M510124
Service Bulletin/Repair Instructions
The bar code on the vehicle identificatio nnumber (VIN) label (aka Manufacturer Compliance Label ) cannot be read.
Vehicle report
2002 MINI COOPER
Service bulletins
40 bulletinsTechnical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
M511616
Service Bulletin/Repair Instructions
Cavity protection applied to underside of the hood is leaking out onto the wheel arch trim and grille.
M120817
Service Bulletin/Repair Instructions
W10 ENGINE: EMS2K - COMPREHENSIVE COMPONENT OBD READINESS MONITOR NOT COMPLETED: An affected vehicle fails to pass a state Inspection and Emission (I/M) test due to the ÒComprehensive ComponentÓ OBD readiness monitor status is Ònot complete,Ó or it fails complete after performing an applicable repair.
M320214
Service Bulletin/Repair Instructions
This Service Information bulletin supersedes SI 32 02 14 dated August 2014. SUBJECT Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle is No Longer Required. Left-hand drive steering spindles are currently available.
11 06 15
Service Bulletin/Repair Instructions
MINI: DIFFERENT FAULTS ACTIVATES ENGINE MALFUNCTION AND OIL WARNING. *MA
12 06 15
Service Bulletin/Repair Instructions
MINI: BECAUSE OF THE DME SOFTWARE, AND A DAMAGED CLUTCH, THE DRIVETRAIN MALFUNCTION CHECK MESSAGE APPEAR. *MA
12 09 15
Service Bulletin/Repair Instructions
MINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA
11 02 15
Service Bulletin/Repair Instructions
MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT. *MA
12 05 15
Service Bulletin/Repair Instructions
MINI: DUE TO FAULTY DME SOFTWARE, THE SERVICE ENGINE LIGHTS COMES ON, INCLUDING THE CHECK CONTROL MESSAGE FOR MOTOR FORCE DECREASE. *MA
12 07 15
Service Bulletin/Repair Instructions
MINI: FAULTY SOFTWARE CAUSES THE CHECK CONTROL AND ENGINE POWER REDUCED LIGHT TO APPEAR. *MA
SIM-11-10-14
Service Bulletin/Repair Instructions
MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE
M010113
Service Bulletin/Repair Instructions
Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Limited Warranty Extension to 13 Years/150,000 Miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail.
SI M01 01 13
Service Bulletin/Repair Instructions
MINI: MODELS R50, R52, AND R53 WITH THE ELECTRO-HYDRAULIC POWER-ASSIST STEERING PUMP AND COOLING FANS WILL HAVE AN LIMITED WARRANTY EXTENSION TO 13 YEARS/150,000 MILES. *TA
M010514
Service Bulletin/Repair Instructions
MINI CVT Replacement Parts Warranty Extension: Additional 12 Months with Up to 50,000 Accumulated Miles. A MINI vehicle's CVT assembly or component that was previously repaired and/or replaced by an authorized MINI dealer or BMW center may experience a subsequent failure.
SIM-01-05-14
Service Bulletin/Repair Instructions
MINI: INFORMATION ON PARTS WARRANTY EXTENSION APPLYING TO PREVIOUS QUALIFYING REPAIRS AND NO IMMEDIATE REPAIR REQUIRED UNLESS CURRENTLY EXPERIENCING PROBLEM WITH CVT ASSEMBLY OR COMPONENT. MODEL 2005-2008 COOPER, COOPER S. *PE
SIM-61-05-14
Service Bulletin/Repair Instructions
MINI: THERE IS A DISCONNECTION OR KINK, IN WNIDSHIELD WASHER HOSE, WHICH IS TOO SHORT, CAUSING WINDSHIELD FRONT WASHER JET TO FAIL. MODEL F56 (COOPER, COOPER S). *PE
MC-10113
Service Bulletin/Repair Instructions
MINI: WARRANTY COVERAGE EXTENSION/REPAIR EXPENSE REIMBURSEMENT FOR THE ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP, WHICH HAS ITS OWN COOLING FAN, ON SOME VEHICLES AND NOT THE ELECTRIC POWER (ASSIST) STEERING (EPS) SYSTEM ON OTHER MINIS. MODELS 2002-2005 COOPER, COOPER S, CONVERTIBLE, CONVERTIBLE S. *PE
SIM-01-01-13
Service Bulletin/Repair Instructions
MINI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A WARRANTY EXTENSION FOR CERTAIN VEHICLES WITH POTENTIAL PROBLEM WITH COOLING FAN AND THE DURABILITY OF ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP. MODELS 2002-2005 R50, R52, R3. *PE UPDATED ON 11/1/2013. *KB UPDATED 3/4/2014 *JS
M120213
Service Bulletin/Repair Instructions
State Inspection and Emission (I/M) Test Fails Due to an Invalid VIN Number. The affected vehicle may fail to pass a State Inspection and Emission (I/M) test due to a noncompliant 17-digit vehicle identification number (VIN) stored in the DME (Digital Motor Electronic). The VIN read-out displayed on the state test printout does not match the actual VIN of the vehicle. If the DME was reprogrammed using the previously available BMW service equipment (e.g., Progman, GT1), it was possible that only the last 7 of the VIN were entered into the DME, and positions 4 through 10 may only contain default characters. For example: The state I/M tester or OBD scan tool may read out WBAAA00000A123456 instead of the correct full 17-digit VIN, WBAZZ03492A123456.
