IDENTIFY WHICH COMPONENTS REQUIRE REPLACEMENT BY ENGINE TYPE. KIA IS REQUESTING THE COMPLETION OF THIS VOLUNTARY EMISSIONS SERVICE CAMPAIGN ON ALL AFFECTED VEHICLES.
TSB-ELE-098-R2
Service Bulletin/Repair Instructions
SERVICE ACTION: BASE AUDIO HEAD UNIT REPLACEMENT (SA211) - THIS BULLETIN PROVIDES THE PROCEDURE TO REPLACE THE BASE AUDIO HEAD UNIT OF SOME 2016MY OPTIMA (JFA) VEHICLES, PRODUCED FROM SOP THROUGH NOVEMBER 10, 2015 WHICH MAY EXHIBIT A HEAD UNIT SCREEN THAT DOES NOT DISPLAY AN IMAGE (BLACK SCREEN) IN COLD WEATHER. TO CORRECT AND/OR PREVENT THIS CONDITION, KIA IS REQUESTING THE COMPLETION OF THIS SERVICE ACTION ON ALL AFFECTED VEHICLES. BEFORE CONDUCTING THE PROCEDURE, VERIFY THE VEHICLE IS INCLUDED IN THE LIST OF AFFECTED VINS
TSBCHA061
Service Bulletin/Repair Instructions
SERVICE ACTION: TMPS REPLACEMENT (SA213) - THIS BULLETIN PROVIDES THE PROCEDURE TO CHECK OR REPLACE THE TPMS SENSORS FOR SOME 2016MY OPTIMA (JFA) AND 2016MY SORENTO (UMA) VEHICLES, PRODUCED FROM SEPTEMBER 28TH, 2015 THROUGH DECEMBER 7TH, 2015 WHICH MAY EXHIBIT A FALSE TPMS MALFUNCTION INDICATOR LIGHT ON THE CLUSTER, WITH DTC C131200, C131300, C131400, AND/OR C131500, EVEN WHEN THE INFLATION PRESSURE IN THE TIRE IS CORRECT. TO CORRECT AND/OR PREVENT THIS CONDITION, KIA IS REQUESTING THE COMPLETION OF THIS SERVICE ACTION ON ALL AFFECTED VEHICLES. BEFORE CONDUCTING THE PROCEDURE, VERIFY THE VEHICLE IS INCLUDED IN THE LIST OF AFFECTED VINS ON PAGE 8.
TSBFUE032
Service Bulletin/Repair Instructions
SERVICE ACTION: INACCURATE READING FROM FUEL GAUGE (SA 212) - THIS BULLETIN PROVIDES THE PROCEDURE TO INSPECT FUEL GAUGE LEVEL INDICATOR ON SOME 2016MY OPTIMA (JFA) VEHICLES, PRODUCED FROM SEPTEMBER 22, 2015 THROUGH OCTOBER 22, 2015 WHICH MAY EXHIBIT AN INACCURATE FUEL GAUGE READING ON THE INSTRUMENT CLUSTER. TO CORRECT AND/OR PREVENT THIS CONDITION KIA IS REQUESTING THE COMPLETION OF THIS SERVICE ACTION ON ALL AFFECTED VEHICLES IN DEALER STOCK. BEFORE CONDUCTING THE PROCEDURE, VERIFY THE VEHICLE IS INCLUDED IN THE LIST OF AFFECTED VINS.
PS440
Service Bulletin/Repair Instructions
OPTIMA (JFA) - FRONT LICENSE PLATE INSTALLATION - THIS ARTICLE PROVIDES INFORMATION REGARDING FRONT LICENSE PLATE INSTALLATION ON 2016 MY OPTIMA (JFA).
PS299R1
Service Bulletin/Repair Instructions
CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - THIS ARTICLE OUTLINES THE PROCEDURE TO BE USED TO RAISE THE WIPER ARMS TO THE FULLY VERTICAL POSITION.
PS438
Service Bulletin/Repair Instructions
OPTIMA (JFA) - ALIGNMENT SPECIFICATIONS - THIS ARTICLE PROVIDES THE ALIGNMENT SPECIFICATIONS FOR 2016MY OPTIMA (JFA). IN THE EVENT A WHEEL ALIGNMENT IS NEEDED, ENSURE YOUR ALIGNMENT EQUIPMENT HAS THE CORRECT SPECIFICATIONS PROGRAMMED INTO THE PC DATABASE.
TSBSST041
Service Bulletin/Repair Instructions
TSB: KDS - AUDIO UPDATE MODULE (AUM) - THE GDS AUDIO UPDATE MODULE (AUM) WAS INTRODUCED IN FOURTH QUARTER OF 2013. THIS SPECIAL SERVICE TOOL (SST) WAS DEVELOPED TO IMPROVE THE EFFICIENCY AND EFFECTIVENESS OF UPDATING 2010MY, AND LATER, KIA AUDIO HEAD UNITS USING A GDS, AND NOW, THE SAME FUNCTIONALITY IS AVAILABLE ON KDS. SOME TECHNICIANS MAY NOT BE AWARE OF THE BENEFITS THE AUM TOOL HAS TO OFFER. THE AUM ELIMINATES THE NEED FOR MULTIPLE USB FLASH DRIVES FOR SPECIFIC VEHICLE MODELS AND APPLICATIONS WHICH, IF MISAPPLIED, MAY RESULT IN AN IMPROPER AUDIO SYSTEM SOFTWARE UPDATE AND/OR LOCKED UP HEAD UNIT. ADDITIONALLY, FIELD REPORTS HAVE INDICATED THAT USB DRIVES FOR AUDIO UPDATES ARE EASILY LOST OR MISPLACED.
