Vehicle report
Technical service bulletins are instructions a manufacturer sent its dealers about a known fault. They are not recalls and the work is usually not free, but they are the clearest signal of a problem the manufacturer already knows about.
9004275
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
08-049-20
Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
31-003-19
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
31-005-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
31-006-19
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
3100319
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.
3100519
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.
3100619
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.
68332810
Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.].
R2118796A
Valve Body. These may cause over drive cycling.
1802002
FLASH PROGRAMMING FAILURE RECOVERY. *SLC
0801001
SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT
1801201
SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO. 81-170-00008 PROVIDED WITH THIS TECHNICAL SERVICE BULLETIN TO PROVIDE REFERENCE INFORMATION WHEN USING GENERIC SCAN TOOL ON OBDII VEHICLES. *TT
2100601
AUTOMATIC TRANSMISSION FLUID USAGE ATF+4. *TT *MJ
0800600REV
SUBJECT REGARDING WIRE SPLICE REPAIRS. *SB
0804000
INFORMATION ON NEW COMPONENTS AND A REPAIR PROCEDURE DEVELOPED TO REPLACE FAILED SEAT SLIDE MOTORS. *TT
2300800B
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
082700
SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES. *TT
230800
SUBJECT REGARDING CHILD SEAT TETHER ANCHORS. *TT
080600
THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS. *TT
180100
SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456. *TT
182699
SOME VEHICLES MAY EXPERIENCE NOX EMISSION FAILURE WHEN PERFORMING AN ASM TYPE INSPECTION / MAINTENANCE (I/M) EMISSION TEST. *TT
083799
DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES. *TT
233599REVA
SUBJECT ON THE CHILD SEAT TETHER ANCHORS. *MJS
090799
INFORMATION REGARDING 2.5L V-6 HEAD GASKET APPLICATION. *TT
090899
TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES. *TT
210599A
THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
233599
INFORMATION ON CHILD SEAT TETHER ANCHORS. *TT
181299
THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST. *TT
020799
CONDITIONS WITH LIGHT KNOCKING NOISE FROM THE REAR SHOCK AREA. *TT
181099
SOME VEHICLES MAY EXHIBIT START AND STALL OR SLOW ROUGH IDLE IMMEDIATELY AFTER START-UP IN AMBIENT TEMPERATURES. *TT
020299
VEHICLES EXHIBITING FRONT COIL SPRING CREAKING, POPPING, OR SQUEAKING. *TT
210699
CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL. *TT
210599
SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET. *TT
210499
SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT
190199
PROCEDURES ON ALIGNING THE POWER STEERING BELT. *TT
081798
SUBJECT REGARDING AIRBAG ON - OFF SWITCHES. *YC
050898
EXHIBITTING A CONDITON WHERE THE STEERING WHEEL SHAKES OR THE BRAKE PEDAL PULSATES DUE TO PREMATURE WEAR OF FRONT BRAKE ROTORS AND PADS. *AK
236098
SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE SUNSHADE FABRIC DELAMINATES FROM THE SUBSTRATE ALONG THE EDEGES OF THE SUNSHADE. *YC
234998
SOME VEHICLES EXHIBIT A WHISTLE ( WINDNOISE) COMING FROM THE " A " PILLAR AREA. *YC
250298
SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION. *YC
183298
SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY. *YC
#9850
CONDITIONS REGARDING PAINT SPLATTER, BELVIDERE RAIL HEAD STORAGE YARD. *YC
980605090398
VEHICLE EXPERIENCING BROKEN VALVE SPRINGS. *YC
9841
SOME VEHICLES MAY EXHIBIT A WHINE OR MOAN NOISE COMING FROAM THE FUEL TANK AREA. *YC
083298
NEW VEHICLE PREP PROCEDURES - COMPASS CALIBRATION / HVAC OPERATION. *YC
020798
CONDITIONS WITH LIGHT KNOCKING OR TAPPING NOISE BEING HEARD FROM THE REAR SHOCK REAR WHILE TRAVELING OVER BUMPS. *YC
232398
INFORMATION ON REMOTE KEYLESS ENTRY PROGRAMMING. *YC
240598
KNOCKING NOISE FROM ENGINE COMPARTMENT OR POSSIBLE OIL PUMP DAMAGE. *YC
98900
INFORMATION ON BROKEN ENGINE VALVE SPRINGS. *YC-*AK
210798
SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT. *AK
020298
A SQUEAKING OR HARD RUBBING NOISE MAY BE HEARD FROM THE REAR OF THE VEHICLE WHEN TRAVELING OVER BUMPS. *YC
081698
INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT. *AK
181898
EXCESSIVE COLD CRANK TIME, START DIE OUT OR WEAK RUN-UP, SAGS/STUMBLE/HESITATION AFTER A COLD START, IDLE RPM CYCLING. *YC
180498
SUBJECT ON ERRONEOUS MIL ILLUMINATION WITH HEX CODE $76, I/M FAILURE AND DRIVEABILITY IMPROVEMENTS. *YC
210398
SUBJECT ON TRANSAXLE DESENSITIZATION TO INTERMITTENT FAULTS / DRIVEABILITY IMPROVEMENTS. *YC
051197
CONCERNS WITH ALTERNATE ABS DIAGNOSTIC CODE RETRIEVAL. *NLM
090997
INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS. *NLM
140897
INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL. *NLM
9742A
EXPERIENCING IMPROPER SUNROOF OPERATION. *YC
9735A
INSTALLATION OF BRAKE ROTOR PROTECTION BAGS. *YC
Complaint counts are reports filed with NHTSA, not failure rates. A common model collects more of them than a rare one that breaks more often.