SI-M-13-01-13
Service Bulletin/Repair Instructions
MINI: THERE IS A PROCEDURAL ERROR IN THE REMOVING AND INSTALLING OR REPLACING HIGH PRESSURE PUMP CURRENT VERSION THAT HAS BEEN REPLACED WITH THE CORRECTED REPAIR INSTRUCTION PORTION FOR THE N14 AND N18 ENGINE. MODELS R55, 56, 57, 58, 59, 60, 61. NO MODEL YEARS LISTED. *PE
SI-M61-01-12
Service Bulletin/Repair Instructions
MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT. *KB
SIM-12-02-11
Service Bulletin/Repair Instructions
BMW: A SOFTWARE ERROR IS CAUSING A HESITATION OR JERKING WHEN ACCELERATING UNDER HIGHER LOADS BETWEEN 3000 ¿ 4000 RPM. *RM
SIM-11-07-08
Service Bulletin/Repair Instructions
BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM. *RM
SI-M-18-01-09
Service Bulletin/Repair Instructions
MINI: DUE TO A FAILURE IN THE PRODUCTION PROCESS,THE CATALYTIC CONVERTER MAY DETERIORATE CAUSING AN INCREASED LEVEL OF VEHICLE EMISSIONS. THE CATALYST EFFICIENCY FAULT CODE (276A) WILL BE STORED IN THE DME MEMORY, AND THE SERVICE ENGINE SOON LAMP WILL BE ILLUMINATED. VEHICLE DRIVABILITY IS NOT AFFECTED BY THIS TYPE OF THE CATALYST FAILURE. (R55, R56). *PE
SIM-12-02-09
Service Bulletin/Repair Instructions
MINI: SERVICE ENGINE SOON OR CHECK GAS CAP WARNING IS ILLUMINATED: TANK LEAKAGE. LEAKAGE IS DETECTED IN THE TANK VENTILATION OR EVAPORATIVE SYSTEM. *PE
SI M21-03-08
Service Bulletin/Repair Instructions
MINI- R5 & R56 (COOPER; COOPER S) WITH GETRAG 6 SPEED MANUAL TRANSMISSION: COMPLAINT OF AN INTERMITTENT NO-CRANK, NO START SITUATION. THE CLUTCH SWITCH MODULE HAS NOT BEEN SECURED IN THE CORRECT POSITION ON THE CLUTCH MASTER CYLINDER. *PE
SI M24 01 08
Service Bulletin/Repair Instructions
MINI: R55, R56 (COOPER, COOPER S) WITH F21 ASIN 6-SPEED AUTOMATIC TRANSMISSION - INCORRECT GEAR DISPLAY. *PE
SI M64-02-08
Service Bulletin/Repair Instructions
MINI: DRIVER FOOTWELL AREA BECOMES HOT. THE HEARTER CORE PIPES ARE POORLY INSULATED. MODEL R56. *PE
SI-M-65-05-08
Service Bulletin/Repair Instructions
MINI: CHECK SVS FUNCTION. ON CERTAIN VEHICLES, THE VOICE INPUT SYSTEM (SVS SA 620) DOES NOT FUNCTION. THE SVS WAS NOT INSTALLED IN THE VEHICLES. *PE
SIM-17-02-07
Service Bulletin/Repair Instructions