PS428
Service Bulletin/Repair Instructions
SIMPLIFIED UVO E-SERVICES ACTIVATION PROCEDURE - THIS ARTICLE OUTLINES THE SIMPLIFIED ACTIVATION PROCEDURE FOR VEHICLES EQUIPPED WITH UVO E-SERVICES. (EXCLUDING 2016 K900 AND SOUL EV)
TSBGEN078
Service Bulletin/Repair Instructions
PRE-DELIVERY INSPECTION (PDI) AND OWNER DELIVERY FOLDER PROGRAM - ALL MODELS EXCLUDING K900 AND SOUL EV -KIA MOTORS AMERICA, INC. IS PLEASED TO ANNOUNCE THE LAUNCH OF AN ALL-NEW PRE-DELIVERY INSPECTION (PDI) AND OWNER DELIVERY FOLDER PROGRAM WHICH HAS BEEN REDESIGNED TO IMPROVE INITIAL VEHICLE QUALITY DURING PDI AND ALSO DURING DELIVERY TO YOUR CUSTOMER
TSBGEN076
Service Bulletin/Repair Instructions
TSB: PROPER OIL GRADE / VISCOSITY SELECTION FOR TURBO EQUIPPED VEHICLES - THIS BULLETIN PROVIDES INFORMATION RELATED TO THE PROPER ENGINE OIL GRADE / VISCOSITY TO BE USED WHEN SERVICING VEHICLES EQUIPPED WITH A TURBOCHARGER. IN ADDITION TO FOLLOWING THE TURBO-SPECIFIC MAINTENANCE INTERVAL SCHEDULES, IT IS VERY IMPORTANT TO FOLLOW THE GRADE AND THE SAE OIL VISCOSITY RECOMMENDATIONS IN THE APPLICABLE SERVICE MANUAL TO ENSURE THE PROPER LUBRICATION IS DELIVERED TO THE TURBOCHARGER AND TO PREVENT ENGINE DAMAGE.
TSBELE089
Service Bulletin/Repair Instructions
TSB: NAVIGATION HEAD UNIT SD CARD REPLACEMENT - THIS BULLETIN DESCRIBES THE SD CARD EXCHANGE/REPLACEMENT PROCEDURE RELATED TO ERROR MESSAGES THAT MAY BE DISPLAYED ON THE NAVIGATION SCREEN WHEN THE INCORRECT SD CARD IS INSERTED. NOTE: ONLY NEW MODELS (DURING PDI INSPECTION OR AT THE POINT OF PURCHASE) OR COMPATIBILITY MISMATCHES THAT OCCUR AFTER HEAD UNIT REPLACEMENT WILL BE CONSIDERED FOR THIS PROGRAM.
PS415R2
Service Bulletin/Repair Instructions
PITSTOP: OIL INTRUSION INTO E-CVVT COVER - WHEN DIAGNOSING A DTC RELATED TO THE E-CVVT SYSTEM, REMOVE THE THE E-CVVT COVER AND CHECK FOR POSSIBLE OIL INTRUSION (A). THE ECVVT SYSTEM UTILIZES TWO SEALS TO PREVENT INTRUSION OF OIL AND/OR DUST A SEAL ON THE COVER (A) AND A SEAL THAT IS RECESSED IN THE ECVVT. IF OIL IS FOUND INSIDE THE COVER; THE COVER, THE OIL SEAL WITHIN THE E-CVVT ASSEMBLY AND THE E-CVVT ASSEMBLY SHOULD BE REPLACED. FOLLOW THE INSTRUCTIONS LISTED IN THE SERVICE INFORMATION, AND IN THE VIDEO LINK BELOW, TO PROPERLY INSTALL THE OIL SEAL TO THE CORRECT DEPTH AND ALIGN THE COVER.
PS400
Service Bulletin/Repair Instructions
PITSTOP: SMART PEDAL FEATURE - THE SMART PEDAL IS AN INTEGRAL PART OF THE ENGINE MANAGEMENT SYSTEM (EMS) FUNCTIONALITY WHICH MONITORS AND PREVENTS THE SIMULTANEOUS ACTIVATION OF ACCELERATOR AND BRAKE PEDALS. WHEN ENGAGED, THE FEATURE REDUCES ENGINE POWER TO IDLE. MOST CUSTOMERS WILL NEVER NOTICE THE SMART PEDAL FEATURE WHEN ACTIVE, HOWEVER, CUSTOMERS WHO TEND TO REST THEIR FOOT ON THE BRAKE PEDAL WHILE DRIVING MIGHT DESCRIBE A HESITATION OR DELAY SYMPTOM AND NOT REALIZE THAT THE EMS ELECTRONIC CONTROL MODULE IS INTERVENING, AS DESIGNED.