MINI: ELECTRIC COOLING FAN RUNS AFTER ENGINE IS SHUT OFF. AFTER THE ENGINE IS SHUT OFF, THE ELECTRIC COOLING FAN CONTINUES TO RUN. DUE TO THE OPERATING STRATEGY OF THE DME, THE ELECTRIC COOLING FAN MAY CONTINUE TO RUN AFTER THE ENGINE IS SHUT OFF IN TWO DIFFERENT SCENARIOS. ENGINE COOLANT TEMP REACHES 108 DEGREES CELSIUS (DUE TO HEAT SOAK), COOLING FAN WILL ACTIVATE TIL COOLANT TEMP DROPS BELOW 105 DEGREES CELSIUS. FAN WILL RUN TO ASSIST THE AUXILIARY WATER PUMP, WHICH IS USED TO COOL TURBO CHARGER AFTER ENGINE SHUT DOWN. NO MODEL YEARS LISTED. *PE
SIM-51-09-07
Service Bulletin/Repair Instructions
MINI: WATER LEAK FROM THE FRONT DOORS. AFTER HEAVY RAIN, THE CARPET MAY BE WET IN THE AREA NEAR THE REAR OF THE FRONT DOORS OR IN THE FOOTWELL AREA. WATER WHICH IS ALLOWED TO ENTER THE VEHICLE AT THE TOP REAR EDGE OF THE DOOR IS NOT ABLE TO DRAIN OUT THROUGH THE BOTTOM OF THE DOOR SEAL. AS A RESULT, THE WATER TRAVELS ALONG THE DOOR SEAL AND INTO THE PASSENGER COMPARTMENT. *PE
360106
Service Bulletin/Repair Instructions
NITROGEN INFLATED TIRES. *TT
120104
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS RECALL CAMPAIGN 04E-A01 - REPROGRAM DME FOR TANK LEAKAGE DIAGNOSTICS. TANK LEAKAGE DIAGNOSTICS DOES NOT RUN CORRECTLY DUE TO AN ERROR IN THE DME SOFTWARE. AS A RESULT, THE CHECK ENGINE SOON LIGHT WILL NOT BE ILLUMINATED IN CASE OF LEAKAGE IN THE EVAPORATIVE SYSTEM. *TT *SC
110104
Service Bulletin/Repair Instructions
VOLUNTARY EMISSIONS RECALL CAMPAIGN 04E-A03 - REPLACE CRANKCASE BREATHER LINE. THE CRANKCASE VENTILATION BREATHER HOSE MAY SOFTEN AND EVENTUALLY MAY COLLAPSE AFTER EXTENDED TIME IN SERVICE. A HISSING OR HUMMING NOISE MAY BE NOTICED DURING LIGHT ACCELERATION. THE SERVICE ENGINE SOON LIGHT MAY BE ILLUMINATED AND VARIOUS DRIVABILITY PROBLEMS (ROUGH IDLE, STALLING) MAY BE EXPERIENCED. *TT
120302
Service Bulletin/Repair Instructions
ENGINE SPEED FLUCTUATION WHILE COASTING DOWN COOPER WITH MANUAL TRANSMISSION PRODUCED UP TO 07/02. *TT
240102
Service Bulletin/Repair Instructions
SERVICE ACTION TO FLUSH AND REPLACE INCORRECT CVT TRANSMISSION OIL. PRODUCED FROM 2002. *TT
110202
Service Bulletin/Repair Instructions
LUBRICANT FOR WATER PUMP O-RING. *TT
410102
Service Bulletin/Repair Instructions
RATTLES FROM REAR HATCH. *TT
610102
Service Bulletin/Repair Instructions
BATTERY MAINTENANCE REQUIREMENTS. *TT
520102
Service Bulletin/Repair Instructions
FRONT SEAT BACKREST WILL NOT HOLD WHEN ADJUSTED TO THE DESIRED POSITION. *TT
Reading this report
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.